Page 1
Kenwood. Disclaimer While every precaution has been taken in the preparation of this manual, Kenwood assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Kenwood reserves...
TK-3170/3173 GENERAL / SYSTEM SET-UP INTRODUCTION PERSONAL SAFETY SCOPE OF THIS MANUAL The following precautions are recommended for personal safety: This manual is intended for use by experienced techni- • DO NOT transmit until all RF connectors are verified se- cians familiar with similar types of commercial grade commu- cure and any open connectors are properly terminated.
TK-3170/3173 PARTS LIST ✽ New Parts. indicates safety critical components. L : Scandinavia K : USA P : Canada Parts without Parts No. are not supplied. Y : PX (Far East, Hawaii) T : England E : Europe Les articles non mentionnes dans le Parts No. ne sont pas fournis. Y : AAFES (Europe) X : Australia M : Other Areas...
Page 5
TK-3170/3173 PARTS LIST TX-RX UNIT (X57-7010-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation CK73HB1H681K CHIP C 680PF C121 CK73HB1A393K CHIP C 0.039UF C43,44 CK73HB1C103K CHIP C 0.010UF C122 CK73HB1H471K CHIP C 470PF CS77AA0J220M...
Page 6
TK-3170/3173 PARTS LIST TX-RX UNIT (X57-7010-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation C502 CC73HCH1H470J CHIP C 47PF C559 CC73HCH1H090B CHIP C 9.0PF C503 CC73HCH1H101J CHIP C 100PF C560 CC73HCH1H101J CHIP C 100PF...
Page 7
TK-3170/3173 PARTS LIST TX-RX UNIT (X57-7010-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation C646 CK73HB1H471K CHIP C 470PF C720 CK73HB1C103K CHIP C 0.010UF C648 CK73HB1H471K CHIP C 470PF C721 CK73HB1H471K CHIP C 470PF...
Page 8
TK-3170/3173 PARTS LIST TX-RX UNIT (X57-7010-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation ✽ C781 CK73HB1H471K CHIP C 470PF L512 L41-2275-43 SMALL FIXED INDUCTOR (22NH) K3,K6,M3 C782 CC73HCH1H220J CHIP C 22PF K3,K6,M3 L513...
Page 9
TK-3170/3173 PARTS LIST TX-RX UNIT (X57-7010-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation CP16 RK74HB1J102J CHIP-COM 1.0K 1/16W RK73GB2A391J CHIP R 1/10W K4,K6,M CP18 RK74HB1J102J CHIP-COM 1.0K 1/16W RK73GB2A391J CHIP R 1/10W M3,B...
Page 10
TK-3170/3173 PARTS LIST TX-RX UNIT (X57-7010-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation R158 RK73HB1J334J CHIP R 330K 1/16W R242 RK73HB1J104J CHIP R 100K 1/16W R159 RK73HB1J474J CHIP R 470K 1/16W R243...
Page 11
TK-3170/3173 PARTS LIST TX-RX UNIT (X57-7010-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation R548 RK73HB1J000J CHIP R 1/16W R717 RK73HB1J272J CHIP R 2.7K 1/16W R550 RK73GB2A000J CHIP R 1/10W R718 RK73HB1J100J CHIP R...
Page 12
TK-3170/3173 PARTS LIST TX-RX UNIT (X57-7010-XX) Desti- Desti- Ref. No. Address Parts No. Description Ref. No. Address Parts No. Description parts nation parts nation D517 MA2S077-F DIODE Q506,507 2SC5488 TRANSISTOR D601 UDZS4.7B ZENER DIODE Q601 2SC5488 TRANSISTOR D604-608 HVC131 DIODE Q602 2SK3077F ✽...
TK-3170/3173 EXPLODED VIEW 701x2 RF UNT TX-RX unit (D/4) SHIELDING PLATE TX-RX unit (A/4) TX-RX unit (B/4) TX-RX unit (C/4) 707 : M : N09-2438-05 : N14-0805-04 : N14-0833-04 D M2.6 x 10 : N30-2610-48 705 : K M3 x 6 BLK : N30-3006-43 M2 x 3 : N79-2030-48 G M2 x 5...
TK-3170/3173 ADJUSTMENT ■ Frequency and Signaling Controls The set has been adjusted for the frequencies shown in Selector Selector the following table. When required, readjust them following Volume Volume the adjustment procedure to obtain the frequencies you want in actual operation. •...
Page 16
TK-3170/3173 ADJUSTMENT ■ 3 or 5 reference level adjustments frequency Panel Tuning Mode ■ Preparations for tuning the transceiver Tuning TK-3170/3173 K,K4 TK-3170 K3,K6,M3 Tk-3170 M Before attempting to tune the transceiver, connect the point RX (MHz) TX (MHz) RX (MHz) TX (MHz) RX (MHz) TX (MHz) unit to a suitable power supply.
Page 17
TK-3170/3173 ADJUSTMENT ■ Flow chart 3 reference level Frequency adjustments 5 reference level High power adjustments 3 reference level Low power adjustments Center 3 reference level Balance Narrow adjustments [Side2] [Side2] Max deviation Narrow Max deviation Wide High 3 reference level adjustments 3 reference level adjustments exit...
Page 18
In order to turn the volume nut and the channel selector not performed. nut, use a recommendation tool. KENWOOD part No. : W05-1123-00 Note : When using the battery jig, you must measure the voltage at the terminals of the battery jig. Otherwise, a slight...
Page 19
TK-3170/3173 ADJUSTMENT Common Section Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 1. Setting 1) BATT terminal voltage : 7.5V 2) SSG standard modulation [Wide] MOD : 1kHz, DEV : 3kHz [Narrow] MOD : 1kHz, DEV : 1.5kHz ±...
Page 20
TK-3170/3173 ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 6. DQT balance 1) Adj item : [BAL_ _] Panel Panel Selector Make the demodu- adjust Adjust : [✳✳✳.] knob lation waves into These 2 peaks to Deviation meter filter Deviation SP/MIC...
Page 21
TK-3170/3173 ADJUSTMENT Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment ± 0.04kHz 13. LTR 1) Adj item : [LTR_ _] Power meter Panel Panel Selector 0.75kHz deviation Adjust : [✳✳✳.] knob adjust Deviation meter filter Deviation SP/MIC •...
Page 22
TK-3170/3173 ADJUSTMENT Receiver Section Measurement Adjustment Item Condition Specifications/Remarks Test- Unit Terminal Unit Parts Method equipment 1. Sensitivity 1) Adj item : [SENS_] Panel Panel Selector Adjust for Rotate the selector knob and adjust Adjust : [✳✳✳] knob RSSI MAX increase the adjustment value 2) Adj item : [S.ENS_] →...
TK-3170/3173 KSC-30 (CHARGER) External View Operating Flow Chart Power ON Initialization Insert battery Does S terminal connect? Vs : High Battery is not (Li-ion) Distinguish the correspond kinds of battery LED OFF Vs : Low Parts List (Ni-Cd or Ni-MH) Desti- Ref.
13, Boulevard Ney, 75018 Paris, France Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road, Kwai Fong, N.T., Hong Kong KENWOOD House, Dwight Road, Watford, Herts., WD18 9EB United Kingdom 1 Ang Mo Kio Street 63, Singapore 569110...