Table of Contents
Advertisement
Quick Links
Installation and Operation
Instructions for
Vented Gas Log Sets
Model OD30CFLN/P
DECORATIVE GAS APPLIANCE FOR INSTALLATION IN SOLID FUEL BURNING FIREPLACES
IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT,
CAUSING PROPERTY DAMAGE, INJURY, OR LOSS OF LIFE.
FOR YOUR SAFETY:
Do not store gasoline or other flammable
vapors or liquids near this or any other appli-
ance.
WHAT TO DO IF YOU SMELL GAS:
•
SHUT OFF ALL GAS TO THE APPLIANCE.
•
DO NOT TRY TO LIGHT ANY APPLIANCE; EX-
TINGUISH ANY OPEN FLAME
•
IMMEDIATELY PHONE YOUR GAS SUPPLIER
FROM A NEIGHBOR'S PHONE. FOLLOW THE
SUPPLIER'S INSTRUCTIONS.
•
IF YOU CANNOT REACH THE GAS SUPPLIER,
PHONE THE FIRE DEPARTMENT.
Certified as:
CSA 7.94 U.S. manually lighted decorative gas appliance
for installation in solid fuel burning fireplaces and the ap-
plicable requirements of UL127 factory-suit fireplaces.
CAN 1-2.21-M85 Gas Fired Appliances for Outdoor
Installation
W A R N I N G
CFM Specialty Home Products
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777
www.majesticproducts.com • www.vermontcastings.com
SAVE THIS MANUAL FOR FUTURE REFERENCE
C E R T I F I E D
ATTENTION
INSTALLATION AND SERVICE MUST BE PER-
FORMED BY A QUALIFIED AGENCY, INDIVIDUAL,
FIRM, CORPORATION, OR COMPANY, EXPE-
RIENCED IN THE INSTALLATION, REPAIR, AND
SERVICING OF THIS TYPE OF GAS APPLIANCE.
DO NOT MODIFY, ALTER OR TAMPER WITH ANY
PART OF THIS HEATER, CONTROL, OR LOGS.
INSTALLER PLEASE NOTE:
DO NOT BEGIN INSTALLATION OF THIS GAS
LOGSET UNTIL ALL INSTRUCTIONS HAVE
BEEN READ AND UNDERSTOOD.
OWNER PLEASE NOTE:
READ THESE INSTRUCTIONS AND FOLLOW THE
WARNINGS.
GAS-FIRED
20004180 10/05 Rev. 2
Advertisement
Table of Contents
Related Manuals for Vermont Castings OD30CFLN/P
Summary of Contents for Vermont Castings OD30CFLN/P
- Page 1 Installation and Operation Instructions for Vented Gas Log Sets Model OD30CFLN/P GAS-FIRED C E R T I F I E D DECORATIVE GAS APPLIANCE FOR INSTALLATION IN SOLID FUEL BURNING FIREPLACES W A R N I N G IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT, CAUSING PROPERTY DAMAGE, INJURY, OR LOSS OF LIFE.
- Page 2 Keep the gas log set clear and free from combustible materials, gasoline and other flammable vapors and liquids. If the log set is to be installed in a fireplace other than the Vermont Castings ODSHR42 fireplace, the minimal firebox dimensions and stainless steel grate must be used. Refer to Page 12 for Optional Ac- cessories.
-
Page 3: General Information
General Information • WARNING: If the fireplace contains glass doors, In order to assure a safe and effective instal- they must remain open at all times during the opera- lation, only a qualified service person who is tion of the logset, allowing combustion air to circulate. familiar with the building codes and installation •... -
Page 4: Tools Required
Pre-Installation Checklist Is the gas type you are using the same as the gas type listed on the rating plate for this appliance? Does the firebox meet the minimum size dimensions below? Is the gas supply inlet pressure correct? Refer to Table below. Is your fireplace plumbed with gas on the right side (facing) of the fireplace? If not, refer to page 5. - Page 5 NOTE: This is for burner connection purposes only. Ex- act burner placement will be covered on Page 7, after all connections have been made. 3. Attach the Gas Supply Fitting onto your fireplace’s gas supply pipe, as shown in Figure 2. 4.
-
Page 6: Damper Stop Installation
Leak Test Procedures After connecting the gas supply, test for leaks. Use a 50/50 solution of liquid soap and water to test for leaks at gas fitting and joints. Apply water/soap solution with brush only - do not over apply. NEVER test with an open flame. - Page 7 Grate Placement Grate Assembly 1. Place the grate steps onto the back of the grate as shown in Figure 7. 2. Place grate assembly over top of burner so that the front two middle legs of grate are resting against the front portion of the main burner area. (Fig.
-
Page 8: Log Placement
Log Placement 1. Place the larger bottom logs (longer log in back, 2. Next, place the smaller top logs diagonally onto shorter (2) logs in front) onto the grate, leaving as the bottom logs, so that the logs are in notches much space between them as possible. -
Page 9: Lighting Instructions
For Your Safety Read Before Lighting WARNING: If you do not follow these directions exactly, a fire or explosion may result caus- ing property damage, personal injury, or loss of life. What To Do If You Smell Gas • Do not try to light any appliance. •... -
Page 10: Troubleshooting
Troubleshooting Log Set Is Smoking/Sooting Excessively It is natural and unavoidable for vented gas log sets to produce moderate levels of carbon (soot) where flame contacts the logs. The logs can be cleaned using a soft-bristle brush. However, if soot is pro- duced where there is no flame impingement, one of the following may be the cause: Fireplace venting system not drafting properly: Make sure the damper is wide open at all times. - Page 11 4108 CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. OD30CFL Vented Gas Logs Ref. Description OD30CFL Complete Log Set 20003917 4108 Outside Left Cross Log (NNS2) 4312778 OD3CFL Left Cross Log (NNS4)
-
Page 12: Optional Accessories
OD30CFL Vented Gas Logs (continued) Ref. Description OD30CFL Regulator - Propane 3304191 Orifice - Propane 20001280 Orifice Holder - Propane 20000012 Air Mixer Shutter 20000013 Air Shutter Screen 20004686 Optional Accessories Item Description Part Number Grate (Stainless Steel) For use in fireplaces other than the ODSHR42 20002230 20004180... - Page 13 20004180...
- Page 14 20004180...
- Page 15 A and B below with respect to its ARE HEREBY EXPRESSLY INCLUDED. IN NO EVENT Vermont Castings Decorative Gas Appliances (the “Gas Ap- SHALL ANY IMPLIED WARRANTY PRESCRIBED BY LAW pliance”), including CFM Specialty Home Products supplied...
- Page 16 CFM Specialty Home Products 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www.majesticproducts.com • www.vermontcastings.com...