Page 1
MODEL 463270708 • PRODUCT GUIDE THIS GRILL IS FOR OUTDOOR USE ONLY. CAUTION: WARNING: Read and follow all safety statements, assembly Failure to follow all manufacturer’s instructions could instructions, and use and care directions before result in serious personal injury and/or property attempting to assemble and cook.
Page 2
CAUTION CAUTION CAUTION: Indicates a potentially hazardous situation or For residential use only. Do not use for commercial unsafe practice which, if not avoided, may result in minor cooking. or moderate injury. 2 • 463270708...
Page 4
• Do not release liquid propane (LP) gas into the atmosphere. This is a hazardous practice. • To remove gas from LP cylinder, contact an LP dealer or call a local fire department for assistance. Check the telephone directory under “Gas Companies” for nearest certified LP dealers. 4 • 463270708...
Nipple has to be centered into the LP cylinder valve. WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! 463270708 • 5...
6. Always close LP cylinder valve after performing leak test by department. turning hand wheel clockwise. • If you cannot stop a gas leak, immediately close LPcylinder valve and call LP gas supplier or your fire department! 6 • 463270708...
Page 7
• Always close LP cylinder valve and remove burners closest to the IGNITION BURNER first. If ignition still does not occur, follow match-lighting coupling nut before moving LP cylinder from instructions. specified operation position. Lighting instructions continued on next page. 463270708 • 7...
Page 8
• Cooking surfaces: If a bristle brush is used to clean any of HIGH .Be sure burner the grill cooking surfaces, ensure no loose bristles remain on lights and stays lit. cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot. 8 • 463270708...
Page 9
• Store grill indoors ONLY if LP cylinder is turned off and Firebox disconnected, removed from grill and stored outdoors. Electrode burner • When removing grill from storage, follow “Cleaning the Burner bracket Assembly” instructions before starting grill. 463270708 • 9...
Page 10
• When reheating takeout foods or fully cooked meats like hot dogs, grill to 165° F, or until steaming hot. 2 Burner Cooking Great indirect cooking on low. Produces slow, even heating. Ideal for slow roasting and baking. 10 • 463270708...
Page 11
The methods below are suggestions for cleaning stainless steel surfaces. Choose a cleaning method appropriate for your needs. It is recommended that you use a Char-Broil® grill cover to help prolong the life and prevent discoloration of your grill.
PARTS LIST – Model No. 463270708 Key Qty Description Part # Key Qty Description Part # Left Door Assembly ....80010474 Bottom Shelf..... 80017114 Door Handle .
ASSEMBLY – Model No. 463270708 Attach the two locking casters at the rear of the bottom shelf and the two fixed casters at the front. Use the provided caster wrench to fully tighten casters. Fixed caster Locking caster Front Bottom shelf Attach side panels to bottom shelf using three 1/4-20x1/2”...
Page 15
Carefully lower the grill head onto the cart, aligning slots at bottom of grill head with posts on cart side panels. Make sure the regulator hose is hanging outside the cart. Grill head must face open side of cart. Grill head Regulator hose 463270708 • 15...
Page 16
1/4-20x1½” screw, 7mm lock washer, and 7mm flat washer on each side. Do not fully tighten screws until side shelf installation is complete in later steps. 1/4-20x1½” 7mm lock 7mm flat screw washer washer Rear upper panel 16 • 463270708...
Page 17
Now you may fully tighten lower screws on upper back panel. 7mm flat washer 1/4-20x1/2” 7mm lock screw washer 7mm lock washer 7mm flat Tabs washer into 1/4-20x1½” screw holes Left sideburner shelf 7mm flat 7mm lock washer washer Fascia, left sideburner shelf 1/4-20x1/2” screw 463270708 • 17...
Page 18
See illustration C for proper burner-to-valve engagement. Secure burner to bracket using two #10-24x3/8” screws, 5mm lock washers, and 5mm silicone washers (B). Sideburner burner 5mm silicone washer 5mm lock washer #10-24x3/8” screw 18 • 463270708...
Page 19
#8-32x3/8” Tank heat shield extension Screw Tank heat shield 4mm Flat washer 4mm Lock washer #8-32 Hex nut Some components not shown for illustration purposes. #8x3/8” self- Right grease Left grease tapping screw tray rail tray rail 463270708 • 19...
Page 20
NOTE: Once doors are installed adjust Door Brace up or down to adjust for proper door clearance, then tighten screws to Door Brace from step 5. PRESS Top of door Hinge pin on bottom of door Right door Left door 20 • 463270708...
Page 21
Place cooking grates onto the firebox as shown. Insert the three wire ends at rear of warming rack into holes in back of firebox. Front wires of warming rack rest on sides of firebox. Assembled warming rack Warming rack Cooking grate 463270708 • 21...
Page 22
Grease tray Unscrew electronic ignition button on front of control panel. Insert AA battery into ignitor, negative (—) end first. Replace button. Electronic Ignition Button 22 • 463270708...
• Wires are loose or disconnected. • Reconnect wires or replace electrode/wire assembly. • Wires are shorting (sparking) between • Replace ignitor wire/electrode assembly. ignitor and electrode. • Dead battery. • Replace with a new AA-size alkaline battery. 463270708 • 23...
Page 24
• The worn nozzles don’t have enough “bite” to engage the valve. Try cylinder. with worn threads. a second LP dealer. One burner does not • Grease buildup or food particles in • Clean carry-over tube(s) with wire brush. light from other end(s) of carryover tube(s). burner(s). 24 • 463270708...
Page 25
Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates. Artisan Collection by Char-Broil ™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™, Grill 2 Go™, Grillin’ Stick™, Keeper of the Flame™, Keepers of the Flame™, Natural Grip™, Outdoor Cooking Collection and Design™, Patio Bistro™, PrecisionFlame™, Pro-Check™, QuickSet Grills and Design™, SmokerTents™, The Big Easy™, The Minute Grill™, The Edge™, The Tuscan Collection™, and The Urban Grill™...
Consumer returns will not be accepted unless a valid Return Authorization is first acquired by calling 1-800-241-7548 and then clearly marked on the outside of the package and the package is shipped freight/postage pre-paid to the address above. 26 • 463270708...
Page 27
Merci d’avoir bien voulu remplir ce questionnaire. Vos réponses nous aideront et aideront d’autres compagnies à vous communiquer des offres spéciales susceptibles de vous intéresser. Si vous préférez ne pas recevoir d’informations concernant ces offres spéciales, veuillez cocher ici 463270708 • 27...
Page 28
Always ensure control knobs are in OFF position and regulator is attached to tank BEFORE opening tank valve to avoid low flames. Perform leak test regularly. Thank You for Your Purchase! Char-Broil, LLC • Columbus, GA 31902 • Printed in China...