Page 1 All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by ER/EL 0965 BU TV Consumer Care, the Netherlands...
Page 2: Revision List
Styling Published in: 32PFL9604H/12 Elite Core 3122 785 18310 32PFL9604H/60 3122 785 18310 37PFL9604H/12 3122 785 18310 37PFL9604H/60 3122 785 18311 56PFL9954H/12 3122 785 18311 Directions for Use You can download this information from the following websites: http://www.philips.com/support http://www.p4c.philips.com 2009-May-08...
Page 3 Technical Specifications and, Connections Q549.2E LA EN 3 Connections SERVICE UART AUDIO IN VGA NETWORK 18310_001_090317.eps 090317 Figure 2-1 Connection overview 2009-May-08...
Page 4 EN 4 Q549.2E LA Technical Specifications and, Connections Note: The following connector colour abbreviations are used Cinch: S/PDIF - Out (acc. to DIN/IEC 757): Bk= Black, Bu= Blue, Gn= Green, Gy= Bk - Coaxial 0.4 - 0.6V / 75 ohm Grey, Rd= Red, Wh= White, Ye= Yellow.
Page 5 Technical Specifications and, Connections Q549.2E LA EN 5 Cinch: Audio - In (VGA/DVI) - Shield Rd - Audio R 0.5 V / 10 kohm - D1- Data channel Wh - Audio L 0.5 V / 10 kohm - D0+ Data channel - Shield - D0- Data channel...
Page 6 Spare Parts • Check the strain relief of the Mains/AC Power cord for proper function. For the latest spare part overview, consult your Philips Spare • Check the electrical DC resistance between the Mains/AC Part web portal. Power plug and the secondary side (only for sets that have a Mains/AC Power isolated power supply): 1.
Page 7 Precautions, Notes, and Abbreviation List Q549.2E LA EN 7 3.3.6 Alternative BOM identification Abbreviation List It should be noted that on the European Service website, 0/6/12 SCART switch control signal on A/V “Alternative BOM” is referred to as “Design variant”. board.
Page 8 6.5 MHz. L' is Band E-DDC Enhanced Display Data Channel I, L is all bands except for Band I (VESA standard for communication LG.Philips LCD (supplier) channel and display). Using E-DDC, Loudspeaker the video source can read the EDID LVDS Low Voltage Differential Signalling information form the display.
Page 9 System on Chip Sync On Green SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4- wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board STBY STand-BY SVGA 800 ×...
Page 10: Mechanical Instructions
EN 10 Q549.2E LA Mechanical Instructions 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing and Taping • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assy/Panel Removal 4.4 Set Re-assembly Cable Dressing and Taping 18310_210_090318.eps...
Page 11 Mechanical Instructions Q549.2E LA EN 11 18310_211_090318.eps 090318 Figure 4-2 Cable dressing 37" 18311_200_090506.eps 090506 Figure 4-3 Cable dressing 56" (21:9) 2009-May-08...
Page 12 EN 12 Q549.2E LA Mechanical Instructions Service Positions 4.3.3 Ambi Light Each Ambi Light unit is mounted on a subframe. Refer to For easy servicing of this set, there are a few possibilities Figure 4-5 for details. created: • The buffers from the packaging. •...
Page 13 Mechanical Instructions Q549.2E LA EN 13 1. Remove the Main Supply Panel as earlier described. 2. Remove the stand [1] and its subframe [2]. 3. Now you gain access the IR & LED board. When defective, replace the whole unit. 4.3.6 Piezo Touch Control Panel The flexfoil between Piezo Flexfoil Assy (mounted on the...
Page 14 EN 14 Q549.2E LA Mechanical Instructions 18310_217_090318.eps 090320 Figure 4-10 LCD Panel -1- 18310_218_090318.eps 090319 Figure 4-11 LCD Panel -2- 4.3.9 Wi-Fi antenna Follow the instructions for LCD Panel until “remove plastic rim”. After removal of this rim, you gain access to the Wi-Fi antennas.
Page 15: Service Modes, Error Codes, And Fault Finding
Service Modes, Error Codes, and Fault Finding Q549.2E LA EN 15 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: • All service-unfriendly modes (if present) are disabled, like: 5.1 Test Points – (Sleep) timer. 5.2 Service Modes –...
Page 16 “OK” button on the RC. Code Contents of SAM (see also Table 6-4) 39mm • Hardware Info. PHILIPS – A. SW Version. Displays the software version of the MODEL: 32PF9968/10 main software (example: Q5492-1.2.3.4 = PROD.SERIAL NO: AG 1A0620 000001 AAAAB_X.Y.W.Z).
Page 17 Service Modes, Error Codes, and Fault Finding Q549.2E LA EN 17 • With the “OK” key, it is possible to activate the selected NVM. ComPair will foresee in a possibility to do this. This action. identification number is the 12nc number of the SSB. •...
Page 18 EN 18 Q549.2E LA Service Modes, Error Codes, and Fault Finding Stepwise Start-up mode with a faulty FET 7U08 is done, you can destroy all IC’s supplied by the +3V3, due to overvoltage (12V on 3V3-line). It is recommended to measure first the FET 7U08 or others When the TV is in a protection state due to an error detected by FET’s on shortcircuit before activating SDM via the service stand-by software (error blinking is displayed) and SDM is...
Page 19 Service Modes, Error Codes, and Fault Finding Q549.2E LA EN 19 Stand by or Mains is applied Protection Standby Supply starts running. All standby supply voltages become available . st-by µP resets Initialise I/O pins of the st-by µP: If the protection state was left by short circuiting the - Switch reset-AVC LOW (reset state) SDM pins, detection of a protection condition during - Switch WP-NandFlash LOW (protected)
Page 20 EN 20 Q549.2E LA Service Modes, Error Codes, and Fault Finding From I_17660_125a.eps From I_17660_125a.eps Reset-system is switched HIGH by the Reset-system is switched HIGH by the Release reset MPEG4 module: AVC at the end of the bootscript AVC at the end of the bootscript BOLT-ON-IO: High Reset-system is connected to USB -reset,...
Page 21 Service Modes, Error Codes, and Fault Finding Q549.2E LA EN 21 Constraints taken into account: - Display may only be started when valid LVDS output clock can be delivered by the AVC . - Between 5 and 50 ms after power is supplied, display should receive valid lvds clock . action holder: AVC - minimum wait time to switch on the lamp after power up is 200ms.
