All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by MB/JH 0962 BU TV Consumer Care, the Netherlands...
EN 2 QCG1.0S LA Revision List 1. Revision List Manual xxxx xxx xxxx.0 • First release. 2. Technical Specifications, Connections, and Chassis Overview Index of this chapter: 2.1 Technical Specifications 2.2 Directions for Use 2.3 Connection Overview 2.4 Chassis Overview Notes: •...
Page 3
Technical Specifications, Connections, and Chassis Overview QCG1.0S LA EN 3 Connection Overview (OUT) (IN) (IN)(OUT) 9 10 18430_001_090122.eps 090218 Figure 2-1 Rear and Side I/O connections Note: The following connector colour abbreviations are used 4 - Spring Clip Speaker Connections: Audio - Out (acc.
Page 4
EN 4 QCG1.0S LA Technical Specifications, Connections, and Chassis Overview - D2+ Data channel 8 - VGA RGB 3 & RGB IN: Video RGB - In - Shield - D2- Data channel - D1+ Data channel - Shield 10000_002_090121.eps 090121...
• Route the wire trees correctly and fix them with the • The correct component values are listed on the Philips mounted cable clamps. Spare Parts Web Portal. • Check the insulation of the Mains/AC Power lead for external damage.
Page 6
EN 6 QCG1.0S LA Safety Instructions, Warnings, Notes, and Abbreviation List B.O.M. (Bill Of Materials) that has been used for producing the Abbreviation List specific TV set. In general, it is possible that the same TV model on the market is produced with e.g. two different types...
Page 7
Safety Instructions, Warnings, Notes, and Abbreviation List QCG1.0S LA EN 7 Monochrome TV system. Sound lines. The fields are written in “pairs”, carrier distance is 6.5 MHz causing line flicker. Dynamic Frame Insertion Infra Red Directions For Use: owner's manual...
Page 8
4.406250 MHz and 4.250000 MHz Sound Intermediate Frequency SMPS Switched Mode Power Supply System on Chip Sync On Green SOPS Self Oscillating Power Supply S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board STBY STand-BY SVGA 800x600 (4:3)
Mechanical Instructions QCG1.0S LA EN 9 4. Mechanical Instructions Index of this chapter: 4.1 Cable Dressing Notes: 4.2 Service Positions • Figures below can deviate slightly from the actual situation, 4.3 Assy/Panel Removal due to the different set executions. 4.4 Set Re-assembly •...
Page 10
EN 10 QCG1.0S LA Mechanical Instructions 4.3.2 Rear Cover 4.3.7 Keyboard Control Panel Warning: Disconnect the mains power cord before you open 1. Place the set in the service position, see Service Positions. the set. 2. Remove the fixation screws that hold the keyboard control 1.
Page 11
Mechanical Instructions QCG1.0S LA EN 11 4.3.11 Small Signal Board (SSB) 3. Unplug the other connectors [3] from the SSB. 4. Remove all screws [4] securing the SSB connectors. 5. Remove all screws [5] securing the rim and take it out.
Page 12
EN 12 QCG1.0S LA Mechanical Instructions 4.3.12 LCD Panel Important: Be sure to work in a dust free environment during the following activities. In addition, the use of (fabric) hand gloves is advised. 18430_102_090211.eps.eps 090211 Figure 4-4 LCD panel disassembly 1.
“SET”, “MENU”. • Please note that this set does not respond on the standard Philips remote controllers, but only responds to the with the set supplied remote control. • When in the factory mode at the top right of the menu an “F”...
Alignments QCG1.0S LA EN 15 6. Alignments Index of this chapter: Setting Range Default value 6.1 General Alignment Conditions Sharpness 0 to 100 6.2 Hardware Alignments Black level 0 to 100 6.3 Software Alignments Noise reduction 6.4 Option Settings 6.5 Software upgrade...
Page 16
EN 16 QCG1.0S LA Alignments 6.3.4 PIP defaults Monitor information Setting Range Default value Setting Range Default value Model name Type number PIP size Small, Middle, Large Small Serial no Serial number PIP audio Main, Sub Main Operating hours Operating hours...
Page 17
Alignments QCG1.0S LA EN 17 Date and time Hours running Setting Range Default value Setting Resetable Default value Year 2000/2099 2000 Resetable on Monitor power on time Month 01-12 Unresetable on monitor power on 01-31 time Hour 00-23 Minute 00-59...
Page 18
EN 18 QCG1.0S LA Alignments Brightness DRAMCLK Setting Range Default value Setting Range Default value PC max brightness 0 to 255 On/Off On/Off PC min brightness 0 to 255 Amplitude 0-127 Video max brightness 0 to 255 Period 0-31 Video min brightness...
Page 19
Alignments QCG1.0S LA EN 19 Software upgrade 6.5.1 Hardware Connect the cable of RS232 with PC COM port by jump wire. 6.5.2 Software 1. Install the Serial upgrade program GProbe5.1.0.17.EXE on a PC and run it. 18430_203_090213.eps 2. Check “Options”, “Connection settings”, “Serial”, “Port” and 090213 “Baud Rate”, see...
EN 20 QCG1.0S LA Circuit Descriptions 7. Circuit Descriptions Index of this chapter: NXP PCA9555 16-bit I C and SMBus I/O port 7.1 ST FLI32626H Single-chip enhanced TV with interrupt 7.2 Fairchild NC7SB3157 Low-Voltage SPDT Analog Switch 7.3 Microchip 24LC64 The PCA9555 consist of two 8-bit Configuration (Input or 7.4 NXP PCA9555 16-bit I2C and SMBus I/O port with interrupt...
