CVP-205/CVP-205M SERVICE MANUAL CVP-205 CONTENTS SPECIFICATIONS ··································································· 3 PANEL LAYOUT ······································································· 5 CIRCUIT BOARD LAYOUT & WIRING ···································· 8 DISASSEMBLY PROCEDURE ·············································· 10 LSI PIN DESCRIPTION ························································· 23 IC BLOCK DIAGRAM ···························································· 29 CIRCUIT BOARDS ································································ 31 TEST PROGRAM ·································································· 50 SYSTEM RESET ···································································...
Page 2
IMPORTANT NOTICE This manual has been provided for the use of authorized Yamaha Retailers and their service personnel. It has been assumed that basic service procedures inherent to the industry, and more specifically Yamaha Products, are already known and understood by the users, and have therefore not been restated.
CVP-205/CVP-205M DISASSEMBLY PROCEDURE Floppy Disk Drive (Time required: About 10 minutes) Remove the four (4) screws marked [50A]. The FDD unit can then be removed. (Fig. 1) Remove the four (4) screws marked [8A]. The FDD cover can then be removed. (Fig. 2) Remove the screw marked [3A].
Page 11
CVP-205/CVP-205M • Bottom view • Side view Mic. & phones unit Knob Knob [40A] [40B] [40]: Hexagonal Nut 12.0 14x2 MFZN2BL (VB508600) Fig. 4 Music Rest Assembly (Time required: About 5 minutes) Remove the four (4) screws marked [7A]. The music rest assembly can then be removed.
Page 12
CVP-205/CVP-205M • Rear view [6A] x 8 [6A] x 8 Speaker box assembly R Speaker box assembly L [5c] Woofer Woofer [5c] [5c]: Bind Head Tapping Screw-1 4.0x16 MFZN2BL (EP040250) Fig. 7 FU60 Assembly, FU60 Circuit Board (Time required: About 10 minutes) Remove the FU assembly.
Page 13
CVP-205/CVP-205M Woofers (Time required: About 10 minutes) Remove the speaker box assembly L and R. (See procedure 5.) Remove the four (4) screws marked [5c]. The woofer can then be removed. (Fig. 7) The left and right woofer each can then be removed in the same manner.
Page 14
CVP-205/CVP-205M PEDAL (D-JACK) Circuit Board (Time required: About 10 minutes) 11-1 Remove the back board assembly. (See procedure 4.) 11-2 Disconnect the PK-LF cable. (Fig. 11) 11-3 Remove the PK connector assembly. (See procedure 10.) 11-4 Remove the two (2) screws marked [35c]. The PEDAL (D- JACK) circuit board can then be removed.
Page 15
CVP-205/CVP-205M Arm assembly L Rack cover L [27A] [27A]: Bind Head Tapping Screw-B 3.0x8 MFZN2Y (EP600250) Key cover assembly Fig. 13 Fig. 14 Guide pin Guide pin Guide rail Guide rail Key cover assembly Fig. 15 Circuit Boards and Assemblies (Main Unit - PART2) (Time required: About 5 minutes each) Remove the following screws after removing the panel...
Page 16
CVP-205/CVP-205M Monitor speaker L Rack assembly L [8B] [8B] [38c] Fig. 17 Fig. 18 Circuit Boards and Assemblies (Panel Assembly) (Time required: About 5 minutes each) Remove the following screws after removing the panel assembly. Each unit and assembly can then be removed. (Table-4) Circuit Board and Unit Ref.
Page 17
CVP-205/CVP-205M GLL Circuit Board, GLC Circuit Board, GLR Circuit Board (Time required: About 25 minutes) 17-1 Remove the GL case assembly. (See procedure 16.) 17-2 Remove the five (5) screws marked [7B]. The GLL circuit board can then be removed. (Fig. 19) 17-3 Remove the four (4) screws marked [7C].
Page 18
CVP-205/CVP-205M 20-6 Remove the four (4) screws marked [15A] and the five (5) screws marked [18A]. The arm assembly can then be removed. (Fig. 1, Fig. 22) The left and right arm assembly each can then be removed in the same manner. Back Top Board Assembly (Time required: About 45 minutes) 21-1...
