Page 2
的信息而导致的损害负责。Kenwood 公司保留出于改进的需要 rors or omissions. Neither is any liability assumed for dam- 而随时对文中的产品信息做出更改的权利。 ages resulting from the use of the information contained herein. Kenwood reserves the right to make changes to any products herein at any time for improvement purposes.
TK-3178 概述 GENERAL / 引言 INTRODUCTION 本手册的范围 SCOPE OF THIS MANUAL 本手册是提供给熟悉通信专业并且具有维修经验的技术人 This manual is intended for use by experienced tech ni - 员使用的。它包括了维修该设备所需要的全部资料和现行出 cians familiar with similar types of commercial grade com - 版日期。在出版后可能发生变动,如果需要,可以参照《维 mu ni ca tions equipment. It contains all required service 修通报》或《手册修订本》进行补充。...
Type 频率范围 (MHz) 射频功率 类型 Choose the type of transceiver TX/RX 350~390 TK-3178(L) C6 选择手持对讲机的类型 A personal computer, programming interface (KPG-22/22A), and Transceiver programming programming software (KPG-127D) are required for programming. 手持对讲机编程 (The frequency, TX power HI/LOW, and signaling data are programmed for the transceiver.)
Page 5
TK-3178 模式组合 REALIGNMENT / 模 式 功 能 Mode Function 手持对讲机信息模 用于确认 MPT ESN、固件版本和手持对讲 Transceiver infor- Used to confi rm the MPT ESN, fi rmware ver- 式 机序列号。 mation mode sion and transceiver serial number. 固件版本信息 用于确认内部固件版本。 Firmware version Used to confi rm the internal fi rmware ver- information sion.
Page 6
TK-3178 模式组合 REALIGNMENT / 注意 : Note: • 个人电脑保存的数据写入 EEPROM 时,必须与机型和类型相 • The data stored in the personal computer must match 符。 Model Name and Model Type when it is written into EE- • 请勿在数据发送或接收期间按 [PTT] 键。 PROM. • Do not press the [PTT] key during data transmission or reception.
Page 7
TK-3178 模式组合 REALIGNMENT / 6. 固件编程模式 6. Firmware Programming Mode 6-1. 前言 6-1. Preface 闪存被安装在手持对讲机上。当将来出现新功能时,允许 Flash memory is mounted on the transceiver. This allows 手持对讲机升级。( 要了解如何获得固件的详细情况,请与供 the transceiver to be upgraded when new features are re- 应商联系。) leased in the future. (For details on how to obtain the fi rm- ware, contact Customer Service.)
Page 8
TK-3178 模式组合 REALIGNMENT / 7. 手持对讲机信息模式 7. Transceiver Information Mode 该功能用于确认 MPT ESN、固件版本和手持对讲机序列号。 Use this function to confi rm the MPT ESN, the fi rmware version and the transceiver serial number. 1. 打开电源时按住 [B] 键约 2 秒钟。 2. 用 [ 选择器 ] 选择确认项目。...
TK-3178 维修拆卸 DISASSEMBLY FOR REPAIR / 1. Removing the FPC (J87-0033-05) 2. Separating the Speaker Holder (J19- 1) Remove the solder from the TX-RX unit using a solder 5481-03) from the Control Unit iron ( q ). 1) As in shown in the fi gure below, the speaker holder is at- 2) Peel the double-sided tape ( w ).
Page 10
TK-3178 维修拆卸 DISASSEMBLY FOR REPAIR / 3. 如何组装天线连接器 (E04-0467-05) 和它 3. How to Assemble the Antenna Connec- 的端子 (E23-1188-04) tor (E04-0467-05) and its Terminal (E23- 天线连接器和它的端子是作为单独的零件提供的。 1188-04) 更换天线连接器和 / 或端子时,应在更换前组装零件。 The antenna connector and its terminal are supplied as separate parts.
Page 11
TK-3178 维修拆卸 DISASSEMBLY FOR REPAIR / 4) Lift the speaker holder ( r ), then fl ip it over to the left ( t ). 3) Match the speaker and microphone lead wires with the color-code of silkscreen of the printed circuit board ( e ), 5) Insert the tabs of the speaker holder into the slots of the then solder them in place.
TK-3178 电路说明 CIRCUIT DESCRIPTION / 1. 频率构成 1. Frequency Confi guration 接收部采用二次变频超外差方式。第一中频为 49.95M H z, The receiver utilizes double conversion. The first IF is 第二中频为 450kHz。第一本振频率信号由锁相环电路提供。 49.95MHz and the second IF is 450kHz. The fi rst local oscil- 发射部由锁相环电路直接产生所需要的频率。图 1 显示各...
Page 13
TK-3178 电路说明 CIRCUIT DESCRIPTION / 2-3. 中频放大电路 2-3. IF Amplifi er Circuit 第一中频信号通过晶体滤波器 ( X F701) 消除相邻信道的信 The fi rst IF signal is passed through a four-pole monolithic 号。经滤波的第一中频信号被第一中频放大器 ( Q703) 放大并 crystal fi lter (XF701) to remove the adjacent channel signal.
