Table of Contents
Advertisement
Quick Links
hatcocorp.com
Register Online!
(see page 2)
Bain-Marie Heaters/Food Rethermalizers
Installation and Operating Manual
WARNING
Do not operate this equipment unless you
have read and understood the contents of
this manual! Failure to follow the
instructions contained in this manual may
result in serious injury or death. This
manual
contains
important
information concerning the maintenance,
use, and operation of this product. If
you're unable to understand the contents
of this manual, please bring it to the
attention of your supervisor. Keep this
manual in a safe location for future
reference.
P/N 07.04.364.00
HYDRO-HEATER
Sanitizing Sink Heaters
3CS2 and FR2 Series
No opere este equipo al menos que haya
leído y comprendido el contenido de este
manual! Cualquier falla en el seguimiento
de las instrucciones contenidas en este
manual puede resultar en un serio lesión
safety
o
muerte.
importante información sobre seguridad
concerniente al mantenimiento, uso y
operación de este producto. Si usted no
puede entender el contenido de este
manual
por
supervisor. Almacenar este manual en
una localización segura para la referencia
futura.
ADVERTENCIA
Este
manual
contiene
favor
pregunte
a
su
AVERTISSEMENT
Ne pas utiliser cet équipement sans avoir
lu et compris le contenu de ce manuel !
Le
non-respect
des
contenues dans ce manuel peut entraîner
de graves blessures ou la mort. Ce
manuel
contient
des
importantes
concernant
l'utilisation et le fonctionnement de ce
produit. Si vous ne comprenez pas le
contenu de ce manuel, veuillez le signaler
à votre supérieur. Conservez ce manuel
dans un endroit sûr pour pouvoir vous y
référer plus tard.
© 2017 Hatco Corporation
instructions
informations
l'entretien,
Advertisement
Table of Contents
Related Manuals for Hatco HYDRO-HEATER 3CS2 Series
Summary of Contents for Hatco HYDRO-HEATER 3CS2 Series
- Page 1 Almacenar este manual en dans un endroit sûr pour pouvoir vous y reference. una localización segura para la referencia référer plus tard. futura. P/N 07.04.364.00 © 2017 Hatco Corporation...
-
Page 2: Table Of Contents
Water Heater in the spaces below. Please have (Summer Hours: June to September— this information available when calling Hatco for service 7:00 to 5:00 CST Monday–Thursday assistance. -
Page 3: Important Safety Information
This unit has no “user-serviceable” parts. If service is inspectors for proper procedures and codes. required on this unit, contact an Authorized Hatco Service • Unit is not weatherproof. Locate the unit indoors where Agent or contact the Hatco Service Department at the ambient air temperature is a minimum of 70°F... -
Page 4: Model Description
Drain FR2 Models 3CS2/FR2 Series Hydro-Heater The Hatco FR2 Hydro-Heater is designed to be used with a Bain-Marie or Food Rethermalizer to heat or hold foods at safe temperatures between 140ºF and 190ºF (60° and 88ºC). An electronic controller with digital display maintains an accurate setpoint temperature, and “free flow”... -
Page 5: Model Designation
MODEL DESIGNATION 3 C S 2 - X B 3CS = Three Compartment Sink Balanced—3 Phase FR = Food Rethermalizer/ Kilowatt Rating Bain-Marie Heater Hydro-Heater Model Designation SPECIFICATIONS Plug Configurations Some units are supplied from the factory with an electrical cord and plug installed. -
Page 6: Electrical Rating Chart-Fr2 Models
SPECIFICATIONS Electrical Rating Chart—FR2 Models Kilowatts Wiring Sizing Fuse or Model Voltage (kW) Phase Amps AWG*† Circuit Breaker* Shipping Weight FR2-3 14.4 24 lbs. (11 kg) 12.5 24 lbs. (11 kg) FR2-4 19.2 24 lbs. (11 kg) 16.7 24 lbs. (11 kg) FR2-6 28.8 27 lbs. -
Page 7: Dimensions
The Hatco FR2 unit attaches to the bottom of the vessel and supplies hot water to the vessel. -
Page 8: Installation
INSTALLATION General Installing the Unit Hatco 3CS2 and FR2 Series Hydro-Heaters are shipped fully An adhesive backed paper template is shipped with the unit and assembled. Care should be taken when unpacking the shipping is used to locate the sink strainer holes. Use the following carton to avoid damage to unit and components enclosed. -
Page 9: Electrical Information
Anti-Sway Anchor Points b. Screw the union nut to the threaded drain spud Electrical Information assembly. Hatco 3CS2 and FR2 Series Hydro-Heaters are available for operation with standard power systems. Check the specification NOTICE label for the proper power supply. -
Page 10: Operation
If this occurs, contact the Hatco Parts and 5. Move the POWER ON/OFF (I/O) switch to the ON (I) Service Team or an Authorized Service Agent in your position. -
Page 11: Maintenance
This unit has no “user-serviceable” parts. If service is the unit needs to be delimed. Units used with water that required on this unit, contact an Authorized Hatco Service contains high lime and mineral content may require Agent or contact the Hatco Service Department at deliming on a daily basis. -
Page 12: Troubleshooting Guide
Troubleshooting Questions? If you continue to have problems resolving an issue, please contact the nearest Authorized Hatco Service Agency or Hatco for assistance. To locate the nearest Service Agency, log onto the Hatco website at www.hatcocorp.com and click on... -
Page 13: Options And Accessories
OPTIONS AND ACCESSORIES Auto-Fill System 10. Tighten until snug. Be careful not to over-tighten the nut. Over-tightening may cause leaks and/or crack the sensor. A factory-installed Auto-Fill feature is available for 3CS2 and FR2 models. Units equipped with Auto-Fill require the following 11. - Page 14 OPTIONS AND ACCESSORIES Remote Mounted Control Flush Hose Kit A remote mounted control is available for 3CS2 and FR2 The Flush Hose Kit is available for 3CS2 and FR2 models and models. The remote mounted control is shipped with a 45" is used to power flush the unit to keep it working at peak (1143 mm) cord and plug.
-
Page 15: Limited Warranty
Product’s purchase date by registering the Product bulbs, fluorescent lights, heat lamp bulbs, coated halogen light with Hatco or by other means satisfactory to Hatco in its sole bulbs, halogen heat lamp bulbs, xenon light bulbs, LED light discretion. -
Page 16: Authorized Parts Distributors
Lexington 803-996-9900 TENNESSEE Marren Group Camp Electric Northants +44(0)1933 665313 Memphis 901-527-7543 Register your unit online! HATCO CORPORATION P.O. Box 340500 See IMPORTANT OWNER INFORMATION Milwaukee, WI 53234-0500 U.S.A. section for details. 800-558-0607 414-671-6350 partsandservice@hatcocorp.com www.hatcocorp.com Printed in U.S.A. May 2017...