Page 19
CVP-205/CVP-205M Front board assembly [BC] Side board assembly L [BD] [BB] Side board assembly R [BB] [CA] [BB]: Truss Head Screw 4.0x14 MFZN2BL (VB931700) [CA]: Truss Head Screw 6.0x25 MFZN2BL (VQ448400) [BC]: Truss Head Screw 4.0x14 MFZN2BL (VB931700) [BD]: Truss Head Screw 4.0x14 MFZN2BL (VB931700) Fig.
Page 20
CVP-205/CVP-205M • Bottom view [6C] [7E] Pedal assembly [6C] [6C] [6C]: Bind Head Tapping Screw-1 4.0x14 MFZN2Y (EP040230) [7E]: Truss Head Tapping Screw-1 4.0x12 MFZN2BL (03747270) Fig. 28 Disassembling the Keyboard (Time required: About 15 minutes) After inserting a round stick (Rod: TX000670) between the frame and the keys, remove the circuit boards.
Page 21
CVP-205/CVP-205M White key Thin metal plate etc Spring Triangle mark Round stick (Rod: TX000670) Fig. 31 Fig. 32 Hammer, white key Spring Stopper (L88_W) Hook Fig. 33 Fig. 34 Assembling the Keyboard (Time required: About 15 minutes) 27-1 Hammer, White Key (Hammer, Black Key) Place the keyboard assembly upside-down, insert a hammer assembly into the frame, and put the stopper (L88_W) on.
Page 22
CVP-205/CVP-205M Hammer, white key Stopper (L88_W) Spring Frame Hook Frame Fig. 35 Fig. 36 White key Keyboard assembly Hook GH-D SW H Spring Key guide Triangle mark GH-DclSW L Fig. 37 Fig. 38...
Page 24
CVP-205/CVP-205M HD6417709F80B (XV250B00) CPU DM: IC018 NAME FUNCTION NAME FUNCTION CKE/PTK5 CK enable / Port K Mode control /RAS3L/PTJ0 3L Row address strobe / Port J Vcc(RTC) Power supply +3.3V /RAS2L/PTJ1 2L Row address strobe / Port J XTAL2 /CASLL//CAS/PTJ2 LL Column address strobe / Column address strobe / Port J Crystal oscillator EXTAL2...
Page 25
CVP-205/CVP-205M DM: IC036 HG73C205AFD (XU947C00) SWX00B (Tone Generator) SWX: IC001, 2 NAME FUNCTION NAME FUNCTION Initial clear CMA3 Program address bus RFCLKI PLL Clock CMA8 Program address bus PLL Control CMA2 Program address bus AVDD_PLL Power supply read signal AVSS_PLL Ground CMA1 Program address bus...
Page 26
CVP-205/CVP-205M JG760082A (XV481B00) Gate Array (Video Out) DM: IC019 NAME FUNCTION NAME FUNCTION RESET Reset (High/Low) Read strobe (High/Low) TEST Test mode setting (High/Low) Write strobe (High/Low) MODE Mode select (High/Low) Ground (Out buffer) NTSC/PAL NTSC/PAL signal input (High/Low) Frame Line latch pulse Power supply (5 v) XSCL...
Page 27
CVP-205/CVP-205M HD63266F (XI939A00) FDC (Floppy Disk Controller) DM: IC009 NAME FUNCTION NAME FUNCTION 8"//5" Data transmission speed /TRKO Track 00 signal XTALSET Clock select /INDEX Index signal /RESET Rest /RDATA Read data input from FDD E//RD Enable/Read XTAL2 Clock RW//WR Read/write/Write EXTAL2 Chip select...
Page 28
CVP-205/CVP-205M SED1335F0B (XQ595A00) LCDC (LCD Controller) DM: IC008 NAME FUNCTION NAME FUNCTION Data bus output for 4 bit dot VRAM address bus XECL S driver enable, chain clock XSCL Data bus shift clock Ground /VWR VRAM read/write X driver latch pulse /VCE Memory control Frame signal for X/Y driver...
CVP-205/CVP-205M CIRCUIT BOARDS A-JACK Circuit Board N.C. N.C. VIDEO OUT L/L+R L/L+R ( LEVEL FIXED ) AUX IN AUX OUT Component side Pattern side 2NA-V714700...
