Service Procedures; Remote Control Unit; Battery Replacement Tips; Battery Replacement - Meridian Seed Express 840 Operator's Manual

10. SERVICE PROCEDURES

10.1 REMOTE CONTROL UNIT

The remote transmitter unit is powered by two
AA batteries. The display window on the remote
transmitter indicates the remaining battery life.
When batteries are new, the display indicates
100% power. As the remote transmitter is used,
the power decreases. When the battery power
becomes low, the batteries should be replaced
immediately, or discontinue the use of the remote
transmitter.

10.1.1 Battery Replacement Tips

• Check the batteries at least every six months (for
low Voltage, leakage, etc.).
• Always use the correct size and type of battery.
Replace old batteries with new 1.5 Volt AA,
alkaline batteries.
• Always replace both batteries at the same time.
• Do not mix types, brands, or ages of replacement
batteries.
• Do not install the batteries backwards. Make sure
you insert the batteries with the + (plus) and –
(minus) terminals aligned correctly.
• Remove the batteries from the controller if not
expected to be in use for several months.
• Do not attempt to recharge a battery unless it is
specifi cally marked "rechargeable."
• Dispose of old batteries properly.
44

10.1.2 Battery Replacement

1. Remove the four Phillips head screws from the
cover on the bottom of the unit.
2. Replace the batteries, making sure they are
correctly positioned.
3. Replace the cover.
10.1.3 Battery Replacement - Roll-Up
Tarp Remote Control Unit
1. The roll-up tarp remote control unit is powered
by two AAA batteries. When the BATT
indicator light turns ON, the batteries should
be replaced immediately, or discontinue the
use of the remote transmitter.
2. Remove the cover on the back of the unit.
3. Replace the batteries, making sure they are
correctly positioned.
4. Replace the cover.