Page 1
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936...
Page 2
, a l way s c o n s u l t t h e c u r r e n t P I O N E E R Service Manual. A subscription to, or additional copies Also test with plug reversed u163 of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. SC-07 http://www.xiaoyu163.com...
Page 5
11.14 ZOUT, PRIMARY GUARD and REG ASSYS......................196 11.15 PRIMARY ASSY ..............................200 11.16 ICE REG ASSY ..............................202 11.17 B DIODE and B REG ASSYS..........................204 11.18 DCDC and HDMI RECT ASSYS ..........................206 12. ELECTRICAL PARTS LIST ............................. 207 L 13942296513 u163 SC-07 http://www.xiaoyu163.com...
PCB ASSY Part No. Ref No. FUNCTION Part No. Remarks L 13942296513 IC101 HDMI Receiver SII9135CTU IC with heat-pad HDMI NETWORK SC-07 : AWX9135 IC701 MEDIA Processor DM850E IC with heat-pad ASSY SC-05 : AWX9190 IC791 iPod Co-Processor 341S2154 IC with heat-pad...
1.3 NOTES ON ASSEMBLING 3 7 63 1515 0 When assembling the ICE amplifier block, please note the following points of screws to prevent from short circuit. The following 7 points of screws must always be used PMH30P080FCC L 13942296513 u163 SC-07 http://www.xiaoyu163.com...
Page 8
3 7 63 1515 0 Points to be watched for swarf L 13942296513 If a screw at any of these points needs to be removed for service, be sure to check that the swarf is not on the screw before refastening. u163 SC-07 http://www.xiaoyu163.com...
Antenna ....... Loop antenna Multi channel simultaneous power output (1 kHz, 1 %, 8 Ω) 7ch total ....700 W (SC-07)/630 W (SC-05) Miscellaneous Continuous Power Output (20 Hz to 20 kHz, 8 Ω, 0.09 %)
Resolution is set to a setting other than PURE (for example, when the video input signal is upscaled HDMI indicator – Blinks when connecting an HDMI- equipped component; lights when the component is connected. u163 4 Remote sensor Receives the signals from the remote control. SC-07 http://www.xiaoyu163.com...
Page 12
USB audio device for playback. 19 VIDEO 3 INPUT 20 MCACC SETUP MIC jack Use to connect the supplied microphone. 21 PHONES jack Use to connect headphones. When the headphones are connected, there is no sound output from the speakers. u163 SC-07 http://www.xiaoyu163.com...
Page 13
Use for connection to a PC for graphical output when using Advanced MCACC or Full Band Phase Control. 2 HDMI connectors (x6 (SC-07), x5 (SC-05)) Multiple inputs and one (SC-05) or two (SC-07) outputs 11 Component video inputs (x3) for high-quality audio/video connection to compatible Use the inputs to connect any video source that has HDMI devices.
Page 14
19 Multichannel analog audio inputs 7.1 channel inputs for connection to a DVD player with multichannel analog outputs. 20 Speaker terminals Use for connection to the main front, center, surround and surround back speakers. L 13942296513 u163 SC-07 http://www.xiaoyu163.com...
Page 15
Light according to the active Audio parameter(s) and/or 19 Character display ANALOG ATT. Displays various system information. 9 V.SB u163 20 Input source indicators Lights during Virtual surround back processing. Light to indicate the input source you have selected. 10 TUNER indicators SC-07 http://www.xiaoyu163.com...
Page 16
FM broadcasts. If the signal is weak, then 6 Character display (LCD) u163 switching to mono will improve the sound quality. This display shows information when transmitting NOISE CUT MODE 1 to 2 can be selected control signals. when receiving AM broadcasts. SC-07 http://www.xiaoyu163.com...
Page 17
(this feature is available only when a Pioneer DVD recorder supporting HDMI Control is connected to this receiver via HDMI). SC-07 only: HDMI OUT – Switch the HDMI output terminal. Press TUNER first to access: D.ACCESS – After pressing, you can access a radio station directly using the number buttons.
Disturbed image (video jumpiness) Volume too high Too dark Volume fluctuating Too bright Sound interrupted Mottled color Cleaning the Fan Before shipment, be sure to clean the fan, using the following cleaning materials: Cleaning paper : GED-008 u163 SC-07 http://www.xiaoyu163.com...
Page 20
Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. LIST OF ASSEMBLIES SC-07/KUXJ SC-05/KUXJ Mark Symbol and Description 1..ICEPOWER AMP ASSY...
GGD1593 Diagnosis 5p extension cable GGD1594 Diagnosis [2] Lubricants and Glues List Name Lubricants and Glues No. Remarks Lubicating Oil GYA1001 Refer to “9.5 FRONT PANEL SECTION” Silicone Grease GEM1057 Refer to “9.3 CHASSIS SECTION” L 13942296513 u163 SC-07 http://www.xiaoyu163.com...
4. BLOCK DIAGRAM 3 7 63 1515 0 4.1 OVERALL WIRING DIAGRAM FRONT IN ASSY (AWX9142) DISPLAY ASSY (SC-07:AWX9158) (SC-05:AWX9238) VOL ASSY (AWX9159) B REG ASSY (AWX9150) COMPONENT ASSY (SC-07:AWX9141) (SC-05:AWX9211) L 13942296513 V-BRIDGE ASSY (AWX9161) COMPOSITE S A...
Page 23
3 7 63 1515 0 DISPLAY ASSY (SC-07:AWX9158) (SC-05:AWX9238) • When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST". POWER SW • The mark found on some component parts indicates the importance of the safety factor ASSY of the part.
