Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
EN 2 QM15.1L LA Revision List 1. Revision List Manual xxxx xxx xxxx.0 Manual xxxx xxx xxxx.2 • First release. • Chapter 2: Updated table 2.1 Technical Specifications. • Chapter 6: Updated tables 6-2 White tone default settings 6-3 Display code overview.
Page 3
Technical Specs, Diversity, and Connections QM15.1L LA EN 3 Connections Rear Connectors Side Connectors HDMI 1 SPDIF NETWORK TV ANTENNA HDMI 3 HDMI 4 AUDIO IN ARC/2.0 HDMI 2 SERV.U 19920_001.eps Figure 2-1 Connection overview Note: The following connector colour abbreviations are used 4- USB1 2.0...
Page 4
EN 4 QM15.1L LA Technical Specs, Diversity, and Connections 12 - CLK- Data channel Rd - Audio - R 0.5 V / 10 kW 13 - Easylink/CEC Control channel 14 - ARC Audio Return Channel 11 - HDMI 1: Digital Video - In, Digital Audio with ARC -...
Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 QM15.1L LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M.
Page 7
Precautions, Notes, and Abbreviation List QM15.1L LA EN 7 DRAM Dynamic RAM a maximum data rate of 270 Mbit/s, Digital Rights Management with a minimum bandwidth of 135 Digital Signal Processing MHz. Dealer Service Tool: special remote Institutional TeleVision; TV sets for control designed for service hotels, hospitals etc.
Page 8
SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
Mechanical Instructions QM15.1L LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal(for 7100 series) 4.4 Assembly/Panel Removal(for 6801 series)
Page 13
Mechanical Instructions QM15.1L LA EN 13 Service Positions Assembly/Panel Removal(for 7100 series) For easy servicing of a TV set, the set should be put face down Instructions below apply to the 55PUG7100/77, but will be on a soft flat surface, foam buffers or other specific workshop similar for other 7100 series models.
Page 14
EN 14 QM15.1L LA Mechanical Instructions M3 × 8 M3× 8 M3 × 6 Q3 × 6 19920_105.eps Figure 4-9 Rear cover removal [1] 4. Lift the ambilight panel from the rear cover. Make sure that wires and flat foils are not damaged while lifting the ambilight panel from the rear cover.
Page 15
Mechanical Instructions QM15.1L LA EN 15 19920_107.eps Figure 4-11 Keyboard & Ambilight removal 4.3.4 Small Signal Board (SSB) 4.3.5 Power Supply Unit (PSU) Refer to Figure 4-12 for details. Caution: it is mandatory to remount all different screws at their Caution: it is mandatory to remount all different screws at their original position during re-assembly.
Page 16
EN 16 QM15.1L LA Mechanical Instructions 4. Remove the SSB as described earlier. 4.4.1 Rear Cover 5. Remove the PSU as described earlier. 6. Remove the speakers as described earlier. Refer to Figure 4-13 for details. 7. Remove the IR/LED board as described earlier.
Page 17
Mechanical Instructions QM15.1L LA EN 17 4.4.2 Keyboard Control unit 3. Gently take the keyboard out. Refer to Figure 4-15 details. When defective, replace the whole unit. 1. Unplug the connector [2] from the keyboard control panel. 2. Remove the fixation screws [1] that secure the keyboard 20110_105.eps...
Page 18
EN 18 QM15.1L LA Mechanical Instructions 4.4.4 IR/LED Board 3. Take the speakers out. When defective, replace the both units. Refer to Figure 4-17 Figure 4-18 for details. 1. Remove the fixation screws [1] from the stand bracket, pull 4.4.7 LCD Panel out the assy from the set.
Service Modes, Error Codes, and Fault Finding QM15.1L LA EN 19 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: SAM in a decimal value. Every two soft-resets increase the 5.1 Test Points hour by + 1. Stand-by hours are not counted.
Page 20
EN 20 QM15.1L LA Service Modes, Error Codes, and Fault Finding Table 5-1 SAM mode overview Main Menu Sub-menu 1 Sub-menu 2 Description Hardware Info SW version e.g. TPM156L.3.186.0.37” See paragraph Software Identification, Version, and Cluster for the software name definition.
