Troubleshooting - Schumacher SF 2001 Owner's Manual

M.
If a problem does occur, check the following:
PROBLEM
No Meter Reading
(AC Cord Unplugged)
Charger will not turn
on when properly
connected.
Clicking noise from
charger.
NOTE: Fan will operate when in "OFF" position. Unplug to stop fan.
SCHUMACHER ELECTRIC CORPORATION, 801 BUSINESS CENTER DRIVE, MOUNT PROSPECT, ILLINOIS, 60056-2179
MAKES THIS LIMITED WARRANTY TO THE ORIGINAL PURCHASER AT RETAIL OF THIS PRODUCT. THIS LIMITED WAR-
RANTY IS NOT TRANSFERABLE.
Schumacher Electric Corporation warrants this battery charger for 3 years, and the transformer and rectifiers for 5 years from date of
purchase at retail against defective material or workmanship. If such should occur, the unit will be repaired or replaced at the option of
the manufacturer. It is the obligation of the purchaser to forward the unit together with proof of purchase, transportation and / or mailing
charges prepaid to the manufacturer or its authorized representative. This limited warranty is void if the product is misused, subjected to
careless handling, or repaired by anyone other than the factory or other authorized factory representative. The manufacturer makes no
warranty other than this limited warranty and expressly excludes any implied warranty including any warranty for consequential dam-
ages.
This is the only express limited warranty and the manufacturer neither assumes nor authorizes anyone to assume or make any other
obligation towards the product other than this express limited warranty. The manufacturer makes no warranty of merchantability or
fitness for purpose of this product and expressly excludes such from this limited warranty. Some states do not allow the exclusion or
limitation of incidental or consequential damages or length of implied warranty so the above limitations or exclusions may not apply to
you. "This warranty gives you specific legal rights, and you may have other rights which vary from state to state."
553

TROUBLESHOOTING

POSSIBLE CAUSE
Clips are not making
a good connection.
Battery voltage is too
low.
2 amp charge rate
being used.
AC outlet is dead.
Poor electrical
connection.
Circuit breaker is
cycling.
Battery is defective.
Severely discharged
battery but otherwise
a good battery.
Reverse connections
at battery.
LIMITED WARRANTY
7
SOLUTION
Rock clips back and
forth for a better connection.
Plug AC line into outlet.
Meter should now indicate.
None, meter will not indicate
here.
Plug in a lamp to check for
voltage.
Check connections, rock
back and forth for a better
connection.
May be in the wrong switch
position
Have Battery checked.
Allow charging to continue
until battery has a chance
to recover sufficiently to take
a charge. If more than 20
min. stop charging and have
the battery checked.
Shut off charger and correct
lead connections.