4.4 HDMI NETWORK BLOCK DIAGRAM 3 7 63 1515 0 Component CVBS Component CVBS L 13942296513 I2S/DSD SPDIF/DSD Component for SUB ROOM GUI CVBS SPDIF TMDS Video BUS u163 Analog Video AUDIO SC-07 http://www.xiaoyu163.com...
Failure in DIR Input the PCM (such as CD) signals. Change the listening mode to "Pure Direct (PCM Direct)". Set the signal switching to "Auto" or "PCM". Failure in DSP Failure in D/A • Perform DSP converter Diagnosis u163 SC-07 http://www.xiaoyu163.com...
Page 33
Is the voltage CN2401 3.3V? in the path. FRONT-IN Assy. Is the Insert the connectors cable securely securely. IC2704 (Pin 20) LATCH 1 inserted? Check the parts and patterns Is the voltage To Step2 in the path. 3.3V? u163 SC-07 http://www.xiaoyu163.com...
Page 34
3.3V? The output and GND may be short- circuited. Check the path between them. To Step 3 IC2701 (Pin 1, etc.) 1st DSP 1V Check the parts and patterns Is the voltage in the path. u163 SC-07 http://www.xiaoyu163.com...
Page 35
IC2701 (Pin 97) DATA 2nd DSP EXTAL IC2801 (Pin 45) Is there Is there master clock input data input Check the signal path. Check the path. (24.576 MHz)? to 1st DSP? To Step 5 To Step 4 u163 SC-07 http://www.xiaoyu163.com...
Page 36
Check the parts and patterns data input in the path. to selector? Is there Check the parts and patterns data input to 2nd DSP? in the path. It is very difficult to diagnose which part is in failure. To Step 6 u163 SC-07 http://www.xiaoyu163.com...
Page 37
It is very difficult to diagnose which part is in failure. Does clock signal output have Replace IC2701. DSP1SS0 and DSP1SS1 for a period of "L"? u163 It is very difficult to diagnose which part is in failure. SC-07 http://www.xiaoyu163.com...
Page 38
3 7 63 1515 0 3) D-MOTHER Assy check points (DSP section) D-MOTHER ASSY SIDE A L 13942296513 u163 SC-07 http://www.xiaoyu163.com...
Page 39
: To Step 3-1 To Step 5-1 correctly, replace IC1021. Video converter (Analog input) Scaler diagnosis : diagnosis : To Step 4-1 To Step 5-1 u163 GUI(EMMA) diagnosis : Scaler diagnosis : To Step 6-1 To Step 5-1 SC-07 http://www.xiaoyu163.com...
Page 40
3 7 63 1515 0 * HDMI Switch. Step 3-1: Power supply, CLK 1.8 V(Switch) L1152, L1153 V+1R8HD SC-07 only 5 V(HDMI OUT1) JA301(Pin 18) Is the voltage Replace L1152 and L1153. 1.8 V? Check the soldering of IC1051 and Is the voltage the peripheries of IC1051.
Page 41
3 7 63 1515 0 SC-07 only HPD(HDMI OUT1) R1057 V+6HD TX2RST R354 Is the voltage Check the patterns in the path. "H" (6 V)? Check the JA301. Check the parts and Is the voltage patterns in the path.
Page 42
Replace IC1151. Check the JA1102. (0 - 5 V) RXDSCL1 R108(Pin 6) Replace JA1102. Is there Check the patterns in the path. a same signal as SCL (IN2) (0 - 3.3 V) Check the IC1151(Pins 76,77). u163 Replace IC1151. SC-07 http://www.xiaoyu163.com...
Page 43
Check the IC1204 and IC1208. Is there Check the patterns in the path. a same signal as SDA (OUT2) (0 - 3.3 V) Check the R366 and R368. Replace IC1204 and IC1208. SC-07 only Replace Q352. SDA(HDMI OUT1) JA301(Pin 16) DSCL R357 Does a signal output in Check the patterns in the path.
Page 44
3 7 63 1515 0 Step 3-7: TMDS(OUTPUT) Step 3-6: TMDS(INPUT) * When connected the source SC-07 only equipment to BD IN. TMDS(HDMI OUT1) JA301(Pins 1,3,4,6, IC1151(Pins 58,59, TMDS(BD IN) * 7,9,10,12) 61,62,64,65,67,68) Are there signals Check the parts and patterns in Are there signals (approx.
Page 45
CLK? Replace IC101. RXSD0-3 R115(Pins 1-4) BFADT CN201(Pin 22) Is there a Check the parts and patterns in Diagnosis the INTERFACE ASSY Is there a DATA? the path (IC101 - IC201). or D-MOTHER ASSY. DATA? Replace IC101. u163 SC-07 http://www.xiaoyu163.com...
Page 46
(CN201 - IC251 and IC251 - IC351). Replace IC251. TXSD0 IC351(Pin 9) Check the parts and patterns in Is there a Data? the path (CN201 - IC251 and IC251 - IC351). Replace IC251. TO STEP 4-1 u163 SC-07 http://www.xiaoyu163.com...
Page 47
Pb signal? Assy Replace L602. 1.8V(VIDEO DEC) L402 COMPONENT Cr IN CN6009(Pin 8) V+1R8DE Check the patterns in the path Is the voltage 1.8V? Is there a Diagnose the COMPONENT Check the L402. Pr signal? Assy Replace L402. u163 SC-07 http://www.xiaoyu163.com...
