Maintenance Instructions; Moving And Storage Instructions; Replacement Parts - Schumacher Electric DSR104 Owner's Manual

IMPORTANT:
• Never connect the booster to a battery or starter which is in short-circuit. The internal fuse will blow.
• Make sure the connectors are connected correctly.
• Never disconnect the booster while engine running when there is no battery in the vehicle or when the
vehicle's battery is at 0 volt. This may damage the alternator.
10. After the engine starts, disconnect the output voltage selector. Then, disconnect the auxiliary
DC cable from the vehicle and then the jump starter. Insert the cover into the auxiliary DC cable
connection on the jump starter.
11. Immediately recharge the booster.
9.

MAINTENANCE INSTRUCTIONS

After use and before performing maintenance, unplug and disconnect the booster.
9.1
Use a dry cloth to wipe all battery corrosion and other dirt or oil from the battery clips, cords, and the
9.2
booster's case.
Ensure that all of the booster's components are in place and in good working condition, including the
9.3
plastic boots on the battery clips.
All servicing should be performed by qualified service personnel.
9.4

10. MOVING AND STORAGE INSTRUCTIONS

IMPORTANT:
10.1
• CHARGE IMMEDIATELY AFTER PURCHASE
• KEEP FULLY CHARGED
The internal battery will gradually self-discharge (lose power) over time, especially in warm environments.
Leaving the battery in a discharged state may result in permanent battery damage.
Store inside, in a cool, dry place. The ideal storage temperature is between 50°-77°F (0°-25°C).
10.2
Clamps must be stored on their support posts, to make sure they do not come to contact with any
10.3
metallic surface.
If the booster is moved around the shop or transported to another location, take care to avoid/prevent
10.4
damage to the cords, clips and the unit. Failure to do so could result in personal injury or property damage.
IMPORTANT: Do not use and/or store the booster in or on any area or surface where damage could
occur if the internal battery should unexpectedly leak acid.

11. REPLACEMENT PARTS

Booster
Meter .............................................................................................................................. 5399200032Z
Push button .................................................................................................................... 0499000177Z
Internal battery (12V, 50Ah) ........................................................................................... 5799000043Z
Battery clamps ............................................................................................................... 2299002913Z
Fuse (AMG heavy-duty, 500A) ...................................................................................... 3999002114Z
Wheel (front) .................................................................................................................. 4999001284Z
Wheel (side) ................................................................................................................... 4999001285Z
Charger
Charger .......................................................................................................................... 2299002873Z
Plug kit. .......................................................................................................................... 2299002914Z
• 11 •