Page 1 owner's mat...
Page 4 Wearing a safety belt correctly is one your passengers can kformation about safety belt usage, air 'ages vehicle adjust the seats. d through pages to learr, these ling, defogging and defrosting features in your veh clock, To set e on the :onds, press and hold the S gppears.
Page 5 Supplement to the 1998 Chevrolet Cavalier and Pontiac Sunfire Owner’s Manual This information replaces the “Instrument Panel Fuse Block” and “Engine Compartment Fuse Block” information found on pages 6-59 through 6-62 in Section 6 o f your Owner’s Manual. Part No. 226...
Page 6 Fuse...
Page 7 Fuse Usage Remote Keyle,ss.Entry .RADIO Radio, ALARM Alarm Module -.Interior.Lamps, Warning Chimes CRUISE Cruise. Control STOPIHAZ Exterior Lamps, Anti-Lock :.Brakesystem, Cruise, Turn Signals Cigarette Lighter INST LPS ,Instrument; Panel, Lights, ,,J&-ning, Chimes PCM/ICiN Powertrain, Control L:HDLP Left Headlamp,. Fog Lamp (z-~~..Mo&I Oniyj Fuse...
Page 8 Engine Compartment Fuse Block The engine compartment fuse block driver’s side of the engine compartment. Lift off the cover check fuses. Fuse BATT located BATT COOLING FAN ABS/EVO Usage Ignition Switch Circuits Yower ACC/Stoplamp Circuits Lighting Circuits Anti-Lock Brake System Engine Cooling Fan A/C Blower Heater...
Page 9 picture of the in this section is The location of the features and controls you w e r Boor Locks AM-FM Stereo AM-FM Stereo with Cassette Tape Player AM-FM with Cassette Tape Play&%~ Stereo AM-FM Stereo with Compact Disc Player overall instrument panel haat rnfi...
Page 10 to turn on your hazara jump start your vehicle your vehicle should be tu-t;u What to do if your engine overheats change a flat tire...
Page 11 This section tells you when to perform vehicle maintenance and what fluids and lubricants to use. Customer Assistance Information This section tells you how to contact Pontiac for assistance and how to get service and owner publications. It also gives you information on “Reporting Safety Defects” on page 8-10.
Page 12: For Canadian Owners Who Prefer A French Language Manual
GENERAL MOTORS, GM, the GM Emblem, PONTIAC, the PONTIAC Emblem and the name SUNFIRE are registered trademarks of General Motors Corporation. This manual includes the latest information at the time it was printed. We reserve the right to make changes in the product after that time without further notice.
Page 13: How To Use This Manual
How to Use this Manual Many people read their owner’s manual from beginning to end when they first receive their new vehicle. If you do this, it will help you learn about the features and controls for your vehicle. In this manual, you’ll find that pictures and words work together to explain things quickly.
Page 14: Vehicle Damage Warnings
Vehicle Damage Warnings Also, in this book you will find these notices: These mean there is something that could In the notice area, we tell you about something that can damage your vehicle. Many times, this d m a g e would not be covereld by your warranty, and it could be costly.
Page 15 Vehicle Symbols These are some of the symbols you These symbols For example, are important these symbols for you and are used on an your passengers original battery: whenever your vehicle is CAUTION driven: POSSIBLE INJURY PROTECT EYES BY SHIELDING CAUSTIC &...
Page 17: Section 1 Seats And Restraint Systems
Section 1 Seats and Restraint Systems Here you’ll find information about the seats in your Pontiac and how to use your safety belts properly. You can also learn about some things you should not do with air bags and safety belts.
Page 18: Seats And Seat Controls
Seats and Seat Controls This section tells you about the seats & e m adjust also about reclining seatbacks head restraints. Manual Front Seats You can lose control of the vehicle if you! try to driver’s seat adjust a manual while the vehicle is moving.
Page 19 If your vehicle is not equipped with easy entry seats, your passenger seat adjuster looks like this. Slide the lever under the passenger’s seat to the right to unlock it. Slide the seat to where you want it. Then release the lever and try to move the seat with your body, to make sure the seat is locked into place.
Page 20: Manual Lumbar Support (If Equipped)
Manual Lumbar Support (If Equipped) The manual lumbar support control is located at the front of driver’s toward the right. Turn the knob seat, the right or left to increase or decrease the amount of support to your lower back. Reclining Front Seatbacks To adjust lift the lever on the outer...
Page 21: Head Restraints
Sitting in a reclined position when your vehicle is in motion can be dangerous. Even if you buckle up, your safety belts can’t do their job when you’re reclined like this. The shoulder belt can’t do its job because it won’t be against your body.
Page 22 When you return the seatback to its original position, make sure the seatback is locked. The latch must be down the seat to properly. work locked, it the seatback isn’t forward in a sudden stop or crash. That could cause injury to the person sitting there. Always press rearward on the seatback to be sure it is locked.
Page 23: Rear Seats
Rear Seats Folding the Rear Seat To open the fold-down rear seat, pull forward on the seat tab. close seat, seatback up push the original position. Check to ensure the seatback is in its original position and securely latched by pulling forward on the top of the seatback.
Page 24 Safety Belts: They’re This part of the manual tells you how to properly. I t also tells you some things you should not with safety belts. And it explains the Supplemental Restraint System (SRS), or air bag system. Don’t let anyone ride where he or she can’t wear a safety belt properly.
Page 25: Why Safety Belts Work
In most states and Canadian provinces, the law says to wear safety belts. Here’s why: They work. know You never if you’ll be in a crash. If you do have a crash, you don’t know if it will be a bad one. few crashes are mild, and some crashes can be so serious that even buckled up a person wouldn’t survive.
Page 26 Put someone on it. Get it up to speed. Then stop the vehicle. The rider doesn’t stop. 1-10...
Page 27 or the instrument panel The person keeps going until stopped by something. In a real vehicle, it could be the windshield 1-11...
Page 28: About Safety Belts And The Answers
safety belts! With safety belts, you slow down as the vehicle does. You get more time stop. You stop over more distance, your strongest bones take the farces. That’s why safety belts make such good sense. 1-12 Here Are Questions Many People Ask About Safety Belts and the Answers Q.’...
Page 29: How To Wear Safety Belts Properly
&.’ If I’m a good driver, and I never drive far from I wear home, why should safety belts? You may be an excellent driver, but if you’re in an even one that isn’t your fault -- you and accident your passengers can be hurt.
Page 30: Driver Position
Driver Position This part describes the driver’s restraint system, Lap-Shoulder Belt The driver has a lap-shoulder belt. Here’s how to wear it properly. 1. Close lock the door. Adjust the seat (to see how, see “Seats” in the Index) so you can sit up straight. 1-14 Pick up the latch plate and pull the belt across you.
Page 31 If the belt stops before it reaches the buckle, tilt the latch plate and keep pulling until you can buckle the belt. Pull up on the latch plate to make sure it is secure. If the belt isn’t long enough, see “Safety Belt Extender”...
Page 32 part of the belt should be worn low and snug on just touching the thighs. In the hips, force to the strong pelvic bones. And you’d be less likely to slide under the lap belt. If you slid under it, the belt would apply force at your abdomen.
Page 33 Adjust the height so that the shoulder belt is centered on your shoulder. The belt should be away from your face and neck, but not falling off your shoulder. &: What's wrong with this? The shoulder belt is too loose. It won't give nearly as much protection this way.
Page 34 The belt buckled in the wrong place. 1-18 You can be seriously injured if your belt is bu'ckled the wrong place like this. In a crash, the belt would go up over your abdomen. The belt forces would be there, not at the pelvic bones.
Page 35 &.' What's wrong with this? The shoulder belt is worn under the arm. It should be worn over the shoulder at all times. You can be seriously injured if you wear the shoulder belt under your arm. In a crash, your body would move too far forward, which would increase the chance of head and neck injury.
Page 36 What’s wrong with this? The belt is twisted across the body. 1-20 You can be seriously injured by a twi a crash, you wouldn’t have the full width belt to spread impact forces. If a belt is twisted, make it straight so it can work properly, or ask your dealer to fix it.
Page 37 To unlatch the belt, just push the button on the buckle. The belt should go back out of the way. Before you close the door, be sure the belt is out of the way. If you slam the door on it, you can damage both the belt and your vehicle.
Page 38: Right Front Passenger Position
The best way to protect the fetus is to protect the mother. a safety belt is worn properly, it’s more When likely that the fetus won’t be hurt in a crash. For pregnant women, as for anyone, the key to making safety belts effective is wearing them properly.
Page 39 Air bags inflate with great force, faster than the blink of an eye. I f you’re too close to an inflating air bag, it could seriously injure you. This is true even with reduced-force frontal air bags. Safety belts help keep you in position before and during a crash.
Page 40: How The Air Bag System Works
How the Air Bag System Works Where are the air bags? The driver’s air bag is in the middle of the steering wheel. The right front passenger’s air bag is in the instrument panel on the passenger’s side.
Page 41 If something is between an occupant and an air bag, the bag might not inflate properly or it might force the object into that person. The path of an inflating air bag must be kept clear. Don’t put anything between an occupant and an air bag, and don’t attach or put anything on the steering wheel hub or on or near any other air bag covering.
Page 42 does an air bag restrain? In moderate to severe frontal or near-frontal collisions, even belted o~ccupants can contact the steering wheel or A i r bags supplement the protection the instrument panel. provided by safety belts. Air bags distribute the force of impact more evenly over the occupant’s upper body, stopping the occupant more gradually.
Page 43: Servicing Your Air Bag-Equipped Vehicle
Your vehicle equipped with diagnostic module, which records information about the bag system. The module records information about the readiness of the system, when the sensors are activated and driver’s safety belt usage at deployment. Let only qualified technicians work on your air bag system.
Page 44: Rear Seat Passengers
For up to 10 minutes after the ignition key is turned off and the battery is disconnected, an air bag can still inflate during improper service. You can be injured if you are close to an air bag when connectors. They are it inflates.
Page 45 Lap-Shoulder Belt The positions next to the windows have lap-shoulder belts. Here’s how to wear one properly. 1. Pick up the latch plate and pull the belt across you. Don’t let it get twisted. The shoulder belt may lock if you pull the belt across you very quickly.
Page 46 3. To make the lap part tight, pull down on the buclde end of the belt as you pull up on the shoulder part. The lap part of the belt should be worn low and snug on the hips, just touching the thighs. In a crash, this applies force to the strong pelvic bones.
Page 47 The safety belt locks if there’s a sudden stop or a crash, or if you pull the belt very quickly out of the retractor. be seriously hurt if your shoulder belt is You can too loose. In a crash, you would too much, which could increase injury.
Page 48: Rear Safety Belt Comfort Guides For Children And Small Adults
Rear Safety Belt Comfort Guides for Children and Small Adults Rear shoulder belt guides will provide added comfort comfort for who have safety b'elt children child restraints and for small adults. When installed on a shoulder belt, the comfort guide pulls the belt away from the neck head.
Page 49 2. Slide the guide under and past the belt. The elastic cord must be under the belt. Then, place the guide over the belt, and insert the two edges of the belt into the slots of the guide. 3. Be sure that the belt is not twisted and it lies flat. The elastic cord must be under the belt and the guide on top.
Page 50: Center Passenger Position
4. Buckle, position and release the safety belt as described in “Rear Seat Outside Passenger Positions” earlier in this section. Make sure that the shoulder belt crosses the shoulder. 1-34 To remove and store the comfort guides, squeeze the belt edges together so that you take them out from guides.
Page 51 Lap Belt When you sit in the center seating position, you have a lap safety belt, which has no retractor. To make the belt longer, tilt the latch plate and pull it along the belt. To make the belt shorter, pull its free end as shown until the belt is snug.
Page 52: Smaller Children And Babies
Children Everyone in a vehicle needs protection! That includes infants and children smaller than adult size. Neither the distance traveled nor the age changes the need, for everyone, to use safety restraints. In fact, the law in every state in the United States and in every Canadian province says children up to must be restrained while in a vehicle.
Page 53 Smaller children and babies should always be child or infant restraint. The restrained in instructions for the restraint will say whether it is th’e right type and size for your child. A very young child’s hip bones are so small that a regular belt might not stay low on the hips, as it should.