Page 14
TK-3178 电路说明 CIRCUIT DESCRIPTION / 2-6. 静噪电路 2-6. Squelch Circuit FM IC(IC701) 输出的 AF 信号的一部分再进入 IC,噪声成 Part of the AF signal from the IC enters the FM IC (IC701) 份通过滤波器和放大器进行放大和修正,生成与噪声电平相 again, and the noise component is amplifi ed and rectifi ed by 应的...
Page 15
TK-3178 电路说明 CIRCUIT DESCRIPTION / 3-2. 驱动器和终端放大器电路 3-2. Drive and Final Amplifi er Circuit 来自于 T/R 开关 (D516 ON) 的信号被预驱动放大器 (Q602) The signal from the T/R switch (D516 is on) is amplifi ed 和驱动放大器 (Q603) 放大到 50mW。 by the pre-drive (Q602) and drive amplifi er (Q603) to 50mW.
Page 16
TK-3178 电路说明 CIRCUIT DESCRIPTION / I C4 的 R X 针 脚 在 接 收 模 式 时 为“ 低 ” 电 位, 使 Q503 和 The RX pin of IC4 goes “low” in receive mode causing Q504(2/2) 打 开。T X 针 脚 在 发 射 模 式 时 为“ 低 ” 电 位, 使...
Page 17
TK-3178 电路说明 CIRCUIT DESCRIPTION / 5-1. 频率偏移电路 5-1. Frequency Shift Circuit 微处理器 (IC7) 在 11.0592MHz 时钟下工作。此振荡器有可 The microprocessor (IC7) operates at a clock of 11.0592 以被拍频偏移开关 (Q17,Q18) 变换频率的电路。 MHz. This oscillator has a circuit that shifts the frequency by 如果“拍频偏移”被设定为 ON,可以避免产生拍频声音。...
Page 18
TK-3178 电路说明 CIRCUIT DESCRIPTION / 低 电 池 电 量 警 告 电 池 状 态 Low battery warning Battery status 电池电压低,但手持对讲机仍 The red LED blinks during the The battery voltage is low but 发射期间红色 LED 闪烁。 能使用。 transmission. the transceiver is still usable.
Page 19
TK-3178 电路说明 CIRCUIT DESCRIPTION / 5-6. LCD 5-6. LCD LCD 是用 TX-RX 单元 (B/4) 的连接口 (CN82) 的总线来控制 The LCD is controlled using the bus lines on the connec- 的。使用 VR1 补正 LCD 的对比度电压。 tor (CN82) of the TX-RX unit (B/4). It corrects the LCD con- trast voltage using VR1.
Page 20
TK-3178 电路说明 CIRCUIT DESCRIPTION / 6-2. 解码 6-2. Decode ■ QT/DQT ■ QT/DQT I F I C ( I C701) 的输出信号通过 I C11 送入微处理器 ( I C7)。 The output signal from IF IC (IC701) enters the micropro- I C7 确认 Q T 或 D Q T 是否与预设值匹配,并用 I C5 控制 A M1,...
Page 21
TK-3178 半导体数据 SENCONDUCTOR DATA / 微处理器 : 30875MHB069GP(TX-RX 单元 IC7) MCU: 30875MHB069GP (TX-RX unit IC7) 管脚号 端口名称 输入 / 输出 功 能 Pin No. Port Name Function SFTOE 输出 BU4094BCFV 输出启动 SFTOE BU4094 output enable SFTSTB 输出 BU4094 选通脉冲 SFTSTB BU4094 strobe 输出...
TK-3178 元件说明 COMPONENTS DESCRIPTION / TX-RX 单元 (X57-7013-06) TX-RX unit (X57-7013-06) 有关号码 零件名称 说 明 Ref. No. Part Name Description 电压检测器 /INT Voltage detector / INT 电压调节器 /5V Voltage regulator / 5V 电压检测器 / 复位 Voltage detector / RESET IC4,5 位移寄存器...
Page 25
TK-3178 元件说明 COMPONENTS DESCRIPTION / 有关号码 零件名称 说 明 Ref. No. Part Name Description 场效应管 AF 放大器直流电源开关 AF amplifi er DC supply switch Q25,26 场效应管 麦克风 ALC Q25,26 MIC ALC 晶体管 AF 静音控制开关 Transistor AF mute control switch 场效应管 AF 静音开关...
TK-3178 零件表 PARTS LIST / CAPACITORS 2 2 0 • Capacitor value CC45 Color* 010 = 1pF 0 = 22pF 1 = Type ... ceramic, electrolytic, etc. 4 = Voltage rating 100 = 10pF 2 = Shape ... round, square, etc.
Page 28
TK-3178 零件表 PARTS LIST / ✽ New Parts. indicates safety critical components. L : Scandinavia K : USA P : Canada Parts without Parts No. are not supplied. Y : PX (Far East, Hawaii) T : England E : Eu rope Les articles non mentionnes dans le Parts No.
