SERVICE MANUAL AUDIO/VIDEO CONTROL RECEIVER MB534 2006 RX-D205SJ,RX-D206BJ, RX-D206BC Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade) TABLE OF CONTENTS PRECAUTION............... . . 1-3 SPECIFIC SERVICE INSTRUCTIONS .
Page 2
SPECIFICATION Amplifier 110 W per channel, min. RMS, driven into 6 Ω at 20 Hz to 20 kHz with no more Output Power At stereo operation Front channels than 0.8% total harmonic distortion. 110 W per channel, min. RMS, driven into 6 Ω at 1 kHz with no more than 0.8% At surround operation Front channels total harmonic distortion.
SECTION 1 PRECAUTION Safety Precautions (1) This design of this product contains special hardware and voltmeter. many circuits and components specially for safety purpos- Move the resistor connection to each exposed metal es. For continued protection, no changes should be made part, particularly any exposed metal part having a return to the original design unless authorized in writing by the path to the chassis, and measure the AC voltage across...
SECTION 3 DISASSEMBLY Main body section 3.1.1 Removing the top cover (See Figs.1 and 2) (1) From the both sides of the main body, remove the four screws A attaching the top cover. (See Fig.1) Top cover (2) From the back side of the main body, remove the six screws B attaching the top cover.
Page 7
3.1.3 Removing the fan motor (See Fig.4) • Remove the top cover. Fan bracket Main amplifier board Reference: Remove the tie band bundling the wires. (1) From the top side of the main body, disconnect the wire Fan motor on the main amplifier board. from the connector CN103 (2) Remove the three screws D and take out the fan motor as-...
Page 8
3.1.8 Removing the speaker terminal 1 and 2 board (See Fig.7) • Remove the top cover, tuner, compulink board and rear panel. (1) From the top side of the main body, disconnect the wires CN261 CN262 from the connectors (CN261, CN461) on the speaker ter- CN461 CN263 minal 1 board.
Page 9
3.1.10 Removing the primary board (See Fig.9) • Remove the top cover. Primary board Reference: Remove the tie band bundling the wires. Main amplifier board (1) From the top side of the main board, remove the wires from CN120 CN121 CN111 CN105 the connectors (CN120, CN121) on the primary board.
Page 10
3.1.12 Removing the volume board (See Fig.10) • Remove the top cover, tuner, compulink board, rear panel, DSP board and video board. Connect board Volume board (1) From the top side of the main body, disconnect the connec- CN524 CN413 CN503 CN413 on the main amplifier board from the volume...
Page 11
3.1.15 Removing the main amplifier board (See Figs.11 and 12) • Remove the top cover, tuner, compulink board, rear panel, DSP board, video board and volume board. Main amplifier board (1) From the top side of the main body, disconnect the wires CN111 Front input board from the connectors (CN261, CN262, CN263) on the...
Page 12
3.1.18 Removing the front panel assembly (See Figs.14 and 15) • Remove the top cover. Front panel assembly Reference: Remove the tie bands and wire holder bundling the wires. Front input board (1) From the top side of the main body, disconnect the card on the regulator board 1.
3.1.19 Removing the front input board (See Fig.16) • Remove the top cover and front panel assembly. From the inside of the front panel assembly, remove the two Front panel assembly screws W attaching the front input board. CN913 3.1.20 Removing the JOG board FL board (See Figs.16 and 17) •...
Page 14
Victor Company of Japan, Limited Audio/Video Systems Category 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.MB534) Printed in Japan...
Page 15
SCHEMATIC DIAGRAMS AUDIO/VIDEO CONTROL RECEIVER RX-D205SJ,RX-D206BJ,RX-D206BC CD-ROM No.SML200605 Lead free solder used in the board (material : Sn-Ag-Cu, melting point : 219 Centigrade) Contents Block diagrams Standard schematic diagrams Printed circuit boards 2-19 to 28 No.MB534SCH COPYRIGHT 2006 Victor Company of Japan, Limited.
Page 16
In regard with component parts appearing on the silk-screen printed side (parts side) of the PWB diagrams, the parts that are printed over with black such as the resistor ( ), diode ( ) and ICP ( ) or identified by the " " mark nearby are critical for safety.
Page 46
Victor Company of Japan, Limited Audio/Video Systems Category 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.MB534SCH)
Page 47
PARTS LIST RX-D205SJ,RX-D206BJ,RX-D206BC * All printed circuit boards and its assemblies are not available as service parts. - Contents - 3- 2 Exploded view of general assembly and parts list (Block No.M1) 3- 6 Electrical parts list (Block No.01~03) 3-20 Packing materials and accessories parts list (Block No.M3)
Page 48
Exploded view of general assembly and parts list Block No. Regulator board 2 FL board Front input board JOG board...
Page 50
Block No. [M][1][M][M] Symbol No. Part No. Part Name Description Local LV11052-029A FRONT PANEL D205SJ LV11052-030A FRONT PANEL D206BJ,D206BC LV43338-002A JVC MARK LV43622-002A FOOT (x2) LV35714-001A SOURCE INDICATO LV21918-005A LIGHT LENS D205SJ LV21918-006A LIGHT LENS D206BJ,D206BC LV30225-0P9A SPACER (x2)
Page 51
Symbol No. Part No. Part Name Description Local QYSDSG3008MA TAP SCREW M3 x 8mm(x4) D206BJ,D206BC LV44151-007A ROTARY KNOB ASS (x2) D205SJ LV44151-008A ROTARY KNOB ASS (x2) D206BJ,D206BC LV30225-0M7A SPACER (x2) LV30225-0M7A SPACER LV30227-026A SPACER LV30227-056A SPACER QMF51U1-2R0-J8 FUSE F101 2A AC125V QMF51U1-2R0-J8 FUSE...
