Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Figures can deviate due to the different set executions. drivers. Table 2-1 Described Model Numbers and Diversity Mechanics Block Diagrams Schematics 19PFL3507H/12 10.1 10.3 10.6 10.7 11.1 19PFL3507T/60 10.1 10.5 10.6 10.7 11.1 22PFL3507H/12 10.1 10.3 10.6 10.7 11.2 22PFL3517H/12 10.1...
Page 3
Technical Specs, Diversity, and Connections TPM9.3E LA EN 3 Connections Rear Connectors Side Connectors TV ANTENNA SERV .U SCART (RGB/CVBS) AUDIO IN USB2 DVI/VGA CVBS/Y USB1 NETWORK HDMI 2 HDMI1 DIGITAL AUDIO OUT HDMI 19270_001_120410.eps 120412 Figure 2-1 Connection overview Note: The following connector colour abbreviations are used - D2+ Data channel...
Page 4
EN 4 TPM9.3E LA Technical Specs, Diversity, and Connections - Audio R 0.5 V / 1 k 11 - RJ45: Ethernet - Audio R 0.5 V / 10 k - Audio L 0.5 V / 1 k - Ground Audio - Ground Blue - Audio L 0.5 V...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 TPM9.3E LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
Page 7
6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions TPM9.3E LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly Cable Dressing 19270_100_120401.eps 120412...
Page 10
EN 10 TPM9.3E LA Mechanical Instructions 19270_101_120401.eps 120412 Figure 4-2 Cable dressing (22PFL3507H) Figure 4-3 Cable dressing (22PFL3507T/22PFL3517T) back to 2013-Mar-01 div. table...
Page 11
Mechanical Instructions TPM9.3E LA EN 11 19272_101_120628.eps 120719 Figure 4-4 Cable dressing (22PFL3557H) 19270_102_120401.eps 120401 Figure 4-5 Cable dressing (24PFL3507) back to 2013-Mar-01 div. table...
Page 12
EN 12 TPM9.3E LA Mechanical Instructions Service Positions Assembly/Panel Removal For easy servicing of a TV set, the set should be put face down Instructions below apply to the 22PFL3507H/12, but will be on a soft flat surface, foam buffers or other specific workshop similar for other models.
Page 13
Mechanical Instructions TPM9.3E LA EN 13 4.3.2 Rear Cover 1. Remove the fixation screws [1] that secure the rear cover. 2. Lift the rear cover from the TV. Make sure that wires and flat foils are not damaged while lifting the rear cover from Refer to Figure 4-7 for details.
Page 14
EN 14 TPM9.3E LA Mechanical Instructions 1. Release the clips from the LVDS/Flat Foil connector that 2. Remove the fixations screws that secure the subframe to connect with the SSB [1]. the panel. Caution: be careful, as these are very fragile connectors! 3.
Service Modes, Error Codes, and Fault Finding TPM9.3E LA EN 15 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: Life Timer 5.1 Test Points During the life time cycle of the TV set, a timer is kept (called 5.2 Service Modes “Op.
Page 16
EN 16 TPM9.3E LA Service Modes, Error Codes, and Fault Finding – Automatic user menu time-out (menu switches controls will not have I+ button, but an “INFO” button back/OFF automatically. instead. – Auto Volume levelling (AVL). How to Exit SDM How to Activate SDM •...
Page 17
Service Modes, Error Codes, and Fault Finding TPM9.3E LA EN 17 Main Menu Sub-menu 1 Sub-menu 2 Description Download from USB Copy Channel List from USB To download several settings from the USB stick to the TV Copy NVM from USB Copy Readable Info from USB Copy EDID from USB Initialize NVM...
Page 18
EN 18 TPM9.3E LA Service Modes, Error Codes, and Fault Finding Default value Item Item value 19" 22" 24" Description NVM COPY TV to USB Press OK Use this to store the NVM data to the REPAIR folder of a FAT formatted USB memory stick. The TV will write two files in the REPAIR folder of the memory stick.
