Table of Contents
Advertisement
Quick Links
Installation and Operating
Instructions for Vented Gas Log
Sets - Remote Hearth Kits
Models:
SA18SHKRN, SA18SHKRP,
SA24SKHRN, SA24SHKRP,
SA30SKHRN, SA30SKHRP
Decorative Gas Appliance For Installation In Solid Fuel Burning Fireplaces
If the information in this manual is not followed exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.
—
Do not store or use gasoline or other flam-
mable vapors and liquids in the vicinity of
this or any other appliance.
—
WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance.
•
Do not touch any electrical switch; do not
use any phone in your building.
•
Immediately call your gas supplier from a
neighbor's phone. Follow the gas suppli-
er's instructions.
•
If you cannot reach your gas supplier, call
the fire department.
Please record your gas log's model number for
future reference here:
Note: This model # can be found on the box or
the label attached to the back of the burner pan.
When used without fresh air, gas logs may give off carbon monoxide, an odorless, poisonous gas. Some
people such as pregnant women, people with heart or lung disease, and persons at high altitudes are
more affected by carbon monoxide than others.
Early signs of carbon monoxide poisoning resemble the flu: Headache, dizziness, and/or nausea. If
you have these signs, the gas logs may not be installed or working properly. Get fresh air at once!
Have the gas log set and chimney serviced before using it again.
WARNING
Carbon Monoxide Poisoning May Lead To Death
CFM Corporation
410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777
www.majesticproducts.com • www.vermontcastings.com
Certified to ANSI Z21.60
and CGA 2.26 Standards
ATTENTION
Installation, service, and repair of this ap-
pliance must be performed by a qualified
installer, service agency, company or gas
supplier experienced with this type of gas
appliance.
INSTALLER:
Read these instructions completely and care-
fully prior to beginning installation. After instal-
lation, leave these instructions with the owner.
OWNER:
Read these instructions and follow the warn-
ings. Save this manual for future reference.
Check local codes before installing this log set.
In some areas of the country, gas log sets are
restricted.
The installation and the provisions for combus-
tion and ventilation air must conform with the
National Fuel Gas Code, ANSI Z223.1/NFPA 54.
C E RT I F I E D
3311857 12/05 Rev. 5
Advertisement
Table of Contents
Related Manuals for Vermont Castings SA18SHKRN
Summary of Contents for Vermont Castings SA18SHKRN
- Page 1 Installation and Operating Instructions for Vented Gas Log Sets - Remote Hearth Kits Models: SA18SHKRN, SA18SHKRP, SA24SKHRN, SA24SHKRP, SA30SKHRN, SA30SKHRP Decorative Gas Appliance For Installation In Solid Fuel Burning Fireplaces If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life.
-
Page 2: Technical Information
Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read these directions thoroughly before installation. For assistance or additional information, consult your gas log dealer, qualified installer, service agency or gas supplier. WARNING Do not use this appliance or any part that has been under water. -
Page 3: Fireplace Specifications
A. The appliance should be inspected before use and at least annually by a professional service person. More frequent cleaning may be required due to excessive lint from etc. It is imperative that control compartments, burners and circulating air passageways of the appli- ance be kept clean. - Page 4 Pre-Installation Checklist Is the gas supply inlet pressure correct? NG: Min. 5.5” w.c./Max. 14.0” w.c. LP: Min. 11” w.c./Max. 14.0” w.c. Does the firebox meet the minimum size dimensions below? Is your fireplace plumbed with gas on the right side (facing) of the fireplace? If not, refer to ee Page 5 Is the gas supply line sized properly (Minimum 1/2”...
-
Page 5: Tools Required
8” adjustable crescent wrench ; Pipe thread sealant compound or teflon tape ; 12” pipe wrench or channel lock pliers. Gas Plumbed on Left Hand Side of Fireplace NOTE: Your gas log set is assembled at the factory to be installed in a fireplace plumbed with the gas on the right side (facing). - Page 6 The Damper Clamp provided keeps your damper from accidentally closing during operation of your set. This Damper Clamp must be installed onto your Damper at all times. NOTE: The damper clamp is designed to hold the damper plate open 3 inches. However, the damper must be fully open when the log set is in op- eration.
