Introduction - Patterson-Kelley STORM ST-2500 Installation & Owner's Manual

1 Introduction

This manual describes the installation and operation of
the following P-K STORM
controls.
ST-2500, ST-3000, ST-3500 & ST-4000:
•
Natural Gas, 208-240V (three phase)
•
Natural Gas, 440-480V (three phase)
NOTICE! This manual covers single fuel P-K
®
STORM boilers (Natural Gas).
Individual differences between boiler models will be
called out and defined in separate sections and the titles
of these sections will include the boiler model number. If
the boiler model numbers are not listed in the section
title, that section is common to all boiler models.
If you have any questions on the information contained
within, or do not fully and completely understand the
content, please contact Patterson-Kelley Technical
Service at 570.476.7261 or toll free at 877.728.5351.
™
The P-K STORM gas-fired boiler is fully modulating
using a variable speed combustion blower, sophisticated
microprocessor controls, modulating gas safety shut off /
control valves and a unique stainless steel heat
exchanger capable of operating in a fully condensing
mode to provide maximum efficiency in a minimum
amount of space. The high-quality materials and design
of the boiler should provide years of trouble-free service
if the instructions in this manual are followed carefully.
The boiler is only a part of the complete heating system.
This boiler may be fully operational but because of poor
circulation, improper control, or other site related
characteristics, not deliver heat to the desired location.
Additional equipment such as temperature sensors,
pumps, flow switches, balancing valves, and check
valves will be required for satisfactory operation of any
system. Patterson-Kelley cannot be responsible for the
design or operation of such systems and a qualified
engineer or contractor must be consulted.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
Ne pas entreposer ni utilizer d'essence ou ni
d'autres vapeurs ou liquids inflammables à
proximité de cet appareil ou de tout autre
Revised: June 26, 2020
Released: June 26, 2020
™
boilers featuring NURO
appareil.
© Patterson-Kelley 2020
All Rights Reserved.
Technical Service 1.877.728.5351
If the information in this manual is not
®
followed, fire or explosion may result causing
property damage, personal injury, or loss of
life.
Do not store or use gasoline or other
flammable vapors or liquids in the vicinity of
this or any other appliance. Installation and
service must be performed by a qualified
installer, service agency, or the gas supplier.
WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas
supplier's instructions.
• If you cannot reach your gas supplier,
call the fire department.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR
• Ne pas tenter d'allumer d'appareils.
• Ne touches à aucun interrupteur. Ne pas
vous server des téléphones dans le
bâtiment où vous vous trouvez.
• Appelez immédiatement votre
fournisseur de gaz depuis un voisin.
Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoinder le
fournisseur de gaz, appelez le service
des incendies.
It is essential to read, understand, and follow
the recommendations of this manual before
installing, operating or servicing this
equipment. Failure to do so could result in
personal injury or death.
Installation and service must be performed
by a qualified and knowledgeable individual
who has been certified on the
boiler. The features which permit this boiler
to achieve high-efficiency performance can
be misused which could result in personal
Installation and Owners Manual Rev A.docx
TM
P-K Storm Gas Fired Boiler
DE GAZ:
P-K STORM
injury or death.
2691000273 P-K Storm ST2500-ST4000
™
Page viii