Advertisement
Quick Links
MODEL SRA-125/SRAX-125
DOUBLE-RAIL LIFT-OUT RAIL SYSTEM
INSTALLATION AND SERVICE MANUAL WITH PARTS LIST
For MG, WG(X), WGL, and Grinder Pumps for Effluent and Sewage.
NOTE! To the installer: Please make sure you provide this manual to the owner of the equip ment or to the responsible
party who maintains the system.
Part # M-03-305 | © 2012 Pentair Pump Group, Ltd. | 11/13/12
Advertisement
Related Manuals for Pentair MYERS SRA-125
Summary of Contents for Pentair MYERS SRA-125
- Page 1 For MG, WG(X), WGL, and Grinder Pumps for Effluent and Sewage. NOTE! To the installer: Please make sure you provide this manual to the owner of the equip ment or to the responsible party who maintains the system. Part # M-03-305 | © 2012 Pentair Pump Group, Ltd. | 11/13/12...
-
Page 2: General Information
CAUTION! 16. Do not lift pump by the power cord. 17. Do not exceed manufacturer’s recommendation Read these safety warnings first before installing, for maximum performance, as this could cause the servicing, or operating any pump. motor to overheat. 18. Secure the pump in its operating position so it CALIFORNIA PROPOSITION 65 WARNING: cannot tip over, fall or slide. - Page 3 Level Sensing Controls: The float level controls IMPORTANT: DISCHARGE PIPE AND GUIDE RAILS maintain the basin sewage water level by controlling MUST BE PARALLEL IF INTERMEDIATE GUIDE BRACKET IS USED. pump turn-on and turn-off levels. 1. The lower turn-off control should be set so that the INSTALLING INTERMEDIATE pump stops at approximately the top of the pump.
- Page 4 INSTALLATION FOR RAIL SYSTEM 4" " " " 7" " x 2" lg. Stud (4) Req’d. Centerline Rails 4" and Base Studs " " " Hatch Cover Frame 7" Top Rail Support STUD PATTERN FOR BASE Guide Rails, 1" Intermediate Guide Bracket (Req’d for depths over 20 feet) Lift-out Chain Lift Bail...
-
Page 5: Parts List
SIMPLEX TYPICAL INSTALLATION 24 or 30" Dia. Simplex Junction Box Basin Cover, Struct. Plastic or Fiberglass Conduit Flange SST Fasteners EY Conduit Seal (req’d by others) Rail Support Lift-out Chain 1-1/4" Anti-Siphon Valve, PVC 1-1/2" Conduit Discharge Guide Rails, 1" Pipe 1-1/4"... - Page 6 DUPLEX TYPICAL INSTALLATION 20 Min. Clear Opening Control Mounting Bracket 8 Min. 30 Min. 48Ø Clear 8 Min. Opening 1-1/4" Ball Valve, PVC True Union, Blocked Type Alum. or Steel Basin Hatch w/hinged access door Duplex Junction Box Valve Extension Handle 1-1/4"...
- Page 7 THIS PAGE INTENTIONALLY LEFT BLANK...
-
Page 8: Standard Limited Warranty
STANDARD LIMITED WARRANTY Myers warrants its products against defects in material and workmanship for a period of 12 months from the date ® of shipment from Myers or 18 months from the manufacturing date, whichever occurs first - provided that such products are used in compliance with the requirements of the Myers catalog and technical manuals for use in pumping raw sewage, municipal wastewater or similar, abrasive free non-corrosive liquids.