Intel SSR212MA Technical Product Specification
Hardware
Hide thumbs
Also See for SSR212MA:
- Install manual (20 pages) ,
- Configuration manual (10 pages) ,
- Install manual (14 pages)
Related Manuals for Intel SSR212MA
Summary of Contents for Intel SSR212MA
- Page 1 ® Intel Storage System SSR212MA Technical Product Specification (Hardware) Revision 1.4 Storage Group Technical Marketing...
- Page 2 Revision History Intel® Storage System SSR212MA TPS Revision History Date Revision Modifications Number May 12, 2005 Initial draft for review. June 23, 2005 Updated graphics, updated MTBF table, added DOM graphic, corrected various branding errors. August 11, 2005 Updated memory DIMM types, block diagram, DOM information, cooling module information, power supply specs.
- Page 3 Intel disclaims any express or implied warranty, relating to sale and/or use of Intel products including liability or warranties relating to fitness for a particular purpose, merchantability, or infringement of any patent, copyright or other intellectual property right.
-
Page 4: Table Of Contents
Table of Contents Intel® Storage System SSR212MA TPS Table of Contents 1. Feature Summary ......................... 1 System Components ....................5 System Board Feature Set ..................7 Serial ATA (SATA) Host Bus Adapter..............9 SATA Hot Swap Backplane ..................9 Enclosure Management..................10 1.5.1... - Page 5 Intel® Storage System SSR212MA TPS Table of Contents Hard Disk Drive Bays..................... 25 4.1.1 Hard Disk Drive Carrier..................26 Disk On Module (DOM) ..................28 4.2.1 Features......................... 28 5. System Interconnection..................... 29 Chassis Internal Cables and Connector ..............29 I/O Panel Connectors .................... 29 SATA HSBP Connectors ..................
- Page 6 Figure 1. Intel Storage System SSR212MA ................1 ® Figure 2. Intel Storage System SSR212MA Block Diagram ............5 Figure 3. System Components ..................... 6 Figure 4. SATA HSBP Block Diagram ..................10 Figure 5. SATA HSBP I C Bus Connection Diagram..............11 Figure 6.
- Page 7 Table 16. Front Panel Power Connector..................32 Table 17. SATA Host I C Header Pin-out ................... 32 ® Table 18. Intel Storage System SSR212MA System Office Environment Summary....36 ® Table 19. Intel Storage System SSR212MA Operating and Non-Operating Environmental Limits ............................ 37 ®...
- Page 8 List of Tables Intel® Storage System SSR212MA TPS This page intentionally left blank viii Revision 1.4...
-
Page 9: Feature Summary
Xeon® processors. ® For more information on the Intel Storage System SSR212MA SAN Management Software, please refer to the Intel® Storage System Software Manual available from Intel Business Link (IBL), support.intel.com or your Intel sales representative. ® Figure 1. Intel Storage System SSR212MA Revision 1.4... - Page 10 NOTE: For specific drive family and capacities supported, please refer to the SSR212MA Tested Hardware and OS List (THOL). Processor A single Low Voltage Intel® Xeon® processor 2.80 GHz with 1 MB L2 cache. Expandable to 16 GB maximum, using DDR2-400 memory.
- Page 11 Feature Summary baseboard and SATA Host Bus Adapter (HBA) cards. The Power supply enclosure contains one 60mm fan. Power 500 W continuous, 1+1 redundant power supplies. Intel Storage Configuration System SSR212MA ships with one 500W power supply Max AC input current 7.2 Amperes at 110 Vrms, 3.5 A at 220 Vrms (each power supply...
- Page 12 Feature Summary Intel® Storage System SSR212MA United States UL– 60950 – CSA 60950 (UL and cUL) Electromagnetic Capability (Class A) (EMC) Australia/New Zealand AS/NZS 3548 (based on CISPR 22) Canada ICES-003 GB 9254 - CNCA Certification China GB 17625 - (Harmonics) CNCA Certification Europe, CE Mark EN55022;...