Page 22 EN 22 Q549.2E LA Service Modes, Error Codes, and Fault Finding Constraints taken into account: - Display may only be started when valid LVDS output clock can be delivered by the AVC . - Between 5 and 50 ms after power is supplied, display should receive valid lvds clock . action holder: AVC - minimum wait time to switch on the lamp after power up is 200ms.
Page 23 Service Modes, Error Codes, and Fault Finding Q549.2E LA EN 23 action holder: AVC Constraints taken into account: - Display may only be started when valid LVDS output clock can be delivered by the AVC . action holder : St-by - Between 5 and 50 ms after power is supplied, display should receive valid lvds clock .
Page 24 EN 24 Q549.2E LA Service Modes, Error Codes, and Fault Finding action holder: AVC Active action holder: St-by autonomous action Mute all sound outputs via softmute Wait 100ms Set main amplifier mute (I/O: audio-mute) Force ext audio outputs to ground (I/O: audio reset) And wait 5ms switch off Ambilight...
Page 25 Service Modes, Error Codes, and Fault Finding Q549.2E LA EN 25 Semi Stand by action holder: MIPS action holder: St-by autonomous action If ambientlight functionality was used in semi -standby (lampadaire mode), switch off ambient light *) If this is not performed and the set is Delay transition until ramping down of ambient light is switched to standby when the switch off of finished.
Page 26 EN 26 Q549.2E LA Service Modes, Error Codes, and Fault Finding action holder: MIPS action holder: St-by autonomous action Log the appropriate error and set stand-by flag in NVM Redefine wake up reasons for protection state and transfer to stand-by µP. Switch off LCD lamp supply If needed to speed up this transition, Wait 250ms (min.
Page 27 5.4.1 ComPair if the PNX5100 is enabled and audio-testing. Introduction What is needed? ComPair (Computer Aided Repair) is a Service tool for Philips – An USB-stick Consumer Electronics products. and offers the following: – “TESTSCRIPT Q549”. Downloadable from the Philips 1.
Page 28 EN 28 Q549.2E LA Service Modes, Error Codes, and Fault Finding For all errors detected by MIPS which are fatal => • Via polling on I/O pins going to the stand-by processor. rebooting of the TV set (reboot starts after LAYER 1 •...
Page 29 Service Modes, Error Codes, and Fault Finding Q549.2E LA EN 29 Table 5-2 Error code overview Monitored Error/ Error Buffer/ Description Layer 1 Layer 2 Prot Blinking LED Device Defective Board MIPS BL / EB MIPS BL / EB SSB/Display SSB/display PNX doesn’t boot (HW cause) Stby µP...
Page 30 EN 30 Q549.2E LA Service Modes, Error Codes, and Fault Finding logged and displayed via the blinking LED procedure when • Activate the CSM. The blinking front LED will show only SDM is switched on. the latest layer 1 error, this works in “normal operation” •...
Page 31 Service Modes, Error Codes, and Fault Finding Q549.2E LA EN 31 loudspeakers will move slowly in one or the other direction started immediately when +12V incoming voltage is available until the initial failure shuts the amplifier down, this cyclus (+12V is enabled by STANDBY signal, active low). Supply starts over and over again.
Page 32 EN 32 Q549.2E LA Service Modes, Error Codes, and Fault Finding look for item “DisplayRawNumber” in the beginning of the logging. Tip: when there is no picture available during rebooting you are able to check for “error devices” in the logging (LAYER 2 error) which can be very helpful to determine the failure cause of the reboot.
Page 33 Service Modes, Error Codes, and Fault Finding Q549.2E LA EN 33 5.8.15 SSB Replacement Follow the instructions in the flowchart in case a SSB has to be exchanged. See figure “SSB replacement flowchart”. Instruction note: SSB replacement Q528.x, Q522.x, Q529.x, Q54x.x Q54x.x START Set is still...
Page 34 Service 1. Disconnect the TV from the Mains/AC Power. technicians. 2. Press the “OK” button on a Philips TV remote control or a • FlashUtils_Q5492_x.x.x.x_commercial.zip. Not to be Philips DVD RC-6 remote control (it is also possible to use used by Service technicians.
Page 35 (UPG). This SW is not part of the FUS autorun.upg! and is not available in the One-Zip software file but provided separately via the commercial Philips website (software for servicers only). Instructions for upgrading are included in the zip file.
Page 36 EN 36 Q549.2E LA Alignments 6. Alignments Index of this chapter: • EU/AP-PAL models: a PAL B/G TV-signal with a signal 6.1 General Alignment Conditions strength of at least 1 mV and a frequency of 475.25 MHz 6.2 Hardware Alignments •...
Page 37: Option Settings
Alignments Q549.2E LA EN 37 • Set the RED, GREEN and BLUE default values according The first line (group 1) indicates hardware options 1 to 4, the to the values in Table 6-2. second line (group 2) indicate software options 5 to 8. •...
Page 38 This implies that only a main software upgrade is 2. Download the latest main software (FUS) from the required if you use a “repaired” SSB for board swap instead of www.p4c.philips.com website. a “new” SSB. Total Overview SAM modes...
Page 39 Alignments Q549.2E LA EN 39 Main Menu Sub-menu 1 Sub-menu 2 Sub-menu 3 Description Dealer options Picture mute Off/On Select Picture mute On/Off. Picture is muted / not muted in case no input signal is detected at input connectors. Virgin mode Off/On Select Virgin mode On/Off.
Page 40 EN 40 Q549.2E LA Alignments Main Menu Sub-menu 1 Sub-menu 2 Sub-menu 3 Description Audio reproduction Acoustic system Cabinet design used for setting dynamic audio pa- rameters. Source selection EXT1/AV1 type SCART CVBS RGB LR Select input source when connected with external equipment.
Page 41 Alignments Q549.2E LA EN 41 Main Menu Sub-menu 1 Sub-menu 2 Sub-menu 3 Description Development file ver- Development 1 file version Display parameters DISPT 3.26.8.7 Display information is for development purposes. sions Acoustics parameters ACSTS 3.6.6.5 PQ - PRFPP 1.26.10.4 Ambilight parameters PRFAM 2.6.1.3 Development 2 file version 12NC one zip software...
