Table Of Contents - Burnham MINUTEMAN II Installation, Operating And Service Instructions

The New York City Department of Buildings has approved the Minuteman® II boiler: Approval No. MEA 332-93-E.
The City of New York requires a Licensed Master Plumber supervise the installation of this product.
The Massachusetts Board of Plumbers and Gas Fitters has approved the Minuteman® II boiler. See the Massachusetts Board of
Plumbers and Gas Fitters website, http://license.reg.state.ma.us/pubLic/pb_pre_form.asp for the latest Approval Code or ask
your local Sales Representative.
The Commonwealth of Massachusetts requires this product to be installed by a Licensed Plumber or Gas Fitter.
The following terms are used throughout this manual to bring attention to the presence of hazards of various risk
levels, or to important information concerning product life.
DANGER
Indicates an imminently hazardous situation
which, if not avoided, will result in death, serious
injury or substantial property damage.
WARNING
Indicates a potentially hazardous situation which,
if not avoided, could result in death, serious injury
or substantial property damage.

Table of Contents

I. Pre-Installation .........................................4
II. Unpack Boiler .......................................... 5
III. Boiler Water Piping . ..................................5
IV. Domestic Hot Water Performance and
Piping .......................................................9
V. Gas Piping ..............................................10
This boiler contains controls which may cause the boiler to shut down and not restart without service. If
damage due to frozen pipes is a possibility, the heating system should not be left unattended in cold weather;
or appropriate safeguards and alarms should be installed on the heating system to prevent damage if the
boiler is inoperative.
2
Indicates a potentially hazardous situation which,
if not avoided, may result in moderate or minor
injury or property damage.
Indicates special instructions on installation,
operation, or maintenance which are important
but not related to personal injury hazards.
VI. Venting/Air Intake Piping . ......................12
VII. Electrical .................................................20
V III. System Start-up . ......................................21
IX. Service . ....................................................28
X. Repair Parts ............................................36
CAUTION
CAUTION
NOTICE