Page 54 Never hold baby in your arms while riding in a vehicle. A baby doesn’t weigh much crash, During a crash a baby will become so heavy you can’t hold For example, in CAUTION: (Continued) 1-38 at only mph (40 will suddenly become a 240-1b. (110 kg) force on your arms.
Page 55: Child Restraints
Child Restraints Every time infants and young children ride in vehicles, they should have protection provided by appropriate restraints. What are the different types of add-on child restraints? Add-on child restraints are available in four basic types. When selecting a child restraint, take into consideration not only the child’s weight and size, but also whether or not the restraint will be compatible with the motor vehicle in which it...
Page 56 A rear-facing infant restraint (B) positions face the rear of the vehicle. Rear-facing infant. restraints are designed for infants of up to about 20 Ibs. (9 kg) and about one year of of restraint faces the rear that the infant’s head, neck and body have the...
Page 57 A forward-facing child restraint (C-E) positions a child upright to face forward in the vehicle. These forward-facing restraints are designed to help protect children who are from 20 to 40 lbs. (9 to 18 kg) and about 26 to 40 inches (66 to 102 cm) in height, or up to around four years of age.
Page 58 1-42 A booster seat (F, G) is designed for children who are about 40 to 60 lbs. (1 8 to 27 kg) and about eight years age. It’s designed to improve four to the fit of the vehicle’s safety belt system. Booster seats with shields use lap-only belts;...
Page 59: Where To Put The Restraint
When choosing a child restraint, be sure the child restraint is designed to be used in a vehicle. If it is, it will have a label saying that it meets Federal Motor Vehicle Safety Standards Then follow the instructions for the restraint. You may find these instructions on the restraint itself or in a booklet, or both.
Page 60: Top Strap
Pontiac to put one in dealer anchor yourself, your dealer can tell you how to do it.
Page 61 Securing Child Restraint in a Rear Outside Seat Position You’ll be using the lap-shoulder belt. See the earlier part about the top strap if the child restraint has one. Be sure to follow the instructions that carne with the child restraint.
Page 62 Buckle the belt. Make sure the release button is positioned so you would be able to unbuckle the safety belt quickly if you ever had to. 1-46 4. To tighten the belt, pull up on you push down on the child restraint. If you’re using a forward-facing child restraint, you may find it helpful to use your knee to push down on the child restraint as you tighten the belt.
Page 63: Securing A Child Restraint In The Center Rear Seat Position
To remove the child restraint, just unbuckle the vehicle’s safety belt and let it go back all the way. The safety belt will move freely again and be ready to work for an adult or larger child passenger. Securing a Child Restraint in the Center Rear Seat Position You’ll be using the lap belt.
Page 64: Securing A Child Restraint In The Right Front Seat Position
4. Buckle the belt. Make sure the release button is positioned so you would be able to unbuckle the safety belt quickly if you ever To tighten the belt, pull its free end while on the child restraint. If you're using a down forward-facing child restraint, h'elpful to use your knee to push dawn on...
Page 65 You’ll be using the lap-shoulder belt. See the earlier part about the top strap if the child restraint has one. Be sure to follow the instructions that came with the child restraint. Secure the child in the child restraint when and as the instructions say.
Page 66 4. Buckle the belt. Make sure the release button is positioned so you would be able to unbuckle the safety belt quickly if you ever had to. To tighten the belt, pull up on the shoulder belt while you push down on the child restraint. You may find it helpful to use your knee to push down on the child restraint as you tighten the belt.
Page 67: Larger Children
Larger Children Children who have outgrown child restraints should wear the vehicle’s safety belts. If you have the choice, a child should sit next to a window so the child can wear a lap-shoulder belt and get the additional restraint a shoulder belt can provide. Accident statistics show that children are safer if they are restrained in the rear seat.
Page 68 1-52 Never do this. Here children wearing the same belt. The can’t belt properly spread the impact crash, the two children can be crushed together and seriously injured. A belt must be used by only one person at a time. @’...
Page 69 Never do this. Here a child is sitting in a seat that has a lap-shoulder belt, but the shoulder part is bebind the child, If the child wears the belt in this way, in a crash the child might slide under the belt. The belt's force would then be applied right on the child's abdomen.
Page 70: Safety Belt Extender
Safety Belt Extender If the vehicle’s safety belt will fasten around you, you should use it. But if a safety belt isn’t long enough to fasten, your dealer will order you an extender. It’s free. When you go in to order it, take the heaviest coat you will wear, so the extender will be long enough for you.
Page 71: Section 2 Features And Controls
Section 2 Features and Controls Here you can learn about the many standard and optional features on your vehicle, and information on starting, shifting and braking. Also explained are the instrument panel and the warning systems that tell you if everything is working properly -- and what to do if you have a problem.
Page 72 Keys CAUTION: Leaving young children in vehicle with the ignition key is dangerous many rea,sons. A child or others could be badly injured or even killed. They could operate power windows or other move. controls or even make the vehicle Don’t leave the keys in a vehicle with young children.
Page 73 Keep the tag in a safe place. If you lose your key, you’ll be able to have a new one made easily using the tag. If you need a new key, contact your Pontiac dealer who can obtain the correct key code. Remember to carry the pre-cut emergency key which Pontiac sends after delivery (this service is not available in Canada).
Page 74: Door Locks
Door Locks Unlocked doors can be dangerous. Passengers especially children open the doors and fall out. When a door is locked, the inside handle won’t open it. Outsiders can easily enter through an unlocked door when you slow down or stop your vehicle. may not be so This obvious: You increase the...
Page 75: Power Door Locks - If Equipped
Power Door Locks (If Equipped) You can lock or unlock all doors of your vehicle from the driver’s or front passenger’s door lock switch. Push the lower portion of the switch to doors. Push the upper portion of the switch to unlock your doors.
Page 76: Leaving Your Vehicle
The rear doors of your vehicle cannot be opened from inside when this feature is in use. If you want to open a rear door when the security lock is on: 1. Unlock the door from the inside. Then open the door from the outside. If you don’t cancel the security lock older children who ride in the rear won’t be able to open...
Page 77: Operation
This device complies with RSS-210 of Industry Canada. Operation is subject to the following two conditions: (1) this device may not cause interference, and ( 2 ) this device must accept any interference received, including interference that may cause undesired operation of the device.
Page 78: Matching Transmitter(S) To Your Vehicle
Matching Transmitter(s) To Your Vehicle Each remote keyless entry transmitter is coded to prevent another transmitter from unlocking your vehicle. If a transmitter is lost or stolen, a replacement can be purchased through your dealer, Remember to bring any remaining transmitters with you when you go to your dealer.
Page 79 Replacing the Battery in the Remote Keyless Entry System Transmitter To replace the battery in the transmitter: 1. Use a small coin or flathead screwdriver to separate the bottom half from the top half of the transmitter. 2. Remove the battery and replace it with the new one. Make sure positive side...
Page 80: Remote Trunk Release (If Equipped)
Trunk It can be dangerous to drive with the trunk lid open because carbon monoxide (CO) gas can come into your vehicle. You can’t see or smell CO. It can cause unconsciousness and even death. you must drive with the trunk lid open electrical wiring or other cable connections must pass through the seal between the body and the trunk lid:...
Page 81: Key In The Ignition
Key in the Ignition you leave your vehicle with the keys inside, it’s an easy target for joy riders or professional thieves don’t do it. When you park your vehicle and open the driver’s door, you’ll hear a chime reminding you to remove your key from the ignition and take it with you.
Page 82 THEFT SYSTEM light comes on while the engine is running, a problem has been detected and the system may need service. See your dealer for service. In an emergency, call the Pontiac Roadside Assistance Center at 1-800-ROADSIDE or 1-800-742-3743. In Canada call 1-800-268-6800. 2-12 New Vehicle CCBreak-In2’...
Page 83: Ignition Positions
Ignition Positions With the ignition key in the ignition switch, you can turn the switch to five positions. ACCESSORY (A): In this position, you can operate your electrical power accessories. Press in the ignition switch as you turn it toward you. LOCK (B): This is the only position in which you can remove the key.
Page 84 manual transaxle vehicles, turning the key to LOCK will lock the steering column and result in steer a loss of ability tu the vehicle. This could cause a collision. If you need to turn the engine off while the vehicle is moving, turn the key only to OFF.
Page 85: Starting Your Engine
To restart when you’re already moving, safety use NEUTRAL (N) only. NOTICE: Don’t try to shift to PARK (P) if your Pontiac is moving. If you do, you could damage the transaxle. Shift to PARK (P) only when your vehicle is stopped.
Page 86 2. If your engine still won’t start stops), it could be flooded with too much gasoline. Try pushing your accelerator pedal all the way to the floor and holding it there as you hold the key in START for about three seconds. If the vehicle starts briefly but then stops again, do the this time keep the pedal down for five or six seconds.
Page 87 If your engine still won’t start (or starts but then stops), it could be flooded with too much gasoline. pushing your accelerator pedal all the way to the floor and holding it there as you hold the key in START for a maximum of 15 seconds. This clears the extra gasoline from the engine.
Page 88: Engine Coolant Heater (If Equipped)
Engine Coolant Heater (If Equipped) 2.4L (Code T) Engine In very cold weather, 0°F C) or colder, the engine 2.2L (Code 4) Engine coolant heater can help. You’ll get easier starting and better fuel economy during engine warm-up. Usually, the coolant heater should be plugged in a minimum of four hours prior to starting your vehicle.
Page 89: Automatic Transaxle Operation
tne Engine Coolant Heater Turn the engine. 2. Open the hood and unwrap the electrical cord. On vehicle with a 2.2L (Code 4) engine, the cord is located near the engine oil dipstick. On a vehicle with a 2.4L (Code T) engine, the cord is located in front of the air filter on the passenger’s side.
Page 90 v v v v v v N D 2 . 1 3-Speed Automatic Transaxle v v v v v N D 3 2 1 4mSpeed Automatic Transaxle 2-20 PARK (P): This position locks your front wheels. It’s the best position to use when you start your engine because your vehicle can’t move easily.
Page 91 Ensure the shift lever is fully in PARK (P) range before starting the engine. Your vehicle has a brake-transaxle shift interlock. You have to fully apply your regular brakes before you can shift from PARK ignition key is in RUN. If you cannot shift out of PARK (P), ease pressure on the shift lever shift lever all the way into PARK (P) and also release the shift lever button on...
Page 92 Forward Gears (3-Speed) DRIVE (D): This position is for normal driving. SECOND ( 2 ) : This position gives you more power but lower fuel economy. You can use SECOND (2) on hills, can help control your speed as you mountain roads, but then you would also want to use your brakes off and on.
Page 93 THIRD ( 3 ) : This position is also used for normal driving, however, it offers more power and lower fuel economy than AUTOMATIC OVERDRIVE (D). Here are some times you might choose THIRD (3) instead of AUTOMATIC OVERDRIVE (D): When driving on hilly, winding roads.
Page 94: Manual Transaxle Operation
Manual Transaxle Operation Here’s how to operate your transaxle: FIRST (I): Press the clutch pedal and shift into FIRST (1). Then, slowly let up on the clutch pedal as you press the accelerator pedal. You can shift into FIRST (1) when you’re going less than 20 mph (32‘...
Page 95: Shift Speeds
(R): REVERSE To back up, press down the clutch pedal and shift into REVERSE (R). Let up on the clutch pedal slowly while pressing the accelerator pedal. NOTICE: Shift to REVERSE only after your vehicle is stopped. Shifting to REVERSE vehicle is moving could damage Also, use REVERSE (R), along with the parking brake, for parking your vehicle.
Page 96: Parking Brake
Parking Brake The parking brake lever is located between the bucket seats. 2-26 To set the parking brake, hold the brake pedal down and pull up on the parking brake lever. If the ignition is on, the brake system warning light will come on. To release the parking brake, hold the brake pedal down.
Page 97 Shifting Into PARK (P) (Automatic Transaxle Only) It can be dangerous to get out of your vehicle if the shift lever is not fully in PARK parking brake firmly set. Your vehicle can roll. you have left the engine running, the move suddenly.
Page 98 Leaving Your Vehicle With the Engine Running (Automatic Transaxle Only) It can be dangerous to leave your vehicle with the engine running. Your vehicle could move suddenly if the shift lever is not fully in PARK (P) with the parking brake firmly set. And, if you leave the vehicle with the engine running, overheat and even catch fire.