Page 42: Architecture Elite Core Platform Overview
EN 42 Q549.2E LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: Main difference with the previous platform is the introduction of 7.1 Introduction “Net TV” and “CI+”. 7.2 Power Architecture 7.3 Front-End 7.1.1 Implementation 7.4 HDMI 7.5 Video and Audio Processing - PNX8543 Key components of this chassis are: 7.6 Common Interface CI+ •...
Page 43 Circuit Descriptions Q549.2E LA EN 43 7.1.3 SSB Cell Layout 1M71 1M59 1M01 1F02 1R12 serv Xilinx 1E51 DDR2 1E50 uart Head PCI/ pci/xio ² Right Left DDR2 CVBS Tuner PNX8542/3 GPIO Wifi DDR2 HDMI RJ45 Ethernet 1P00 FLASH Class-D 18310_201_090317.eps 090317 Figure 7-2 SSB layout cells (top view)
Page 44: Power Architecture Platform
EN 44 Q549.2E LA Circuit Descriptions Power Architecture Refer to figure Figure 7-3 for the power architecture of this platform. F use 12VD isp V display P la tfo rm LC D P o w e r Power-on Standby PNX5100 3V3stby +3V3 stby +1V2...
Page 45 Circuit Descriptions Q549.2E LA EN 45 Front-End P la tfo rm w ith e m b e d d e d E D ID The Front-End consist of the following key components: • Tuner HD1816AF E D ID : 2 5 3B •...
Page 46 EN 46 Q549.2E LA Circuit Descriptions PNX8543x MEMORY CONTROLLER TS in from channel decoder MPEG SYSTEM CI/CA LVDS for TS out/in for PRIMARY PROCESSOR flat panel display VIDEO PCMCIA LVDS (single or dual OUTPUT channel) DV-ITU-656 DV INPUT AV-PIP SUB-PICTURE VIDEO CVBS, Y/C, 3D COMB...
Page 47 Circuit Descriptions Q549.2E LA EN 47 DDR2-SDRAM PNX8543x MCU-DDR VCP/PC 2D_DE VCP_ VCP_RX LOW IF GFX1 VCP_ LCD panel CVBS GFX2 WIFD FPD-LVDS1 CPIPE_ LVDS_BUF (ADC) L2QTV LVDS_TX YPbPr LCD panel PC_RX FPD-LVDS2 main HDMI MBVP_ L2QTV HDMI_ Dual HDMI HDMI_UIP MBVP_ L2VO1...
Page 48 EN 48 Q549.2E LA Circuit Descriptions DDR2-SDRAM PNX8543x TM2270 TS-IN VMSP (MPEG, AC-3, MP3 DECODER) SPDIF-IN1 SPDIF-IN SPDIF-OUT SPDIF-Out SPDIF-IN2 fast SPDIF I2S-IN-SD1 I2S-IN-SD2 I2S-IN-SD3 I2S-IN-SD4 I2S-IN-WS I2S-IN-SCK I2S-IN-OSC 4 × I 2 S SPDIF 4 × I 2 S HDMI HDMI_RX 4 ×...
Page 49 Circuit Descriptions Q549.2E LA EN 49 DDR2-SDRAM PNX8543x MCU_DDR I2C-1 IIC4_DMA I2C-2 IIC2_DMA MIPS 4KEc EJTAG I2C-3 IIC3_DMA AVDSP UART-1 UART1 PCI_XIO PCI/XIO UART-2 UART2 CI/CA USB2.0 I2C-MC SYSTEM UART-3 CONTROLLER PWMs 80C51 JTAG_MMIO EJTAG GPIOs 18440_205_090226.eps 090226 Figure 7-10 PNX8543 connectivity and compute subsystem The Connectivity Subsystem consists of: keys in the components, unauthorised exchange of these •...
Page 50 EN 50 Q549.2E LA Circuit Descriptions Common Interface CI+ Access Module (CAM) and the Integrated Digital Television (IDTV). The security mechanisms in CI+ are derived/copied from POD (with the exception of Out Of Band (OOB) used in Together with this platform, an extention to the Common US CA systems).
Page 51 Circuit Descriptions Q549.2E LA EN 51 18310_203_090317.eps 090317 Figure 7-12 Interface between Ambi Light and SSB 7.8.1 ARM controller The SPI bus is a synchronous serial data link standard that operates in full duplex mode. Refer to Figure 7-13 below for signal interfacing to and from the ARM controller.
Page 52 EN 52 Q549.2E LA Circuit Descriptions Figure 7-14 SPI communication between ARM controller and LED drivers The ARM controller communicates with the LED drivers (on each AL module) via an SPI bus. For debugging purposes, the working principle is given below: •...
Page 53: Ic Data Sheets
IC Data Sheets Q549.2E LA EN 53 8. IC Data Sheets This chapter shows the internal block diagrams and pin electrical diagrams (with the exception of “memory” and “logic” configurations of ICs that are drawn as “black boxes” in the ICs).
Page 54 EN 54 Q549.2E LA IC Data Sheets Diagram SSB: Front End B02B, DRX3926K (IC 7T50) Block Diagram RF AGC MPEG-2 DVB-T/QAM IF AGC Main IF AMP CVBS Tuner DVB-T/QAM/ATV Demodulator Stereo Decoder Integrated Tuner S Audio Presaw Sense System Controller GPIO Pin Configuration VSSAH_CVBS...
Page 55: Block Diagram
IC Data Sheets Q549.2E LA EN 55 Diagram SSB: PNX8543 - Stand-by Controller B04A, PNX8543 (IC7H00) Block Diagram PNX8543x MEMORY CONTROLLER TS in from channel decoder MPEG CI/CA SYSTEM LVDS for PRIMARY TS out/in for PROCESSOR flat panel display PCMCIA VIDEO LVDS (single or dual...
Page 56 EN 56 Q549.2E LA IC Data Sheets Diagram SSB: Ethernet B05A, PNX5120 (IC7C00) Block Diagram PNX51xx MEMORY CONTROLLER TM327x 1 LVDS RX 1 GIC 1 Video UIP L3K7 TM327x 2 GIC 2 LVDS RX 2 TM327x 3 GIC 3 PCI/XIO LVDS TX 1 Video LVDS TX 2...