Page 21
Service Modes, Error Codes, and Fault Finding QM15.1L LA EN 21 Table 5-2 Factory mode overview Default value Item Item value 43" 49" 55" 65" Description F/W VERSION Press OK Displays the software versions of the supplier, Flash PQ, Smart Picture, BL Dimming, Source Meter, the Picture Quality checksum, the Dimming library, the Source meter library, the Flash AQ, MCU and OAD software versions.
Page 22
EN 22 QM15.1L LA Service Modes, Error Codes, and Fault Finding The CSM is a read-only mode; therefore, modifications are not • 3.4 Ethernet MAC address A Media Access Control possible in this mode. address (MAC adress) is a unique identifier assigned to network interfaces for communications on the physical network segment.
Page 23
Service Modes, Error Codes, and Fault Finding QM15.1L LA EN 23 Stepwise Start-up Standby Soft Mode Command Received, Switch previously in Standby Off(Mains Soft Mode (Power tact Standby Power Plug) switch) Digital Digital background background tasks started tasks completed TV Wakeup...
Page 24
A description on how to upgrade the main 1. ComPair helps to quickly get an understanding on how to software can be found in the DFU or on the Philips website. repair the chassis in a short and effective way.
Page 25
Service Modes, Error Codes, and Fault Finding QM15.1L LA EN 25 • FUS_clustername_version.zip: Contains the file downloaded which is needed to upgrade the TV main software and the software download application. • NVM_clustername_version.zip: Default NVM content. Must be programmed via ComPair.
Page 26
EN 26 QM15.1L LA Service Modes, Error Codes, and Fault Finding – ERROR: 034 013 000 000 000: Error code 13 was Caution: detected first and error code 34 is the last detected • Do not change these, without understanding the function of...
Alignments QM15.1L LA EN 27 6. Alignments Index of this chapter: In case you have a colour analyser: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyser (e.g. Minolta CA-210) in the centre of the screen.
Page 28
EN 28 QM15.1L LA Alignments After a repaired SSB has been mounted in the set (set repair Colour temperature on board level), the type number (CTN) and production code of Picture mode Screen size Green Blue the TV has to be set according to the type plate of the set. For...
7. Circuit Descriptions Index of this chapter: Introduction 7.1 Introduction The QM15.1L LA is a new chassis launched in LATAM in 7.2 Power Supply 2015. The whole range is covered by MT5593UPIJ 7.3 DC/DC Converters HSBGA-900 main IC, so-called MT5593 platform. The major 7.4 Front-End Analogue and DVB-T, DVB-C;...
Page 30
EN 30 QM15.1L LA Circuit Descriptions 7.1.3 SSB Cell Layout DC/DC DC/DC DC/DC NT3333 DC/DC DC/DC ANALOG I/O DC/DC MT5593 HDMI SERVICE DC/DC CONNECTOR NETWORK TUNER NETWORK NETWORK Audio in Headphone SPDIF OUT HDMI 19920_200.eps Figure 7-1 SSB layout cells (top view)
Page 31
The following displays can be distinguished: specifications! This part is available in the regular market. • CCFL/EEFL backlight: power panel is conventional IPB Consult the Philips Service web portal for the order codes of the • LED backlight: boards. - side-view LED without scanning: PSL power panel - side-view LED with scanning: PSLS power panel Important delta’s with the QM15.1L LA classis platform are:...
Page 32
EN 32 QM15.1L LA Circuit Descriptions 7.2.3 Connector overview Table 7-1 Connector overview Connector 43" 49" & 55" 65" power board 715G6679 driver board 715G7111 power board 715G6973 driver board 715G7111 power board 715G6887 driver board(outsourcing Number CN9101 CN9201 CN8602...
Page 33
Circuit Descriptions QM15.1L LA EN 33 Figure 7-3 DC/DC converters Front-End Analogue and DVB-T, DVB-C; HDMI ISDB-T reception Refer to figure 7-6 HDMI input configuration for the application. 7.4.1 Front-End Analogue part MHL_SENSE The Front-End for analogue tuner consist of the following key...
Page 34
EN 34 QM15.1L LA Circuit Descriptions reach very smooth picture quality for motions. A 3D comb filter added to the TV decoder recovers great details for still pictures. The special color processing technology provides a natural deep colors and true studio quality video. Moreover , the MT5593 family has built-in high resolution and high-quality audio codec.
IC Data Sheets QM15.1L LA EN 35 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic”...