Page 48
Step 4-5: VIDEO CLK,DATA Is there a Check the parts and patterns in DATA? the path(IC401 - IC601). IC401(Pin 17) Replace IC401. Check the parts and patterns in Is there a the path(IC401 - IC1301 and CLK? IC401-IC1381). u163 Replace IC401. SC-07 http://www.xiaoyu163.com...
Page 49
CN6009(Pin 6) Check the parts and patterns in Is there a Y signal? the path(IC601 - CN601). Replace L661 and Q661 or the peripheries of L661 and Q661. Replace IC601. Diagnose the INTERFACE Assy u163 or COMPONENT Assy SC-07 http://www.xiaoyu163.com...
Page 50
3.3 V (SDRAM) L1351 Replace IC401. P22-29 IC1301(Pins 29, Is the voltage Check the L1351. 32-35,38-40) 3.3 V? Replace L1351. Check the parts and patterns in Is there a DATA? the path (IC401 - IC1301). u163 Replace IC401. SC-07 http://www.xiaoyu163.com...
Page 51
CLK? Replace IC1301 or IC1351. D16-23 IC1301(Pins 148-155) Is there a Check the IC1301 and IC1351. DATA? Replace IC1301 or IC1351. TD28-35 IC1301(Pins 130-137) Is there a Check the IC1301 and IC1351. DATA? Replace IC1301 or IC1351. u163 SC-07 http://www.xiaoyu163.com...
Page 52
Step 6-2: X'tal, Reset Does a signal output in X'tal X1701 Check the CN1701 (Pin 11). constant period (0 - 3.3 V) Diagnosis the D-MOTHER ASSY. Is oscillation Check the X1701. of 27.0 MHz Replace X1701 or IC1703. u163 SC-07 http://www.xiaoyu163.com...
Page 53
CN6004(Pin 13) Is there a L 13942296513 Check the IC1701 and IC1901. composite signal? Replace IC1701 or IC1901. SC-07 only ZONE COMPONENT Y CN6009(Pin 30) Is there a Check the IC1701 and IC1901. Y signal? Replace IC1701 or IC1901. ZONE COMPONENT Cb...
Page 55
3 7 63 1515 0 HDMI NETWORK ASSY SIDE B V+3R3HD L 13942296513 1pin V+12HDMI 30pin u163 SC-07 http://www.xiaoyu163.com...
Page 56
• Check the bus power. Is “USB” -> Power consumption of portable shown on the HDD, e.g. does not allow drive. Top menu u163 • Check the file format of USB. FAT16 or 32 only can be used. SC-07 http://www.xiaoyu163.com...
Page 57
Is IC11 Is the abnormally voltage 3.3V? hot? Replace IC21. Replace IC11. u163 The output and GND may be The output and GND may be short-circuited. Check the path short-circuited. Check the path between them. between them. SC-07 http://www.xiaoyu163.com...
Page 59
Step 6 : Audio Output CN201 (Pin 23) Is there the SPDIF digital Check the D-MOTHER part audio signal? IC701 (Pin 39) Is there Check the parts and patterns in the SPDIF digital the path. audio signal? u163 Check the DM850E operation SC-07 http://www.xiaoyu163.com...
Page 60
Is CPRDY OK? IC701(Pin 35). L 13942296513 Operation of IC791 is OK. Step 9 : Photo Image Output CN701(Pin2,4,5,6,7,161,162,163,164) Is there the BT.656 Check the HDMI digital video signal? circuit on this board. Check the DM850E operation u163 SC-07 http://www.xiaoyu163.com...
Page 61
(Are the pins 5 and 6 of CN4000 AMUTE and SBMUTE. of ICEPOWER AMP Assy set to H?) Check again whether the audio signal is not output in the speaker output even if the input signal level is increased. u163 SC-07 http://www.xiaoyu163.com...
Page 62
L 13942296513 a failure in the power amplifier upon the power failure. Also, diagnose the amplifier ±64V supplied? (Pins 1 and 4 of circuit by Amplifier Diagnosis without Current Applied.) CN4900) Perform Amplifier Diagnosis without Current Applied u163 SC-07 http://www.xiaoyu163.com...
Page 63
Check that the driver IC is not damaged (IC4101) Check that the L and R connected in series to the power supply are not damaged (L4104, R4147) u163 SC-07 http://www.xiaoyu163.com...
Page 64
It is likely that the XM antenna disconnected, the +5V power is input sources. Check with analog is in failure. supplied from this unit.) Operation OK and digital inputs. Replace the antenna. SC-07 http://www.xiaoyu163.com...
Page 65
Subscription Updating Unit is updating subscription. Wait until the encryption code has been updated. Updating Channels Unit is updating channels. Wait until the encryption code has been updated. Invalid Channel Selected channel is not available/does not exist. Select another channel. u163 SC-07 http://www.xiaoyu163.com...
Voltgae No micro-computer Detects low voltage of modulator No micro-computer detection control but modulator IC detection IC power supply (normally ± 5V) Recoverable by power-on exists. (Modulator becomes below ± 2 - 3V stops by itself. u163 SC-07 http://www.xiaoyu163.com...
Page 72
(12) Flashes DSP NG during communication with the DSP micro-computer. [Detection and Display Priority] In principle, the abnormality is preferentially detected as the following order. AMP system DC Detect AMP B1Error AMP Overload Detection FANDET Thermal_Overload u163 SC-07 http://www.xiaoyu163.com...
