Page 1: Table Of Contents
2008 Saturn Astra Owner Manual ... 1-1 Seats and Restraints Front Seats ... 1-2 Rear Seats ... 1-7 Safety Belts ... 1-8 Airbag System ... 1-23 Child Restraints ... 1-37 Keys, Doors and ... 2-1 Windows Keys ... 2-2 Doors and Locks ...
Page 2: Using This Manual
MOTORS and GM are registered trademarks of General Motors Corporation. This manual includes the latest information at the time it was printed. Saturn reserves the right to make changes after that time without further notice. Litho in U.S.A. Part No. 94701908 B Second Printing...
Page 3: Index
Index To quickly locate information about the vehicle use the Index in the back of the manual. It is an alphabetical list of what is in the manual and the page number where it can be found. Cautions and Notices There are a number of safety cautions in this book.
Page 4 Preface NOTES...
Page 5 Seats and Restraints Front Seats Manual Seats ...1-2 Seat Height Adjuster ...1-2 Lumbar Seat Adjustment ...1-3 ...1-3 Reclining Seatbacks Head Restraints ...1-5 Heated Seats ...1-6 Rear Seats Rear Seat Operation ...1-7 Safety Belts Safety Belts ...1-8 How to Wear Safety Belts Properly ...1-12 Lap-Shoulder Belt...
Page 6: Seats And Restraints
Seats and Restraints Front Seats Manual Seats CAUTION You can lose control of the vehicle if you try to adjust a manual driver’s seat while the vehicle is moving. The sudden movement could startle and confuse you, or make you push a pedal when you do not want to.
Page 7: Lumbar Seat Adjustment
Lumbar Seat Adjustment On seats with this feature, turn the knob clockwise or counterclockwise to increase or decrease the lumbar support. Reclining Seatbacks CAUTION You can lose control of the vehicle if you try to adjust the seat while the vehicle is moving.
Page 8 Seats and Restraints To adjust a manual reclining seatback, turn the knob. Do not lean on the seatback while adjusting it. Seatback Latches (Three Door Model) For easy entry/exit to the rear seats on three door models: 1. Lift the lever, and tilt the seatback forward.
Page 9: Head Restraints
Head Restraints The vehicle’s front seats have adjustable head restraints. CAUTION With head restraints that are not installed and adjusted properly, there is a greater chance that occupants will suffer a neck/spinal injury in a crash. Do not drive until the head restraints for all occupants are installed and adjusted properly.
Page 10: Heated Seats
Seats and Restraints Active Head Restraint System The vehicle has an active head restraint system in the front seating positions. These automatically tilt forward to reduce the risk of neck injury if the vehicle is hit from behind. Rear Seat Headrests The vehicle has headrests in all seating positions of the rear seats.
Page 11: Rear Seats
Rear Seats Rear Seat Operation CAUTION If the seatback is not locked, it could move forward in a sudden stop or crash. That could cause injury to the person sitting there. Always push and pull on the seatback to be sure it is locked.
Page 12: Safety Belts
Seats and Restraints To return the seat to the sitting position: 1. Make sure the safety belt is through the storage clip. 2. Lift the seatback and push it rearward until it is locked in the sitting position. 3. Push and pull on the seatback to make sure it is locked.
Page 13 CAUTION It is extremely dangerous to ride in a cargo area, inside or outside of a vehicle. In a collision, people riding in these areas are more likely to be seriously injured or killed. Do not allow people to ride in any area of your vehicle that is not equipped with seats and safety belts.
Page 14 1-10 Seats and Restraints Put someone on it. Get it up to speed. Then stop the vehicle. The rider does not stop. The person keeps going until stopped by something. In a real vehicle, it could be the windshield...
Page 15: Safety Belts
or the instrument panel... or the safety belts! With safety belts, you slow down as the vehicle does. You get more time to stop. You stop over more distance, and your strongest bones take the forces. That is why safety belts make such good sense.
Page 16: How To Wear Safety Belts Properly
1-12 Seats and Restraints If I am a good driver, and I never drive far from home, why should I wear safety belts? You may be an excellent driver, but if you are in a crash — even one that is not your fault — you and your passenger(s) can be hurt.
