Warranty service is available by returning the Craftsman Power Mower to the nearest Sears Service Centre/Department in Canada. This warranty applies only while this prod- uct is used in Canada.
Page 3
• Do not pull mower backwards unless • Do not trim excessively steep slopes. absolutely nec es sary. Always look down • Do not mow on wet grass. Reduced and behind before and while moving footing could cause slipping. backwards. •...
V. GENERAL SERVICE • Never attempt to make wheel height • Never run machine inside a closed area. adjustments while the engine is running. • Never make adjustments or repairs with • Grass catcher components are sub ject the engine (motor) running. Dis con nect the to wear, dam age, and de te ri o ra tion, spark plug wire, and keep the wire away from the plug to prevent ac ci den tal starting.
ASSEMBLY / PRE-OPERATION Read these instructions and this manual in Operator MOWING its entirety before you attempt to assemble presence POSITION or operate your new lawn mower. control bar IMPORTANT: This lawn mower is shipped LIFT WITHOUT OIL OR GASOLINE in the engine.
OPERATION KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND ALL SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your lawn mower or in literature supplied with the product.
Page 7
risk of blade contact injury. Do not under The operation of any lawn any circumstances attempt to defeat the mower can result in foreign function of this control. objects thrown into the eyes, which can result in Operator presence control bar Blade/brake severe eye damage.
Page 8
TO ADJUST CUTTING HEIGHT Grass catcher All four wheels are adjusted by a single lever. frame • Pull adjuster lever toward wheel. To handle raise mower, move lever forward to desired position. To lower mow er, move the lever toward the rear. LEVER BACKWARD TO LOWER...
Page 9
CAUTION: Do not run your lawn mower CAUTION: DO NOT overfi ll engine with with out mulcher plug, clipping defl ector or oil, or it will smoke on startup. ap proved grass catch er in place. Never 1. Be sure lawnmower is level. at tempt to op er ate the lawn mow er with 2.
Page 10
TO STOP ENGINE • Pores in cloth grass catchers can be- come fi lled with dirt and dust with use • To stop engine, move throttle control and catchers will collect less grass. To lever to STOP position. Wait until blade prevent this, reg u lar ly hose catcher off and all moving parts have stopped and with water and let dry before using.
MAINTENANCE BEFORE AFTER EVERY EVERY EVERY BEFORE EACH EACH 25 HOURS STORAGE HOURS OR SEASON HOURS Check for Loose Fasteners Clean / Inspect Grass Catcher * Check Tires Check Drive Wheels *** Clean Lawn Mower **** Clean under Drive Cover *** Check Drive Belt / Pulleys *** Check / Sharpen / Replace Blade Lubrication...
Page 12
LAWN MOWER Always observe safety rules when per- Blade form ing any main te nance. TIRES • Keep tires free of gasoline, oil, or insect control chemi cals which can harm rubber. • Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage.
Page 13
ENGINE 4. Wipe off any spilled oil from lawn mower or side of engine. Maintenance, repair, or replacement of 5. Fill engine with oil. Slowly pour oil the emission control devices and systems, down the oil fi ll spout into the engine. which are being done at the customers ex- 6.
CLEANING • Keep fi nished surfaces and wheels free of all gasoline, oil, etc. IMPORTANT: For best performance, keep • We do not recommend using a garden mower housing free of built-up grass and hose to clean lawn mower unless the trash.
CARBURETOR for proper engine speed. Over speed ing the engine above the factory high speed Your carburetor is not adjustable. If your setting can be dangerous. If you think engine does not operate properly due to the engine-governed high speed needs suspected carburetor problems, take your adjusting, contact a Sears or other lawn mower to a Sears or other qualifi...
FUEL SYS TEM ENGINE OIL Drain oil (with engine warm) and replace IMPORTANT: It is important to prevent with clean engine oil. (See “ENGINE” in gum deposits from forming in essential the Maintenance section of this manual). fuel system parts such as carburetor, fuel fi...
Page 17
PROBLEM CAUSE CORRECTION Loss of power 1. Rear of lawn mower 1. Raise cutting height. housing or cutting blade dragging in heavy grass. 2. Cutting too much grass. 2. Raise cutting height. 3. Dirty air fi lter. 3. Clean/replace air fi lter. 4.