Page 99: Shifting Out Of Park (P) (Automatic Transaxle)
Shifting Out of PARK (P) (Automatic Transaxle) Your vehicle has a brake-transaxle shift interlock. You have to fully apply your regular brakes before you can shift from PARK (P) when the ignition is in RUN. See “Automatic Transaxle” in the Index. If you cannot shift out of PARK (P), ease pressure on the shift lever push the shift lever all the way into...
Page 100: Parking Over Things That Burn
Parking Over Things That Burn Things that can burn could touch hot exhaust parts under your vehicle and ignite. Don? park over papers, leaves, dry grass or other things that can burn. 2-30 Engine Exhaust Engine exhaust can kill. It contains the gas (CO), carbon monoxide which you can’t see or...
Page 101 Running Your Engine While You’re Parked (Automatic Transaxle) It’s better not to park with the engine running. But if you ever have to, here are some things to know. CAUTION: Idling the engine with the climate control system off could allow dangerous exhaust into your vehicle (see the earlier Caution under “Engine Exhaust”).
Page 102: Power Windows - If Equipped
Windows On a vehicle with manual windows, use the window crank to open and close each window, Power Windows (If Equipped) With power windows, switches on the control each of the windows only when the ignition is on. In addition, in four-door models, each rear passenger door has a control switch for its own window.
Page 103: Tilt Wheel (If Equipped)
Tilt Wheel (If Equipped) A tilt steering wheel allows you to adjust the steering wheel before you drive. You can also raise highest level to give your legs more room when you exit and enter the vehicle. To tilt the wheel, hold the steering wheel and pull the lever.
Page 104: Turn And Lane-Change Signals
Turn and Lane Change Signals The turn signal two upward (for right) and two downward (for left) positions. These positions allow you to signal a turn or a lane change. To signal a turn, move the lever all the way up down.
Page 105: Windshield Wipers
Windshield Wipers You control the windshield wipers by moving the stalk with the windshield wiper symbol on it up or down. For a single wiper cycle, push the stalk down to MIST, then release it. The wipers will stop after one cycle. For more cycles, hold the wiper stalk down longer.
Page 106: Windshield Washer
Windshield Washer To wash your windshield, pull the stalk with the wiper symbol on it toward you time. When you release the stalk, the washers will stop. The wipers continue for approximately three cycles and will either stop will resume the speed you were using before. In freezing weather, don’t your washer until the windshield is warmed.
Page 107 Cruise control can be dangerous where you steady speed. So, can’t drive safely at don’t use your cruise control on winding roads or in heavy traffic. Cruise control can be dangerous on slippery roads. On such roads, fast changes in tire traction can cause needless wheel spinning, and you could lose control.
Page 108 3. Push in the SET button at the end of the lever and release it. L C . Take your foot off the accelerator pedal. Resuming a Set Speed Suppose you set your cruise control at a desired speed then you apply the brake or clutch pedal. This, of course, shuts off the cruise control.
Page 109 Reducing Speed While Using Cruise Control There are two ways to reduce your speed while using cruise control: Press the button at the end of the lever until you reach the lower speed you want, then release it. TO slow down in very small amounts, briefly press the button.
Page 110: Exterior Lamps
Exterior Lamps The band on the turn signal/multifunction lever controls your vehicle’s lamps. Parking Lamps This position will turn on the following: Lamps Parking Sidemarker Lamps Taillamps Instrument Panel Lights Headlamps This position will turn on the following: Headlamps Parking Lamps Sidemarker Lamps Taillamps Instrument Panel Lights...
Page 111: Daytime Running Lamps
Daytime Running Lamps Daytime Running Lamps (DRL) can make it easier for others to see the front of your vehicle during the day. DRL can be helpful in many different driving conditions, but they can be especially helpful in the short periods after dawn and before sunset.
Page 112: Interior Lamps
Interior Lamps Instrument Panel Intensity Control You can brighten or dim the instrument turning the dial left right. Turn the dial way to up all the interior courtesy lamps. Illuminated Entry you open When the lamps inside your vehicle will go on. These lamps will fade off after is turned on after all of the doors have been closed.
Page 113: Front Reading Lamps (If Equipped)
Battery Saver Front Reading Lamps (If Equipped) A front door must be opened. These lamps are located on the rearview mirror. Turn The battery saver feature will also be activated when one on and off by pressing its each switch. any door is left open.
Page 114 Mirrors Inside Daymight Rearview Mirror To reduce glare from lamps behind you, move the lever toward you to the night position. 2-44 Manual Remote Control Mirror The outside rearview mirror should be adjusted you can just of your vehicle when you are sitting in a comfortable driving position.
Page 115: Convex Outside Mirror
Power Remote Control Mirror (If Equipped) The mirror control is located on the driver’s door. Rotate the control to the right or to the left to choose mirror you want to adjust. control in direction you want Then move the mirror to move.
Page 116: Storage Compartments
Storage Compartments Center Console Storage Area TO open the center console, press the latch button and lift the lid back. To close the center console, press the lid down until clicks. Inside the storage compartment, you will find a slotted area for cassettes and compact discs.
Page 117: Convenience Net (If Equipped)
There are also cupholders for the rear seat passengers in the back of the console. Grab the cupholder cover from both sides and pull it down. Convenience Net (If Equipped) Your vehicle may have a convenience net. You’ll see it just inside the back wall of the trunk. Put small loads, like grocery bags, in the net.
Page 118: Sun Visors
To clean the center console ashtray, remove the entire ashtray and empty it, The ashtray can be placed in the the rear rear cupholder for seat passengers to use. NOTICE: Don't put papers and other things that burn into your ashtrays. If you do, cigarettes or other smoking materials could set them on fire, causing damage.
Page 119: Convertible Top (If Equipped)
Convertible Top (If Equipped) The following steps explain the proper operation of your convertible top. NOTICE: Remove any items from the convertible top storage area before you lower the top. Even small items in the storage area can damage the top other parts the system.
Page 120 5. Pull the latch handle rearward away from the the latch handle up to the locked position. Rotate windshield and hold it until the convertible top is fully lowered.
Page 121: Installing The Boot
Installing the Boot From inside the vehicle, pull the tab on the rear seat to fold down the seat. See “Fold-Down Rear Seat” in the Index. Open the and remove both boot side covers. trunk Leave the open. trunk 3. Install the boot side cover by inserting the tab (A) on the underside of the cover into the slot (B) at the top of the quarter trim panel.
Page 122 4. Attach the two snaps on the inside flap of the side cover, to side 'of the quarter trim panel. Attach front snap (E) first and then the rear snap (F). The rear snap is adjustable for ease of installation. 2-52 the bout center cover from behind the rear 5 .
Page 123: Removing The Boot
Go to the rear of the vehicle. Place the boot center cover flap along the trunk lid opening. Align one snap on the corner of the boot to the ball stud and push forward. Repeat for the other snap, Close the trunk lid. Raise the rear seatback to the up position.
Page 124 Pull. to the rear of the vehicle. rearward to disengage the rear center cover. boot behind Carefully tuck center seatback. Make sure that the center cover is not covering seatback latch. the rear center boot rearward to keep it seatback hinge. knobs the snap 5.
Page 125 Lift the side cover eyelet at the rear of the side boot cover from the snap ball stud back of the boot side cover to unhook the tab from the slot (B) in the quarter same on the other side. 7.
Page 126: Raising The Convertible Top
Raising the Convertible Top 1. Set the parking brake and shift your automatic transaxle to PARK (P) or your manual transaxle (N). to NEUTRAL Turn the ignition to RUN. 3. Lower the door windows to avoid wear to the weather strips, 2-56 Push the button in the latch handle and rotate the handle down.
Page 127 Lowering the Top Manually NOTICE: Do not attempt to lower the top manually damage to the vehicle will occur. If the top fails to raise or lower complletely, see “Raising the Top Manually” following. Raising the Top Manually your vehicle loses power, or something else happens that prevents you from raising the top electrically, you the top manually.
Page 128 4. Press the bypass switch down to the EMERGENCY OVERRIDE position. The switch is located under the shelf panel the driver’s side in the 5. Remove as described in the top boot 7 in “Removing the Boot” earlier 6. Lower the door windows completely. If the power work, leave the doors open.
Page 129 Pull down on the and rotate to lock the convertible top. Be sure the top is securely latched on both sides. Press the bypass switch up to the NORMAL OPERATION position. Close the trunk. handle up latch 2-59...
Page 130: Instrument Panel
Instrument Panel...
Page 131 Your instrument panel is designed to let you know at a glance how your vehicle is running. You'll how fast you're going, how much fuel and economically. The main components of your instrument panel are: 1. Instrument Panel Intensity Control 2.
Page 132: Instrument Panel Cluster
Instrument Panel Cluster v v v v v v v P R N D 3 2 1 I n n UNLEARED BRAKE FUEL ONLY...
Page 133 Speedometer and Qdometer Your speedometer lets you see your speed in both miles per hour (mph) and kilometers per hour odometer shows how far your vehicle has been driven, in either miles (used in the United States) or kilometers (used in Canada). You may wonder what happens if your vehicle needs a new odometer installed.
Page 134: Warning Lights, Gages And Indicators
Tachometer The tachometer displays the engine speed in revolutions per minute (rpm). 1000 NOTICE: Do not operate the engine with the tachometer in the red area, or engine damage may occur. Warning Lights, Gages and Indicators This part describes the warning lights and gages that may be on your vehicle.
Page 135: Safety Belt Reminder Light
Safety Belt Reminder Light When the key is turned to or START, a chime will come on for about eight seconds to remind people to fasten their safety belts, unless the driver’s safety belt is already buckled. The safety belt light will also come on and stay on for about 20 seconds, then it will flash for about...
Page 136: Battery Light
Battery Light The battery light will come on when you turn on the ignition, and the engine is I-fl not running, as a check to show you Then it should the engine starts. it stays or comes on while you are driving, you may have a problem with the electrical charging system.
Page 137: Anti-Lock Brake System Warning Light
If the light comes on while you are driving, pull off the road and stop carefully. You may notice that the pedal is harder to push. Or, the pedal may go closer to the floor. It may take longer to stop. If the light is still on, have the vehicle towed for service.
Page 138: Warning Light
Enhanced Traction System (If Equipped) With the Enhanced Traction System (ETS), light shlould come on b’riefly as you If the warning light doesn’t come on then, have it fixed it will be ready w m you if there’s If the warning light stays on, or comes on when you’re driving, there may be a problem with your Enhanced Traction System m d your vehicle may need service.
Page 139: Enhanced Traction System Active Light
Enhanced Traction System Active Light When your Enhanced Traction System wheel spin, this light will come on. TRAC Slippery road conditions may exist if the Enhanced Traction System active light comeson, so adjust your driving accordingly. The light will stay on for a few seconds after the Enhanced Traction System stops limiting wheel spin.
Page 140: Low Coolant Warning Light
Low Coolant Warning Light If this light stays on, your system is low on coolant and the engine may overheat. See “Engine Coolant” in the Index and have your as soon as you can. vehicle serviced Malfunction Indicator Lamp (Check Engine Light) Your vehicle is equipped with a computer which monitors operation of the...
Page 141 This light will also come on during a malfunction in one of two ways: Light Flashing A misfire condition has been detected. A misfire increases vehicle emissions and may damage the emission control system on your vehicle. Dealer or qualified service center diagnosis and service may be required.
Page 142: Oil Pressure Light
Have you recently changed brands of fuel? If so, be sure to fuel your vehicle with quality fuel (see “Fuel”’ in the Index). Poor fuel quality will cause your engine not to run as efficiently as designed. You may notice this as stalling after start-up, stalling.when put the vehicle into gear, misfiring, hesitation on acceleration stumbling on acceleration.
Page 143 Don’t keep driving if the oil pressure is low. If you do, your engine can become so hot that catches fire. You or others could be burned. Check your oil as as possible and have your soon vehicle serviced. NOTICE: Damage to your engine fiom neglected problems can be costly and is not covered by your warranty.
Page 144 Check Gages Light This light will come on briefly when you are starting the engine. CHECK GAGES the light comes on and stays on while you your various driving, check gages to see if they are in the warning zones or if you are low on fuel, Fuel Gage When the ignition is on, your fuel gage tells you...