Page 52
Electrical parts list Front board Symbol No. Part No. Part Name Description Local Block No. [0][1] C108 QFLC1HJ-473Z M CAPACITOR 0.047uF 50V J Symbol No. Part No. Part Name Description Local C109 QFLC1HJ-473Z M CAPACITOR 0.047uF 50V J C110 QETN1HM-227Z E CAPACITOR...
Page 53
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R110 NRSA02J-104X MG RESISTOR 100kΩ 1/10W J CN205 QGA2001C1-06 CONNECTOR W-B (1-6) R151 QRL01DJ-100X OMF RESISTOR 10Ω 1W J CN206 WJK0208-003A-E E-SI C WIRE ...
Page 54
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local IC361 IRS20124S-X D401 1SS355W-X DIODE IC401 JCV8015-X D451 1SS355W-X DIODE IC451 IRS20124S-X D801 1SS355W-X DIODE IC461 IRS20124S-X D851 1SS355W-X DIODE IC801 JCV8015-X ...
Page 55
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C269 QFVM2AJ-104Z MF CAPACITOR 0.1uF 100V J C452 NCB31CK-105X C CAPACITOR 1uF 16V K C270 NCB31HK-102X C CAPACITOR 1000pF 50V K C453 NCB21EK-334X C CAPACITOR 0.33uF 25V K...
Page 56
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C1127 QETN1CM-107Z E CAPACITOR 100uF 16V M C1369 QFVM2AJ-104Z MF CAPACITOR 0.1uF 100V J C1151 QETN1EM-476Z E CAPACITOR 47uF 25V M C1370 NCB31HK-102X C CAPACITOR 1000pF 50V K...
Page 57
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R236 NRSA63J-0R0X MG RESISTOR 0Ω 1/16W J R362 NRS144J-470X MG RESISTOR 47Ω 1/4W J R241 NRSA63J-105X MG RESISTOR 1MΩ 1/16W J R364 NRS016J-220X MG RESISTOR 22Ω...
Page 58
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R832 NRSA63J-104X MG RESISTOR 100kΩ 1/16W J R1203 NRSA63J-0R0X MG RESISTOR 0Ω 1/16W J R833 NRSA63J-472X MG RESISTOR 4.7kΩ 1/16W J R1205 NRSA63J-155X MG RESISTOR 1.5MΩ...
Page 59
IC911 PCM2704DB-X L1101 QQL78AK-220 COIL 22uH K IC912 SN74AHC1G08V-X L1102 QQL78AK-220 COIL 22uH K L1261 QQL77AK-220 COIL 22uH K Q501 2SC3576-JVC-T TRANSISTOR L1361 QQL77AK-220 COIL 22uH K Q503 2SC3576-JVC-T TRANSISTOR L1461 QQL77AK-220 COIL 22uH K Q504 2SC3576-JVC-T TRANSISTOR Q505 RT1P441C-X...
Page 60
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local Q1551 2SC3928A/RS/-X TRANSISTOR C529 NCB31CK-104X C CAPACITOR 0.1uF 16V K Q1561 2SC3928A/RS/-X TRANSISTOR C530 NCB31CK-104X C CAPACITOR 0.1uF 16V K Q2101 2SD2114K/VW/-X TRANSISTOR C531 QEKC1HM-475Z...
Page 61
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C2133 NDC31HJ-330X C CAPACITOR 33pF 50V J C2614 NCB31HK-102X C CAPACITOR 1000pF 50V K C2134 NDC31HJ-330X C CAPACITOR 33pF 50V J C2621 NCB31CK-104X C CAPACITOR 0.1uF 16V K...
Page 62
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local C4515 NCB31CK-104X C CAPACITOR 0.1uF 16V K R555 NRSA63J-105X MG RESISTOR 1MΩ 1/16W J C5501 QEKC1HM-475Z E CAPACITOR 4.7uF 50V M R556 NRSA63J-221X MG RESISTOR 220Ω...
Page 63
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R1564 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R2242 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R1565 NRSA63J-101X MG RESISTOR 100Ω 1/16W J R2243 NRSA63J-102X MG RESISTOR 1kΩ...
Page 64
Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local R2608 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R2771 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R2611 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R2772 NRSA63J-105X MG RESISTOR 1MΩ...
Page 65
Symbol No. Part No. Part Name Description Local R5534 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R5535 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R5536 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R5537 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R5538 NRSA63J-0R0X MG RESISTOR 0Ω...
Page 66
Packing materials and accessories parts list Block No. No additional / supplemental order of WARRANTY CARDs are available RX-D205SJ RX-D206BC RX-D206BJ A1 A2 A3 A1 A3 A4 A6 A7 A6 A7 RX-D205SJ RX-D206BJ 3-20...
Page 67
Packing and Accessories Block No. [M][3][M][M] Symbol No. Part No. Part Name Description Local LVT1556-001A INST BOOK D205SJ,D206BJ LVT1556-002A INST BOOK ENG FRE D206BC BT-51034-2 REGISTRATION CARD D205SJ,D206BJ YU20333 SAFETY INST. ------------ WARRANTY CARD BT-52006-2 D206BC ------------ BATTERY 1.5V(x2) QAL0457-001 ANT.WIRE QAL0476-002...