Page 33
CVP-205/CVP-205M DM Circuit Board to A-JACK-CN540 to PNR-CN1 to GH-DclSW L-CN1 Component side 2NA-V716590-1...
Page 34
CVP-205/CVP-205M DM Circuit Board Pattern side 2NA-V716590-2...
Page 35
CVP-205/CVP-205M PNR Circuit Board to PNCR-CN201 to DM-CN9 REVERB LCD CONTRAST PIANO&HARPSI. E.PIANO VOICE PART ON/OFF (LAYER) BRASS WOODWIND VOICE PART ON/OFF (LEFT) ENTER MUSIC FINDER INV Circuit Board FREEZE PIANO ENC Circuit Board DATA ENTRY Component side Component side PNR, ENC: 2NA-V713520-1 INV: 2NA-V713450...
Page 36
CVP-205/CVP-205M to PNL-CN1 to PNL-CN2 to PNL-CN3 VOICE EFFECT VARIATION HARMONY/ECHO MONO LEFT HOLD VOICE ORGAN&ACCORDION PERCUSSION GUITAR BASS STRINGS CHOIR&PAD SYNTH. USER WIND ONE TOUCH SETTING REGISTRATION MEMORY MEMORY to GLR-CN3 Component side 2NA-V713520-1...
Page 38
CVP-205/CVP-205M Pattern side ENC Circuit Board Pattern side PNR, ENC: 2NA-V713520-2...
Page 39
CVP-205/CVP-205M PNL Circuit Board to PNR-CN2 METRONOME START/STOP EXTRA TRACKS FADE IN/OUT STAR AUTO FILL IN BREAK INTRO MAIN A MAIN B ACMP STYL OTS LINK to GLL-CN1 PNCB Circuit Board DOWN DOWN DOWN DOWN DOWN DOWN DOWN DOWN DIRECT ACCESS LCD select PNL, PNCB: 2NA-V713450...
Page 40
CVP-205/CVP-205M to PNR-CN3 to PNR-CN4 to PNCL-CN101 TRACK 2 TRACK 1 START/STOP REPEAT GUIDE SONG TAP TEMPO TRANSPOSE - TRANSPOSE + TEMPO MAIN C MAIN D ENDING/rlt. SYNC.STOP SYNC.START START/STOP STYLE to GLC-CN2 Component side EXIT Component side PNL, PNCB: 2NA-V713450...
Page 41
CVP-205/CVP-205M PNCL Circuit Board to PNL-CN4 Component side Pattern side FU60 Circuit Board to Power Transformer (Primary) to POWER Switch VOLTAGE SELECTOR AC INLET Component side PNCL: 2NA-V713500 FU60: 2NA-VT47830...
Page 42
CVP-205/CVP-205M PNCR Circuit Board to PNR-CN5 Component side Pattern side MIC Circuit Board N.C. to DM-CN11 INPUT MIC./LINE IN MIC./LINE VOLUME Component side Pattern side PNCR: 2NA-V713500 MIC: 2NA-V313580...
Page 43
CVP-205/CVP-205M SWX Circuit Board Component side to DM-CN10 Pattern side 2NA-V716050...
Page 44
CVP-205/CVP-205M D-JACK Circuit Board MIDI AUX PEDAL TO HOST HOST SELECT THRU to DM-CN5 Component side Pattern side PEDAL (D-JACK 2/2) Circuit Board HP Circuit Board N.C. to Keybed GND to PEDAL(SW)-CN1 to A-JACK-CN530 Component side Component side Pattern side PHONES D-JACK, PEDAL (D-JACK 2/2): 2NA-V493830 2NA-VT47830...
Page 45
CVP-205/CVP-205M GLC Circuit Board to PNL-CN6 Component side Pattern side 2NA-V713570...
Page 46
CVP-205/CVP-205M GLL Circuit Board to PNL-CN5 Component side Pattern side 2NA-V713570...
Page 47
CVP-205/CVP-205M GLR Circuit Board to PNR-CN6 Component side Pattern side 2NA-V713570...
Page 48
CVP-205/CVP-205M PEDAL (SW) Circuit Board Left Pedal Sostenuto Pedal Damper Pedal Component side to PEDAL(D-JACK 2/2)-JK5 PEDAL VR Circuit Board MV Circuit Board Damper Volume to A-JACK-CN510 Component side MASTER VOLUME Component side PEDAL (SW), PEDAL VR: 2NA-V233730 2NA-V713450...