Page 36
EN 36 QM15.1L LA IC Data Sheets Diagram 10-5-3 Peripheral (4) B03, MT5593UPIJ (IC U401) Block diagram MT5593FPIJ/UPIJ 19930_300.eps Figure 8-2 Internal block diagram and pin configuration back to 2017-May-27 div.table...
Page 37
IC Data Sheets QM15.1L LA EN 37 Pinning Information MT5593FPIJ/UPIJ HDMI_ HDMI_ HDMI_ HDMI_ HDMI_ HDMI_ HDMI_ HDMI_ AVDD AVDD AVDD DEMO CI_A1 CI_MD CI_MD SPI_D CI_TS SSUSB AIN_R AIN_R USB_D USB_D SSUSB SSUSB 0_RX_ 0_RX_ 0_RX_ 0_RX_ 1_RX_ 1_RX_...
Page 38
EN 38 QM15.1L LA IC Data Sheets Diagram10-5-8 Speaker/Headphone(6) B8, TAS5760LDDCAR (IC U601) Block diagram TAS5760LD PVDD GVDD_REG Internal Internal Reference Internal Gate DRVDD Voltage Regulators Drive Regulator Supplies Closed Loop Class D Amplifier SFT_CLIP Full Bridge Digital to SPK_OUTA+...
Page 39
IC Data Sheets QM15.1L LA EN 39 Diagram10-5-11 ISDBT Tuner(1) B11, TC90537FG (IC U101) Block diagram TC90537FG Quadrature Interpolation ISIC Adaptive (unguarded IF input Filter Frequency Pilot detection phase pre/post echo interpolation or IQ input extraction suppression) Correction filter Tuner...
Page 40
EN 40 QM15.1L LA IC Data Sheets Diagram10-5-17 NVT333_DDR2 (4) B17, NT72333TBG/C (IC U5000) Block diagram NT72333TBG/C 19920_303.eps Figure 8-6 Internal block diagram back to 2017-May-27 div.table...
Page 41
IC Data Sheets QM15.1L LA EN 41 Pinning Information NT72333TBG/C 19920_304.eps Figure 8-7 Internal pin configuration back to 2017-May-27 div.table...
Page 42
EN 42 QM15.1L LA IC Data Sheets Personal Notes: 10000_012_090121.eps 110804 back to 2017-May-27 div.table...
Block Diagrams QM15.1L LA EN 43 9. Block Diagrams Block diagram 7100/6801 series Wi-Fi/BT 1x DDR3 1x DDR3 1600 1600 Ethernet 1Gbit 1Gbit USB 2.0 USB 2.0 8-Lane Vx1 8 Lane Vx1 USB 2.0 USB 3.0 LVDS/Vx1 UHD60 Transmitter NT333...
Page 46
Circuit Diagrams and PWB Layouts QM15.1L LA EN 46 10-1-3 Main Power Main Power COLD 12VS L9105 Q9111 C9110 IC9104 new part(ER31) 470UF 25V P1604ED +12V C9130 NC_L78L12ABUTR R9151 T9101 100KOHM +-5% 1/8W POWER X'FMR 100N 50V SY NC R9124...
Page 47
Circuit Diagrams and PWB Layouts QM15.1L LA EN 47 10-1-4 CN8601 HS9202 +VLED CN9201 COLD CONN -VLED-1 R8105 +VLED +VLED R8156 0.1R D8602 +24V for PSU function C9114 NC/0 OHM +-5% 1/8W FMXA-2203SE HEAT SINK +12V 3D_DB BL_ON/OFF -VLED-2 C8104...
Page 48
Circuit Diagrams and PWB Layouts QM15.1L LA EN 48 10-1-5 Power layout top J901 CN8601 GND5 J902 CN9101 L9102 C9126 L8601 GND4 CN9201 J903 J946 J907 J906 J905 J908 J909 C8605 C8607 C9110 C9112 J910 J911 C8606 J912 SU10 FB8601...
Circuit Diagrams and PWB Layouts QM15.1L LA EN 65 10.5 B 715G7161 SSB 10-5-1 System Power 1(7) System Power 1(7) +12V_SKYPE +12V_SKYPE 16 +12V-AMBI +12V-AMBI +12V-AMBI 6 +12V +12V 6,12,20 BRIGHT_ADJ: INVERTER_ON_OFF: OPWRSB: Normal:Max:+3V3, Min:0V Normal: High Normal: High MAIN POWER...
