Safety And Instruction Decals; Assembly; Unpacking The Lawn Mower; Installing The Handle - Toro Super Recycler 20040 Operator's Manual

Safety and Instruction Decals

Safety decals and instructions are easily visible to the operator and are located near any
area of potential danger. Replace any decal that is damaged or lost.
On Mower Housing
(Part No. 43-8480)

Assembly

Note: Determine the left and right sides of the lawn
mower by standing in the operating position.

Unpacking the Lawn Mower

WARNING
POTENTIAL HAZARD
Folding or unfolding the handle improperly can
pinch, stretch, or damage one or more of the
cables.
WHAT CAN HAPPEN
Any pinched, stretched, or damaged cable may
cause an operational failure that results in an
unsafe operating condition.
HOW TO AVOID THE HAZARD
Do not pinch, stretch, or damage the cables.
Handle the cables with care when folding or
unfolding the handle.
Do not use the lawn mower if one or more of
the cables are pinched, stretched, or damaged.
Contact your Authorized Service Dealer.
1. Open the box from the top.
2. Remove the fillers from the box, allowing the upper
handle section to rest on the top of the lawn mower.
3. Remove the lawn mower from the box.
4. Lay the upper handle section on the ground behind the
lawn mower with the handle label facing up and the
control cables routed between the handle mounting
brackets.
On Mower Housing
(Part No. 93-0248)

Installing the Handle

1. Remove the four handle bolts and knobs from the
lower handle section (two bolts have a flat cap and the
other two have a contoured cap to fit the handle as
shown in Figure 2).
1
1. Lower handle
2. Support bracket
POTENTIAL HAZARD
Folding or unfolding the handle improperly can
pinch, stretch, or damage one or more of the
cables.
WHAT CAN HAPPEN
Any pinched, stretched, or damaged cable may
cause an operational failure that results in an
unsafe operating condition.
HOW TO AVOID THE HAZARD
Do not pinch, stretch, or damage the cables.
Handle the cables with care when folding or
unfolding the handle.
Do not use the lawn mower if one or more of
the cables are pinched, stretched, or damaged.
Contact your Authorized Service Dealer.
6
On Mower Housing
(Part No. 99-6018)
3
4
2
Figure 2
3. Knob
4. Flat handle bolt
WARNING
m–4272