Page 49
CVP-205/CVP-205M MA60 Circuit Board NET1 Circuit Board to Woofer and Tweeter Speakers to DM-CN3 N.C. Component side CN002 XT123 CAUTION: REPLACE WITH SAME TYPE 5A 125V FUSE. ATTENTION: UTILISER UN FUSIBLE DE RECHANGE DE MÉME TYPE DE 5A 125V. CN003 NOTE : The symbol ( ) shows Slow operating fuse.
CVP-205/CVP-205M TEST PROGRAM 1. Preparation 1) The volume is usually moved to the use position when no volume change is required. 2) Measuring instruments: frequency counter, level meter (with JIS-C filter) Note: Connect a stereo plug to the [PHONES] jack at 33 ohms. 3) Jigs: foot volume (FC-7), MIDI cable, floppy disk (2HD &...
Page 51
CVP-205/CVP-205M LCD (initial) Test Function and Judgment criteria 015: Pitch Check Pitch check: Connect the frequency counter to the [PHONES] jack (33 ohm load). Outputs the sine wave at 440 +/-0.2 Hz. (PAN = Center) Decline quantity check of the volume: Connect the level meter (with a JIS-C filter) to the [PHONES] jack. Set the [MASTER VOLUME] at MIN and check the output level.
Page 52
CVP-205/CVP-205M LCD (initial) Test Function and Judgment criteria 042: MIC Check Connect a microphone to the [MIC./LINE IN] jack and speak to it. Set the [MIC./LINE] select switch to [MIC.] and set the [INPUT VOLUME] at maximum. Check the voice sound by hearing that there is not unusual noise or abnormal sound. 043: ROM Check2 Checks the ROMs that are connected to the CPU bus.
Page 53
CVP-205/CVP-205M • TABLE 1 ORDER SWITCH NOTE ORDER SWITCH NOTE METRONOME EXTRA TRACKS TRACK2 TRACK1 START/STOP (SONG) EXIT BACK REPEAT NEXT GUIDE FADE IN/OUT TEMPO - TEMPO + TAP TEMPO TRANSPOSE - LAYER TRANSPOSE + LEFT ACCOMP. ON/OFF ENTER AUTO FILL IN REVERB OTS LINK BREAK...
CVP-205/CVP-205M SYSTEM RESET This operation lets you restore the CVP-205/205M to its original factory settings. These settings include System Setup, MIDI Setup, User Effect, Music Finder, and Files & Folders. Restores the System Setup parameters to the original factory settings. You can also restore The functions and settings below do only the System Setup settings by not apply to the Factory Reset ope-...
CVP-205/CVP-205M MIDI DATA FORMAT Many MIDI messages listed in the MIDI Data Format are expressed in decimal numbers, binary numbers and hexadecimal numbers. Hexadecimal numbers may include the letter “H” as a suffix. Also, “n” can freely be defined as any whole number. To enter data/values, refer to the table below.
Page 58
CVP-205/CVP-205M MIDI CHANNEL MESSAGE (1) O: available MIDI Events Status byte 1st Data byte 2nd Data byte Corresponding Voice/Part MIDI Reception (respond/ignore) MIDI Transmission (generated data) Status Data (HEX) Parameter Data (HEX) Parameter Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel Upper...
Page 59
CVP-205/CVP-205M MIDI Events Status byte 1st Data byte 2nd Data byte Corresponding Voice/Part MIDI Reception (respond/ignore) MIDI Transmission (generated data) Status Data (HEX) Parameter Data (HEX) Parameter Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel Upper M.Pad Style Song MIDI Organ Voice Layer...
Page 60
CVP-205/CVP-205M NRPN (Vocal Harmony) NRPN Data Entry Parameter Data Range Corresponding Voice/Part MIDI Reception (respond/ignore) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel Upper M.Pad Style Song MIDI Organ Voice Voice Layer (main generation Lower Left method)
Page 61
CVP-205/CVP-205M MIDI PARAMETER CHANGE TABLE * Not Received when Receive System Exclusive Message Parameters is set to off. * Not transmitted when Transmit System Exclusive Message Parmeters is set to on. MIDI Parameter Change table (XG SYSTEM) CVP-203 CVP-205 CVP-207 CVP-209 O: available Address...