Page 17 If you slid under it, the belt would apply force on your abdomen. This could cause serious or even fatal injuries. The shoulder belt should go over the shoulder and across the chest. These parts of the body are best able to take belt restraining forces.
Page 18 1-14 Seats and Restraints What is wrong with this? The belt is buckled in the wrong buckle. CAUTION You can be seriously injured if your belt is buckled in the wrong place like this. In a crash, the belt would go up over your abdomen.
Page 19 CAUTION You can be seriously injured if your belt goes over an armrest like this. The belt would be much too high. In a crash, you can slide under the belt. The belt force would then be applied on the abdomen, not on the pelvic bones, and that could cause serious or fatal injuries.
Page 20 1-16 Seats and Restraints What is wrong with this? The belt is behind the body. CAUTION You can be seriously injured by not wearing the lap-shoulder belt properly. In a crash, you would not be restrained by the shoulder belt. Your body could move too far forward increasing the chance of head and neck injury.
Page 21: Lap-Shoulder Belt
CAUTION You can be seriously injured by a twisted belt. In a crash, you would not have the full width of the belt to spread impact forces. If a belt is twisted, make it straight so it can work properly, or ask your dealer/ retailer to ﬁx it.
Page 22 1-18 Seats and Restraints 4. If equipped with a shoulder belt height adjuster, move it to the height that is right for you. Improper shoulder belt height adjustment could reduce the effectiveness of the safety belt in a crash. See “Shoulder Belt Height Adjustment”...
Page 23 To move it, push the button on the front of the height adjuster and move the height adjuster to the desired position. After you move the adjuster to where you want it, try to move it down without pushing the button to make sure it has locked into position.
Page 24 1-20 Seats and Restraints 2. Place the guide over the belt and insert the two edges of the belt into the slots of the guide. 3. Be sure that the belt is not twisted and it lies ﬂat. The elastic cord must be under the belt and the guide on top.
Page 25: Safety Belt Use During Pregnancy
4. Buckle, position, and release the safety belt as described previously in this section. Make sure that the shoulder belt crosses the shoulder. To remove and store the comfort guide, squeeze the belt edges together so that you can take them out of the guide.
Page 26: Safety Belt Extender
1-22 Seats and Restraints Safety Belt Extender If the safety belt will fasten around you, you should use it. But if a safety belt is not long enough, your dealer/retailer will order you an extender. When you go in to order it, take the heaviest coat you will wear, so the extender will be long enough for you.
Page 27: Replacing Safety Belt System Parts After A Crash
Replacing Safety Belt System Parts After a Crash CAUTION A crash can damage the safety belt system in the vehicle. A damaged safety belt system may not properly protect the person using it, resulting in serious injury or even death in a crash.
Page 28 1-24 Seats and Restraints For frontal airbags, the word AIRBAG will appear on the middle part of the steering wheel for the driver and on the instrument panel for the right front passenger. With seat-mounted side impact airbags, the word AIRBAG will appear on the side of the seatback closest to the door.
Page 29: Where Are The Airbags
CAUTION Airbags inﬂate with great force, faster than the blink of an eye. Anyone who is up against, or very close to, any airbag when it inﬂates can be seriously injured or killed. Do not sit unnecessarily close to the airbag, as you would be if you were sitting on the edge of your seat or leaning forward.
Page 30 1-26 Seats and Restraints Driver Side shown, Passenger Side similar The seat-mounted side impact airbags for the driver and right front passenger are in the side of the seatbacks closest to the door. The roof-rail airbags for the driver, right front passenger, and second row outboard passengers are in the ceiling above the side windows.
Page 31: When Should An Airbag Inﬂate
When Should an Airbag Inﬂate? Frontal airbags are designed to inﬂate in moderate to severe frontal or near-frontal crashes to help reduce the potential for severe injuries mainly to the driver’s or right front passenger’s head and chest. However, they are only designed to inﬂate if the impact exceeds a predetermined deployment threshold.
Page 32: What Makes An Airbag Inﬂate
1-28 Seats and Restraints Seat-mounted side impact and roof-rail airbags are not intended to inﬂate in frontal impacts, near-frontal impacts, rollovers, or rear impacts. A seat-mounted side impact airbag is intended to deploy on the side of the vehicle that is struck. A roof-rail airbag is intended to deploy on the side of the vehicle that is struck.