Page 19
Service Modes, Error Codes, and Fault Finding TPM9.3E LA EN 19 Contents of CSM • 1.1 Set Type This information is very helpful for a helpdesk/workshop as reference for further diagnosis. In this way, it is not necessary for the customer to look at the rear of the TV-set.
Page 20
EN 20 TPM9.3E LA Service Modes, Error Codes, and Fault Finding Stepwise Start-up Standby Soft Mode Command Received, Switch previously in Standby Off(Mains Soft Mode (Power tact Standby Power Plug) switch) Digital Digital background background tasks started tasks completed TV Wakeup commands Received Standby...
Page 21
A description on how to upgrade the main 1. ComPair helps to quickly get an understanding on how to software can be found in the DFU or on the Philips website. repair the chassis in a short and effective way.
Page 22
EN 22 TPM9.3E LA Service Modes, Error Codes, and Fault Finding • FUS_clustername_version.zip: Contains the “autorun.upg” which is needed to upgrade the TV main software and the software download application. • NVM_clustername_version.zip: Default NVM content. Must be programmed via ComPair. 5.5.7 How to Copy NVM Data to/from USB When copying data to and from a USB memory stick, the folder...
Page 23
Service Modes, Error Codes, and Fault Finding TPM9.3E LA EN 23 – ERROR: 034 013 000 000 000: Error code 13 was Fault Finding and Repair Tips detected first and error code 34 is the last detected Note: (newest) error •...
Page 24
EN 24 TPM9.3E LA Service Modes, Error Codes, and Fault Finding 5.8.10 Display option code Attention: In case the SSB is replaced, always check the Panel Code in CSM, even when picture is available. Performance with the incorrect display option code can lead to unwanted side-effects for certain conditions.
Alignments TPM9.3E LA EN 25 6. Alignments Index of this chapter: In case you have a colour analyser: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyser (e.g. Minolta CA-210) in the centre of the screen. 6.3 Software Alignments Consequently, the measurement needs to be done in a 6.4 Option Settings...
Page 26
EN 26 TPM9.3E LA Alignments Option Settings 6.5.1 Reset of Repaired SSB 6.4.1 Introduction Instruction: After NVM replacement, reload MAC address via SAM menu.This ensures the correct MAC address to be available in The microprocessor communicates with a large number of I CSM for future repair actions.
Circuit Descriptions TPM9.3E LA EN 27 7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The TPM9.3E LA is a new chassis launched in Europe in 7.2 Power Supply 2012.The whole range is covered by the IC MT5366.The major 7.3 DC/DC Converters deltas versus its predecessor supports decoder and a TV 7.4 Front-End Analogue and DVB-T, DVB-C reception...
Page 28
EN 28 TPM9.3E LA Circuit Descriptions 7.1.3 SSB Cell Layout DC/DC COMMON INTERFACE MT5366 CLASS-D TUNER SCART NETWORK SERVICE CONNECTOR Headphone ANALOG I/O HDMI SWITCH HDMI 19270_200_120401.eps 120412 Figure 7-1 SSB layout cells (top view) back to 2013-Mar-01 div. table...
Page 29
This part is available in the regular The following displays can be distinguished: market. • CCFL/EEFL backlight: power board is conventional IPB Consult the Philips Service web portal for the order codes of the • LED backlight: boards. - side-view LED without scanning: PSL power board - side-view LED with scanning: PSLS power board Important delta’s with the S35 series platform are:...
Page 30
EN 30 TPM9.3E LA Circuit Descriptions Connector Number CN8101 CN8102 CN8103 CN901 CN9101 Description to panel to panel to panel Mains inlet to SSB Not connected Not connected Pdim On/Off inverter DC/DC Converters The on-board DC/DC converters at the SSB deliver the following voltages (depending on set execution): •...
Page 31
Circuit Descriptions TPM9.3E LA EN 31 MT5366CVNG TMDS361B RX3 RX2 19240_206_120224.eps RX3 RX2 120224 CN5004 CN5002 Figure 7-6 Front-End DVB-T2 DTV block diagram 19240_208_120224.eps Front-End DVB-S(2) reception 120501 The Front-End for the DVB-S(2) application consist of the following key components: Figure 7-8 HDMI input configuration •...