Page 57 IC Data Sheets Q549.2E LA EN 57 Diagram SSB: Ethernet B07G, DP83816 (IC7N04) Pin Configuration Block Diagram TPRDP/M 3V DSP Physical Layer TPTDP/M MA2/LED100N MA1/LED10N MA0/LEDACTN IAUXVDD VREF Pin1 RESERVED Identification MD4/EEDO AUXVDD 25 MHz Clk TPRDM TPRDP SRAM IAUXVDD MD1/CFGDISN RX-2 KB REGEN...
Page 58 EN 58 Q549.2E LA IC Data Sheets Diagram SSB: Audio B10A, TPA3123D (IC 7D10) Block Diagram 0.22 F 22 H 470 F ROUT 0.68 F PGNDR 0.68 F PGNDL LOUT BYPASS 22 H 470 F AGND 0.22 F PVCCL AVCC PVCCR VCLAMP Shutdown...
Page 59: Block Diagrams Wiring Diagram 32" (Elite Core)
Block Diagrams Q549.2E LA EN 59 9. Block Diagrams Wiring Diagram 32" (Elite Core) WIRING DIAGRAM 32" (ELITE CORE) WIFI ANTENNA WIFI ANTENNA (1044) (1043) LCD DISPLAY (1004) 1M85 (AL4) 1M83 14. GND (AL1) 13. VLED2 1. SCL 12. GND 2.
Page 60: Wiring Diagram 37" (Elite Core)
Block Diagrams Q549.2E LA EN 60 Wiring Diagram 37" (Elite Core) WIRING DIAGRAM 37" (ELITE CORE) WIFI ANTENNA WIFI ANTENNA (1044) (1043) 8802 8802 1M83 1M84 (AL1) (AL1) 1. SCL 14. GND 2. GND 13. VLED2 3. SDA 12. GND 4.
Page 61 Block Diagrams Q549.2E LA EN 61 Wiring Diagram 56" (Elite Core) WIRING DIAGRAM 56" (ELITE CORE) WIFI ANTENNA (1044) WIFI ANTENNA (1043) AMBI-LIGHT MOD. AMBI-LIGHT MOD. AMBI-LIGHT MOD. AMBI-LIGHT MOD. AMBI-LIGHT MOD. 1M83 1M85 (AL4) (AL1) (1073) (1080) (1076) (1074) (1072) 14.
Page 62: Block Diagram Video
Block Diagrams Q549.2E LA EN 62 Block Diagram Video VIDEO B02A FRONT-END B07A CI: PCMCIA CONNECTOR 7P15-7P16 PNX8543: B06G FPGA WOW - IO BANKS B05B PNX5100: VIDEO-IN B05E PNX5100: LVDS 74LVC245APW 1G50 1P00 7H00 +3V3 PNX85439EH/M2 7FN0 7C00 EP3C25F324C7N PNX5120EH/M2 B04N VIDEO STREAMS B04O...
Page 63: Block Diagram Audio
Block Diagrams Q549.2E LA EN 63 Block Diagram Audio AUDIO B02A FRONT-END B07A CI: PCMCIA CONNECTOR PNX8543: B04I PNX8543: AUDIO B10A AUDIO 7P15-7P16 74LVC245APW 1P00 7H00 +3V3 PNX85439EH/M2 B04N VIDEO STREAMS B04L AUDIO MDO(0-7) BUFFER CA-MDO(0-7) CA_MD0 5HRW 7D10 AADC VDDA-AUDIO 5HRZ TPA3123D2PWP...
Page 64: Block Diagram Control & Clock Signals
Block Diagrams Q549.2E LA EN 64 Block Diagram Control & Clock Signals CONTROL + CLOCK SIGNALS B07G ETHERNET B07A CI: PCMCIA CONNECTOR PNX8543: B02A FRONT END 7H00 7303 PNX85439EH/M2 DRX3926K-XK-A3 TUN_CA B04N 7N04 1P00 1N00 DP83816AVNGNOPB TNR_TSDI FE-DATA(0-7) DEMODULATOR CA-MICLK CA_MICLK FE-CLK CA-MDI(0-7)
Page 65 Block Diagrams Q549.2E LA EN 65 Block Diagram I I²C B04E PNX8543: CONTROL B07D HDMI B02B DEMODULATOR B02A FRONT-END B05F PNX5100: CONTROL B06E FPGA WOW B06G FPGA WOW - IO BANKS B06A FPGA BACKLIGHT - LVDS & I2C - MUX B08D ANALOGUE EXTERNALS D- POWER &...
Page 66: Supply Lines Overview
Block Diagrams Q549.2E LA EN 66 Supply Lines Overview SUPPLY LINES OVERVIEW SUPPLY B01B DC / DC B07A CI: PCMCIA CONNECTOR B04I PNX8543: AUDIO B01C DC/DC B05F PNX5100: CONTROL B09A MINI PCI CONNECTOR +AUDIO-POWER +AUDIO-POWER +3V3 +3V3 B01b B01a +12V +3V3 +3V3 +12VD...
Page 67: Circuit Diagrams And Pwb Layouts
DC-DC INTERFACE 08-08-06 3104 328 58351 08-06-19 08-09-18 3104 313 6325 AMBI 2K9 3104 328 58361 08-08-06 08-10-23 3104 328 58371 08-10-23 08-12-06 NAME Peter Van Hove SUPERS. CHECK ******** DATE 08-06-06 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_600_090305.eps 090305 2009-May-08...
Page 68 I209 B6 I210 C6 I211 C3 I212 C3 08-06-19 CLASS_NO DC-DC INTERFACE 08-08-06 08-06-19 3104 313 6325 08-09-18 AMBI 2K9 08-08-06 08-10-23 08-10-23 08-12-06 NAME Peter Van Hove SUPERS. CHECK DATE 08-06-09 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_601_090305.eps 090305 2009-May-08...
Page 69: Interface Ambilight: Microcontrollerblock
7303 F2 9300 E3 9301 F3 9302 F3 SETNAME 08-06-19 CLASS_NO DC-DC INTERFACE 08-08-06 08-06-19 08-09-18 3104 313 6325 AMBI 2K9 08-08-06 08-10-23 08-10-23 08-12-06 NAME Peter Van Hove SUPERS. CHECK DATE 08-06-09 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_602_090305.eps 090410 2009-May-08...