-
Page 13: System Components
(PDB, 60 mm Fan) Hot Swap SATA Backplane 2x 500 Watt (“1+1” Power Supply Modules) SATA SATA SATA HDD #12 Up to 12 optional 1.5 or 3.0 Gb/s SATA drives ® Figure 2. Intel Storage System SSR212MA Block Diagram Revision 1.4... -
Page 14: Figure 3. System Components
Feature Summary Intel® Storage System SSR212MA The components included with this storage system are diagrammed below. Figure 3. System Components Revision 1.4... -
Page 15: System Board Feature Set
Dual 604-pin Socket Support for FC-mPGA2P Low Voltage Intel® Xeon® processors with 800 MHz systen bus speed. NOTE: Storage System only supports a single Low Voltage Intel® Xeon® processor 2.8 GHz with 800 MHz system bus and 1MB L2 cache. - Page 16 64-bit/133 MHz PCI-X Slot 3 used for FibreChannel or expanded Ethernet client connectivity. One RJ-45 serial port for initial Intel Storage System SSR212MA configuration via a local console. IDE interface for Disk On Module (DOM) support. . ®...
-
Page 17: Serial Ata (Sata) Host Bus Adapter
Intel® Storage System SSR212MA Feature Summary Serial ATA (SATA) Host Bus Adapter ® The Intel Storage System SSR212MA ships with two 8 port PCI-X to SATA Host Bus Adapters. Each SATA HBA board provides the following feature set: Feature Description Number of ports... -
Page 18: Enclosure Management
C Interfaces. Audible Alarm A piezo-electric buzzer on the backplane provides an audible alarm. However, this buzzer is disabled on the SSR212MA. The following figure shows the functional blocks of the SATA Hot Swap Backplane. Figure 4. SATA HSBP Block Diagram Enclosure Management The enclosure management controller monitors various aspects of a storage enclosure. -
Page 19: Fan Control
C interface ports with bus speeds of up to 400 Kb/s. The figure below provides a block diagram of I C bus connection implemented on the Storage System SSR212MA SATA Hot Swap Backplane (HSBP). I2C Buffer for Backplane R147 R148... -
Page 20: Hard Disk Drive Leds
Feature Summary Intel® Storage System SSR212MA 1.5.4 Hard Disk Drive LEDs ® The Intel Storage System SSR212MA SATA HSBP contains two LEDs for each of the twelve drive slots. Table 1. HDD LED Function Activity Light States Drive Status Idle... -
Page 21: Back Panel I/O Ports And Features
Intel® Storage System SSR212MA Feature Summary Back Panel I/O Ports and Features At the rear of the chassis is a serial management port and two 10/100/1000 Network Interface Card (NIC) connectors. The Input/Output (I/O) connectors are integrated to the back panel. The figure below shows the rear of the storage system. -
Page 22: Front Panel And Hdd Bays
Feature Summary Intel® Storage System SSR212MA Front Panel and HDD Bays Figure 7. Chassis Front and Rear Revision 1.4... -
Page 23: Front/Rear Panel Controls And Indicators
Figure 8. Front Panel Fan Monitoring The fans provided in the Storage System SSR212MA contain a tachometer signal that can be monitored by the SAN management software. 1.10 Storage System Security The storage system includes a preinstalled intrusion switch that can be monitored by SAN management software. -
Page 24: 1.11 Rack And Cabinet Mounting Options
Feature Summary Intel® Storage System SSR212MA 1.11 Rack and Cabinet Mounting Options The chassis was designed to support cabinets that are 19 in (483 mm) wide by up to 36 in (914 mm) deep, and are compliant to the SSI Server Rack specification and EIA 310-D. A set of Rack Mounting Rails are provided and will accommodate either square or round hole rack mounting methods. -
Page 25: Power Sub-System
Intel® Storage System SSR212MA Power Sub-System Power Sub-System This section provides an overview of the Storage System SSR212MA power supply sub-system; the power supply enclosure and the power supply module. NOTE: The Storage System SSR212MA ships with one 500 Watt power supply module. -
Page 26: Hot Swapping Power Modules
2.1.2 Power Supply Outputs The Storage System SSR212MA power system supports one or two 500 W Power Supply module’s in a 1+1 redundant configuration. The power supply module provides five DC output rails; +12V1, +12V2, +12V3, -12V, +5VSB, while the Power Supply Enclosure provides two DC output rails: +3.3V and +5V. -
Page 27: Output Power/Currents