Page 145: Section 3 Comfort Controls And Audio Systems
Section 3 Comfort Controls and Audio Systems In this section, you'll find out how to operate the comfort control and audio systems offered with your vehicle. Be sure to read about the particular systems supplied with your vehicle. Comfort Controls Air Conditioning (If Equipped) Heating Ventilation System...
Page 146: Comfort Controls
Comfort Controls This section tells how to make your air system work for yon. The optional climate control system with air conditioning uses ozone-friendly R- 134a refrigerant. With these systems, you can control the ventilation and heating in your vehicle. Your vehicle also has the flow-through ventilation system described later in this section.
Page 147 BI-LEVEL: This setting brings in outside air and directs it two ways. Some is directed through the instrument panel outlets. Most of the air is directed through the floor ducts and a little to the defrost and side window vents. + ’...
Page 148 e Knob The center knob changes the temperature of the air coming through the system. Turn this knob toward red (to the right) for warmer air. Turn it toward blue (to the left) for cooler air. Mode Knob The right knob has several settings to control the direction of airflow.
Page 149: Air Conditioning (If Equipped)
Air Conditioning (If Equipped) On very hot days, open the windows long enough to let hot inside escape. This reduces the time it takes for your vehicle to cool down, which should help fuel economy. For quick cool-down on very hot days, use MAX with the temperature knob all the way in the blue area.
Page 150: Defogging And Defrosting
Ventilation Tips Keep the hood and front air inlet free of ice, snow or any other obstruction, such as leaves. The heater and defroster will work far better, reducing the chance of fogging the inside of your windows. When you enter vehicle in cold weather, adjust the FLOOR the fan...
Page 151: Rear Window Defogger (If Equipped)
Rear Window Defogger (If Equipped) The rear window defogger uses a warming grid to remove fog from the rear window. Press the button to turn the defogger on. It will turn itself off after about 10 minutes. If you turn it on again, the defogger will only run for about five minutes before turning off.
Page 152 Setting the Clock for All +stems Except ANI-FM Stereo Press and hold HR until the correct hour appears. Press and hold MIN until the correct minute appears, There will b'e a two-second delay before the clock goes into time-set mode, and the colon on the display will blink while in this mode.
Page 153: Am-Fm Stereo With Cassette Tape Player (If Equipped)
In addition to the four stations already set, up to three more stations may be preset on each band by pressing two adjoining buttons at the same time. Just: 1. Tune in the desired station. 2. Press SET. (SET will appear on the display.) 3.
Page 154 TUNE: Press knob lightly so it extends. Turn it to this choose radio stations. Push the knob back into its stored position when you're not using it. SEEK: Press the up or down arrow higher or lower station and stay there. PUSHBUTTONS: The six numbered pushbuttons let you return to your favorite stations.
Page 155 If E and a number appear on the radio display, the tape won’t play because of an error. E10: The tape is tight and the player can’t turn the tape hubs. Remove the tape. Hold the tape with the open end down and try to turn the right hub to the with pencil.
Page 156 FWD (6): Press this button to advance quickly to another part of the tape. Press the button again to return to playing speed. The radio will play the last-selected station while the tape advances. You may select stations during FWD operation by using SEEK or TUNE. AM-FM: Press this button to play the radio when a tape is in the player.
Page 157: Am-Fm Stereo With Cassette Tape Player And Equalizer (If Equipped)
AM-FM Stereo with Cassette Tape Player and Equalizer (If Equipped) Playing the Radio POWER-VOL: Press this knob to turn the system on and off. To increase volume, turn the knob to the right. Turn it to the left decrease volume. RECALL: Display time with the ignition off by pressing this button.
Page 158 Adjusting the Speakers BAL: Press this knob lightly so it extends. Turn it move the sound to the left or right speakers. The middle position balances the sound between the speakers. FADE: Press this knob lightly so it extends. move the sound to the front or rear speakers. The middle position balances the sound between the speakers.
Page 159 NEXT (2): Press this button or the SEEK up arrow to search for the next selection on the tape. If you hold the button, the player will continue moving forward through the tape. Your tape must have at least three seconds of silence between each selection for NEXT or SEEK to work.
Page 160: Am-Fm Stereo With Compact Disc Player And Equalizer (If Equipped)
CD Adapter Kits a CD adapter lut with your casette It is possible to use tape player after activating bypass feature on your tape player. activate the bypass feature, use the following steps: 1. Turn the ignition key to RUN or ACCES'SORY. 2.
Page 161 Finding a Station AM-FM: Press this button to switch between AM, FM1 and FM2. The display shows your selection. TUNE: Press this knob lightly so it extends. Turn choose radio stations. Push the knob back into its stored position when you're not using it. SEEK: Press the up or down arrow to go to the next higher or lower station and stay there.
Page 162 If you’re driving on a very rough road or if it’s very hot, the disc may not play and E (error) and a number may appear on the radio display. If the disc comes out, it could be that: The disc is upside down. It is dirty, scratched wet.
Page 163: Theft-Deterrent Feature (If Equipped)
Theft-Deterrent Feature (If Equipped) THEFTLOCK" is designed to discourage theft of your radio. It works by using a secret code to disable all radio functions whenever battery power is removed. The THEFTLOCK feature for the radio ignored. If ignored, the system plays normally and the radio is not protected by the feature.
Page 164 Unlocking the Theft-Deterrent Feature After Power Loss as follows; Enter your secret code 15 seconds between steps: LOC appears when the ignition is on. Press and 000 will appear on the display. Press MIN again to make the last two digits agree with your code.
Page 165: Audio Steering Wheel Controls (If Equipped)
Audio Steering Wheel Controls (If Equipped) vehicle you can control certain I f your has this feature, radio functions using the buttons on your steering wheel. SEEK: Press the up arrow to tune to the next radio station and the down arrow to tune to the previous radio station.
Page 166: Tips About Your Audio System
Tips Your Audio System About Hearing damage from loud noise is almost undetectable until it is too late. Your hearing can adapt to higher volumes of sound. Sound that seems normal cin ble loud and harmful to your hearing. Take precautions by adjusting the volume control on your radio to a safe sound level b'efore your hearing adapts...
Page 167: Care Of Your Cassette Tape Player
Care of Your Cassette Tape Player tape player that is not cleaned regularly can cause reduced sound quality, ruined cassettes or a damaged mechanism. Cassette tapes should be stored cases away from contaminants, direct sunlight and extreme heat. If they aren’t, they may not operate properly or may cause failure of the tape player.
Page 168: Care Of Your Compact Disc Player
After you clean the player, press and hold EJECT for five seconlds to reset the CLN indicator, The radio will display to show the indicator was reset. Cassettes are subject to wear and the sound quality may degrade over time, Always make sure the cassette tape is in good condition before you have your tape player serviced.
Page 169: Section 4 Your Driving And The Road
Section 4 Your Driving and the Road Here you’ll find information about driving on different kinds of roads and in varying weather conditions. We’ve also included many other useful tips on driving. Defensive Driving Drunken Driving Control of a Vehicle Braking 4- 10 Steering...
Page 170: Defensive Driving
Drive defensively. Please start with a very important safety device in your Pontiac: Buckle up. (See “Safety Belts” in the Index.) Defensive driving really means “be ready for anything.” On city streets, rural roads or freeways, it “always expect the unexpected.”...
Page 171: Drunken Driving
Drunken Driving Death and injury associated with drinking and driving is a national tragedy. It’s the number one contributor to the highway death toll, claiming thousands of victims every year. Alcohol affects four things that anyone needs to drive a vehicle: Judgment Muscular Coordination Vision...
Page 172 It’s the amount of alcohol that counts. For example, if the same person drank three double martinis (3 ounces 90 ml of liquor each) within an BAC would be close to 0.12 percent. A person who consumes food just before or during drinking will have a somewhat lower BAC level.
Page 173: Control Of A Vehicle
right answer. What if there’s an emergency, a need to take sudden action, when a child darts into the street? person with even a moderate BAC might not be able to react quickly enough to avoid the collision. There’s something else about drinking and driving that know.
Page 174 Braking Braking action involves perception time and reaction time. First, you have to decide to push on the brake pedal, That’s perception time. Then you have to bring up your foot and do it, That’s reaction time. Average reaction time is about 314 of a second. But that’s only an average.
Page 175: Anti-Lock Brakes (Abs)
Anti-Lock Brakes (ABS) Your vehicle has anti-lock brakes (ABS). ABS is an advanced electronic braking system that will help prevent a braking skid. When you start your engine, or when you begin to drive away, your anti-lock brake system will check itself. You may hear a momentary motor or clicking noise while this test is going on, and you may even notice that your brake pedal moves or pulses a little.
Page 176: Enhanced Traction System
The anti-lock system can change the brake pressure faster than any driver could. The computer is programmed to make the most of available tire and road conditions. You can steer around the obstacle while braking hard. As you brake, your computer keeps receiving updates on wheel speed and controls braking pressure accordingly.
Page 177 This light will come on when your Enhanced Traction System wheel spin. See “Enhanced TRAC Traction System Active Light” in the Index. You may feel or hear the system working, but this is normal. The Enhanced Traction System operates in all transaxle shift lever positions.
Page 178: Braking In Emergencies
When you turn the system off, the Enhanced Tracti’on System warning light will come on and stay on. If the Enhanced Traction System is limiting wheel spin when you press the button turn the system off, the warning light will come on but the system won’t turn off right away.
Page 179: Steering In Emergencies
The traction you can get in a curve depends on the condition of your tires and the road surface, the angle at which the curve is banked, and your speed. While you’re in a curve, speed is the one factor you can control.
Page 180: Off-Road Recovery
An emergency like this requires close attention and a quick decision. If you are holding the steering wheel at the recommended 9 and 3 o’clock positions, you can turn it a full. 180 degrees very quickly without removing either hand. But you have to act fast, steer quickly, and just as quickly straighten the wheel once you have avoided the object.
Page 181 Passing The driver a vehicle about to pass another on two-lane highway waits for just the right moment, accelerates, moves around the vehicle ahead, then goes back into the right lane again. A simple maneuver? Not necessarily! Passing another vehicle on a two-lane highway is a potentially dangerous move, since the passing vehicle occupies the same lane as oncoming traffic for several seconds.
Page 182: Loss Of Control
Check your mirrors, glance over your shoulder, ,and start your left lane change signal before moving out the right lane to pass. When you are far enough ahead of the passed vehicle to see its front in your inside mirror, activate your right lane change signal and move back into the right lane.
Page 183: Driving At Night
Of course, traction is reduced when water, snow, ice, gravel or other material is on the road. For safety, you’ll want to slow down and adjust your driving to these conditions. It is important to slow down on slippery surfaces because stopping distance will vehicle control more limited.
Page 184: Night Vision
Adjust your inside rearview mirror to reduce the glare from headlamps behind you. Since you can’t see as well, you may need to slow keep more space between you down and other vehicles. Slow down, especially on higher speed roads. Your so much headlamps can light up only In remote areas, watch for animals.
Page 185: Driving In Rain And On Wet Roads
Driving in Rain and on Wet Roads Rain and wet roads can mean driving trouble. On a wet road, you can’t stop, accelerate your tire-to-road traction isn’t as good as on dry roads. And, if your tires don’t have much tread left, you’ll get even less traction.
Page 186 Driving too fast through large water puddles or even going through some car washes can cause problems, too. The water may affect your brakes. Try to avoid puddles. But if can’t, try to slow down before you hit them. 4-18 CAUTION: Wet brakes can cause accidents.
Page 187: Driving Through Deep Standing Water
Driving Through Deep Standing Water If you drive too quickly through deep puddles standing water, water can come in through your engine’s air intake and badly damage your engine. Never drive through water that is slightly lower than the underbody of your vehicle. If you can’t avoid deep puddles or standing water, drive through them very slowly.
Page 188: Freeway Driving
Here are ways to increase your safety in city ldriving: &ow the best way to get to where you are going. city map and plan unknown part of the city just as cross-country trip. Try to use the freeways that rim and crisscross most large cities.
Page 189: Before Leaving On A Long Trip
If it needs service, have it done before starting out. Of course, you'll find experienced and able service experts in Pontiac dealerships all across North America. They'll be ready and willing to help if you need it. proper...