Page 70 Circuit Diagrams and PWB Layouts Q549.2E LA EN 70 Layout DC/DC Interface Ambilight Personal Notes: 1M85 1302 5201 2208 2209 3338 6201 2210 9104 2203 9103 2301 3306 2302 2321 3308 2218 2323 2319 3324 2206 2200 9201 3326 2312 9202 6200 5200...
Page 71 7101 A7 7102 E6 7110 F4 7116-1 B11 1X03 REF EMC HOLE 2008-06-10 CLASS_NO DRIVER 6LED LITEON 2008-08-08 2008-10-27 8204 000 8857 2008-08-08 2008-10-27 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_610_090305.eps 090410 2009-May-08...
Page 72 Circuit Diagrams and PWB Layouts Q549.2E LA EN 72 6 LED Low-Pow: Microcontroller Block Liteon 2201 B8 2202 C8 2203 D8 2209 B2 2210 G6 MICROCONTROLLER LITEON 2211 I6 2214 A6 INPUT BUFFER 2215 F7 2216 F7 2217 B12 2218 C12 2219 D12 +3V3 +3V3...
Page 73 9307 A6 9308 A6 9309-1 B6 9309-2 B6 9309-4 B6 9310-1 B8 2008-06-10 CLASS_NO DRIVER 6LED LITEON 2008-08-08 2008-10-27 8204 000 8857 2008-08-08 2008-10-27 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_612_090305.eps 090305 2009-May-08...
Page 74 Circuit Diagrams and PWB Layouts Q549.2E LA EN 74 Layout 6 LED Low-Pow 9313 2129 2128 3120 1M83 1M84 3128 3119 9315 3129 2101 9121 3132 3133 3138 3136 C140 3106 3127 I110 2106 3139 3222 7110 2209 2108 1101 2119 2117 3103...
Page 75 7102 E6 7110 F4 7116-1 B11 1X03 REF EMC HOLE SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 3104 313 6314.3 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_650_090508.eps 090507 2009-May-08...
Page 76 100R DATA-RETURN-SWITCH DATA-RETURN-SWITCH 3214 +3V3 XHALF XERR GND GND_HS +3V3 SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 3104 313 6314.3 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_651_090508.eps 090508 2009-May-08...
Page 77 9308 A6 9309-1 B6 9309-2 B6 9309-4 B6 9310-1 B8 SETNAME CLASS_NO 2008-06-10 DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 3104 313 6314.3 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_652_090508.eps 090508 2009-May-08...
Page 78 3574 3590 560R 3591 1X04 REF EMC HOLE SETNAME 2008-05-23 CLASS_NO 2LED + CONNECTOR 2008-08-08 2008-05-23 8204 000 8874 3104 313 6314.3 2008-08-08 2008-10-31 NAME Peter Van Hove SUPERS. CHECK DATE 2008-04-20 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_653_090508.eps 090508 2009-May-08...
Page 79 Circuit Diagrams and PWB Layouts Q549.2E LA EN 79 Layout 8 LED Low-Pow 9313 2129 2128 1M83 3120 1M84 1M85 3128 3119 3129 9315 2101 9121 3132 3133 3138 3136 3106 3127 C140 2106 3139 3222 I110 7110 2209 2108 1101 2119 2117...
Page 80 3142 F11 7101 A7 7102 E6 7110 F4 7116-1 B11 1X03 REF EMC HOLE SETNAME 2008-06-10 CLASS_NO DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_630_090306.eps 090306 2009-May-08...
Page 81 SPI-DATA-OUT SOUT SPI-DATA-OUT-FIL 100R DATA-RETURN-SWITCH DATA-RETURN-SWITCH 3214 +3V3 XHALF XERR GND GND_HS +3V3 SETNAME 2008-06-10 CLASS_NO DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_631_090306.eps 090306 2009-May-08...
Page 82 9306-4 D5 9307 A6 9308 A6 9309-1 B6 9309-2 B6 9309-4 B6 9310-1 B8 SETNAME 2008-06-10 CLASS_NO DRIVER 6LED LITEON 2008-08-08 8204 000 8857 2008-08-08 NAME Peter Van Hove SUPERS. CHECK DATE 2008-06-02 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_632_090306.eps 090306 2009-May-08...
Page 83 560R 3574 3590 560R 3591 1X04 REF EMC HOLE 2008-08-14 CLASS_NO 4 LED + CONNECTOR 2008-10-24 2008-10-31 8204 000 8897 LITEON 2K9 2008-08-14 2008-10-31 NAME Peter Van Hove SUPERS. CHECK DATE 2008-07-29 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_633_090306.eps 090306 2009-May-08...
Page 84 Circuit Diagrams and PWB Layouts Q549.2E LA EN 84 Layout 10 LED Low-Pow 9313 2129 2128 1M83 1M84 1M85 3120 3128 3119 3129 9315 2101 9121 3132 3133 3138 3136 3106 3127 C140 I110 2106 3139 3222 7110 2209 1101 2119 2117 2108...
Page 85 IU1D 120R IU0T IU19 GND-SIG GND-SIG GND-SIG GND-SIG GND-SIG GND-SIG 1X08 REF EMC HOLE SETNAME 2008-11-21 CLASS_NO DC/DC 8204 000 8932 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-20 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_500_090302.eps 090302 2009-May-08...
Page 86 5U06 F2 5U20 5U07 A1 5U08 E7 2K9 supplies 5U10 A1 5U21 5U11 A1 5U12 A1 CLASS_NO 2008-11-21 DC/DC 8204 000 8932 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-20 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_501_090302.eps 090302 2009-May-08...
Page 87 FU0D SENSE+1V2-PNX5100 IU2Y IU33 120R CU25 IU2T GND-SIG1 GND-SIG1 GND-SIG1 GND-SIG1 GND-SIG1 GND-SIG1 GND-SIG1 SETNAME CLASS_NO 2008-11-21 DC/DC 8204 000 8932 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-20 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_502_090302.eps 090302 2009-May-08...
Page 88 IT25 C13 IT26 D10 IT28 D7 IT30 D9 IT32 D11 IT34 F11 IT36 G11 SETNAME 2008-11-21 CLASS_NO FRONT-END 8204 000 8929 TV543 R2 LDIPNX 2008-10-10 NAME Randal De Keyzer SUPERS. CHECK DATE 2008-06-03 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_503_090302.eps 090302 2009-May-08...