Page 29
TK-3178 零件表 PARTS LIST / TX-RX UNIT (X57-7013-06) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation CS77AA0J150M CHIP TNTL 15UF 6.3WV C134 CK73HB1A473K CHIP C 0.047UF CK73HB1A104K CHIP C 0.10UF...
Page 30
TK-3178 零件表 PARTS LIST / TX-RX UNIT (X57-7013-06) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation C291 CK73HB1A104K CHIP C 0.10UF C583 CK73HB1A104K CHIP C 0.10UF C294-296 CK73HB1A104K CHIP C 0.10UF...
Page 31
TK-3178 零件表 PARTS LIST / TX-RX UNIT (X57-7013-06) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation C714 CC73HCH1H390J CHIP C 39PF C904 CK73HB1H471K CHIP C 470PF C715 CK73HB1H471K...
Page 32
TK-3178 零件表 PARTS LIST / TX-RX UNIT (X57-7013-06) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation L613 L41-8268-14 SMALL FIXED INDUCTOR (8.2NH) RK73HB1J103J CHIP R 1/16W L614 L41-2285-45...
Page 33
TK-3178 零件表 PARTS LIST / TX-RX UNIT (X57-7013-06) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation R135 RK73HB1J000J CHIP R 1/16W R215 RK73HB1J334J CHIP R 330K 1/16W R137...
Page 34
TK-3178 零件表 PARTS LIST / TX-RX UNIT (X57-7013-06) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation R507 RK73HB1J101J CHIP R 1/16W R634 RK73HB1J103J CHIP R 1/16W R508 RK73HB1J330J...
Page 35
TK-3178 零件表 PARTS LIST / TX-RX UNIT (X57-7013-06) Desti- Desti- Ref. No. Ad dress Parts No. Description Ref. No. Ad dress Parts No. Description parts nation parts nation S70-0424-05 TACT SWITCH Q17,18 2SC4919-S TRANSISTOR S70-0457-05 TACT SWITCH SSM3K15TE(F) S3,4 S70-0424-05...
TK-3178 ADJUSTMENT Controls “FNC” appears Selector Function Display Volume High power / Low power Low: icon appears Function off Compander on/off icon appears Beat shift on/off icon appears [Selector] Test frequency CH up/down - [Side1] Squelch level 0 icon appears...
Page 44
In adjustment mode, battery type detection is nut, use a recommendation tool. not performed. KENWOOD part No.: W05-1123-00 Note: When using the battery jig, you must measure the voltage at the terminals of the battery jig. Otherwise, a slight voltage drop may occur within the power cable, be- tween the power supply and the battery jig, especially while the transceiver transmits.
TK-3178 TERMINAL FUNCTION ■ CN18 and CN901 ■ CN82 CN18 CN901 Terminal Terminal Pin No. Terminal function Terminal function name name Pin No I/O Pin No. I/O LCD Driving voltage output LCD Driving voltage output Transmitter Power control voltage LCD Driving voltage output...
TK-3178 SPECIFICATIONS GENERAL Frequency range .........350~390MHz Channel spacing .........Wide : 25kHz Narrow : 12.5kHz Battery voltage ...........7.5V DC ±20% Battery life (5-5-90 duty cycle)/Approx. hours KNB-26N (2000mAh) .......12 KNB-35L (1950mAh) .......11 Operating temperature range .....–22°F~+140°F (–30°C~+60°C) Frequency stability ........±0.00025% (–22°F~+140°F) Antenna impedance ........50Ω...
Page 74
Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road, Bp 58416 Villepinte, 95944 Roissy Ch De Gaulle Cedex Kwai Fong, N.T., Hong Kong KENWOOD House, Dwight Road, Watford, Herts., 1 Ang Mo Kio Street 63, Singapore 569110 WD18 9EB United Kingdom...
Page 75
TK-3178 板 PC BOARD / PC TX-RX UNIT (X57-7013-06) (A/4) Component side view (J79-0286-09 A/4) Component side Ref. No. Address Layer 1 IC501 Layer 2 L619 IC601 Layer 3 IC701 Layer 4 Q501 Layer 5 D901 Q605 Layer 6 F901...
Page 76
TK-3178 板 PC BOARD / PC TX-RX UNIT (X57-7013-06) (A/4) Foil side view (J79-0286-09 A/4) Component side Ref. No. Address Ref. No. Address Layer 1 Q502 D513 Layer 2 Q503 D514 Layer 3 Q504 D515 Layer 4 Q505 D516 Layer 5...
Page 77
TK-3178 TK-3178 板 板 PC BOARD / PC PC BOARD / PC TX-RX UNIT (X57-7013-06) (C/4) Component side view Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Component side (J79-0286-09 C/4) IC17 Layer 1...
Page 78
TK-3178 TK-3178 板 板 PC BOARD / PC PC BOARD / PC TX-RX UNIT (X57-7013-06) (C/4) Foil side view Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Component side (J79-0286-09 C/4) IC25 Layer 1...