Page 190: Highway Hypnosis
Here are some things you can check before a trip: Windshield Washer Fluid: Is the reservoir full? Are all windows clean inside and outside? Wiper Blades: Are they in good shape? Fuel, Engine Oil, Other Fluids: Have you checked all levels? Lamps: Are they all working? Are the lenses clean? Tires: They are vitally important to a safe, trouble-free trip.
Page 191: Hill And Mountain Roads
Hill and Mountain Roads Driving on steep hills or mountains is different from driving in flat or rolling terrain. If you drive regularly in steep country, or if you’re planning to visit there, here are some tips that can make your trips safer and more enjoyable.
Page 192 Coasting downhill in NEUTRAL (N) ignition off is dangerous. Your brakes will have to do all the work of slowing down. They could get so hot that they wouldn’t work well. You would then have poor braking or even none going down a hill.
Page 193: Winter Driving
Winter Driving Here are some tips for winter driving: Have your vehicle in good shape for winter. You may want to put winter emergency supplies in your trunk. Include an ice scraper, a small brush or broom, a supply of windshield washer fluid, a rag, some winter outer clothing, a small shovel, a flashlight, a red cloth and a couple of reflective warning triangles.
Page 194 4-26...
Page 195: If You're Caught In A Blizzard
Your anti-lock brakes improve your vehicle’s stability when you make a hard stop on a slippery road. Even though you have the anti-lock braking system, you’ll than want to begin stopping sooner pavement. See “Anti-Lock‘’ in the Index. Allow greater following distance slippery road.
Page 196 If you are stopped by heavy snow, you could be in a serious situation. should probably stay with your know vehicle unless you for sure that can hike through the snow. Here are some things to do to summon help and keep yourself safe: passengers...
Page 197: Recreational Vehicle Towing
Snow can trap exhaust gases under your vehicle. This can cause deadly CO (carbon monoxide) gas to get inside. CO could overcome you and kill you. You can’t see it or smell it, so you might not know it is in your vehicle. Clear away snow from around the base of your vehicle, especially any that is blocking your exhaust pipe.
Page 198 Towing Your Vehicle from the Front (With a Dolly) 4-30 Follow these steps: Put the front wheels’ on a dolly. Set the parking b’rake. Open the fuse panel on the driver’s side of the instrument panel. Remove the CLSPCM. This will keep your battery from draining while towing.
Page 199 Towing Your Vehicle From the Front (Without a Dolly) You may tow your vehicle with all four wheels on the ground if you have a four-speed automatic or a five-speed manual transaxle. Follow these steps: Set the parking brake. Open the fuse panel on the driver’s side instrument panel.
Page 200: Towing Your Vehicle From The Rear
Towing Your Vehicle from the Rear NOTICE: Do not tow your vehicle from the rear. vehicle could be badly damaged and the repairs would n’ot be covered by your warranty. 4-32 Loading Your Vehicle ‘ m OCCUPANTS FRT. CTR. MAX. LOADING & GVWR SAME AS VEHICLE CAPACITY WEIGHT TIRE SIZE FRT.
Page 201 MFD BY GENERAL MOTORS CORP DATE GVWR GAWR FRT THIS VEHICLE CONFORMS TO ALL APPLI- CABLE U.S. FEDERAL MOTOR VEHICLE SAFETY, BUMPER, AND THEFT PREVENTION STANDARDS IN EFFECT ON THE DATE OF MANUFACTURE SHOWN ABOVE. The other label is the Certification label, found on the rear edge of the driver’s door.
Page 202 Things you put inside your vehicle can strike and injure people in a sudden stop crash. Put things in the trunk of your vehicle. In a as far trunk, put them €orward as you can. 91ry to spread the weight evenly. If you rear foldedown seats, you’ll find four...
Page 203 Your vehicle can tow trailer if it is equipped with a 2.4L engine and 4-speed automatic transaxle and the proper trailer towing equipment. vehicle trailering capacity is for your vehicle, you should read the information in “Weight of the Trailer” that appears later in this section.
Page 204: Weight Of The Trailer Tongue
C ~ D special equipment that you have on your vehicle. You can ask your dealer for our trailering information or advice, or you can write us at: Pontiac Customer Services Department One Bontiac Plaza Pontiac, Michigan 48340-2952 In Canada, write to: General Motors ‘of Canada Limited...
Page 205: Total Weight On Your Vehicle's Tires
you’re using weight-carrying hitch, the tongue (A) should weigh 10 percent of the total loaded trailer weight (B). If you have a weight-distributing hitch, the trailer tongue (A) should weigh 12 percent of the total loaded trailer weight (B). After you’ve loaded your trailer, weigh the trailer and then the tongue, separately, to see if the weights are proper.
Page 206 Safety Chains You should always attach chains between your vehicle and your trailer. Cross the safety chains under the tongue the trailer that the tongue will not drop if it becomes separated from the hitch. Instructions about safety chains may be provided by the hitch manufacturer or by the trailer manufacturer.
Page 207: Turn Signals When Towing A Trailer
Backing Up Hold the bottom the steering wheel with Then, to move the trailer to the left, just move that hand to the left. To move the trailer to the right, move your hand to the right. Always back up slowly and, if have someone guide you.
Page 208: Parking On Hills
Reduce speed and shift to a lower gear before you s8tart down a long or steep downgrade. If you don’t shift down, you might have to use your brakes so much that would get they hot and no longer work well. On a long uphill grade, shift down and reduce your speed to around 45 mph (70 km/h)
Page 209: Maintenance When Trailer Towing
Maintenance When Trailer Towing Your vehicle will need service more often when you’re pulling a trailer. See the Maintenance Schedule for more on this. Things that are especially important in trailer operation are automatic transaxle fluid (don’t overfill), engine oil, drive belt, cooling system and brake adjustment.
Page 211: Section 5 Problems On The Road
Section 5 Problems on the Road Here you’ll find what to do about some problems that can occur o’n the road. Hazard Warning Flashers Other Warning Devices Jump Starting Towing Your Vehicle 5- 14 Engine Overheating 5-16 Cooling System 5-22 If a Tire Goes Flat 5-23 Changing a Flat Tire...
Page 212: Hazard Warning Flashers
Hazard Warning Flashers Your hazard warning flashers let you warn others. They also let police know you have a problem. Your front and rear turn signal lamps will flash on and off. Your hazard warning flashers wo position your key is in, and To turn off the flashers, move tht When the hazard warning flashel signals won’t work.
Page 213: Jump Starting
Jump Starting your battery has run down, you may want to use another vehicle and some jumper cables to start your vehicle. But please follow the steps below to do it safely tteries can hurt you. They can be dangerous because: They contain acid that can burn you.
Page 214 Get the vehicles close enough so the jumper c a l k s can reach, but be sure the vehicles aren't touchihg each other. If they are, it could cause a ground connection you don't want. You wouldn't be ab e to start your vehicle, and the bad grounding could damage the electrical systems.
Page 215 ‘ CAUTION: Using a match near a battery can cause battery gas to explode. People have been hurt doing this, and some have been blinded. Use a flashlight if you need more light. Be sure the battery has enough water. You don’t need to add water to the ACDelco Freedom’...
Page 216 Remove the red plastic cap, and connect the red positive cable to the positive the vehicle with the dead battery. Use a remote positive terminal if the vehicle has one. terminal of It goes to a heavy unpainted met 1 part on the engine of the vehicle with the dead battery..
Page 217 Attach the cable at least 18 inches (45 cm) away from the dead battery, but not near engine parts that move. The electrical connection is just as good there, but the chance of sparks getting back to the battery is much less. Now start the vehicle with the good battery and run the engine for a while.
Page 218: Towing Your Vehicle
Towing Your Vehicle have a dealer a professional towing semiice your vehicle. They provide the right equipment and h o w how to tow your vehicle without damage. (See "Roadside Assistance" the Index.) If your vehicle has been changed was factory-new by adding aftermarket lamps, aero skirting, or special tires and wheels, these instructions and illustrations may not be correct.
Page 219 To help avoid injury to you or others: Never let passengers ride in a vehicle that is being towed. Never tow faster than safe or posted speeds. Never tow with damaged parts not fully secured. Never get under your vehicle after it has been lifted by the tow truck.
Page 220: Front Towing
Front Towing Before hooking up to a tow truck, be sure to read all the information in “Towing Your Vehicle” earlier in this section. s in the bottom of the Attach T-hook chains into the slc (eels, on both sides. floor pan, just behind the front w These slots are used when loadin car-carrier equipment.
Page 221: Rear Towing
NOTICE: Do not tow with sling-type equipment or fascidfog lamp damage will occur. Use wheel-lift or car-carrier equipment. Additional ramping may be required for car-carrier equipment. Use safety chains and wheel straps. Towing over rough surfaces could damage a vehicle. Damage can occur from vehicle to ground or vehicle to wheel-lift equipment.
Page 222 Before hooking up to a tow truck, be sure to read all the information in “Towing Your Vehicle” earlier in this section. Also be sure to use the proper hook-up for your particular vehicle. Attach T-hook chains on both sic in the bottom of the frame rail wheels.
Page 223 NOTICE: Do not tow your vehicle from the rear with the front wheels on the ground or your transaxle can be damaged. Do not tow with sling-type equipment or rear facia will be damaged. Use wheel-lift equipment or car-carrier equipment. Additional ramping may be required for car-carrier equipment.
Page 224: Engine Overheating
Engine Overheating You will find a coolant temperature gage and a low your cooIant warning light on vehicle’s instrument panel. See “Engine Coolant Temperature Gage” an “Low Coolant Warning Light” in the Index. If Steam Is Coming From Your Engine Steam from an overheated badly, even if you just open from...
Page 225: If No Steam Is Coming From Your Engine
If No Steam Is Coming From you get the overheat warning but see or hear no steam, the problem may not be too serious. Sometimes the engine can get a little too hot when you: Climb a long hill on a hot day. Stop after high-speed driving.
Page 226 2.2L Engine A. Coolant Surge Tank with Pressure Cap B. Electric Engine Cooling Fan 5-16 2.4L Engir A. Coolant Surge Tank with Pres Electric Engine Cooling Fan ure Cap...
Page 227 An electric engine cooling fan under the hood can start up even when the engine is not running and can injure you. Keep hands, clothing and tools away from any underhood electric fan. If the coolant inside the coolant surge tank is boiling, don’t do anything else until it cools down.
Page 228 NOTICE: from Engine damage running your engine without coolant isn’t covered by your warrant If there seems to be no leak, with the engine on, cooling fan is see if the electric engine engine is overheating, the fan should isn’t, your vehicle needs service. How to Add Coolant Surge Tank If you haven’t found a problem yet, but the coolant level...
Page 229 Adding only plain water to your cooling system can be dangerous. Plain water, or some other liquid like alcohol, can boil before the proper coolant mixture will. Your vehicle’s coolant warning system is set for the proper coolant water mixture. With plain or the wrong mixture, your engine could get too hot but you wouldn’t get the overheat warning.
Page 230 You can be burned if you spill coolant on hot engine parts. Coolant contains ethylene glycol and it will burn if the engine parts are hot enough. Don't spill coolant on a hot engine. 5-20 1. You can remove the co'olant rge tank pressure cap when the cooling system, incl tank pressure cap and upper r:...
Page 231 3. Then fill the coolant surge tank with the proper With the coolant surge tank pressure cap off, start the mixture, up to the FULL COLD mark. engine and let it run until you can feel the upper radiator hose getting hot. Watch out for the engine cooling fan.
Page 232: If A Tire Goes Flat
5 , Then replace the pressure cap. Be sure Check the level in the surge tank when the ~oolin; system has cooled down. If the coolant isn’t at the proper level, repeat Steps 1 to 3 and reinstall the cap or see your dealer.
Page 233: Changing A Flat Tire
Changing Flat Tire a tire goes flat, avoid further tire and wheel damage by driving slowly to a level place. Turn on your hazard warning flashers. a tire Changing can cause an injury. The vehicle can slip off the jack and roll over you or other people.
Page 234: Removing The Spare Tire And Tools
Removing the Spare Tire and Tools The equipment you’ 1 1 is in the trunk. Turn the center retainer nut on th compact spare cover to the left Lift and remove the tire cover. See “‘Compact Spare Tire’’ later in this section for more information about the compact spare.