Page 66
Circuit Diagrams and PWB Layouts QM15.1L LA EN 66 10-5-2 System Power 2(7) System Power 2(7) PANEL_VCC_ON/OFF 13,24,25 PANEL_VCC_ON/OFF +5V_SW 5,11,14,15,16,18,24 +5V_SW +12V 5,12,20 +12V DVDD3V3 5,7,8,12,13,15,16,17,18,19,20,24 DVDD3V3 +12V-AMBI +12V-AMBI +12V-AMBI 5 AMBI-POWER AMBI-POWER AMBI-POWER 16 PANEL_VCC 13,24 PANEL_VCC 5,7,8,9,10,11,12,13,14,15,16,17,18,19,20,21,23,24,25,26,27,28...
Page 71
Circuit Diagrams and PWB Layouts QM15.1L LA EN 71 10-5-7 CVBS/DVI Audio IN (1) CVBS/DVI Audio IN (1) U401-4 5,6,7,8,9,10,12,13,14,15,16,17,18,19,20,21,23,24,25,26,27,28 A n a l o g P o w AIN_R0 AR0O AIN_R0 AR0_ADAC AIN_L0 AL0O AIN_L0 AL0_ADAC AIN_R1 AVDD3V3 AVDD3V3...
Page 74
Circuit Diagrams and PWB Layouts QM15.1L LA EN 74 10-5-10 MHL/HDMI Input(5) MHL/HDMI Input(5) U401-6 HDMI_CEC R501 RX_0_0 HDMI_CEC HDMI_0_RX_0 5,6,7,8,9,10,11,12,13,15,16,17,18,19,20,21,23,24,25,26,27,28 100R 1/16W 5% RX_0_0B A n a l o g P o w HDMI_0_SCL HDMI_0_RX_0B RX_0_1 HDMI_0_SCL HDMI_0_RX_1 HDMI_1_SCL...
Page 75
Circuit Diagrams and PWB Layouts QM15.1L LA EN 75 10-5-11 ISDBT Tuner(1) ISDBT Tuner(1) I S D B - T T U N E R & D e m o d u l a t o r C I R C U I T...
Page 76
Circuit Diagrams and PWB Layouts QM15.1L LA EN 76 10-5-12 Internal CONN(4? Internal CONN(4) OSDA1 3V3SB K E Y P A D A R D OSDA1 OSCL1 OSCL1 LED_PWM0 7,17 LED_PWM0 R4100 LED_PWM1 7,17 LED_PWM1 6.8K +-1% 1/16W 3 1 1 G...
Page 78
Circuit Diagrams and PWB Layouts QM15.1L LA EN 78 10-5-14 USB/ETHERNET PHY (4) USB/ETHERNET PHY (4) 5,6,7,8,9,10,11,12,13,14,15,16,17,19,20,21,23,24,25,26,27,28 E T H E R N E T P H Y 3V3SB M u s t d i f f e r e n t i a l...
Page 80
Circuit Diagrams and PWB Layouts QM15.1L LA EN 80 10-5-16 NVT333_D/D (4) NVT333_D/D (4) DVDD3V3 +12V R4901 NC/0R05 1/16W NVT324_DD_PG S Y 8 3 6 6 ( 3 5 6 G D 5 6 3 0 1 0 2 0 5 )
Page 81
Circuit Diagrams and PWB Layouts QM15.1L LA EN 81 10-5-17 NVT333_DDR2 (4) NVT333_DDR2 (4) U5000A FRC_MMU_VREF DDR_VREF FRC_DDRA_VREF MCM_A_VREF AF25 FRC_DDRB_VREF MCM_B_VREF NT72333 FRC_1.8V FRC_1.8V FRC_1.8V L a y o u t : L a y o u t :...
Page 82
Circuit Diagrams and PWB Layouts QM15.1L LA EN 82 10-5-18 NVT333_RX_LVDS (4) NVT333_RX_LVDS (4) F o r L V D S L a y o u t : 1. Trace length difference require < 100mil under same group.(PortAB, PortCD) 2. Each P/N pair length difference require < 10mil if possible.