Page 32
EN 32 TPM9.3E LA Circuit Descriptions Back-End The back-end of this chassis is integrated in the main processor and is connected via LVDS to the 50 Hz LED back lit LCD panel. Refer to section 7.2.2 Diversity for an in-depth explanation of the different power boards that are used.
IC Data Sheets TPM9.3E LA EN 33 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 34
EN 34 TPM9.3E LA IC Data Sheets Pinning information MT5366CV [1/2] 19080_301_110316.eps 120102 Figure 8-2 Pin configuration [1/2] back to 2013-Mar-01 div. table...
Page 35
IC Data Sheets TPM9.3E LA EN 35 Pinning information MT5366CV [2/2] 19080_302_110316.eps 120102 Figure 8-3 Pin configuration [2/2] back to 2013-Mar-01 div. table...
Page 36
EN 36 TPM9.3E LA IC Data Sheets Diagram 10-3-1 System Power 1 B01, TPS54319RTE (IC U7004) Block diagram PWRGD Shutdown Thermal UVLO Shutdown Enable Comparator Logic Shutdown Shutdown Logic 107% Enable Threshold Boot Voltage Charge Reference Boot Minimum Current UVLO COMP Clamp Sense ERROR...
Page 37
IC Data Sheets TPM9.3E LA EN 37 Diagram 10-3-6 Speaker B06, STA381BWTR (IC U6002) Block diagram STA381BW OUT 1A OUT 1B 2.1 Channel Half MCLK OUT 2A Audio Processor Bridges OUT 2B Modulator STAudioFx FFX3A LRCKI STSpeakerSafe FFX3B Parametric EQ BICKI Binary Volume...
Page 38
EN 38 TPM9.3E LA IC Data Sheets Diagram 10-3-12 GPIO & RJ45 B12, RTL8201FL-VB-CG (IC U4010) Block diagram RTL8201FL Pinning information RTL8201FL 19240_302_120221.eps 120221 Figure 8-6 Internal block diagram and pin configuration back to 2013-Mar-01 div. table...
Block Diagrams TPM9.3E LA EN 43 9. Block Diagrams Wiring diagram 19PFL3507 WIRING DIAGRAM 19" (S35) Board Level Repair Component Level Repair Only for authorized workshops to panel CN4012 (1053) MAIN POWER SUPPLY USB 2 (1054) USB 1 SERV.U TV ANTENNA AUDIO IN DVI/VGA SCART...
Block Diagrams TPM9.3E LA EN 44 Wiring diagram 22PFL3507H WIRING DIAGRAM 22" (S35) Board Level Repair Component Level Repair Only for authorized workshops to panel CN4010 (1053) MAIN POWER SUPPLY (1054) USB2 USB1 SERV .U SCART TV ANTENNA (RGB/CVBS) AUDIO IN DVI/VGA CVBS/Y Pb HDMI...
Block Diagrams TPM9.3E LA EN 45 Wiring diagram 22PFL3507T WIRING DIAGRAM 22" (S35) Board Level Repair Component Level Repair Only for authorized workshops to panel CN4010 (1053) MAIN POWER SUPPLY (1054) USB2 USB1 SERV .U SCART TV ANTENNA (RGB/CVBS) AUDIO IN DVI/VGA CVBS/Y Pb HDMI...
Block Diagrams TPM9.3E LA EN 46 Wiring diagram 22PFL3557H WIRING DIAGRAM 22" (S35) Board Level Repair Component Level Repair Only for authorized workshops to panel CN9101 CN4012 MAIN POWER SUPPLY (1054) (1053) USB2 DVD MODULE (1187) USB1 SCART (RGB/CVBS) TV ANTENNA SERV .U AUDIO IN DVI/VGA...
Page 47
Block Diagrams TPM9.3E LA EN 47 Wiring diagram S35 24" WIRING DIAGRAM 24" (S35) Board Level Repair Component Level Repair Only for authorized workshops to panel CN4012 (1053) MAIN POWER SUPPLY (1054) USB 2 USB 1 SERV.U TV ANTENNA SCART (RGB/CVBS) AUDIO IN DVI/VGA...