Page 235: Removing The Flat Tire And Installing The Spare Tire
Remove the jack and the wheel wrench from the trunk. Your vehicle’s jack and wheel wrench are stored in a foam tray. Remove the band around the jack. Removing the Flat Tire and Installing the Spare Tire Using the wheel wrench, remove the plastic nut caps (if equipped).
Page 236 18" (46cm) 4, Near each wheel well is a notch in the frame wh'ch the jack head fits in. The front notch is 9 inches (23 cm) back from the front wheel well. The re notch is 8 inches (20 cm) forward fkom the rear wheel well.
Page 237 Raise the vehicle rotating the jack handle to the right. Raise the vehicle enough off the ground so there is enough room for the spare tire to fit. 6. Remove all of the wheel nuts. 7. If you have a wheel cover, use your fingers to 'carefully pull the wheel cover from the wheel.
Page 238 Remove from mounting spare wheel. Rust or dirt th'e wheel, on the parts to which it is fastened, can make the wheel nuts become loose after a time. The wheel could off and cause an accident. When you change a wheel, remove any rust or dirt from the places where the wheel attaches to the vehicle.
Page 239 by rotating the jack handle to the 11. Lower the vehicle left. Lower the jack completely. 12. Tighten the wheel nuts firmly in a crisscross sequence, Incorrect wheel nuts or improperly tightened wheel nuts can cause the wheel to become loose and even come off.
Page 240 Store the wheel cover and plastic caps in the you have the flat tire repaired or replaced. NOTICE: your compact spare. If Wheel covers won't fit you try to put a wheel cover on your compact spare, you could damage the cover or the spare. Storing a jack, tire or other equipment passenger compartment of the vehicle could...
Page 241: Storing The Spare Tire And Tools
Storing the Spare Tire and Tools Storing a jack, a tire or other equipment in the passenger compartment of the vehicle could cause injury. In a sudden stop or collision, loose equipment could strike someone. Store all these in the proper place. The compact spare is for temporary the compact spare tire with a full-size tire as soon as you can.
Page 242 Compact Spare Although the compact spare tire wa,s fully new, it your vehicle was can lose the inflation pressure regularly. It should be (420 kPa). After installing the compact spare'on should stop as soon as possible and make sure your spare tire is correctly inflated.
Page 243: If You're Stuck: In Sand, Mud, Ice Or Snow
If You’re Stuck: In Sand, Mud, Ice or Snow What you don’t want to do when your vehicle is stuck is to spin your wheels too fast. The method known as “rocking” can help you get out when you’re stuck, but you must use caution.
Page 244 5-34...
Page 245: Section 6 Service And Appearance Care
Section 6 Service and Appearance Care Here you will find information about the care of your vehicle. This section begins with service and fuel information, and then it shows how to check important fluid and lubricant levels. There is also technical information about your vehicle, and a part devoted to its appearance care.
Page 246 Bag-Equipped Vehicle” in the You should keep a record with all the mileage perform. See “Maintenance Reco Vork service work, you’ll Pontiac Se vice Manual. It tells ice y o u vehicle er service in the Index. L. Before xvicing Your Air own service work, se’e “S...
Page 247: Adding Equipment To The Outside Of Your Vehicle
CAUTION: You can be injured and your vehicle could be damaged if you try to do service work on a vehicle without knowing enough about it. Be sure you have sufficient knowledge, experience, the proper replacement parts and tools before you attempt any vehicle maintenance task.
Page 248 If this occurs, r to your authorized Pontiac dealer for diagnosis to determine the cause of failure. In the event it is determined that the cause of the condition is the...
Page 249: Fuels In Foreign Countries
Fuels in Foreign Countries If you plan on driving in another country outside the United States or Canada, the proper fuel may be hard to find. Never use leaded gasoline or any other fuel not recommended in the previous text on fuel. Costly repairs caused by use of improper fuel wouldn’t be covered by your warranty.
Page 250 The cap is behind a hinged door on your vehicle. While refueling, hang the cap inside the fuel door 1 placing fuel cap strap in the strap hanger. remove the cap, turn it slowly (counterclockwise). The cap has go of the cap too soon, it If you get gasoline on yoursel something ignites it, you coulr Gasoline can spray out on yo1...
Page 251: Filling A Portable Fuel Container
When you put the cap back on, turn it to the right (clockwise) until you hear a clicking sound. Make sure you fully install the cap. The diagnostic system can determine if the fuel cap has been left off or improperly installed.
Page 252: Hood Release
Checking Things Under the H o d An electric fan under the hood 'can start up and injure you even when the engine is not running. Keep hands, clothing and tools away from underhood electric fan. Things get on hot engine parts and that burn can start fire.
Page 253 Then go to the front of the vehicle and lift up on the secondary hood release lever. The secondary hood release lever is located near the front center of the hood toward the driver’s side. Lubricate the hood least once a year. latch at Lift the hood, release the hood prop from its retainer...
Page 254 2 . 2 L Engine (Code 4) When you open up the hood you’ll see: Coolant Surge Tank B . Power Steering Fluid Reservoir C. Engine Oil Fill Cap/Dipstick D. Brake Fluid Reservoir Hydraulic Clutch Fluid Reservoir (If Equipped) E Automatic Transaxle Fluid Dipstick (If Equipped) Air Cleanei H.
Page 255 2.4L Engine (Code T) When you open up the hood you’ll see: A. Coolant Surge Tank B. Engine Oil Fill Cap C. Engine Oil Dipstick Power Steering Fluid Reservoir E. Brake Fluid Reservoir E Hydraulic Clutch Fluid Reservoir Equipped) G. Battery H.
Page 256: Engine Oil
Engine Oil It’s a good idea to check your engine oil every time’ you get fueL In order to get an accurate reading, the oil must be warrn and the vehicle must be 6-12 level ground, If you have a 2.4L engine, the di] yellow ring.
Page 257: Checking Engine Oil
Checking Engine Oil Pull out the dipstick and clean it with a paper towel cloth, then push it back in all the way. Remove it again, keeping the tip down, and check the level. When to Add Engine Oil If the oil is at or below the ADD mark, then you’ll need to add at least one quart of oil.
Page 258 This is where you add oil if you have Be sure to fill it enough to put the level somewhere the proper operating range. Push the dipstick all the back in when you're through. 6-14 What Kind of Engine 0 Oils recornended looking indicates that the oil has been...
Page 259 RECOMMENDED SAE VISCOSITY MADE ENGINE OILS FOR BEST FUEL ECONOMY AND COLD STARTING, SAE VISCOSITY GRADE OIL THE EXPECTED TEMPERATURE RANGE. LOOK FOR THI S WEATHER SYMBOL “F e lo[ 1OW-30 COLD WEATHER DO NOT USE SAE 2OW-50 GRADE OIL NOT RECOMMENDED As shown in the chart, SAE 5W-30 is best for your vehicle.
Page 260: Engine Oil Additives
Engine Oil Additives Don’t add anything to your oil. Your dealer advise if you think something should be added. Engine Oil When to Change If any one of these is true for you, use the short t r i ~ . ’ : ! ~ maintenance schedule: Most trips are less than 5 to 10...
Page 261: Air Cleaner
Air Cleaner The air cleaner is located on the driver’s side of the engine compartment near the battery. To check or replace the filter, remove the screws that hold the cover on and lift the cover. Be sure to reinstall the air cleaner filter and replace the cover tightly.
Page 262 Operating the engine with the air cleaner off can cause you or others to be burned, The air cleaner cleans the air, it stops flame if the engine only backfires. If it isn’t there, and the engine backfires, you could be burned. Don’t drive with it off, and be careful working on the engine with cleaner off.
Page 263: How To Check
How to Check Because this operation can be a little difficult, you may choose to have this done at your Pontiac dealership Service Department. If you do it yourself, be sure to follow all the instructions here, or you could get a false reading on the dipstick.
Page 264: How To Add Fluid
Checking the Fluid Level Park your vehicle on a level place. Keep the engine running. With the parking brake applied, place the shift lever in PARK (P). With your foot on the brake pedal, move the shift lever through each gear range, pausing for about three seconds in each range.
Page 265 It is not necessary to check the transaxle fluid level. A transaxle fluid leak is the only reason for fluid loss. If a leak occurs, take the vehicle to your Pontiac dealership Service Department and have it repaired possible. You may also have your fluid level checked by your dealer or service center when you have your oil changed.
Page 266: Manual Transaxle Fluid
How to Check Because this operation can be a little difficult, you may choose have this done at your Pontiac dealership Service Department. If you do it yourself, be sure to follow all the instructions here, or you could get a false reading...
Page 267: Hydraulic Clutch
the dipstick and read the lower 3. Check both sides of level. The fluid level must be between the ADD and FULL marks. (Note: Fluid may appear at the bottom of the dipstick even when the fluid level is several pints low.) 4.
Page 268: When To Check And What To Use
When to Check and What to Use Refer to the Maintenance Schedule often you should check the fluid level in your clutcf master cylinder reservoir and €or the proper fluid. SI “Owner Checks and Services’’ and “Recommended Fluids and Lubricants” in the Index. 6-24 ‘...
Page 269: What To Use
NOTICE: When adding coolant, it is important that you use only DEX-COOL@ (silicate-free) coolant. If coolant other than DEX-COOL is added to the system, premature engine, heater core or radiator corrosion may result. In addition, the engine coolant will require change sooner 30,000 miles 000 km) or whichever occurs first.
Page 270: Checking Coolant
NOTICE: If you use an improper coolant mixture, your engine could overheat and be badly damaged. The repair cost wouldn’t be covered by your water warranty. Too much in the mixture can freeze and crack the engine, radiator, heater corie and other parts.
Page 271: Surge Tank Pressure Cap
Turning the surge tank pressure cap when the engine and radiator are hot can allow scalding liquids to blow out and burn you badly. Never turn the surge tank pressure cap little when the engine and radiator are hot. When your engine cold, the coolant level should be at the FULL COLD mark.
Page 272: How To Check Power Stee Ring Fluid
Thermostat Engine coolant tempera ,ture is control1 in the engine coolant system. The themostat stops tlie flow of coolant through the radiator until the coolant reaches preset temperature. When you replace your thermostat, an ACDelco thermostat is recommended. Power Steering Fluid When to Check Power Ste ring Fluid It is not necessary to regularly che k power steering ed by a thermostat...
Page 273: Windshield Washer Fluid
Windshield Washer Fluid What to Use When you need windshield washer fluid, be sure to read the manufacturer’s instructions before use. If you will be operating your vehicle in an area where the temperature may fall below freezing, use a fluid that has sufficient protection against freezing.
Page 274 Brakes Brake Fluid Your brake master cylinder reservoir i s here. with DOT-3 brake fluid. There are only two reasons why the brake fluid lev6 the reservoir might go down. The first fluid goes down to an acceptable level during norm brake fining wear.
Page 275 What When you do need brake fluid, use only DOT-3 such as Delco Supreme l l @ (GM Part brake fluid No. 12377967). Use new brake fluid from a sealed container only. Always clean the brake fluid reservoir cap and the area around the cap before removing it.
Page 276: Brake Wear
Brake Wear Your vehicle has front disc brakes and rear arum brakes. Disc brake pads have built-in wear indicators that make a high-pitched warning sound when the brake’ pads are worn new pads are needed. The sound come and go or be heard all the time moving (except when you are pushing on the brake pedal firmly).
Page 277: Brake Pedal Travel
Battery Every new Pontiac has an ACDelco Freedom@ battery. You never have to add water to one of these. When it’s time for a new battery, we recommend an ACDelco Freedom battery. Get one that has the replacement number shown on the original battery’s label.
Page 278: Bulb Replacement
The following procedure tells yo from cable bulbs for your vehicle. For any bulb changing procedure section, contact your Pontiac deal Halogen Bulbs - 7 # i ’ : be badly hurt if Halogen bulbs have pressuri can burst if you drop or scr others could be injured.
Page 279 Headlamps To replace one of your headlamps, do the following: 1. Remove the first bolt and carefully pry up the shield that covers the headlamp assembly. Be careful not to break the fasteners that hold the shield in place. Remove the bolt that anchors the headlamp assembly.
Page 280 bulb base from the socket by lifti Disconnect the plastic locking tab. Snap a new bulb into the socket. 6. Replace the bulb assembly by reversing Steps 1 through 3, making sure the lower leg of the headlamp bracket is properly seated into the we shaped retainer.
