Perkins 4006-23 Operation And Maintenance Manual page 85

SEBU9077-01
F
Fan Drive Pulley - Check (4008-30 Engine
Only) .............................................................. 68
Features and Controls..................................... 29
Fire Prevention and Explosion Prevention...... 13
Ether ............................................................ 14
Fire Extinguisher.......................................... 14
Lines, Tubes, and Hoses ............................. 15
Fluid Recommendations (Engine Oil
Specification) ................................................. 47
Engine Oil .................................................... 47
General Lubricant Information..................... 47
Fluid Recommendations (Fuel
Specifications) ............................................... 39
Contamination Control Recommendations for
Fuels .......................................................... 46
Diesel Fuel Characteristics.......................... 41
Diesel Fuel Requirements ........................... 40
General Information..................................... 39
Fluid Recommendations (General Coolant
Information) ................................................... 35
ELC Cooling System Maintenance.............. 37
General Coolant Information ....................... 35
Foreword ........................................................... 4
California Proposition 65 Warning ................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 4
Operation ....................................................... 4
Overhaul ........................................................ 4
Safety............................................................. 4
Fuel Conservation Practices ........................... 33
Fuel Injector - Inspect/Adjust........................... 69
Fuel System - Prime ........................................ 69
Fuel System Filter - Replace ........................... 70
Fuel Filter with Water Separator.................. 70
Fuel System Primary Filter/Water
Separator - Drain ........................................... 71
Fuel Tank Water and Sediment - Drain ........... 71
Drain the Water and the Sediment .............. 72
Fuel Storage Tanks...................................... 72
Fuel Tank ..................................................... 72
Fuel Transfer Pump (Lift Pump) - Inspect ....... 72
Replacement of the Lift Pump ..................... 72
G
General Hazard Information.............................. 9
Containing Fluid Spillage..............................11
Dispose of Waste Properly .......................... 12
Fluid Penetration ......................................... 10
Inhalation ......................................................11
Pressurized Air and Water........................... 10
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ........................11
Governor Actuator - Check ............................. 73
H
Hoses and Clamps - Inspect/Replace............. 73
Clamps and V-Band Clamp Torques ........... 77
Clamps and V-Band Locations .................... 75
Replace the Hoses and the Clamps ............ 73
I
Important Safety Information............................. 2
L
Lifting and Storage .......................................... 26
M
Maintenance Interval Schedule....................... 50
Daily ............................................................. 50
Every 1000 Service Hours........................... 50
Every 12 000 Service Hours or 6 Years....... 50
Every 50 Service Hours or Weekly.............. 50
Every 500 Service Hours ............................. 50
Every 500 Service Hours or 1 Year ............. 50
Every 5000 Service Hours........................... 50
Every 6000 Service Hours or 3 Years ......... 50
Every 7500 Service Hours........................... 50
Every Year ................................................... 50
Initial 100 Service Hours.............................. 50
Overhaul ...................................................... 50
When Required............................................ 50
Maintenance Section....................................... 35
Model View Illustrations (Engine Views for
the Six and Eight Cylinder 4000 Series
Engines) ........................................................ 18
4006-23 Engine Views................................. 19
4008-30 Engine Views................................. 21
4008-30 Radiator ......................................... 23
Model Views .................................................... 18
Monitoring System........................................... 29
Mounting and Dismounting ............................. 15
O
Operation Section............................................ 26
Overhaul (Major) ............................................. 77
Major Overhaul Information ......................... 78
85
Index Section