Section Xii: Start Up Sheet - York 41HP AHR18B Installation Manual

661693-UIM-E-1212

SECTION XII: START UP SHEET

Print Form
Start-Up Date
Owner Information
Name
City
Equipment Data Equipment Data
Unit Model #
General Information
New Construction
Retrofit
Unit Location and Connections
Unit is level
Condensate drain properly connected per the installation instructions
Filters
Filters installed
Number of filters
Electrical Connections & Inspection
208 volts AC
Inspect wires and electrical connections
Line Voltage Measured (Volts AC)
Thermostat wiring is complete
Air Flow Setup
Blower Type
&
Set-Up
Supply static (inches of water column)
Return static (inches of water column)
Total external static pressure
Other Jumpers
(Check all that apply)
HUM STAT
YES
16
Residential Air Handler
with Electric Heat Start-Up Sheet
Proper start-up is critical to customer comfort and equipment longevity
Company Name
Address
State or Province
Unit Serial #
(Check all that apply)
Up flow
Down flow
(Check all that apply)
Duct connections are complete:
Filter size
(Complete all that apply)
230 volt AC
Transformer wired properly for primary supply voltage
Low voltage value between "R" and "C" at control board (Volts AC)
Thermostat cycle rate or heat anticipator adjusted to Installation Manual specifications
COOL
ADJUST
ECM
DELAY
HEAT
X-13 1
Low
PSC
Supply air dry bulb temperature
Return air dry bulb temperature
Temperature drop
NO AC/HP
Start-Up Technician
Supply
Condensate trap has been primed with water
A B
A B
A B
A B
2 3
Medium Low Medium
AC HP CONT FAN
Reset Form
Daytime Phone
Zip or Postal Code
Horizontal Left
Horizontal Right
Return
Ground connected
C
C
C
C
4
Medium High
Outside air dry bulb temperature
Return air wet bulb temperature
Supply air wet bulb temperature
L M
Continued on next Page
Johnson Controls Unitary Products
D
D
D
D
5
High
H