Page 281 3. To remove the bulb, pull it out. 4. Push in a new bulb. 5. Reverse all steps to replace the taillamp assembly. Back-up Lamps (Sedan) If you have a four-door sedan, do the following to replace a back-up lamp. 1.
Page 282 Center High-Mounted Stoplamp (Models Without a Spoiler) a four-door sedan, If you have the Center (CHMSL) High-Mounted Stoplamp change the bulb, do the following: the interior. 1, Open the trunk and view the access hole under the rear shelf. 2. Remove the bulb socket by rotating it in either direction, then pull down.
Page 283: Windshield Wiper Blade Replacement
Without Dome Lamp Integral Reading Lamps To replace a bulb, do the following: 1. From the rear of the dome lamp lens, insert a flat screwdriver between the roof trim and the lens. 2. With the screwdriver, push the tab at the rear of the lens forward to release the lens.
Page 284: Tire Pressure
Your new vehicle comes with high-quality tires mdde by a leading tire manufacturer. If you ever have questions about your tire warranty and where to obtain serviae, see Pontiac your Warranty booklet for details. CAUTION: Poorly maintained and improperly used tires are dangerous.
Page 285: Tire Inspection And Rotation
NOTICE: Don’t let anyone tell you that underinflation or overinflation is all right. It’s not. If your tires don’t have enough air (underinflation), you can get the following: Too much flexing Too much heat Tire overloading Bad wear Bad handling Bad fuel economy.
Page 286 The purpose regular rotation is to achieve more uniform wear for all tires the vehicle. The first rotation is the most important. Maintenance Services” in the Index rotation intervals. When rotating your tires, always use the correct pattern shown here. Don’t include compact spare tire...
Page 287: Buying New Tires
When It’s Time for New Tires One way to tell when it’s time for new tires is to check the treadwear indicators, which will appear when your tires have only 1/16 inch (1.6 mm) or less of tread remaining. You need a new tire if any of the following statements are true: You can see the indicators at three or more places around the tire.
Page 288 Mixing tires could cause you to lose control while driving. If you mix tires of different (radial and bias-belted tires), the vehicle may not handle properly, and you could have Using tires of different sizes may also cause damage to your vehicle. Be sure to use the san-,. size and type tires on all wheels.
Page 289 Treadwear The treadwear grade is comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150 would wear one and a half (1 1/2) times as well on the government course as a tire graded 100.
Page 290: Wheel Alignment And Tire Balance
.:;ii.~ or wheel nuts, replace them on1 This equipment parts. the right wheel, wheel bolts an Pontiac model. Using the wrong replacement bolts or wheel nuts on your dangerous. It could affect th handling of your vehicle, m air and make you lose cont...
Page 291: Tire Chains
NOTICE: The wrong wheel can also cause problems with bearing life, brake cooling, speedometer or odometer calibration, headlamp aim, bumper height, vehicl’e ground clearance and tire or tire chain clearance the body and chassis. See “Changing a Flat Tire” in the Index for more information.
Page 292: Appearance Care
NOTICE: (Continued) do find traction devices that will fit, install1 them the front tires. I f you have other tires, use tire chains legal and only when you must. Use only SAE: Class type chains that are the proper size for “...
Page 293: Cleaning The Inside Of Your Vehicle
Cleaning the Inside of Your Use a vacuum cleaner often to get rid of dust and loose dirt. Wipe vinyl, leather, plastic and painted surfaces with a clean, damp cloth. Your dealer has two cleaners, Multi-Purpose Interior Cleaner and Capture Non-Solvent Dry Spot and Soil Remover.
Page 294: Special Fabric Cleaning Problems
Special Fabric Cleaning Problems Stains caused by such things as catsup, coffee egg, fruit, fmit juice, soft drinks, vomit, milk, blood be removed as follows: Carefully scrape off excess stain, then sponge th soiled area with cool water. If a stain remains, follow the multi-purpo'se inte: cleaner instructions described earlier.
Page 295: Care Of Safety Belts
Care of Safety Belts Keep belts clean and dry. CAUTION: not bleach dye safety belts. If may severely weaken them. In a crash, they might not be able to provide adequate protection. Clean safety belts only with mild soap and lukewarm water.
Page 296: Cleaning The Outside Of Your Vehicle
Weatherstrips Silicone grease weatherstrips will make them’:--; last longer, seal better, and not stick or squeak. Apply silicone grease with a clean cloth at least every six months. During very cold, damp weathgr, more frequent application may be required. “Recommended Fluids Lubricants”...
Page 297 NOTICE: Machine compounding or aggressive polishing on a basecoat/clearcoat paint finish may dull the finish or leave swirl marks. Foreign materials such as calcium chloride and other salts, ice melting agents, road oil and tar, tree sap, bird droppings, chemicals from industrial chimneys, etc., can damage your vehicle’s finish if they remain on painted surfaces.
Page 298: Cleaning Aluminum Wheels (If Equipped)
Cleaning Aluminum Wheels (If Equipped) Keep your wheels clean using a soft clean cloth wit mild soap and water. Rinse with clean water. After rinsing thoroughly, dry with then be applied. The surface of these wheels is similar to the paintec surface of your vehicle.
Page 299: Finish Damage
Although no defect in the paint job causes this, Pontiac will repair, at no charge to the owner, the surfaces of new vehicles damaged by this fallout condition within 12 months or 12,000 miles (20 000 lun) of purchase, whichever occurs first.
Page 300: Appearance Care Materials Chart
Appearance Care Materials Chart SIZE PART NUMBER 105287'0 16oz. (0.473 1052918** (0.237 1052925 16 oz. (0.473 L) DESCRII~TION Wash Wax Cbncentrate b o r AH" rotectant Multi-Purpose Interior Clear,er...
Page 301: Vehicle Identification Number (Vin)
Vehicle Identification Number (VIN) E N G l N E A 9 8 MODEL YEAR CODE This is the legal identifier for your vehicle. It appears on a plate in the front corner of the instrument panel, on the driver’s side. You can see it if you look through the windshield from outside your vehicle.
Page 302 stem Electrical Add-on Electrical Equipment NOTICE: Don't add anything electrical to' your vehicle unless you check with your dealer first. electrical equipment can damage your vehicle and the damage wouldn't be covered by your warranty. add-on electrical equipment Some can keep other components from working as they should.
Page 303: Fuses And Circuit Breakers
Fuses and Circuit Breakers The wiring circuits in your vehicle are protected from short circuits by a combination of fuses, circuit breakers and fusible thermal links. This greatly reduces the chance of damage caused by electrical problems. Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse.
Page 304 Fuse Exterior Lamps, Back-Up TRN-B/L Fuel Pump, Fuel Injectors FP-INJ RR DFOG Instrument Cluster, Anti-Lock CLUSTER Brake System Instrument Cluster, Powertrain, CLSPCM Module, Daytime Control Running Lamps Fuse WIPER AIR BAG PWR ACC EXT LAMP W A C RADIO ALARM - *..
Page 305 Daytime Running Lamps (Relay) Steering Wheel Controls (If Equipped) Fuse Panel Your steering wheel radio controls are protected by fuses. For service, contact your Pontiac Service Department. Engine Compartment Fuse Block The engine compartment fuse block is located on the driver’s side of the engine compartment.
Page 306: Replacement Bulbs
Fuse Usage Ignition Switch Circuits Power ACC/Stoplamp Circuits BATT 1 BATT 2 Lighting Circuits Anti-Lock Brake System COOLING FAN Engine Cooling Fan Heater and A/C Rlower Powertrain Control Module A/C Compressor Anti-Lock Brake System Gen Voltage Sensor (2.2L Engine) Replacement Bulbs OUTSIDE LAMPS Back-up Lamps .
Page 307: Capacities And Specifications
Capacities and Specifications The following approximate capacities are given in English and metric conversions. Please refer to “Recommended Fluids and Lubricants” in the Index for more information. Engine Crankcase Automatic Transaxle (3-Speed Automatic Transaxle)* . . . Pan Removal and Replacement .
Page 308: Normal Maintenance Replacement Parts
Normal Maintenance Replacement Parts Air Ckaner Element ..... . . 2.2L 2.4L Engine Oil Filter ..3 31 L.LL .
Page 309 Dimensions Length ..Coupe 180.3 inches (458.0 cm) ....Sedan 180.3 inches (458.0 cm) ... . Convertible 180.3 inches (458.0 cm) Width...
Page 311: Section 7 Maintenance Schedule
Section 7 Maintenance Schedule This section covers the maintenance required for your vehicle. Your vehicle needs these services to retain its safety, dependability and emission control performance. Introduction Part A: Scheduled Maintenance Services Maintenance Schedule Short TripKity Definition Short TripKity Intervals Long TriplHighway Definition Long Trip/Highway Intervals 7-3 1...
Page 312 Have you purchased the GM Protection Plan? The Plan supplements your new vehicle warranties. See your Warranty and Owner Assistance booklet, or yuur Pontiac dealer fur details. Introduction Your Vehicle and the Envi Proper vehicle maintenance not vehicle in good working conditio environment.
Page 313 UTION: Performing maintenance work on a vehicle can be dangerous. In trying to do some jobs, you can be seriously injured. Do your own maintenance work only if you have the required know-how and the proper tools and equipment for the job. If you have any doubt, have a qualified technician do the work.
Page 314: Using Your Maintenance Schedule
Part A: Scheduled Maintenance Services Using Your Maintenance Schedule We at General Motors want to help you keep your vehicle in good working condition. But we don’t exactly how you’ll drive it. You may drive very short distances only a few times week.
Page 315: Short Trip/City Intervals
Maintenance Schedule Short Trip/City Definition Follow the Short Trip/City Maintenance Schedule if any one of these conditions is true for your vehicle: Most trips are less than 5 to 10 miles (8 to 16 lun). This is particularly important when outside temperatures below freezing.
Page 316: Long Tripmighway Intervals
Maintenance Schedule Follow this maintenance schedule only if none of tde conditions from the Short Trip/City Maintenance Schedule m e . not use this schedule if the ve cle is used for trailer towing, driven in a dusty off paved roads. Use the Short Trip/City schedule f these conditions.
Page 317: Short Trip/City Maintenance Schedule
Short Trip/City Maintenance Schedule The services shown in this schedule up to 100,000 miles (1 66 000 lun) should be performed after 100,000 miles (166 000 at the same intervals. The services shown k m ) 150,000 miles (240 000 should be performed at the same interval after 150,000 miles (240 000 See “Owner Checks and Services”...
Page 318 3,000 Miles (5 000 km) Change engine oil and filter (or every 3 months, Emission Control Sewice. 6,000 Miles (10 000 km) Change engine oil and filter (or An Emission Control Service. Lubricate chassis components (or every 6 mont (See footnote U Rotate tires.
Page 319 Short Trip/City Maintenance Schedule Lubricate chassis components (or every 6 months, whichever occurs first). (See footnote Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote ++.) (Also see footnote 15,000 Miles 000 km) Change engine oil and filter (or every 3 months, whichever occurs first).
Page 320 Short Trip/City Maintenance Sck 21,000 Miles (35 000 km) Change engine oil and filter (or every 3 months, An Emission Contrul Service. 24,bOO Miles (40 000 km) Change engine oil and filter (or every 3 Emission Control Service. Lubricate chassis components (or every 6 montk (See footnote Rotate tires.
Page 321 Short TriplCity Maintenance Schedule Lubricate chassis components (or every (See footnote Replace air cleaner filter. An Emission Control Service. Inspect Exhaust Gas Recirculation (EGR) system (2.2L Code 4 engine only). An Emission Control Service. (See footnote?.) Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage.
Page 322 Short TripKity Maintenance Schedule 36,000 Miles (60 000 km) (Contimed) Lubricate chassis components (or every 6 months, whichever occurs first). (See footnote Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote ++.) (Also see footnote 39,000 Miles (65 000 km)
Page 323 Short Trip/City Maintenance Schedule 45,000 Miles (75 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Inspect air cleaner filter if you are driving in dusty conditions. Replace filter if necessary. An Emission Control Service.
Page 324: Short Tripkity Maintenance Schedule
Short TripKity Maintenance Schedule 50,000 Miles 000 km) (Contimed) When doing frequent trailer towing. Uses such as found in taxi, police or delivery service. do not use your vehicle under any of these #conditions, the fluid and filter do not require changing. Manual transaxle fluid doesn't require change.