Circuit Diagrams and PWB Layouts TPM9.3E LA EN 57 10.3 B 715G5430 SSB S35 series 10-3-1 System Power 1 System Power 1 ANALOG POWER AVDD1V2 from AVDD3V3 PWR_ON/OFF PWR_ON/OFF 3 STANDBY POWER +5VSB from STB_PWR5V OPWRSB OPWRSB BRIGHT_ADJ BRIGHT_ADJ 11 INVERTER_ON_OFF AVDD3V3 INVERTER_ON_OFF 11...
Page 58
Circuit Diagrams and PWB Layouts TPM9.3E LA EN 58 10-3-2 System Power 2 System Power 2 PANEL_VCC_ON/OFF PANEL_VCC_ON/OFF TUNER POWER +5V_TUNER PANEL_VCC PANEL POWER PANEL_VCC form +12V 2,4,5,6,7,8,9,10,11,12,13,14,15,16,17 from +16V via 12V_TUN +5V_SW +12V PWR_ON/OFF R7021 PWR_ON/OFF 2 Q7004 NC/0R05 4A 1/4W R7026 R7030 AON4421...
Circuit Diagrams and PWB Layouts TPM9.3E LA EN 75 10.4 B 715G5475 SSB (for TVs with DVD) 10-4-1 System Power 1 System Power 1 ANALOG POWER AVDD1V2 from AVDD3V3 PWR_ON/OFF PWR_ON/OFF 3 STANDBY POWER +5VSB from STB_PWR5V OPWRSB OPWRSB BRIGHT_ADJ BRIGHT_ADJ 11 INVERTER_ON_OFF AVDD3V3...
Page 76
Circuit Diagrams and PWB Layouts TPM9.3E LA EN 76 10-4-2 System Power 2 System Power 2 PANEL_VCC_ON/OFF PANEL_VCC_ON/OFF TUNER POWER +5V_TUNER PANEL_VCC PANEL POWER PANEL_VCC from +5V_SW 2,4,5,6,7,8,9,10,11,12,13,14,15,16,17 from +16V via 12V_TUN +5V_SW +12V PWR_ON/OFF PWR_ON/OFF 2 R7021 Q7004 0R05 4A 1/4W R7030 R7026 AON4421...
Circuit Diagrams and PWB Layouts TPM9.3E LA EN 93 10.5 B 715G5155 SSB 3000/3500 series 10-5-1 System Power 1 System Power 1 ANALOG POWER AVDD1V2 from AVDD3V3 PWR_ON/OFF PWR_ON/OFF 3 STANDBY POWER +5VSB from STB_PWR5V OPWRSB OPWRSB BRIGHT_ADJ BRIGHT_ADJ 11 INVERTER_ON_OFF DC POWER INPUT AVDD3V3...
Page 94
Circuit Diagrams and PWB Layouts TPM9.3E LA EN 94 10-5-2 System Power 2 System Power 2 PANEL_VCC_ON/OFF PANEL_VCC_ON/OFF 13 TUNER POWER +5V_TUNER 2,4,5,6,7,8,9,10,11,12,13,14,15,16,17 PANEL_VCC PANEL POWER PANEL_VCC from +12V from +16V via 12V_TUN +5V_SW +12V PWR_ON/OFF PWR_ON/OFF 2 R7021 Q7004 NC/0R05 4A 1/4W R7026 R7030...
Styling Sheets TPM9.3E LA EN 119 11.3 S35 series 22" with DVD S35 series 22" with DVD 1053 1054 1185 0031 0041 1187 1185 1057 0032 1050 Pos No. Description Remarks 0050 0031 Front bezel 0032 Deco bezel 1056 0041 Rear cover 0050 Stand assembly...
Page 120
Styling Sheets TPM9.3E LA EN 120 11.4 S35 series 24" S35 series 24" 1185 0041 1054 1057 0031 1185 0050 1050 Pos No. Description Remarks 0031 Front bezel 0041 Rear cover 1056 0050 Stand assembly 1050 Display panel 1053 Panel SSB 1054 Power Supply Unit 1056...