Page 62
CVP-205/CVP-205M MIDI Parameter Change table (EFFECT1) CVP-203 CVP-205 CVP-207 CVP-209 Address Size Data Parameter Description XG Default Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ...
Page 63
CVP-205/CVP-205M Address Size Data Parameter Description XG Default Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ Voice Layer (main generation Voice Left method)
Page 64
CVP-205/CVP-205M Address Size Data Parameter Description XG Default Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ Voice Layer (main generation Voice Left method)
Page 65
CVP-205/CVP-205M MIDI Parameter Change table (EFFECT2) CVP-203 CVP-205 CVP-207 CVP-209 Address Size Data Parameter Description Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ Voice Layer...
Page 66
CVP-205/CVP-205M Address Size Data Parameter Description Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ Voice Layer (main generation Voice Left method) 00-7F...
Page 67
CVP-205/CVP-205M MIDI Parameter Change table (SPECIAL EFFECT) CVP-203 CVP-205 CVP-207 CVP-209 Address Size Data Parameter Description Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ Voice...
Page 68
CVP-205/CVP-205M MIDI Parameter Change table (MULTI PART) CVP-203 CVP-205 CVP-207 CVP-209 Address Size Data Parameter Description XG Default Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ...
Page 69
CVP-205/CVP-205M Address Size Data Parameter Description XG Default Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ Voice Layer (main generation Voice Left method)
Page 70
CVP-205/CVP-205M MIDI Parameter Change table (A/D PART) CVP-203 CVP-205 CVP-207 CVP-209 Address Size Data Parameter Description Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ Voice...
Page 71
CVP-205/CVP-205M MIDI Parameter Change table (DRUM SETUP) CVP-203 CVP-205 CVP-207 CVP-209 Address Size Data Parameter Description XG Default Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Transmission (generated data) Regular/ Mic/Vocal Harmony Natural Song Main Keyboard Style Extra Panel M.Pad Style Song MIDI Organ...
Page 72
Section F0 43 7E 00 ss dd F7 O (Section LED) O (Section Sw) Control 11110000 F0= Exclusive status 01000011 43= YAMAHA ID 01111110 7E= Style 00000000 00= 0sssssss ss= Switch No. INTRO A INTRO B INTRO C INTRO D...
Page 73
*Refer to Parameter Change Table *Refer to Parameter Change Table Parameter 11110000 F0= Exclusive status Table (When Change 01000011 43= YAMAHA ID receiving 0001nnnn 1n= Device Number n=always 0 (when transmit), n=0-F the XG (when recieve) Parameter 01001100 4C= Model ID...
Page 74
CVP-205/CVP-205M System Exclusive Messages (Clavinova compliance) 11110000 F0= Exclusive status 01000011 43= YAMAHA ID 01110011 73= Clavinova ID 11110111 F7= End of Exclusive MIDI Event Data Format Corresponding Voice/Part MIDI Reception (effective or not for each part) MIDI Reception MIDI Transmission (generated data)
Page 75
Volume & F0 43 73 01 11 0n 45 dd F7 Expression 11110000 F0= Exclusive status & Pan 01000011 43= YAMAHA ID Realtime 01110011 73= Clavinova ID control off 00000001 01= Model ID (Clavinova common ID) (Voice 00010001 11= Special Operators Reserve) 0000nnnn 0n= Channel No.
Page 76
F0 43 73 01 11 0n 50 00 ss F7 Harmony 11110000 F0= Exclusive status (Vocal Harmony (Vocal Pitch to 01000011 43= YAMAHA ID Edit) Harmony Edit) Note 01110011 73= Clavinova ID ON/OFF 00000001 01= Model ID (Clavinova common ID) 00010001 11= Special Operators 0000nnnn 0n= Channel No.
CVP-205/CVP-205M OVERALL ASSEMBLY • Rear view Main unit: See page 5. Side board assembly L: See page 24. Front board assembly: See page 28. Pedal box assembly: See page 26. 18 Side board assembly R: See page 24.
Page 79
CVP-205/CVP-205M • CVP-205 PART NO. DESCRIPTION REMARKS REF NO. QTY RANK OVERALL ASSEMBLY CVP-205 Main Unit (V709950) Main Unit (V755960) Main Unit (V755970) Main Unit (V755980) V7101200 Side Board Assembly L LEFT V7101400 Side Board Assembly R RIGHT Pedal Box Assembly (V710160) V7101800 Back Board Assembly...