Page 325 Short Trip/City Maintenance Schedule 57,000 Miles (95 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. 60,000 Miles (100 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
Page 326 Short Trip/City Maintenance Sch 63,000 Miles (105 000 km) Change engine oil and filter (or every 3 months, An Emission Control Service. 66,000 Miles (110 000 km) Change engine oil filter An Emission Control Service. Lubricate chassis components (or every 6 (See footnote Rotate tires.
Page 327 Short Trip/City Maintenance Schedule Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote ++.) (Also see footnote 75,000 Miles (125 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.
Page 328 Short TripKity Maintenance $4000 Miles (135 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. 84,000 Miles (140 000 km) Change engine oil and filter An Emission Control Service. Lubricate chassis components (or every 6 month$, whichever occurs first). (See footnote Rotate tires.
Page 329 Short TriplCity Maintenance Schedule 90,000 Miles (150 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Lubricate chassis components (or every (See footnote #.) Replace air cleaner filter. An Emission Control Service. Inspect fuel tank, cap and lines for damage or leaks.
Page 330 Short TripKity Maintenance Schbdule 96,000 Miles (160 000 km) Change engine oil and filter An Emission Control Service. Lubricate chassis components (or every 6 montik, whichever occurs first). (See footnote Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern additional information.
Page 331 Short Trip/City Maintenance Schedule - In hilly or mountainous terrain. When doing frequent trailer towing. - Uses such as found in taxi, police or delivery service. you do not use your vehicle under any of these conditions, the fZuid and filter do not require changing.
Page 332 The services shown in this schedule up to 100,000 (1 66 1 0 0 0 k m ) should be performed after 100,000 (1 66 1000 k m ) at the same intervals. The at 150,000 miles (240 000 k m ) should be the same interval after 150,0080 miles (240 000 See “Owner Checks and Services”...
Page 333 Long TripBighway Maintenance Schedule 7,500 Miles (12 Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote #.) Rotate tires. See “Tire Inspection and Rotation’’ in the Index for proper rotation pattern and additional information.
Page 334: Long Tripmighway Maintenance Schedule
Long Tripmighway Maintenance Schedule km) (Con tinued) (37 500 Lubricate chassis components (or every 12 (See footnote Rotate tires. See “Tire Inspection and Rotation” ‘n the In’dex for proper rotation pattern and additional information. (Se footnote 30,000 Miles (50 000 km) Change engine oil and filter (or every Emission Control Service.
Page 335 Long Tripmighway Maintenance Schedule 37,500 Miles (62 500 km) Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Lubricate chassis components (or every 12 months, whichever occurs first). (See footnote Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information.
Page 336 Long Tripmighway Maintenance Schedule 50,000 (83 000 krn) Miles (Continued) - In hilly or mountainous terrain. When doing frequent trailer towing. - Uses such as found in taxi, police or deliv If you do not use your vehicle under filter do not require changing. Manual transaxle fluid doesn’t require change.
Page 337 Long Tripmighway Maintenance Schedule R’otate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote ++.) (Also see footnote Inspect engine accessory drive belt. An Emission Control Service. Replace air cleaner filter. An Emission Control Service.
Page 338 Long Tripmighway Maintenance Schedule 75,000 Miles (125 000 km) Change engine oil and filter (or every 12 months, An Emission Control Service. Lubricate chassis components (or every 12 months, (See footnote #.$ Rotate tires. See “Tire Inspection and Rotation” rotation pattern and additional information. ++.) (Also see footnote 829500 Miles (137...
Page 339 TriplHighway Maintenance Long Replace air cleaner filter. Emission Control Service. Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.) Inspect Exhaust Gas Recirculation (EGR) system (2.2L Code 4 engine only). An Emission Control Service.
Page 340 Long Tripmighway Maintenance Schedule 100,000 Miles (I 66 000 km) €7 Replace spark plugs. An Emission Control Service. under one or more of these conditions: - In hilly or mountainous terrain. When doing frequent trailer towing. Manual transaxle fluid doesn’t require change. Miles 000 km) 150,000...
Page 341: At Each Fuel Fill
Part B: Owner Checks and Services Listed below are owner checks and services which should be performed at the intervals specified to help ensure the safety, dependability and emission control performance of your vehicle. Be sure any necessary repairs are completed at once. Whenever any fluids or lubricants are added to your vehicle, make sure they the proper ones, as shown in...
Page 342: At Least Twice A Year
It is not necessary to check the trr A transaxle fluid leak is the only Check for leaks. If a leak occurs, your Pontiac dealership Service I repaired as soon as possible. Hydraulic Clutch System Chec Check the fluid level in the clutcl “Hydraulic Clutch Fluid”...
Page 343: At Least Once A Year
At Least Once a Year Key Lock Cylinders Service Lubricate the key lock cylinders with the lubricant specified in Part D. Body Lubrication Service Lubricate all body door and rear compartment hinges. Also lubricate all hinges and latches, including the primary and secondary hood latch, glove box door, console door and any folding seat hardware.
Page 344 Brake-Transaxle Shift Interlock (BTSI) Check (Automatic Transaxle) ’ CAUTION: Whc you are doing this check, the vehicle move suddenly. If it does, you or others injured. Follow the steps below. Before you start, be sure you have enough ’ . around the vehicle.
Page 345 Parking Brake and Automatic Transaxle PARK (P) Mechanism Check ’ CAUTION: When you are doing this check, your vehicle could begin to move. You or others could be injured and property could be damaged. Make sure there is room in front of your vehicle in case begins roll.
Page 346 Part C: Periodic Maintenance Inspections Listed below are inspections and services which shc be performed at least twice a year (for instance, eac spring and fall). You should let your dealer’s servicl department or other qualified sewice center do thesl sure jobs.
Page 347: Brake System Inspection
Brake System Inspection Inspect the complete system. Inspect brake lines and hoses for proper hook-up, binding, leaks, cracks, chafing, etc. Inspect disc brake pads for wear and rotors surface condition. Also inspect drum brake linings for wear and cracks. Inspect other brake parts, including drums, wheel cylinders, calipers, parking brake, etc.
Page 348 Part D: Recommended Fluids and Lubricants NOTE: Fluids and lubricants identified below by n part number or specification may be obtained fro your dealer. FLUIDLUBRICANT Engine Oil with the American Petroleum Institute Certified F Gasoline Engines “Starburst” symbol of determine the for your vehicle’s engine, see “Engine Oil”...
Page 349 USAGE FLUIDRtUBRICANT Manual Chassis Lubricant (GM Part Transaxle Shift No. 12377985 or equivalent) or lubricant meeting requirements of Linkage NLGI 2, Category LB or GC-LB. Clutch Linkage Engine Oil. Pivot Points Chassis Chassis Lubricant (GM Part Lubrication No. 12377985 or equivalent) or lubricant meeting requirements of NLGI 2, Category LB...
Page 351: Maintenance Record
Maintenance Record ODOMETER DATE SERVICED BY MAINTENANCE PERFORMED READING...
Page 353: Section 8 Customer Assistance Information
Section 8 Customer Assistance Information Here you will find out how to contact Pontiac if you need assistance. This section also tells you how to publications and how to report any safety defects. Pontiac Cares What Makes Up Pontiac Cares?
Page 354: Pontiac Cares
Pontiac Cares PONTIAC CARES, you With are n'ever a phone call away from having your concern taken care 'of. The PONTUC CARES philosopl designed to make you realize that you as a valuable customer, appre decision, and is dedicated to takin...
Page 355: What Makes Up Pontiac Cares
Courtesy Transportation All of these elements combine to make your driving experience an enjoyable one, and are discussed in greater detail further in your owner’s manual. Pontiac is focusing on the changing needs of our customers and you an is committed...
Page 356 Pontiac dealers have the facilities, trained techici s and up-to-date information to promptly address any have. concerns However, if been resolved to your complete satisfaction, take th following steps: STEP Discuss your concern with a rnembe of de'alership management. Normally, concerns can be quickly resolved at that level.
Page 357: Customer Assistance For Text Telephone (Tty) Users
Vehicle delivery date and present mileage Nature of concern We encourage you to call us so we can give your inquiry prompt attention. However, if you wish to write Pontiac, address your inquiry to: Pontiac-GMC Customer Assistance Center P.O. Box 436008...
Page 358: Security While You Travel
Pontiac Roadside Assistance Prog Security While You Travel 1-800-ROADSI&E (1-800-762-3743) As the proud owner of a new Pontiac vehicle, automatically enrolled in the Pontiac Roadside u - w Assistance program. This value-; intended to provide you with pea drive in the city or travel the ope]...
Page 359: Canadian Roadside Assistance
Vehicle Identification Number (VIN) Vehicle license plate number Pontiac reserves the right to limit services or reimbursement to an owner or driver when in Pontiac’s judgement the claims become excessive in frequency or type of occurrence. While we hope that you never have the occasion to use our service, it is added security while traveling for you and your family.
Page 360 Pontiac Courtesy 'rransportatmn Pontiac strives to give you a worry-free ownership your vehicle, and we realize inconvenience of bekg without a car. So Pontiac has come up with a way to i eliminate any frustrations might have when tryiqg to get a...
Page 361: Gm Participation In An Alternative Dispute Resolution Program
Plan (CAMVAP). General Motors reserves the right to change eligibility limitations and/or to discontinue its participation in this program. Both Pontiac and your Pontiac dealer are committed to making sure you are completely satisfied with your new vehicle. Our experience has shown that, if a situation...
Page 362 We prefer you utilize Customer Satisfaction Procedure before you resort to AUTO LINE, but yo may contact BBB at any time. The BBB will at to resolve the complaint serving as this mediation is unsuccessful, an informal hearing will be scheduled where eligible customers may present eir case to impartial third-party arbitrator.
Page 363: Reporting Safety Defects To The Canadian Government
In addition to notifying NHTSA (or Transport Canada) situation like this, we certainly hope you’ll notify us. Please call us at 1-800-FM-CARES or write: Pontiac-GMC Customer Assistance Center P.O. Box 436008 Pontiac, MI 48343-6008 In Canada, please call us at 1-800-263-3777 (English) or 1-800-263-7854 (French). Or, write:...
Page 364 1998 PONTIAC SERVICE PU~BLICATIONS ORDERING I The following publications covering the operation and servicing of your vehicle the Service Publication credit CURRENT PUBLICATUONS FOR 1998 PONTIAC SERVICE Service Manuals have th’e diagnosis and repair infbrmation on engines, transmission, axle, suspensiion, brakes.
Page 366 NOTES...
Page 367: Section 9 Index
Section 9 Index ......A d a p t e r E t . CD Adding Equipment to the Outside of Your Vehicle .
Page 368 Brake Adjustment ........Fluid Master Cylinder .
Page 369 ........Tires ........Vinyl .
Page 370 Driving (Continued) ..... . In Foreign Countries In the Rain Night 'Curves On Hill and Mountain Roads On Snow and Ice Throughwater WetRoads .
Page 371 Front Reading Lamps ... . . Front Towing ..Fuel ....Filling a Portable Container .
Page 372 ......Installing the Boot Instrument Panel ......Brightness Control .
Page 373 ......Lubricants and Fluids ....Lubrication Service.
Page 374 ....Periodic Maintenance Inspections Pontiac Cares Information Power ........
Page 375 Rochng Your Vehicle ..Rotation. Tires Safety Belt Extender ..Safety Belts Adults ..... . . Care .
Page 376 Shifting ......Automatic Transaxle Into Park (P) ManuaI Transaxle Out of Park (P) Shoulder Belt Height Adjuster SigndingTurns .
Page 377 . . . Pressure Temperature ... . . Traction ....... . . Treadwe ar Uniform Quality Grading Used Replacement Wheel...
Page 378 Vehicle (Continued) . . . Identification Number hading .., ......4 - 3 2 .
Page 379 F e d Coupe Halogen Headlamps High1.o w Bear Dome...
Page 380 ' 6 1 ;...
Page 381 cities Transmission 5 Speed M Length Automatic Filter Change) Hear Read...

Pontiac 1998 Sunfire Owner's Manual

Quick Links

Related Manuals for Pontiac 1998 Sunfire

Summary of Contents for Pontiac 1998 Sunfire