Page 83
Circuit Diagrams and PWB Layouts QM15.1L LA EN 83 10-5-19 NVT333_RX_VB1 (4) NVT333_RX_VB1 (4) For Vx1 RX Layout: 1. Trace length difference require < 100mil under same group.(VRX Lane0-3; VRX Lane4-7) 2. Each P/N pair length difference require < 10mil if possible.
Page 85
Circuit Diagrams and PWB Layouts QM15.1L LA EN 85 10-5-21 NVT333_GPIO (4) NVT333_GPIO (4) SCL_MASTER_PANEL SCL-DISP U5000E SCL-DISP SDA_MASTER_PANEL SDA-DISP SDA-DISP PANEL I2C IF DEBUG_IF TO DEBUG UART_TX NT-3D-EN R5085 33R 1/16W 5% GPIOA00 GPIOB00 TO DEBUG UART_RX GPIOA01 GPIOB01...
Page 86
Circuit Diagrams and PWB Layouts QM15.1L LA EN 86 10-5-22 NVT333_SYSTEM (4) NVT333_SYSTEM (4) U5000F 1 2 M C R Y S T A L MTEST XTAL_OUT X 1 : + / - 3 0 P P M , 2 . 5 V ,...
Page 87
Circuit Diagrams and PWB Layouts QM15.1L LA EN 87 10-5-23 NVT333_POWER (4) NVT333_POWER (4) R E S E R V E H E A T - S I N K A R E A f o r M a i n C h i p FRC_1.1V...
Circuit Diagrams and PWB Layouts QM15.1L LA EN 93 10.7 J 715G7074 IR/LED Panel 10-7-1 IR & 3D & Light sensor & LOGO IR & 3D & Light sensor & LOGO Standby Lighting LOGO IR Receiver 3V3SB 3V3SB CN201 3V3SB...
Circuit Diagrams and PWB Layouts QM15.1L LA EN 95 10.8 E 715G7188 Keyboard control panel 10-8-1 CONN TO SSB JOYSTICK Direction switch Key function Resistance Voltage Center 2-5 short Menu CN01 Right 1-5 short 0.5V KEY 1 AMBI_SPI_CLK Left 4-5 short 0.81V...
Page 96
Circuit Diagrams and PWB Layouts QM15.1L LA EN 96 10-8-2 Key board layout Layout Keyboard control panel (top side) Layout Keyboard control panel (bottom side) SW01 SW11 2014-11-06 Keyboard control panel 715G7118 layout top/bottom 19792_511.eps back to 2017-May-27 div.table...
Circuit Diagrams and PWB Layouts QM15.1L LA EN 97 10.9 E 715G7088 Keyboard control panel 10-9-1 JOYSTICK Direction switch Key functionResistance Voltage Center 2-5 short Menu Right 1-5 short 0.5V CN01 KEY 1 Left 4-5 short 0.81V Down 3-5 short VOL- 1.65V...
Page 98
Circuit Diagrams and PWB Layouts QM15.1L LA EN 98 10-9-2 Key board layout Layout Keyboard control panel (top side) SW01 Layout Keyboard control panel (bottom side) 2014-06-06 Keyboard control panel 715G7088 layout top/bottom 19850_525.eps back to 2017-May-27 div.table...
Circuit Diagrams and PWB Layouts QM15.1L LA EN 99 10.10 V 715G7111 Converter board 10-10-1 LED OZ9908A LED OZ990BA 43 inch L8601 R8125 R8126 49/55 inch L8602 L8602 43 inch 2.2A NC/47uH ADIM2 49 inch 1.875A ON OFF FB8601 55 inch 2.5A...
Circuit Diagrams and PWB Layouts QM15.1L LA EN 102 10.11 ALC 715G7046 LED Board 10-11-1 Lited LED Lited LED 3V3SB 3V3SB LED301 LED302 R301 R303 2R2 1/16W 5% 2R2 1/16W 5% R302 Q301 CN301 1K 1/16W 5% BC847C LOGO 3V3SB...
Page 103
Circuit Diagrams and PWB Layouts QM15.1L LA EN 103 10-11-2 Converter layout Layout LED LOGO Board (top side) CN301 Q301 Layout LED LOGO Board (bottom side) 2014-11-01 LED LOGO Board 715G7046 layout top/bottom 19792_513.eps back to 2017-May-27 div.table...