Page 89 9T62 F6 5T55 FT63 +5V-TUN +5V-TUN-CVBS 9T63 E11 9T64 F6 9T70 C2 9T71 C2 SETNAME 2008-11-21 CLASS_NO FRONT-END 8204 000 8929 TV543 R2 LDIPNX 2008-10-10 NAME Randal De Keyzer SUPERS. CHECK DATE 2008-06-03 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_504_090302.eps 090302 2009-May-08...
Page 90 FHC1 H13 FHC2 I14 FHC3 C5 FHC6 H11 1X03 EMC HOLE SETNAME CLASS_NO 2008-11-21 STANDBY CONTROLLER 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Randal De Keyzer SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_505_090302.eps 090302 2009-May-08...
Page 91 FOR DEBUG FH01 IH95 2H07 100p TSTPOINT FOR DEBUG FH08 CLASS_NO 2008-11-21 DEBUG STBY CTRL 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 10000_012_090121.eps 090121 18310_506_090302.eps 090302 2009-May-08...
Page 92 SCL-SET +3V3-PER 100R FH12 3HPU 3HPV SDA2 SDA-SET SDA-SET 100R CLASS_NO 2008-11-21 MIPS , I2C & EJTAG 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_507_090302.eps 090302 2009-May-08...
Page 93 IHF0 3HFP IHF5 PCI-CLK-ETHERNET 3HF2 PCI-CLK-PNX8535 3HF4 CLKOUT 3HFM PCI-CLK-MINI PCI-CLK-PNX5100 3HFN PCI-CLK-MINI SETNAME CLASS_NO 2008-11-21 CONTROL 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-03 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_508_090302.eps 090302 2009-May-08...
Page 94 DDR2-DQS1_N DDR2-DQS3_N 7HG1 F11 VSSQ VSSQ FH06 A12 FH07 A11 IHG0 C7 SETNAME CLASS_NO 2008-11-21 DDR2 INTERFACE 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_509_090302.eps 090302 2009-May-08...
Page 95 HDMIB-RX2+ TH07 DV_YIN HDMIB-RXC- HDMI_RXC_B HDMIB-RXC+ TH08 HOT-PLUG-A 9HK0 HOT_PLUG_A HOT-PLUG HOT_PLUG_B SETNAME CLASS_NO 2008-11-21 VIDEO IN 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_510_090302.eps 090302 2009-May-08...
Page 96 ADAC(2) 7HM2-2 AUDIO-OUT-R IHNE BC847BS(COL) 2HM2 IHNH IHMG 3HMU -AUDIO-R IHNK 3HMM-2 3HMM-1 2HMZ CLASS_NO 2008-11-21 AUDIO 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_511_090302.eps 090302 2009-May-08...
Page 97 3HRU B9 3HRV B8 3HRW C12 3HRY D10 3HRZ D12 3HS0 E10 3HS1 D9 CLASS_NO 2008-11-21 ANALOG AV 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_512_090302.eps 090302 2009-May-08...
Page 98 IHS0 D3 IHS1 D3 IHSU C6 IHSV D6 IHSW C9 IHSY D11 IHSZ D6 SETNAME CLASS_NO 2008-11-21 AUDIO 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2006 18310_513_090302.eps 090302 2009-May-08...
Page 99 IHW8 3HV4-4 RESET-AUDIO 7HVA-1 IHW8 E7 BC847BPN(COL) IHWE C2 IHWJ C5 IHWL C2 SETNAME CLASS_NO 2008-11-21 AUDIO 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_514_090302.eps 090302 2009-May-08...
Page 100 3EN2 BOLT-ON-TS-ENn 3HB6 3HB7 FE-SOP TSO-SYNC FE-VALID TSO-BIT-VALID FE-CLK TSO-BIT-CLK FE-ERR TSO-BIT-ERR SETNAME 2008-11-21 CLASS_NO CONDITIONAL ACCESS 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-06-05 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_515_090302.eps 090302 2009-May-08...
Page 101 LOUT2_D AP24 TX852D+ AL24 TX852E- LOUT2_E AM24 TX852E+ AL23 TX852CLK- LOUT2_CLK AM23 TX852CLK+ SETNAME 2008-11-21 CLASS_NO LVDS 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_516_090302.eps 090302 2009-May-08...
Page 102 5HV4 C3 5HV5 D3 5HV6 D1 5HV7 E1 5HV8 F2 5HV9 E3 5HVA E3 SETNAME CLASS_NO 2008-11-21 POWER 8204 000 8927 PNX8543 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-11-29 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_517_090302.eps 090302 2009-May-08...
Page 103 PNX5100-DDR2-DQS1_P PNX5100-DDR2-DQS3_P 3C13 UDQS PNX5100-DDR2-DQS3_N UDQS PNX5100-DDR2-DQS1_N 100n 100n 3C30-3 33R 1X01 REF EMC HOLE 2008-11-21 CLASS_NO DDR2 PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_518_090302.eps 090302 2009-May-08...
Page 104 RX51001B+ AF19 AE18 AF18 RX51001B- RX51001CLK+ AC18 AD18 RX51001CLK- RX51001C+ RX51001C- RX51001D+ RX51001D- RX51001E+ RX51001E- CLASS_NO 2008-11-21 VIDEO PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_519_090302.eps 090302 2009-May-08...
Page 105 2C92 F9 2C94 F7 2C95 A1 2C96 A2 2C97 A2 5C60 D6 5C61 D6 SETNAME 2008-11-21 CLASS_NO SUPPLY PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_520_090302.eps 090302 2009-May-08...
Page 106 AMBI AB10 AF11 AE11 AD11 AC11 AB11 AB12 SYNC_H 3C41 AC12 AMBI-VS SYNC_V 100R SETNAME CLASS_NO 2008-11-21 AUDIO PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_521_090302.eps 090302 2009-May-08...
Page 107 FCA4 C8 FCA5 C7 FCA6 D8 FCA7 D7 FCA8 D8 FCA9 D7 FCAA D8 SETNAME 2008-11-21 CLASS_NO LVDS PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_522_090302.eps 090302 2009-May-08...
Page 108 WC-EEPROM-PNX5100 WC-EEPROM-PNX5100 +3V3 EEPROM 3CDC SCL-SSB 100R 3CDD only for DEBUG SDA-SSB 100R FCD9 SETNAME 2008-11-21 CLASS_NO CONTROL PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_523_090302.eps 090302 2009-May-08...