Page 73
There is no response from the HDMI microcomputer. (12) DSP NG There is no response from the DSP microcomputer. [How to Enter Release Mode] During Standby mode, simultaneously press and hold the " (DOWN)" and "ZONE2 ON/OFF" keys for 2 seconds. u163 SC-07 http://www.xiaoyu163.com...
[ ← ] [→] PROTECT block 1/11 Display number of times DC is detected. [ ← ] [→] DOWNLOAD block 1/7 L 13942296513 Display MAIN computer DOWNLOAD. [ ← ] [→] Return to VERSION block 1/3. u163 SC-07 http://www.xiaoyu163.com...
Page 75
H * . *** : HDMI microcomputer [ ↑ ] [↓] VERSION block 4/4 f * . *** : 1st DSP firmware 1stDSP/2ndDSP firmware s* . *** : 2nd DSP firmware [ ↑ ] [↓] To PROTECT L 13942296513 block u163 SC-07 http://www.xiaoyu163.com...
Page 76
1 2 6 abnormal temperature at PowerAmp supply is detected. [ ↑ ] [↓] PROTECT block 8/11 Display number of times B E R R : 1 2 5 defect at PowerAmp supply is detected. [ ↑ ] [↓] u163 SC-07 http://www.xiaoyu163.com...
Page 77
The Timer of Exception Setting of the Timer of Exception "Set Stream Path" "Set Stream Path" command command on CEC. on CEC. Key operation FL display [ ↑ ] [↓] [←][→] To DOWNLOAD ↓ block To normal mode L 13942296513 u163 SC-07 http://www.xiaoyu163.com...
Center Beam V1 L 13942296513 Rear view Remove the fourteen screws. Remove the Bonnet. Left Beam 81 ×3 PCB Holder Bonnet ×8 Remove the five Cushion circle 14B. Remove the 69 screws. Remove the Rear Panel. ×3 u163 Rear view SC-07 http://www.xiaoyu163.com...
Page 81
(GGD1589) (GGD1588) (GGD1593) (GGD1593) Diagnosis Note : As mentioned below, detach the rear panel, re-fasten the screws at the corresponding points, and connect the chassis to the ground. u163 Points to be connected to the chassis SC-07 http://www.xiaoyu163.com...
11. "Completed" is displayed in the"ufu.exe" window. Select the communication speed. 12. Please retry it from 2 when it doesn’t so well. • Basic speed: 19200 13. Turn off the unit and end the ufu.exe. • Data transfer speed: 57600 SC-07 http://www.xiaoyu163.com...
Page 83
6) Push “ENTER” key and often a while “OK” is displayed. 15. Check the version. Following the procedures described in "Version indication" in "6.1 TEST MODE", check that the version has been changed to a new one. u163 SC-07 http://www.xiaoyu163.com...
Page 84
7. Turn off the unit and disconnect the USB MEMORY. L 13942296513 [Confirmation] 1. Simultaneously press and hold POWER and RETURN keys for about 5 seconds. 2. The DSP firmware version is dislplayed automatically. Confirm the Version after the update. (F) u163 SC-07 http://www.xiaoyu163.com...
Page 85
Open the Control Panel. ---> Open the Network Connections (double click). L 13942296513 Local Area Connection (right click) ---> Properties Internet Protocol (TCP/IP) Properties Set the following settings. u163 Use the following IP address: IP address: 192.168.000.001 Subnet mask: 255.255.255.0 SC-07 http://www.xiaoyu163.com...
Page 86
Click the browse button and select the firmware file in the PC. L 13942296513 Click and select the firmware file on the PC. Click the Ok button. Click the Upload button. Click. Click. If you want to cancel, click here. u163 SC-07 http://www.xiaoyu163.com...
Page 87
The firmware update will be started. Note: Please restore the Network IP settings of the customer's unit after the update is completed. L 13942296513 After the updating is completed, click the Ok button to return status page. Click. u163 SC-07 http://www.xiaoyu163.com...
Screws adjacent to b mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 9.1 PACKING SECTION L 13942296513 u163 SC-07 http://www.xiaoyu163.com...
Page 89
Remote Control Unit AXD7520 NSP 9 Dry Cell Battery AA/LR6 VEM1031 Protection Sheet LX AEH7030 Front Pad 81 AHA7478 Rear Pad 81 AHA7479 Packing Case AHD8601 (SC-07/KUXJ/CA) Packing Case AHD8602 (SC-05/KUXJ/CA) Packing Sheet RHC1023 Battery Cover AZN8031 L 13942296513 u163 SC-07 http://www.xiaoyu163.com...
Silicon grease GEM1057 Paste lubricant silicon grease (GEM1057) to both sides of the Sheet. FRONT IN CN6301 FRONT IN CN6201 FRONT IN CN6202 FRONT IN CN6351 Refer to u163 "9.5 FRONT PANEL SECTION" (∗c) DISPLAY JH8201 DISPLAY CN8001 SC-07 http://www.xiaoyu163.com...
Page 93
Housing Assy (Y23) ADX7623 NSP 24 Under Base 81 ANA7210 PCB Angle 45 ANG7406 (2) CONTRAST TABLE SC-07/KUXJ/CA and SC-05/KUXJ/CA are constructed the same except for the following: Mark Symbol and Description SC-07/KUXJ/CA SC-05/KUXJ/CA D-MOTHER ASSY AWX9136 AWX9201 11 HDMI NETWORK ASSY...
