Add Fuel - Champion 100326-1 Operator's Manual

100326-1 - 25 TON FULL BEAM LOg SPLiTTER

Once oil has been added, a visual check should show oil about
1-2 threads from running out of the fill hole.
If using the dipstick to check oil level, DO NOT screw in the
dipstick while checking.

Check oil often during the break-in period. Refer to the
Maintenance section for recommended service intervals.

The engine is equipped with a low oil shut-off and will stop
when the oil level in the crankcase falls below the threshold
level.

We consider the first 5 hours of run time to be the break-
in period for the engine. During the break in period we
recommend using standard automotive non-synthetic blended
oils. After the break in period synthetic lubricant can be used
but is not required. Avoid bogging or lugging the engine down
and avoid prolonged running at constant RPM. After the 5 hour
break-in period, change the oil. Using synthetic lubricants does
not decrease the recommended oil change interval.

Weather will affect engine oil and engine performance. Change
the type of engine oil used based on weather conditions to suit
the engine needs.

Synthetic oil may be used after the 5 hour initial break-in
period. Using synthetic oil does not increase the recommended
oil change interval. Full synthetic 5W-30 oil will aid in starting
in cold ambient <5º C (41º F)

Add Fuel

1. Use clean, fresh, regular unleaded gasoline with a minimum
octane rating of 85 and an ethanol content of less than 10%
by volume. y b c
2. DO NOT mix oil with gasoline.
3. Remove the gasoline cap.
NOTiCE
NOTiCE
CAUTiON
NOTiCE
NOTiCE
NOTiCE
4. Slowly add gasoline to the tank. DO NOT OVERFILL. Gasoline
can expand after filling. A minimum of ¼ in. (6.4 mm) of
space left in the tank is required for gasoline expansion,
although more than ¼ in. (6.4 mm) is recommended. Gasoline
can be forced out of the tank as a result of expansion if
overfilled, and can affect the stable running condition of the
log splitter.
5. The approximate fuel level is shown on the fuel gauge on top
of the fuel tank.
Use regular unleaded gasoline with a minimum octane rating
of 85 and an ethanol content of less than 10% by volume.
DO NOT light cigarettes or smoke when filling the tank.
DO NOT mix oil and gasoline.
Fill tank to approximately ¼ in. (6.4 mm) below the top of the
tank to allow for gasoline expansion.
DO NOT pump gasoline directly into the log splitter at the
pump. Use an approved container to transfer the gasoline to
the log splitter.
DO NOT fill tank indoors.
DO NOT fill tank when the engine is running or hot.
DO NOT overfill the tank.
19
ASSEMBLY
CAUTiON