Page 109 PLL_OUT PCI-AD22 PCI-AD23 PCI-AD24 IC50 PCI-AD25 PCI-AD26 PCI-AD27 PCI-AD28 IC51 3CF1 PCI-AD29 +3V3 PCI-AD30 AD25 PCI-AD31 CLASS_NO 2008-11-21 PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_524_090302.eps 090302 2009-May-08...
Page 110 BACKLIGHT-OUT FCG8 B4 IC01 E3 IC02 G3 IC03 G3 ICG1 C4 ICG2 C2 SETNAME 2008-11-21 CLASS_NO DISPLAY INTERF PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_525_090302.eps 090302 2009-May-08...
Page 111 FCJ0 D3 PNX5100 : DEBUG RESERVED +3V3 +3V3 PNX5100-RST-OUT 7CJ0 PDTC114EU FCJ0 SETNAME 2008-11-21 CLASS_NO DEBUG SHEET PNX5100 8204 000 8928 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2008 10000_012_090121.eps 090121 18310_526_090302.eps 090302 2009-May-08...
Page 112 5F03 A2 5F04 A2 5F05 B14 5F06 B14 1X02 EMC HOLE SETNAME CLASS_NO 2008-11-21 FPGA Backlight-LVDS & I2C-MUX 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_527_090302.eps 090302 2009-May-08...
Page 113 FFHE EJTAG-TMS FFHF USE ONLY EJTAG-TCK FFHG FFHJ FFHK FFHH FFHL 5-147279-3 +3V3 2008-11-21 CLASS_NO U-WAND 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 10000_012_090121.eps 090121 18310_528_090302.eps 090302 2009-May-08...
Page 114 PDTA114EU IF60 F8 IF61 F8 IF62 B8 IF63 B7 IF64 B9 IF65 B7 2008-11-21 CLASS_NO TEMPERATURE- & FAN-CONTROL 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_529_090303.eps 090303 2009-May-08...
Page 115 3FH4 A8 TX852E+ RX51002E+ TXF2E+ RX51002E+ 3FH5 B8 180R 5FG1 E8 SETNAME 2008-11-21 CLASS_NO FPGA WOW - LVDS IN/OUT 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_530_090303.eps 090303 2009-May-08...
Page 116 FFHP B9 FFHR C9 FFHS C9 FFHT C11 IFH4 A7 SETNAME CLASS_NO 2008-11-21 FPGA WOW - POWER & CONTROL 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_531_090303.eps 090303 2009-May-08...
Page 117 5FL1 C7 MM1-WE 7FL0 B2 FFL0 B8 FFL1 B7 IFL1 C7 SETNAME CLASS_NO 2008-11-21 FPGA WOW - DDR 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-04 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_532_090303.eps 090303 2009-May-08...
Page 118 +1V2-FPGA VCCINT VCCIO7 +2V5-DDR1 +1V2-FPGA +2V5-DDR1 +1V2-FPGA +1V2-FPGA +2V5-DDR1 +2V5-DDR1 VCCIO8 +2V5-DDR1 CLASS_NO 2008-11-21 FPGA WOW - IO-BANKS 8204 000 8933 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-12-06 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_533_090303.eps 090303 2009-May-08...
Page 119 CA-MOCLK_VS2 3P27-1 MDO7 SETNAME 1X06 EMC HOLE 1X05 CLASS_NO 2008-11-21 REF EMC HOLE UFD2K8 8204 000 8934 DIGI i/O TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-18 ROYAL PHILIPS ELECTRONICS N.V. 2007 10 3 18310_534_090303.eps 090303 2009-May-08...
Page 120 IP07 D4 YKB11-3004 AUDIO-IN4-L 1P0A 1 +12V IP07 FP01 3P07 YKB11-3004 AUDIO-IN4-R FP24 1P0B CLASS_NO 2008-11-21 UFD2K8 8204 000 8934 DIGI I/O TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-18 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_535_090303.eps 090303 2009-May-08...
Page 121 USB20-DP FP29 FP2A 1P10 292303-4 IP13 9P21 9P22 IP19 502382-0570 2008-11-21 CLASS_NO DIGI I/O UFD2K8 8204 000 8934 TV 543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-18 ROYAL PHILIPS ELECTRONICS N.V. 2007 10000_012_090121.eps 090121 18310_536_090303.eps 090303 2009-May-08...
Page 122 FP0W FP0J E1 BP1W DC1R019JB1E400 FP0P D1 FP0R I1 SETNAME 1X07 2008-11-21 CLASS_NO EMC HOLE UFD2K8 8204 000 8934 DIGI IO TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-18 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_537_090303.eps 090303 2009-May-08...
Page 123 IP23 C5 HDMIA-RX1+ 9P31-3 HDMIA-RX2- IP28 B4 9P31-4 HDMIA-RX2+ IP68 C6 FI-RE21S-HF-R1500 SETNAME CLASS_NO 2008-11-21 UFD2K8 8204 000 8934 DIGI I/O TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-18 ROYAL PHILIPS ELECTRONICS N.V. 2006 18310_538_090303.eps 090303 2009-May-08...
Page 124 PCI-AD1 NAND-ALE PCI-CBE1 3P48-3 3 100R NAND-WEn 3P48-4 100R PCI-CBE2 NAND-REn 100R CLASS_NO 2008-11-21 UFD 2K8 8204 000 8934 DIGI I/O TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-18 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_539_090303.eps 090303 2009-May-08...
Page 125 PCI-AD29 PCI-AD30 PCI-AD31 5N07 IN0U +3V3 +3V3-ET-ANA IN0N 7N04-2 220R DP83816AVNG NC10 2008-11-21 CLASS_NO UFD 2K8 8204 000 8934 DIGI I/O TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-18 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_540_090303.eps 090303 2009-May-08...
Page 126 PCI-AD11 PCMCIA-A11 PCI-AD23 CA-IOWR PCI-AD10 PCMCIA-A10 PCI-AD9 PCMCIA-A9 PCI-AD8 PCMCIA-A8 3N33 IN32 CLASS_NO 2008-11-21 UFD 2K8 8204 000 8934 DIGI I/O TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-18 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_541_090303.eps 090303 2009-May-08...
