Cleaning The Versaflame Burner Assembly - Char-Broil PERFORMANCE Series Use And Care Manual
L p gas grill
Hide thumbs
Also See for PERFORMANCE Series:
- Operating instructions manual (60 pages) ,
- Assembly, use and care manual (16 pages) ,
- Quick start manual (16 pages)
Table of Contents
Advertisement
Cleaning The Versaflame Burner Assembly
Follow these instructions to clean and/or replace parts of burner assembly or if you have trouble igniting the grill.
1.
Turn gas off at control knobs and LP cylinder.
2.
Remove cooking grate, burner tent and tent frame.
3.
Under grill remove soup can from grease clip.
4.
Beneath left side of grill bottom remove ignitor wire by pulling down on ceramic insulator (A).
Electronic Ignition Grills: Disconnect battery and then ceramic insulator with ignitor wire.
5.
Under console disengage (B) clips by lightly pushing clip on burner tube away from you and pull down. Remove burners from grill
bottom.
6.
Wipe ceramic electrode (A) with rubbing alcohol and cloth.
7.
Clean burners exterior with soap and water. Lay burners on flat surface, insert garden hose (preferably with nozzle), into burner
tubes forcing water through tubes. Make sure water comes out of every porthole. Open clogged portholes with a thin wire.
out excess water
and examine porthole. Due to normal wear and corrosion some portholes may become enlarged, if so replace
burner. If any horizontal cracks appear from porthole to porthole or large holes (other than portholes) are found replace burner.
Use a wire brush to clean carry-over tube(s).
8.
If grill is to be stored, coat burners lightly with cooking oil. Wrap in protective cover to keep insects out. If not storing use following
steps.
9.
Attach burners into valves, under grill bottom reattach clips.
VERY IMPORTANT: Burner tubes must engage valve
openings as shown (B).
10. Attach ceramic insulator with ignitor wire to left burner.
11. Reposition cooking grates, tent frame and burner tent. Reattach soup can to grease clip under grill bottom.
12. Before cooking again on grill, perform a
12
Replace battery (if featured).
"Leak Test"
and
"Burner Flame Check"
s
Do not use ceramic briquets or charcoal
Remove button and battery on
electronic ignition models
.
Ceramic
Insulator
Burner Tube
Clip
Valve
Shake
A
B
Advertisement
Table of Contents
Troubleshooting