CN7042 Refer to INTERFACE "9.5 FRONT CN7041 PANEL SECTION" (∗b) L 13942296513 INTERFACE (RED) CN7032 ICE REG INTERFACE CN7302 (RED) CN7031 SC-05/KUXJ/CA only B-REG CN7303 INTERFACE CN7051 ICE REG CN7251 (BLUE) ICE REG CN7271 u163 ICE REG CN7241 SC-07 http://www.xiaoyu163.com...
Page 95
VRW1629 4P Housing Assy (Y25) ADX7677 DC Fan Motor AXM7040 Rear Panel See Contrast table (2) (2) CONTRAST TABLE SC-07/KUXJ/CA and SC-05/KUXJ/CA are constructed the same except for the following: Mark Symbol and Description SC-07/KUXJ/CA SC-05/KUXJ/CA COMPONENT ASSY AWX9141 AWX9211...
HDMI NETWORK CN801 D-MOTHER CN2401 INTERFACE CN7062 ∗e ∗a L 13942296513 INTERFACE JH7061 ∗d Double Side Tape 10 X 35 Lubricant GYA1001 Paste lubricant Oil (GYA1001) to Earth Spring and Door Base. ∗a ∗b ∗b ∗c u163 ∗d ∗e SC-07 http://www.xiaoyu163.com...
Page 97
NK90FTC Power Ring B AAK8431 Door Sheet 07KU AAK8438 Display Panel 07KU AAK8441 (2) CONTRAST TABLE SC-07/KUXJ/CA and SC-05/KUXJ/CA are constructed the same except for the following: Mark Symbol and Description SC-07/KUXJ/CA SC-05/KUXJ/CA DISPLAY ASSY AWX9158 AWX9238 22 Front Panel...
Page 99
(SB) (PHONO) : Audio Signal Route (Surround Back L ch) : Audio Signal Route (Phono L ch) (SW) : Audio Signal Route (Subwoofer) : Audio Signal Route (Mic) JH5001 VEF1040-A (HPL) : Audio Signal Route (Headphone L ch) SC-07 http://www.xiaoyu163.com...
Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. YB:CKSRYB, QYB:CKSQYB, SYB:CKSSYB, SCH:CCSSCH, ZL:CEHAZL 3. NM: No Mount mark found on some component CN2403 parts should be replaced with same parts (safety regulation authorized) of identical designation. CKS3815-A CN7009 SC-07 http://www.xiaoyu163.com...
Rated Power: 1/16w unless otherwise noted. Toleranee: (J)5% unless otherwise noted. 2. CAPACITORS Unit: p-pF or u-uF unless otherwise noted. Ratings: Capacity(F)/Voltage(V) unless otherwise noted. CH : CCSRCH NO MARKED : CKSRYB 3. NM: No Mount SC-07 http://www.xiaoyu163.com...
Page 109
: Video Signal Route (Composite Y) (FVL) (CSiteV) : Audio Signal Route (Video L ch) : Video Signal Route (Composite Video) (CSite) : Audio Signal Route (Mic) : Video Signal Route (Composite) (HPL) : Audio Signal Route (Headphone L ch) u163 SC-07 http://www.xiaoyu163.com...
VDD2_6 RADD19 C1711 C1712 C1713 C1714 0.1u/10 0.1u/10 0.1u/10 0.1u/10 C1748 C1749 C1750 C1751 470p/50 470p/50 470p/50 470p/50 GNDDH u163 mark found on some component parts should be replaced with same parts (safety regulation authorized) of identical designation. SC-07 http://www.xiaoyu163.com...
GNDDH IC1071 NJM2885DL1-05 V+5DHD R1071 R1072 V+5AHD R1073 V+5RY GNDDH GNDDH R1074 D1071 D1072 IC1072 Vout CONTROL NOISE_BYPASS u163 mark found on some component GNDDH parts should be replaced with same parts (safety regulation authorized) of identical designation. SC-07 http://www.xiaoyu163.com...
MICSEL HDREQI HDREQI HDREQI HDREQI LSSN GNDHD GNDHD GNDD GNDHD GNDD u163 GNDHD GNDHD (FSC) : S-Video Signal Route (Front C) (FSY) : S-Video Signal Route (Front Y) (FV) : Video Signal Route (Video) : Audio Data Route SC-07 http://www.xiaoyu163.com...
Page 125
L7006 : Audio Signal Route (SIRIUS L ch) : Audio Signal Route (Surround Back L ch) (ZONE) (SW) : Audio Signal Route (Zone L ch) : Audio Signal Route (Subwoofer) (ADC) : Audio Signal Route (ADC L ch) SC-07 http://www.xiaoyu163.com...
Page 131
: S-Video Signal Route (Front C) (FSY) : S-Video Signal Route (Front Y) (FV) : Video Signal Route (Video) (FVL) : Audio Signal Route (Video L ch) : Audio Signal Route (Mic) (HPL) : Audio Signal Route (Headphone L ch) u163 SC-07 http://www.xiaoyu163.com...
IC8002 u163 NO MARKED : CKSRYB VKN1269-A R8077 Vout 3. NM: No Mount VSG1024-A 3 GND mark found on some component parts should be replaced S8008 GP1UE274XKC1 with same parts(safety regulation authorized) of identical designation. VSG1024-A HOME MENU SC-07 http://www.xiaoyu163.com...
Page 137
: Audio Signal Route (Front L ch) (SL) : Audio Signal Route (Surround L ch) : Audio Signal Route (Center) (SB) : Audio Signal Route (Surround Back L ch) (ZONE) : Audio Signal Route (Zone L ch) u163 SC-07 http://www.xiaoyu163.com...
