Trouble Shooting - Nexgrill 720-0896 User Manual

SPIDER AND INSECT WARNING
Checking and cleaning burner/ venturi tubes for insects and insect nests. A clogged tube can lead to a fire beneath the grill.
Although an obstructed burner tube is not the only cause of "FLASH-BACK", it is the most common cause.
To reduce the chance of "FLASH-BACK", you must clean the burner tubes before assembling your grill, and at least once a
month in late summer or early fall when spiders are most active. Also perform this burner tube cleaning procedure if your grill
has not been used for an extended period of time.
WHEN TO LOOK FOR SPIDERS
You should inspect the burners at least once a year or immediately after any of the following conditions occur:
1. The smell of gas in conjunction with the burner flames appearing yellow.
2. The grill does not reach temperature.
3. The grill heats unevenly.
4. The burners make popping noises.
BEFORE CALLING FOR SERVICE
If the grill does not function properly, use the following check list before contacting your dealer for service. You may save the
cost of a service call.
PREHEATING: The grill lid should be in a closed position during the preheat time period. It is necessary to preheat the grill
before cooking certain foods, depending on the type of food and the cooking temperature. Food that requires a high cooking
temperature needs a pre-heat
period of five minutes; food that requires a lower cooking temperature needs only a period of two to three minutes.
COOKING TEMPERATURES
High setting-Use this setting for fast warm-up, for searing steaks and chops, and grilling.
Low setting-Use this setting for all roasting, baking, and when cooking very lean cuts such as fish.
These temperatures vary with the outside temperature and the amount of wind.
Cooking with in-direct Heat: You can cook poultry and large cuts of meat slowly to perfection on one side of the grill by
indirect heat from the burner on the other side. Heat from the lit burner circulates gently throughout the grill, cooking the meat
or poultry without any direct flame touching it. This method greatly reduces flare-ups when cooking extra fatty cuts, because
there is no direct flame to light the fats and juices that drip down during cooking.
CAUTION: If burners go out during operation, close gas supply at source, and turn all gas valves off. Open lid and wait five
minutes before attempting to relight (this allows accumulated gas fumes to clear).
CAUTION: Should a grease fire occur, close gas supply at source, turn off all burners and leave lid closed until fire is out.
CAUTION: DO NOT attempt to disconnect any gas fitting while your grill is in operation. As with all appliances, proper care
and maintenance will keep them in top operating condition and prolong their life. Your gas gill is no exception.
CAUTION: Side burner lid will get hot if used when lid is closed.

Trouble Shooting

12