Page 127 6E12 B6 6E14 C6 6E22 E12 6E23 D11 6E24 D6 1X04 EMC HOLE 2008-11-21 CLASS_NO ANA + SIDE I/O 8204 000 8930 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_542_090303.eps 090303 2009-May-08...
Page 128 CVBS-MON-OUT-CINCH 6E47 E10 6E48 F10 FE43 Y_CVBS-MON-OUT 6E51 H4 6E52 G4 SETNAME CLASS_NO 2008-11-21 ANA + SIDE I/O 8204 000 8930 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2005 18310_543_090303.eps 090303 2009-May-08...
Page 129 FE22 C3 FE23 D3 FE24 F3 FE25 F5 FE56 A2 FE86 B7 SETNAME CLASS_NO 2008-11-21 ANA + SIDE I/O 8204 000 8930 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_544_090303.eps 090303 2009-May-08...
Page 130 SDA-SSB 9E05 E1 3E93 FE28 9E08 C3 100R 9E09 C4 9E30 H11 CLASS_NO 2008-11-21 ANA + SIDE I/O 8204 000 8930 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_545_090303.eps 090303 2009-May-08...
Page 131 FA32 FA36 3A06 MPCIACT MPCIACT +3V3-mPCI IA25 FA33 1734065-3 1734065-3 1X09 REF EMC HOLE CLASS_NO 2008-11-21 MINI PCI 8204 000 8935 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2007-10-16 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_546_090303.eps 090303 2009-May-08...
Page 132 IA07 D4 IA08 D3 2AC0 IA09 E5 100p IA10 C1 IA11 E5 IA12 E7 SETNAME CLASS_NO 2008-11-21 MINI PCI 8204 000 8935 TV543 R2 LDIPNX 2008-10-10 NAME Maelegheer Ingrid SUPERS. CHECK DATE 2008-01-18 ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_547_090303.eps 090303 2009-May-08...
Page 133 FD14 A5 ID05 C8 ID06 C8 ID07 C8 RIGHT-SPEAKER ID08 C8 ID09 C7 CLASS_NO 2008-11-21 CLASS D 8204 000 8931 TV543 R2 LDIPNX 2008-10-10 NAME Randal De Keyzer SUPERS. CHECK DATE 2007-10-12 ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_548_090303.eps 090303 2009-May-08...
Page 134: Ssb: Srp List Explanation
Circuit Diagrams and PWB Layouts Q549.2E LA EN 134 SSB: SRP List Explanation Personal Notes: Example 1 . 1 . Introduction Net Name Diagram +12-15V AP1 (4x) +12-15V AP4 (4x) SRP (Service Re ference Protocol) is a softw are too l that creates a list w i th all refer e n c es to signal lines. The list contains +12-15V AP5 (12x) references to the signals w i thin all schemat ics of a PWB.
Page 135: Ssb: Srp List Part 1
Circuit Diagrams and PWB Layouts Q549.2E LA EN 135 SSB: SRP List Part 1 Netname Schematic B08D +3V3-STANDBY B08A (1×) AV1-B B07H (1×) CA-DATAEN B04H (1×) DDC-SCL B06B (1×) EJTAG-TDO B04A (2×) LED2 B09B +3V3-STANDBY B08D (3×) AV1-B B07A (2×) CA-INPACK B07D (1×) DDC-SCL...
Page 136 Circuit Diagrams and PWB Layouts Q549.2E LA EN 136 SSB: SRP List Part 2 Netname Schematic B05G (2×) PCI-AD25 B09A (1×) PCI-IRDY B05A (2×) PNX5100-DDR2-D30 B05F (1×) SCL-AMBI-3V3 B05E (3×) TX1C- B05E (1×) TXDAT+ B07F (1×) PCI-AD25 B04F (1×) PCI-PAR B05A (2×) PNX5100-DDR2-D31 B06A (1×)
Page 137 Circuit Diagrams and PWB Layouts Q549.2E LA EN 137 Layout Small Signal Board (Top Side) 1F05 1M71 1M59 1R20 1242 1R12 1012 1F53 1FA1 1FA0 1E05 3F01 3F36 2F46 3F383F39 2F47 2EB3 3F37 9F17 9F19 9F20 3ED3 9F18 9FA1 9FA2 2FNE 2FND 3F40...
Page 138 Circuit Diagrams and PWB Layouts Q549.2E LA EN 138 Layout Small Signal Board (Bottom Side) 5E02 FF42 2E81 FF24 FF23 2EB1 IE13 IE07 FF41 FF40 3EA3 FF31 FF44 IE89 FEA8 3EB2 7E16 FF43 3EA2 FEA9 FEA5 7E06 FEA7 FEB1 FF50 FEA6 FF21 IE60...
Page 139 I001 I008 B6 1P09 I000 I009 B6 3015 7001 I010 B6 BC817-25W +5V2 1735446-4 CLASS_NO 2008-10-16 LIGHT STRIP PANEL 3104 313 6344 9 LEDS 2K9 2008-10-17 NAME Luc Buffel SUPERS. CHECK DATE ROYAL PHILIPS ELECTRONICS N.V. 2007 18310_560_090508.eps 090508 2009-May-08...
Page 140 Circuit Diagrams and PWB Layouts Q549.2E LA EN 140 Layout guide panel 7001 2001 1P09 6001 6002 6003 6004 6005 6006 6007 6008 6009 3000 I010 I008 I009 I001 I000 I005 I006 I003 I007 I002 31043136344.1 18310_559_090420.eps 090508 2009-May-08...
Page 141 18310_557_090309 3104 313 6328.2 090309 1000 U.FL-R-SMT-1(10) ******** SETNAME ******** CLASS_NO 08-07-07 WIFI antenna ****** 08-10-20 **-**-** **-**-** 3104 303 5212 08-07-07 **-**-** 08-10-20 **-**-** NAME Maelegheer Ingrid SUPERS. CHECK DATE ****-**-** ROYAL PHILIPS ELECTRONICS N.V. 2008 18310_640_090306.eps 090306 2009-May-08...

This manual is also suitable for:

Q549.2e 32pfl9604h/12 32pfl9604h/60 37pfl9604h/12 37pfl9604h/60 56pfl9954h/12

Philips Q549.2E LA Service Manual

Quick Links

Related Manuals for Philips Q549.2E LA

Summary of Contents for Philips Q549.2E LA

This manual is also suitable for:

Table of Contents