(1/2) NJM4565MD R4860 C4847 1u/10 V-5V V+64V R4761 ACN7165-A 3216 VD_CHK4 L4702 ATL7018-A L4703 ATL7018-A u163 mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical 3216 VS_CHK4 R4762 designation. ACN7165-A V-64V SC-07 http://www.xiaoyu163.com...
1SR154-400 mark found on some component parts should be replaced R7623 -35V with same parts(safety regulation authorized) of identical designation. CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND RATINGS OF FUSE. SC-07 http://www.xiaoyu163.com...
Ratings: Capacity(F)/Voltage(V) CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, unless otherwise noted. CH : CCSRCH , CFTLA : CFTLA NO MARKED : CKSRYB or CEAT REPLACE WITH SAME TYPE AND RATINGS OF FUSE. 3. NM: No Mount SC-07 http://www.xiaoyu163.com...
Page 153
CN7251 V+12DF GND_DF GND_DF V-12DF CN4903 R7255 R7251 GND_DF(S) R7253 V+12RY V-12RY R7256 KM200NA6E IC7252 R7254 -20V NJM79M12FA GND_DF V-12DF u163 mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical designation. SC-07 http://www.xiaoyu163.com...
3. NM: No Mount u163 CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE, REPLACE WITH SAME TYPE AND RATINGS OF FUSE. mark found on some component parts should be replaced with same parts(safety regulation authorized) of identical designation. SC-07 http://www.xiaoyu163.com...
Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B Chip Part P.C.Board transistor Resistor array 3-terminal regulator L 13942296513 u163 SC-07 http://www.xiaoyu163.com...
OPEN SIDE OPEN SIDE KN6351 JA6351 C6304 KN6201 C6232 R6231 KN6202 C6231 [[ G ]] A30C5/C7 JA6202 R6232 IC6201 IC6201 JA6301 JA6201 (ANP7651-B) L 13942296513 SIDE B SIDE B FRONT IN ASSY CN6301 CN6201 u163 CN6202 CN6351 (ANP7651-B) SC-07 http://www.xiaoyu163.com...
Page 177
TO COMPONENT ASS’Y C N 8 6 0 1 UPSIDE [[ G ]] A W X 9 1 6 1 A W X TO COMPOSITE & S ASS’Y CN8602 CN8602 (ANP7655-B) CN6503 L 13942296513 CN6009 CN6004 u163 CN501 CN502 (ANP7651-B) SC-07 http://www.xiaoyu163.com...
Page 178
3 7 63 1515 0 SIDE B V-BRIDGE ASSY CN8601 C8603 UPSIDE TO COMPONENT ASS’Y C8604 C8602 TO COMPOSITE & S ASS’Y C8601 (ANP7655-B) CN8602 L 13942296513 C6122 u163 CN6004 SC-07 http://www.xiaoyu163.com...
Page 179
3 7 63 1515 0 SIDE B COMPONENT ASSY CN6008 L 13942296513 C6122 (ANP7651-B) CN6004 CN6009 u163 SC-07 http://www.xiaoyu163.com...
11.9 FRONT BRIDGE ASSY 3 7 63 1515 0 SIDE A SIDE A FRONT BRIDGE ASSY L 13942296513 u163 (ANP7654-B) SC-07 http://www.xiaoyu163.com...
Page 183
3 7 63 1515 0 SIDE B SIDE B FRONT BRIDGE ASSY C7715 C7711 C7712 C7713 C7714 L 13942296513 u163 R7709 (ANP7654-B) SC-07 http://www.xiaoyu163.com...
3.GNDV ATTENTION EN CAS D 4.GNDV 5.V-5.6V ET P7522 C7602 DE CHEZ L J7605 GNDV ASSY IC7502 IC7521 IC7601 IC7601 IC7602 IC7602 IC7611 IC7611 78M56 IC7501 79M05 78M12 L 13942296513 ZOUT ASSY JA6401 CONTACT SIDE UP u163 (ANP7651-B) SC-07 http://www.xiaoyu163.com...
Page 197
DE CHEZ LITTELFUSE INC. AWX9152 ASSY AWX9153 C7508 C7507 IC7502 IC7521 79M12 IC7501 78M06 78M12 L 13942296513 (ANP7654-B) CN6830 PRIMARY GUARD ASSY CN5752 AWX9172- CN5752 [[ G ]] PRIMARY GUARD CN5751 u163 DO NOT THROW CN5751 (ANP7650-C) CN6504 SC-07 http://www.xiaoyu163.com...
Page 198
1.S4-1-1 D7612 2.S4-2-1 3.S4-G 4.S4-2-2 5.S4-1-2 D7613 REG ASSY D7508 AWX9152 AWX9153 D7616 D7524 NO USE D7506 D7505 C7505 C7522 C7613 L 13942296513 ZOUT ASSY CN5752 AWX9172- [[ G ]] PRIMARY GUARD u163 DO NOT THROW (ANP7651-B) CN5751 SC-07 http://www.xiaoyu163.com...
11.16 ICE REG ASSY 3 7 63 1515 0 SIDE A SIDE A ICE REG ASSY CN4901 CN7241 IC Q IC7252 Q7241 IC7251 BLUE L 13942296513 Q7212 Q7211 (ANP7653-B) IC7272 IC7271 u163 SC-07 http://www.xiaoyu163.com...