Page 21
Circuit Descriptions QCG1.0S LA EN 21 JRC NJW1141 Audio Processor The NJW1141 is a sound processor includes all of the functions required to process the audio signal for TV, such as tone control, balance, volume, mute, and AGC functions. All of...
EN 22 QCG1.0S LA IC Data Sheets 8. IC Data Sheets Index of this chapter: This section shows the internal block diagrams and pin 8.1 Diagram Main Board: HDMI In Sequoia, FLI32626H (IC configurations of ICs that are drawn as “black boxes” in the UD8) electrical diagrams (with the exception of “memory”...
IC Data Sheets QCG1.0S LA EN 23 Diagram Main Board: ISP, NC7SB3157 (IC U18) Block Diagram Input (S) Function Logic Level Low Connected to A Logic Level High Connected to A Pin Configuration Pin Descriptions Pin Names Description A, B...
Page 24
EN 24 QCG1.0S LA IC Data Sheets Diagram Main Board: OCM Peripherals, 24LC64 (IC U25) Block Diagram A0 A1 HV GENERATOR MEMORY EEPROM CONTROL CONTROL XDEC ARRAY LOGIC LOGIC PAGE LATCHES YDEC SENSE AMP R/W CONTROL Pin Configuration 18430_300_090204.eps 090204...
Page 25
IC Data Sheets QCG1.0S LA EN 25 Diagram Main Board: OCM Peripherals, PCA9555 (IC U29) Block Diagram I/O1.0 I/O1.1 I/O1.2 INPUT/ I/O1.3 8-BIT OUTPUT PORTS I/O1.4 I/O1.5 WRITE pulse I/O1.6 READ pulse I/O1.7 C/SMBUS CONTROL I/O0.0 I/O0.1 I/O0.2 INPUT INPUT/ 8-BIT I/O0.3...
Page 26
EN 26 QCG1.0S LA IC Data Sheets Diagram Main Board: Power System, AP1117ELA (IC U46) Block Diagram 1.25V CURRENT LIMIT (FIXED) Thermal Shutdown Pin Configuration NAME PIN # FUNCTION A resistor divider from this pin to the V pin and ground sets the output voltage Adj (GND) (Ground only for Fixed-Mode).
Page 27
IC Data Sheets QCG1.0S LA EN 27 Diagram Extension Board: Video input, MM1671 (IC U1) Block Diagram 75Ω Driver 6.75MHz - t l i f i l bias clamp 6dB ( 9dB( 12dB ( 16.5dB ( MM1671 MM1672 MM1673 MM1674...
Page 28
EN 28 QCG1.0S LA IC Data Sheets Diagram Extension Board: Video input, LM1881 (IC U2) Block Diagram Pin Configuration 18430_304_090204.eps 090204 Figure 8-7 Internal block diagram and pin configuration 2009-Feb-20...
IC Data Sheets QCG1.0S LA EN 29 Diagram Extension Board: Video input, PI5V331 (IC U3) Block Diagram DECODER Pin Configuration Pin Description Pin Name Description A, S Analog Video I/O (Usually Inputs) B , S Select Input Enable Analog Video I/O (Usually Outputs)
Page 30
EN 30 QCG1.0S LA IC Data Sheets Diagram Extension Board: Audio input, NJW1141M (IC U24) Block Diagram TONE TONE OUTa MONa IN1a IN2a VOL1 TONE VOL2 IN3a IN4a C BUS Interface IN1b IN2b VOL1 TONE VOL2 IN3b IN4b Bias MONb...
Page 31
IC Data Sheets QCG1.0S LA EN 31 8.10 Diagram Extension Board: Audio input, TL062 (IC U25) Block Diagram Pin Configuration 18430_312_090205.eps 090205 Figure 8-10 Internal block diagram and pin configuration 2009-Feb-20...
Page 32
EN 32 QCG1.0S LA IC Data Sheets 8.11 Diagram Extension Board: Audio amplifier, YDA148 (IC U27) Block Diagram Pin Configuration < 32-pin QFN Top View > 18430_313_090205.eps 090205 Figure 8-11 Internal block diagram and pin configuration 2009-Feb-20...
Page 33
IC Data Sheets QCG1.0S LA EN 33 8.12 Diagram Extension Board: RS232, SP3243 (IC U29) Block Diagram 0.1 μ F 0.1 μ F 0.1 μ F SP3243 0.1 μ F 0.1 μ F RS-232 TTL/CMOS OUTPUTS INPUTS 5KΩ TTL/CMOS 5KΩ...
Page 34
EN 34 QCG1.0S LA IC Data Sheets 8.13 Diagram IR LED board, ISL29010 (IC U1) Block Diagram PHOTODIODE ARRAY COMMAND REGISTER LIGHT INTEGRATING DATA REGISTER DATA PROCESS TIMING IREF FOSC 2 16 COUNTER REXT Pin Configuration (6 LD ODFN) TOP VIEW REXT 18430_303_090204.eps...
Circuit Diagrams and PWB Layouts QCG1.0S LA EN 58 Extension Board: Analog input Near to CN8 MINI_YKC31_0185V_3P +5VS +5VS 0R/6 P3 P3 B NC_Y BNC_Y 0R/6 P2 P2 BNC_PB BNC_PB 0R/6 P1 P1 BNC_PR BNC_PR Y/PB/PR 3 : 16mil Y/PB/PR TechView International Technology Inc.