Table Of Contents - Hearth and Home Technologies Quadra-Fire CAB50-C Installation Manual

• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the appliance or to property.
Important Safety Information
1
A. Appliance Certification. . . . . . . . . . . . . . . . . . . . . . .
B. Appliance Emissions Certification . . . . . . . . . . . . . .
C. BTU & Efficiency Specifications . . . . . . . . . . . . . . .
D. Glass Specifications . . . . . . . . . . . . . . . . . . . . . . . .
E. Electrical Rating (on high) . . . . . . . . . . . . . . . . . . . .
F. Mobile Home Approved . . . . . . . . . . . . . . . . . . . . . .
G. Non-Combustible Materials. . . . . . . . . . . . . . . . . . .
H. Combustible Materials. . . . . . . . . . . . . . . . . . . . . . .
I. Sleeping Room . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
J. Stove Composition. . . . . . . . . . . . . . . . . . . . . . . . . .
K. California - Prop65 . . . . . . . . . . . . . . . . . . . . . . . . .
Getting Started
2
A. Design, Installation & Location Considerations . . . .
B. Thermostat Wall Control Location . . . . . . . . . . . . . .
C. Tools And Supplies Needed . . . . . . . . . . . . . . . . . .
D. Inspect Appliance and Components . . . . . . . . . . . .
E. Install Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dimensions and Clearances
3
A. Appliance Dimensions . . . . . . . . . . . . . . . . . . . . . . .
B. Clearances to Combustibles (UL and ULC) . . . . .
C. Hearth Pad Requirements. . . . . . . . . . . . . . . . . . .
D. Alcove . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vent Information
4
A. Venting Termination Minimum Requirements . . . .
B. Avoiding Smoke and Odors . . . . . . . . . . . . . . . . . .
C. Negative Pressure. . . . . . . . . . . . . . . . . . . . . . . . .
D. Draft . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
E. Minimum Vacuum Requirements. . . . . . . . . . . . . .
F. Chimney and Exhaust Connection. . . . . . . . . . . . .
G. Equivalent Feet of Pipe. . . . . . . . . . . . . . . . . . . . .
H. Pipe Selection Chart . . . . . . . . . . . . . . . . . . . . . . .
2

TABLE OF CONTENTS

.............3
....................................5
..............8
................................15
Quadra-Fire is a registered trademark of Hearth & Home Technologies.
Safety Alert Key:
Venting Systems
5
A. Through The Wall . . . . . . . . . . . . . . . . . . . . . . . . .
3
B. Vertical into Existing Class A Chimney . . . . . . . . .
3
C. Vertical - Interior - Typical Installation . . . . . . . . . .
3
D. Through The Wall & Vertical - External . . . . . . . . .
4
E. Masonry. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4
F. Alternate Masonry . . . . . . . . . . . . . . . . . . . . . . . . .
4
Appliance Set-Up
6
4
4
A. Outside Air Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4
B. Top Vent Adapter Installation . . . . . . . . . . . . . . . . .
4 C. Rear Vent Adapter Installations. . . . . . . . . . . . . . .
4
D. Thermostat Installation . . . . . . . . . . . . . . . . . . . . .
Mobile Home Installation
7
Reference Materials
5
8
6
A. Service & Maintenance Log . . . . . . . . . . . . . . . . .
6
B. Accessory List . . . . . . . . . . . . . . . . . . . . . . . . . . . .
6
7
8
12
13
14
15
16
17
17
17
17
18
18
7074-803B
...............................19
..............................22
..................25
..........................26
March 17, 2020
19
20
20
20
21
21
22
23
23
24
26
30