Page 203
3 7 63 1515 0 SIDE B SIDE B ICE REG ASSY CN7241 IC Q Q7242 L 13942296513 Q7202 Q7204 Q7205 Q7203 Q7222 Q7201 Q7221 (ANP7653-B) u163 SC-07 http://www.xiaoyu163.com...
V+12HD J8802 HDMI RECT V+12HD R8800 JV8800 CN8801 C8800 H8801 SEC7-2 JH8800 H8802 FU41 SEC7-1 AWX9156 4A 125V HDMI RECT RISK OF FIRE - REPLACE FUSE AS MARKED. CN8802 CN8801 CN8802 (ANP7655-B) (ANP7655-B) To MAIN TRANS JP7104 u163 SC-07 http://www.xiaoyu163.com...
Page 208
AWX9158 and AWX9238 are constructed the same except for the following: Mark Symbol and Description AWX9158 AWX9238 R8015, R8084 Not used RS1/16S0R0J PCB PARTS LIST FOR SC-07/KUXJ/CA UNLESS OTHER WISE NOTED Mark No. Description Part No. Mark No. Description Part No. C 5202,5204,5231,5233...
Page 209
R 2714,2905,2906,2909 RS1/16S103J L 3051-3054 CHIP SOLID INDUCTOR QTL1013 R 2722,2761,2762,2765 RAB4CQ220J L 3081 CHIP SOLID INDUCTOR QTL1013 R 2747,2803 RAB4CQ103J L 3151-3154 CHIP SOLID INDUCTOR QTL1013 R 2759,2760,2763,2764 RAB4CQ221J L 3181 CHIP SOLID INDUCTOR QTL1013 R 2766 RAB4CQ220J SC-07 http://www.xiaoyu163.com...
Page 210
CKSRYB104K16 C 2822,2824,2831,2833 CKSSYB471K50 C 2050-2054,2056-2065 CCSSCH100D50 u163 C 2825,2829,2830,2832 CKSSYB104K10 C 2201,2426,2827 ACH7272 C 2826,3055,3063,3155 ACH7268 C 2202,2204,2205,2208 CCSSCH471J16 C 2834,2836,2839,2840 CKSSYB104K10 C 2206,2965,3052,3071 CCSRCH471J50 C 2835,2837,2838,2841 CKSSYB471K50 C 2216 CEAT102M10 C 2903,2904 DCH1201 C 2222,2224-2226,2228 CKSSYB104K10 SC-07 http://www.xiaoyu163.com...
Page 211
L 2001 CHIP SOLID INDUCTOR QTL1013 IC 2001 PEG489B8 L 2002,2003 CHIP SOLID INDUCTOR ATL7002 IC 2002,2003,2203,2204 TC4094BFN L 2404-2409 CHIP SOLID INDUCTOR QTL1013 IC 2005 BU4842F L 2411-2416 CHIP SOLID INDUCTOR QTL1013 IC 2006 TC74LCX244FTS1 L 2601 CHIP SOLID INDUCTOR ATL7002 SC-07 http://www.xiaoyu163.com...
Page 212
CKSRYB472K50 R 2211,2217,2229,2230 RS1/16S473J C 2013,2220,2221,2954 CKSRYB103K50 u163 R 2216,2218,2223,2226 RAB4CQ101J C 2016,2047,3001,3002 CCSRCH102J50 C 2017,2018,2020-2024 CKSRYB104K16 R 2233,2235 RS1/16S473J R 2234,2425,2730,2812 RAB4CQ101J C 2019,2026,2211-2215 CKSSYB104K10 R 2401,2402 RS1/16S750J C 2025 CEAT331M10 R 2404,2405,2901-2904 RS1/16S220J C 2027,2454,2457,2762 CKSQYB225K10 SC-07 http://www.xiaoyu163.com...
Page 213
FRONT IN ASSY C 2777,2778,2993 CKSQYB225K10 u163 C 2782,2956,2957,3061 ACH7211 SEMICONDUCTORS C 2784,3065,3165,3265 CEHAZL221M10 IC 6201 NJM4565MD C 2792-2795 CCSSCH102J50 Q 6201 HN1C01FU D 6201,6202,6204,6351 1SS302 C 2797,2798,2800,2802 CKSSYB104K10 D 6203,6205,6206 UDZS5R1(B) C 2799 VCH1234 D 6303,6304 UMZU6.2N SC-07 http://www.xiaoyu163.com...
Page 214
C 5830,5831 CKSRYB471K50 C 5832-5834 CCSRCH100D50 CAPACITORS C 5857,5858 CEAT220M50 C 6202,6208,6218,6224 CKSRYB104K16 C 6204,6220,6226,6228 CKSRYB103K50 C 6205,6206 CKSRYB221K50 HDMI NETWORK ASSY (SC-07) C 6209 CKSRYB105K6R3 SEMICONDUCTORS C 6210,6211,6234,6235 CEAT100M50 IC 11 NJM2846DL3-33 C 6212,6351 CKSRYB471K50 IC 21 NJM2846DL3-18 C 6213...
Page 215
L 1052 INDUCTOR ATH7061 R 868-871 RS1/16S49R9F L 1097-1099 INDUCTOR CTF1386 R 919 RS1/10S102J L 1301-1305 CHIP SOLID INDUCTOR ATL7002 R 1009,1056 RS1/16SS1002F L 1351,1901 CHIP SOLID INDUCTOR ATL7002 R 1011 RS1/16SS2001F L 1381-1384 CHIP SOLID INDUCTOR QTL1013 SC-07 http://www.xiaoyu163.com...