Intel® Storage System SSR212MA Power Sub-System Output Power/Currents The following table defines power and current ratings for this 500 Watt continuous (606 Watts peak) power supply in 1+0 or 1+1 redundant configuration. The combined output power of both outputs shall not exceed the rated output power. The power supply must meet both static and dynamic voltage regulation requirements for the minimum loading conditions. -
Page 28: Dynamic Loading
Power Sub-System Intel® Storage System SSR212MA 2.3.1 Dynamic Loading The output voltages shall remain within limits specified in Table 9 for the step loading and capacitive loading specified in Table 10, below. The load transient repetition rate shall be tested between 50 Hz and 5 KHz at duty cycles ranging from 10%-90%. The load transient repetition rate is only a test specification. -
Page 29: Table 11. Over Current Protection Limits
Intel® Storage System SSR212MA Power Sub-System condition. 5Vsb shall be protected under over-current or shorted conditions, so that no damage can occur to the power supply. Table 11. Over Current Protection Limits VOLTAGE OVER CURRENT LIMIT (Iout limit) +3.3V <30A <30A... -
Page 30: Over Voltage Protection (Ovp)
Power Sub-System Intel® Storage System SSR212MA 2.5.2 Over Voltage Protection (OVP) The power supply over voltage protection shall be locally sensed. The power supply shall shutdown and latch off after an over voltage condition occurs. This latch shall be cleared by toggling the PSON signal or by an AC power interruption. -
Page 31: System Cooling Module
System Cooling Module System Cooling Module The Storage System SSR212MA includes a cooling module that has three dual rotor 40 mm fans and two single rotor 40 mm fans, mounted in a common frame for ease of maintenance. The fans are mounted in a single fan tray located in the center of the chassis. The Power Supply enclosure contains one 60 mm fan for cooling the power supply modules. -
Page 32: Chassis Bays
Chassis Bays Intel® Storage System SSR212MA Chassis Bays The Storage System SSR212MA chassis provides twelve hard drive bays at the front of the chassis. All hard drive bays may be populated with a carrier-mounted 3.5 inch SATA hard disk drive. -
Page 33: Hard Disk Drive Bays
Intel® Storage System Software Manual for more information. NOTE: 1) Drive bays 1 thru 6 are controlled by a single Intel® RAID Controller SRCS28X, while drive bays 7 thru 12 are controlled by a second Intel® RAID Controller SRCS28X 2) All drives must be populated in order, from left to right, top to bottom, in drive bay 1 thru drive bay 12, but sequentially distributed across both SRCS28X SATA HBA’s. -
Page 34: Hard Disk Drive Carrier
Chassis Bays Intel® Storage System SSR212MA Figure 13. Hard Disk Drive Bays 4.1.1 Hard Disk Drive Carrier Each hard drive used in the system must be mounted to a drive carrier, making insertion and extraction of the drive from the chassis very simple. Each drive tray has its own dual purpose... -
Page 35: Figure 14. Hard Drive Carrier Assembly
Intel® Storage System SSR212MA Chassis Bays Figure 14. Hard Drive Carrier Assembly Revision 1.4... -
Page 36: Disk On Module (Dom)
IDE connector while the system is operational, or data corruption could occur. For more information on how to upgrade the Storage System SSR212MA SAN Management Software, please refer to the Intel® Storage System Software Manual available from Intel Business Link (IBL) or your Intel sales representative. -
Page 37: System Interconnection
System SSR212MA. These cables support the twelve expansion drives and provide interconnect between the backplane and the two SATA HBA’s. I/O Panel Connectors The Storage System SSR212MA provides an aperture for the rear I/O ports. The following are the I/O ports available: •... -
Page 38: Sata Hsbp Connectors
System Interconnection Intel® Storage System SSR212MA SATA HSBP Connectors 5.3.1 SATA 4-Lane Connector The following table defines the pin-outs of the three SATA 4-Lane Drive Connectors. The first connector carries signals from drive 1 to 4, the second connector is connected to drives 5 to 8 and the third connector connects to drives 9 to 12. -
Page 39: Interposer Connector
Intel® Storage System SSR212MA System Interconnection 5.3.2 Interposer Connector The following table defines the pin-outs of the Interposer Connector. Table 14. Interposer Connector Signal Name Signal Name POWER_SWITCH FAN_PWR_BANK2 FAN_PWR_BANK2 FAN_PWR_BANK2 I2C_SCL_A FAN_TACHO0 I2C_SDA_A FAN_TACHO1 I2C_SCL_B FAN_TACHO2 I2C_SDA_B FAN_TACHO3 COM_TX... -
