Troubleshooting Guide - Quadro 350D Manual

6.21 6.21 6.21 6.21 6.21

TROUBLESHOOTING GUIDE

TROUBLESHOOTING GUIDE TROUBLESHOOTING GUIDE TROUBLESHOOTING GUIDE TROUBLESHOOTING GUIDE
The following table summarises a list of the many problems that may occur with their likely causes and possible fix.
Problem
Engine does not start
Reduced braking power
High noise levels
Vehicle does not move
Engine tends to die
Low compression
Suspensions are ineffective
Poor performance, high fuel consumptions
Troubleshooting guide
Likely cause
A. Check fuel level inside tank.
A. No fuel
B. Clean and replace spark plug.
B. Excessive dirt/corrosion on Spark
C. Clean filter.
Plug
D. Remove spark plug and allow the fuel inside the cylinder to
C. Clogged air or fuel filter
evaporate.
D. Flooded engine
E. Replace blown fuse and have vehicle inspected by an Authorised
E. Blown fuse
Service Centre.
A. Brake hose damaged A. Contact an Authorised Service Centre for the replacement.
B. Excessive wear of tyres or B. Contact an Authorised Service Centre for the replacement.
brake sealing C. Contact an Authorised Service Centre.
C. Wax or grease on brake disc D. Replace worn pads.
D. Worn brake pads E. Contact an Authorised Service Centre.
E. Air in front and rear brake circuit
A. Excessive wear of bearings A. Contact an Authorised Service Centre for the replacement.
B. Damaged exhaust B. Contact an Authorised Service Centre for the replacement.
C. Cylinder head fault C. Contact an Authorised Service Centre for the replacement.
A. Check wear of brake pads.
A. Insufficient brake lever travel
B. Clogged air or fuel filter B. Clean filter.
C. Clogged exhaust C. Contact an Authorised Service Centre.
D. No fuel D. Check fuel level inside tank.
A. Loosen spark plug A. Tighten the spark plug
C. Loosen cylinder head or excessive C. Contact an Authorised Service Centre for the replacement.
wear of piston retaining rings
A. Dampers faulty, oil leaks, A. Contact an Authorised Service Centre.
worn stop buffers.
A. Cl e an t filter
A. Air filter clogged or dirty.
MAINTENANCE VEHICLE MAINTENANCE VEHICLE MAINTENANCE VEHICLE MAINTENANCE VEHICLE MAINTENANCE VEHICLE
Solution
79