Page 80
CVP-205/CVP-205M • CVP-205M PART NO. DESCRIPTION REMARKS REF NO. QTY RANK OVERALL ASSEMBLY CVP-205M Main Unit (V755990) Main Unit (V756000) Main Unit (V756010) V7101300 Side Board Assembly L LEFT V7101500 Side Board Assembly R RIGHT Pedal Box Assembly (V710170) V7101900 Back Board Assembly MAHOGANY/BLACK9 V6816800...
Page 81
Mic. & phones unit: See page 22. FDD unit: See page 19. • Bottom view 10bd 10bc LOCATION SYMBOL Jack unit: See page 23. FU assembly: See page 30. 10be SEC. A-A See A MA60 assembly: See page 29. 10ba 10bb •...
Page 82
• Rear view • Speaker assembly L, R Right should be symmetrical. Key cover assembly: See page 18. • Top view • Side view U.S.A. model only U.S.A. model only U.S.A. model only Top board assembly: See page 11. Music rest assembly: See page 17.
CVP-205/CVP-205M • CVP-205 PART NO. DESCRIPTION REMARKS REF NO. QTY RANK MAIN UNIT CVP-205 Main Unit (V709950) Main Unit (V755960) Main Unit (V755970) Main Unit (V755980) VP834600 Adhesive Tape 12X50 J,E,B,N VP834600 Adhesive Tape 12X50 CB069250 Cord Holder BK-1 J,E,B,N CB069250 Cord Holder BK-1...
Page 84
CVP-205/CVP-205M PART NO. DESCRIPTION REMARKS REF NO. QTY RANK EN630190 Truss Head Tapping Screw-1 3.5X25 MFZN2BL VN887900 Guide Screw 6X14 EP030190 Bind Head Tapping Screw-1 3.5X16 MFZN2Y Electrical Adhesive Tape 25X30 NO.7701 Electrical Adhesive Tape 40X20m NO.7701 (V591400) V7123200 End Block Assembly L LEFT (V604530) V7123400...
Page 85
CVP-205/CVP-205M • CVP-205M PART NO. DESCRIPTION REMARKS REF NO. QTY RANK MAIN UNIT CVP-205M Main Unit (V755990) Main Unit (V756000) Main Unit (V756010) VP834600 Adhesive Tape 12X50 VP834600 Adhesive Tape 12X50 E,B,N CB069250 Cord Holder BK-1 CB069250 Cord Holder BK-1 E,B,N EN630230 Truss Head Tapping Screw-1...
Page 86
CVP-205/CVP-205M PART NO. DESCRIPTION REMARKS REF NO. QTY RANK V7123300 End Block Assembly L V7123500 End Block Assembly R VA076400 Truss Head Tapping Screw-1 3.5X30 MFZN2Y V7125100 Key Cover Assembly V7509600 Rack Cover L LEFT V7509700 Rack Cover R RIGHT EP600250 Bind Head Tapping Screw-B 3.0X8 MFZN2Y...
CVP-205/CVP-205M TOP BOARD ASSEMBLY • Top view • Side view 11 4 PART NO. DESCRIPTION REMARKS REF NO. QTY RANK TOP BOARD ASSEMBLY CVP-205/CVP-205M V7114700 Top Board Assembly CVP-205 V7114800 Top Board Assembly CVP-205M Top Board Assembly CVP-205 (V711490) Top Board Assembly CVP-205M (V711500) Stopper Rail, Music Score...
Page 88
• Top view GL case assembly: • Bottom view 38 58 54 60 41 60 55 60 42 58 7 59 See page 15. SEC. A-A 53 57 8 59 66 67 5 58 LCD assembly: See page 16. • Bottom view LOCATION SYMBOL SEC.
CVP-205/CVP-205M GL CASE ASSEMBLY • Top view • Front view • Bottom view PART NO. DESCRIPTION REMARKS REF NO. QTY RANK GL CASE ASSEMBLY CVP-205/CVP-205M (V756820) V7162200 GL Case L LEFT V7162300 GL Case R RIGHT V7511800 GL Case C CENTER V7135800 Circuit Board...
