Table of Contents
Advertisement
SAFETY CONSIDERATIONS
Adhere to the following warnings and cautions when
installing, adjusting, altering, servicing, or operating the
furnace. To ensure proper installation and operation,
thoroughly read this manual for specifics pertaining to the
installation and application of this product.
This furnace is manufactured for use with natural gas. It
may be field converted to operate on L.P. gas by using the
appropriate L.P. conversion kit listed in the PROPANE
GAS/HIGH ALTITUDE INSTALLATIONS section of this
manual
Install this furnace only in a location and position
as specified in LOCATION REQUIREMENTS &
CONSIDERATIONS section and INSTALLATION
POSITIONS section of this manual.
Provide adequate combustion and ventilation air to the
furnace as specified in COMBUSTION & VENTILATION
AIR REQUIREMENTS section of this manual.
Combustion products must be discharged to the outdoors.
Connect this furnace to an approved vent system only, as
specified in VENT/FLUE PIPE & COMBUSTION AIR PIPE
section of this manual.
Never test for gas leaks with an open flame. Use a
commercially available soap solution made specifically
for the detection of leaks to check all connections, as
specified in GAS SUPPLY AND PIPING section of this
manual.
Always install a furnace to operate within the furnace's
intended temperature-rise range with a duct system which
has external static pressure within the allowable range, as
specified on the furnace rating plate and OPERATIONAL
CHECKS section of these instructions.
When a furnace is installed so that supply ducts carry
air circulated by the furnace to areas outside the space
containing the furnace, the return air shall also be handled
by duct(s) sealed to the furnace casing and terminating
outside the space containing the furnace.
A gas-fired furnace for installation in a residential
garage must be installed as specified in the LOCATION
REQUIREMENTS AND CONSIDERATIONS section of
this manual.
This furnace may be used as a construction site heater
only if certain conditions are met. These conditions are
listed in the PRODUCT APPLICATION section of this
manual.
FROZEN AND BURST WATER PIPE HAZARD
F
AILURE TO PROTECT AGAINST THE RISK OF FREEZING MAY RESULT IN
.
PROPERTY DAMAGE
S
MUST
PECIAL PRECAUTIONS
AREA WHICH MAY DROP BELOW FREEZING
OPERATION OR DAMAGE TO EQUIPMENT
ENVIRONMENT HAS THE POTENTIAL OF FREEZING
DRAIN LINE MUST BE PROTECTED
,
HEATERS
ELECTRIC HEAT TAPE AND
RECOMMENDED FOR THESE INSTALLATIONS
T
O PREVENT PERSONAL INJURY OR DEATH DUE TO IMPROPER
,
INSTALLATION
ADJUSTMENT
. F
REFER TO THIS MANUAL
,
INFORMATION
CONSULT A QUALIFIED INSTALLER
.
THE GAS SUPPLIER
I
F THE INFORMATION IN THESE INSTRUCTIONS IS NOT FOLLOWED
,
EXACTLY
A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY
,
DAMAGE
PERSONAL INJURY OR LOSS OF LIFE
D
O NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS AND
LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE
WHAT TO DO IF YOU SMELL GAS:
D
O NOT TRY TO LIGHT ANY APPLIANCE
D
O NOT TOUCH ANY ELECTRICAL SWITCH
.
IN YOUR BUILDING
I
MMEDIATELY CALL YOUR GAS SUPPLIER FROM A NEIGHBOR
. F
PHONE
OLLOW THE GAS SUPPLIER
I
F YOU CANNOT REACH YOUR GAS SUPPLIER
.
DEPARTMENT
I
NSTALLATION AND SERVICE MUST BE PERFORMED BY A QUALIFIED
,
INSTALLER
SERVICE AGENCY OR THE GAS SUPPLIER
H
EATING UNIT SHOULD NOT BE UTILIZED WITHOUT REASONABLE
,
,
ROUTINE
INSPECTION
MAINTENANCE AND SUPERVISION
BUILDING IN WHICH ANY SUCH DEVICE IS LOCATED WILL BE VACANT
CARE SHOULD BE TAKEN THAT SUCH DEVICE IS ROUTINELY INSPECTED
MAINTAINED AND MONITORED
MAYBE EXPOSED TO FREEZING TEMPERATURES AND WILL BE VACANT
-
ALL WATER
BEARING PIPES SHOULD BE DRAINED
BE PROPERLY WINTERIZED
EVENT THAT THE BUILDING MAY BE EXPOSED TO FREEZING
TEMPERATURES AND WILL BE VACANT
SHOULD BE DRAINED AS WELL AND
SOURCES SHOULD BE UTILIZED
T
O PREVENT POSSIBLE PROPERTY DAMAGE
DEATH DUE TO ELECTRICAL SHOCK
PROTECT THE ELECTRICAL COMPONENTS FROM WATER
4
CAUTION
BE MADE IF INSTALLING FURNACE IN AN
. T
HIS CAN CAUSE IMPROPER
. I
F THE FURNACE
,
THE DRAIN TRAP AND
. T
HE USE OF ACCESSORY DRAIN TRAP
/
RV
OR
ANTIFREEZE IS
.
WARNING
,
,
ALTERATION
SERVICE OR MAINTENANCE
OR ADDITIONAL ASSISTANCE OR
,
SERVICER AGENCY OR
WARNING
.
.
;
DO NOT USE ANY PHONE
'
.
S INSTRUCTIONS
,
CALL THE FIRE
.
WARNING
.
IN THE EVENT THAT THE BUILDING
,
THE BUILDING SHOULD
,
AND THE WATER SOURCE CLOSED
,
ANY HYDRONIC COIL UNITS
,
,
IN SUCH CASE
ALTERNATIVE HEAT
.
WARNING
,
PERSONAL INJURY OR
,
THE FURNACE MUST BE LOCATED TO
.
,
.
'
S
,
. I
F THE
,
,
,
.
IN THE
Advertisement
Table of Contents