Page 216
CKSSYB104K10 C 1007,1029-1031,1041 CKSRYB104K25 C 318,356,358,361 CKSSYB105K6R3 u163 C 1008 CKSQYB105K16 C 320,321,370,371 CKSRYB105K10 C 1009,1052,1151,1156 BCG1059 C 325-332,375-382 VCG1066 C 1023,1027 CCG1233 C 351,352 DCH1165 C 1024,1026 CKSQYB475K10 C 353-355,417,430 CKSQYB106K6R3 C 1025,1028 CCSRCH101J50 C 359,362,366,367 CKSSYB104K10 SC-07 http://www.xiaoyu163.com...
Page 217
L 251,252 CHIP SOLID INDUCTOR QTL1013 IC 352 NJM2872BF05 L 356-359 COIL ATH7022 IC 401 ADV7800BSTZ-80 L 401,402,404,406 CHIP BEADS ATL7010 IC 402 TC7WHU04FU L 403,405 CHIP SOLID INDUCTOR QTL1013 IC 501 PEG118A L 501,601 CHIP SOLID INDUCTOR ATL7002 SC-07 http://www.xiaoyu163.com...
Page 218
CKSQYB106K6R3 R 428,429,789 RAB4CQ330J C 105,113,121,122 CKSSYB105K6R3 u163 R 432,433,1385-1388 RAB4CQ470J C 109,111,131,203 CKSSYB103K16 R 434,437,442,443 RAB4CQ473J R 446,447,450,708 RAB4CQ473J C 114-120,123-126 CKSSYB104K10 C 127,463,740,1339 CCSSCH120J50 R 464,465,467,468 RAB4CQ472J C 128,462,741 CCSSCH100D50 R 480-483,741,761 RAB4CQ220J C 129,130,133,356 CKSSYB105K6R3 SC-07 http://www.xiaoyu163.com...
Page 219
D 7101 D3SBA20(B) u163 C 912,921,1168-1175 CKSSYB471K50 C 934,935,937,938 CKSSYB103K16 MISCELLANEOUS H 7101,7102 FUSE CLIP AKR7001 C 939 CCSSCH180J50 7061 JUMPER WIRE D20PDY0415E C 940 CCSSCH150J50 KN 7001-7006 WRAPPING TERMINAL VNF1084 C 946 CSZS330M6R3 CN 7001 7P PLUG XKP3063 SC-07 http://www.xiaoyu163.com...
Page 223
CN 4300,4600,4700 5P PLUG XKP3062 R 4524,4624,4724 RS1/16S2702F R 4526,4527,4626,4627 RS1/16S1501F CN 4900 4P-TOP POST(VH) B4P-VH R 4528,4628,4728 RS1/10S2702F CN 4901 PLUG(2P) KM200NA2 R 4529,4629,4729 RS1/8SQ1R0J CN 4902 PLUG(4P) KM200NA4 CN 4903 PLUG(6P) KM200NA6 R 4530,4630,4730 RS1/8SQ4702F SC-07 http://www.xiaoyu163.com...
Page 224
CKSRYB105K10 C 4534,4634,4734 ACG7063 C 4116,4151,4216,4251 CKSRYB105K16 u163 C 4535-4538,4635-4638 ACG7065 C 4119,4219,4319,4419 CKSQYB474K16 C 4541,4542,4641,4642 CCG1245 C 4122,4128,4222,4228 ACG7073 C 4543-4546,4643-4646 CCG1248 C 4123,4223,4323,4423 ACG7066 C 4547,4548,4615,4618 CKSRYB105K10 C 4124,4224,4324,4424 ACG7078 C 4549,4550,4649,4650 ACH7304 C 4125,4225,4325,4425 ACG7071 SC-07 http://www.xiaoyu163.com...
Page 225
P 7521,7522 PROTECTOR(1A) AEK7009 IC 8711 NJM78M56FA Q 8712 RT1N431M RESISTORS D 8703,8704,8719 1SS352 u163 D 8711 S1WB(A)60SD R 7621 RS1/16S473J D 8717 1SS357 Other Resistors RD1/4MUF###J D 8718 UDZS5R1(B) CAPACITORS C 7500,7520,7600,7634 CFTLA394J50 MISCELLANEOUS C 7501 CEAT332M25 SC-07 http://www.xiaoyu163.com...
Page 226
CN 7303 4P-TOP POST(VH) B4P-VH CN 7306 PLUG(4P) KM200NA4 RESISTORS u163 CN 7308 CONNECTOR B3P-VH R 7211,7213 RD1/4MUF102J JH 7300 PCB BINDER VEF1040 R 7241 RS1/4S152J R 7255,7256 RS1/10S0R0J P 7300,7301 PROTECTOR(500MA) AEK7005 Other Resistors RS1/16S###J RESISTORS CAPACITORS SC-07 http://www.xiaoyu163.com...
Page 227
RESISTORS R 3901 RN1/16SE1001D R 3902 RN1/16SE3301D Other Resistors RS1/16S###J CAPACITORS C 3901 CEHAZL471M25 C 3902 CKSYB105K25 C 3903 CKSRYB104K25 C 3905 CEHAZL221M10 C 3906,3910 CCSRCH102J50 C 3911 CFTLA394J50 u163 HDMI RECT ASSY SEMICONDUCTORS D 8801 D5SBA20(B) MISCELLANEOUS SC-07 http://www.xiaoyu163.com...