CVP-205/CVP-205M MUSIC REST ASSEMBLY • Bottom view • Side view PART NO. DESCRIPTION REMARKS REF NO. QTY RANK MUSIC REST ASSEMBLY CVP-205/CVP-205M V7420000 Music Rest Assembly CVP-205 V7420100 Music Rest Assembly CVP-205M Music Rest CVP-205 (V742030) Music Rest CVP-205M (V742040) V8437600 Hinge CB054920...
Page 97
CVP-205/CVP-205M • ARM ASSEMBLY L PART NO. DESCRIPTION REMARKS REF NO. QTY RANK ARM ASSEMBLY L LEFT CVP-205/CVP-205M V7115800 Arm Assembly L LEFT CVP-205 V7115900 Arm Assembly L LEFT CVP-205M Side Cover L LEFT CVP-205 (V711620) Side Cover L LEFT CVP-205M (V711630) V7493800...
CVP-205/CVP-205M JACK UNIT • Top view • Front view PART NO. DESCRIPTION REMARKS REF NO. QTY RANK JACK UNIT CVP-205/CVP-205M (V747690) V7475900 Angle, Jack V6366200 Circuit Board D-JACK V7148100 Circuit Board A-JACK EP600190 Bind Head Tapping Screw-B 3.0X8 MFZN2BL GND Wire (V590820) : New Parts RANK: Japan only...
CVP-205/CVP-205M SIDE BOARD ASSEMBLY • Top view • Side view...
Page 101
CVP-205/CVP-205M • SIDE BOARD ASSEMBLY L PART NO. DESCRIPTION REMARKS REF NO. QTY RANK SIDE BOARD ASSEMBLY L LEFT CVP-205/CVP-205M V7101200 Side Board Assembly L LEFT CVP-205 V7101300 Side Board Assembly L LEFT CVP-205M Side Board L LEFT CVP-205 (V710280) Side Board L LEFT CVP-205M...
CVP-205/CVP-205M FU ASSEMBLY • Front view FU60 assembly: See page 31. • Top view PART NO. DESCRIPTION REMARKS REF NO. QTY RANK FU ASSEMBLY CVP-205/CVP-205M FU Assembly CVP-205 J (V775230) FU Assembly (V775240) FU Assembly (V775250) FU Assembly (V775260) FU Box (V775210) VT152000 FU60 Assembly...
Page 109
CVP-205/CVP-205M PART NO. DESCRIPTION REMARKS REF NO. QTY RANK V7803300 KEYBOARD ASSEMBLY GHD_CL88 CVP-205/CVP-205M MK Frame (VU42210) VU101000 White Key VU101100 White Key VU101200 White Key VU101300 White Key VU101400 White Key VU101500 White Key VU101600 White Key VU101700 White Key VU101800 White Key VU102100...
Page 118
CVP-205/CVP-205M PART NO. DESCRIPTION REMARKS REF NO. QTY RANK C0145 US064100 Ceramic Capacitor-B (chip) 0.0100 50V K C0146 US064100 Ceramic Capacitor-B (chip) 0.0100 50V K C0147 US135100 Ceramic Capacitor-F (chip) 0.1000 16V Z C0148 US135100 Ceramic Capacitor-F (chip) 0.1000 16V Z C0149 US063220 Ceramic Capacitor-B (chip)
Page 119
CVP-205/CVP-205M PART NO. DESCRIPTION REMARKS REF NO. QTY RANK CN008 VB389800 Connector Base Post PH 2P TE CN009 VB390700 Connector Base Post PH 11P TE CN010 VM673300 Header HIF3FC26PA-2.54DSA CN011 VB390100 Connector Base Post PH 5P TE CN012 VB390800 Connector Base Post PH 12P TE D0002 VB493900...
Page 128
CVP-205/CVP-205M PART NO. DESCRIPTION REMARKS REF NO. QTY RANK C0010 VS490700 Electrolytic Cap. 47.0 16.0V C0011 VS490700 Electrolytic Cap. 47.0 16.0V CN001 VB389600 Connector Base Post PH 11P SE CN002 VB858900 Connector Base Post PH 10P SE CN003 VB858700 Connector Base Post PH 8P SE CN004 VC166500...