Page 40: Front Panel Connector
System Interconnection Intel® Storage System SSR212MA 5.3.4 Front Panel Connector The following table defines the pin-outs of the 1x14 Front Panel connector. Table 16. Front Panel Power Connector Signal Name COM_CTS COM_RX COM_TX COM_RTS +5V_OPS +5V_OPS I2C_SDA_OPS I2C_SCL_OPS LED1_OPS/SPARE1 (power) -
Page 41: Regulatory Information
6.1.2 Product EMC Compliance – Class A Compliance Note: Legally the product is required to comply with Class A emission requirements as it is intended for a commercial type market place. Intel targets 10db margin to Class A Limits FCC /ICES-003 - Emissions (USA/Canada) Verification CISPR 22 –... -
Page 42: 6.1.3 Certifications / Registrations / Declarations
Regulatory Information Intel® Storage System SSR212MA 6.1.3 Certifications / Registrations / Declarations UL Certification (US/Canada) CE Declaration of Conformity (CENELEC Europe) FCC/ICES-003 Class A Attestation (USA/Canada) VCCI Certification (Japan) C-Tick Declaration of Conformity (Australia) MED Declaration of Conformity (New Zealand) -
Page 43: 6.1.5 Product Ecology Requirements
All cords and cables shall contain < 100 ppm of cadmium. Restriction of Hazardous Substances (RoHS) Intel has a system in place to restrict the use of banned substances in accordance with the European Directive 2002/95/EC. Compliance is based on declaration that materials banned in the RoHS Directive are either (1) below all applicable substance threshold limits or (2) an approved/pending RoHS exemption applies. -
Page 44: Environmental Limits
Intel® Storage System SSR212MA Environmental Limits System Office Environment ® Table 18. Intel Storage System SSR212MA System Office Environment Summary Parameter Limits Operating Temperature 10 degrees celcius to +35 degrees celcius with the maximum rate of change not to exceed 10 degrees celcius per hour. -
Page 45: Environmental Limits
Intel® Storage System SSR212MA Environmental Limits Environmental Limits The following table summarizes environmental limits, both operating and non-operating. ® Table 19. Intel Storage System SSR212MA Operating and Non-Operating Environmental Limits Temperature Specification Non-operating -40 degrees celcius to 70 degrees celcius Operating Temperature... -
Page 46: Serviceability And Availability
Serviceability and Availability Intel® Storage System SSR212MA Serviceability and Availability The system is designed to be serviced by qualified technical personnel only. The desired Mean Time To Repair (MTTR) of the system is TBD minutes, including diagnosis of the system problem. To meet this goal, the system enclosure and hardware have been designed to minimize the MTTR. -
Page 47: Calculated Mtbf
Calculated MTBF Calculated MTBF The Mean Time Between Failures (MTBF) for the Storage System SSR212MA is calculated at 27,196 hours operating at 40 degrees C. The following table shows the MTBF numbers for individual components within the chassis, and does not include hard disk drives. -
Page 49: Appendix A: Spares And Accessories
Intel® Storage System SSR212MA Appendix A: Spares and Accessories Appendix A: Spares and Accessories Upgrade and Accessory Parts Please refer to the SSR212MA Configuration Guide document for the latest order information for spares and accessories, available from IBL or support.intel.com. Revision 1.4... -
Page 50: Glossary
Glossary Intel® Storage System SSR212MA Glossary Word / Acronym Definition Ampere Alternating Current Australian Communication Authority ACPI Advanced Configuration and Power Interface ANSI American National Standards Institute AT Attachment Decibel Average Baseboard Management Controller British Thermal Units Celsius ® Compact Flash... - Page 51 Intel® Storage System SSR212MA Glossary Integrated Circuit I/O Controller Hub Internet Database Connector Integrated Drive Electronics Intel® Management Module Input/Output iSCSI Internet Protocol Small Computer System Interface Information Technology Equipment Kilo (1.024 x 10 Kilobyte Kilovolt Kilohertz Local Area Network...
- Page 52 Glossary Intel® Storage System SSR212MA SMBIOS System Management Basic Input/Output System SOIC Small Outline Integrated Circuit SRAM Static Random Access Memory Server System Infrastructure TQFP Thin Quad Flat Pack Terabyte UART Universal Asynchronous Receiver Transmitter µF Micro Farad (1 x 10 Farads) µS...