- Page 7 1. Open the bag of Vermiculite and spread it evenly across the Burner Pan, to the top, as shown in Figure 5. You may overflow the front and sides of the pan to cover the entire pan and connecting hardware. 2.
-
Page 8: Remote Installation
Create a mixture of equal parts soap and water. Apply to all the joints of the pipe fittings from the gas sup- ply pipe to the burner. Turn on the gas supply valve for no longer than 3-5 seconds. If bubbles appear in the soap solution applied to the joints, there is a leak. - Page 9 Optional Fettel Cast Front Grate Attach the fettel to the front of the grate as shown in Figure 9. Grate Clip Fettel Cast Front Grate Figure 9 Log Placement LG204 1. Place the larger bottom logs onto the grate, Grate Enhance kit leaving as much space between them as pos- 11/01 sible.
- Page 10 18” Standard Split Log Set LG333 24” Standard Split Log Set LG333 18" Standard split log set 4/04 djt 30” Standard Split Log Set LG334 24" Standard split log set 4/04 djt LG335 30" Standard split log set 4/04 djt 18”...
-
Page 11: Lighting The Pilot
WARNING: If you do not follow these directions exactly, a fire or explosion may result causing property damage, personal injury, or loss of life. • Do not try to light any appliance • Do not touch any electrical switch, do not use any phone in your build- •... -
Page 12: Match Lighting
1. Follow the “Lighting the Pilot” instructions steps 1 thru 4 above. 2. Push the control dial in all the way and hold. Immediately light the pilot with a match. Continue to hold the pilot for about one minute after the pilot is lit. Pilot should remain lit. If the pilot goes out, repeat Lighting the Pilot steps 1 thru 4 above and this step 2. - Page 13 Burner Flame Is Too High (8-12” Above Top Logs) Or Too Low: Incorrect gas supply, pressure, or burner orifice used: Make sure the gas pressure coming into the fireplace falls between the minimum and maximum pressures allowed with this gas set (refer to tables on Page 4).
- Page 14 Optional Cast Fettel 16a,b CFM Corporation reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. SA18/24/30SHK Series Vented Gas Logs - Remote Hearth Kit Ref. Description Log Grate Burner Assembly Cast Front Grate w/Clips Grate Clip - Fettel...
- Page 15 SA18/24/30SHK Series Vented Gas Logs - Remote Hearth Kit Ref. Description Gas Supply Fitting Flexible Gas Connector Pilot Bracket 16a. Natural Gas Pilot Assembly 16b. Propane Gas Pilot Assembly Pilot Mounting Screws 18a. Control Valve - NG 18b. Gas Valve - Propane On/Off/RS Switch Gas Supply Tube 21a.
- Page 16 CFM Corporation reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. SA18/24/30SHK Series Vented Gas Logs - Remote Hearth Kit 2g (2) Log parts 4/04 6e (2) 6f (2) 9e (2) 3311857...
- Page 17 SA18/24/30SHK Series Vented Gas Logs - Remote Hearth Kit Ref. Description 24” Split right Front 24” Split Left Front Top Log #3 (2 per set) Top Log (2 per set) 30” Standard Split Log Set 18”/24”/30” Back Log 18”/24”/30” Cross Log 30”...
- Page 19 LIMITED 2/20 YEAR WARRANTY For VERMONT CASTINGS Decorative Gas Appliances CFM Corporation extends the warranties specified in paragraphs A and B below with respect to its Vermont Castings Decorative Gas Appliances (the “Gas Appliance”), including CFM Corporation supplied accessories and components referred to in those paragraphs, subject to the following conditions and limitations: (1) These warranties are extended only to the Gas Ap-...
- Page 20 CFM Corporation 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www.majesticproducts.com • www.vermontcastings.com...