Page 33: What Will You See After An Airbag Inﬂates
What Will You See After an Airbag Inﬂates? After the frontal airbags and seat-mounted side impact airbags inﬂate, they quickly deﬂate, so quickly that some people may not even realize an airbag inﬂated. Roof-rail airbags may still be at least partially inﬂated for some time after they deploy.
Page 34: Passenger Sensing System
1-30 Seats and Restraints Passenger Sensing System The vehicle has a passenger sensing system for the right front passenger position. The passenger airbag status indicator will be visible in the rearview mirror when you start the vehicle. United States Canada The words ON and OFF, or the symbol for on and off, will be visible during the system check.
Page 35 A label on the sun visor says, “Never put a rear-facing child seat in the front.” This is because the risk to the rear-facing child is so great, if the airbag deploys. CAUTION A child in a rear-facing child restraint can be seriously injured or killed if the right front passenger airbag inﬂates.
Page 36 1-32 Seats and Restraints When the passenger sensing system has turned off the right front passenger’s frontal airbag and seat-mounted side impact airbag, the off indicator will light and stay lit to remind you that the airbags are off. See Passenger Airbag Status Indicator on page 4-15.
Page 37 If a person of adult-size is sitting in the right front passenger’s seat, but the off indicator is lit, it could be because that person is not sitting properly in the seat. If this happens, turn the vehicle off, remove any additional material from the seat, such as blankets, cushions, seat covers, seat heaters or seat...
Page 38: Servicing Your Airbag-Equipped Vehicle
1-34 Seats and Restraints We recommend that you not use seat covers or other aftermarket equipment other than any that GM has approved for your speciﬁc vehicle. See Adding Equipment to Your Airbag-Equipped Vehicle on page 1-35 for more information about modiﬁcations that can affect how the system operates.
Page 39: Airbag System
Adding Equipment to Your Airbag-Equipped Vehicle Is there anything I might add to or change about the vehicle that could keep the airbags from working properly? Yes. If you add things that change the vehicle’s frame, bumper system, height, front end or side sheet metal, they may keep the airbag system from working properly.
Page 40: Airbag System Check
1-36 Seats and Restraints Airbag System Check The airbag system does not need regularly scheduled maintenance or replacement. Make sure the airbag readiness light is working. See Airbag Readiness Light on page 4-14 for more information. Notice: If an airbag covering is damaged, opened, or broken, the airbag may not work properly.
Page 41: Child Restraints
Child Restraints Older Children Older children who have outgrown booster seats should wear the vehicle’s safety belts. The manufacturer’s instructions that come with the booster seat, state the weight and height limitations for that booster. Use a booster seat with a lap-shoulder belt until the child passes the below ﬁt test: •...
Page 42: Infants And Young Children
1-38 Seats and Restraints CAUTION Never do this. Never allow two children to wear the same safety belt. The safety belt can not properly spread the impact forces. In a crash, the two children can be crushed together and seriously injured.
Page 43 CAUTION Children can be seriously injured or strangled if a shoulder belt is wrapped around their neck and the safety belt continues to tighten. Never leave children unattended in a vehicle and never allow children to play with the safety belts. Every time infants and young children ride in vehicles, they should have the protection provided by...
Page 44 1-40 Seats and Restraints CAUTION Never do this. Children who are up against, or very close to, any airbag when it inﬂates can be seriously injured or killed. Never put a rear-facing child restraint in the right front seat. Secure a rear-facing child restraint in a rear seat.
Page 45: Child Restraint Systems
CAUTION To reduce the risk of neck and head injury during a crash, infants need complete support. This is because an infant’s neck is not fully developed and its head weighs so much compared with the rest of its body. In a crash, an infant in a rear-facing child restraint settles into the restraint, so the crash forces...
Page 46 1-42 Seats and Restraints (B) Forward-Facing Child Seat A forward-facing child seat (B) provides restraint for the child’s body with the harness. (C) Booster Seats A booster seat (C) is a child restraint designed to improve the ﬁt of the vehicle’s safety belt system. A booster seat can also help a child to see out the window.
Page 47: Where To Put The Restraint
To help reduce the chance of injury, the child restraint must be secured in the vehicle. Child restraint systems must be secured in vehicle seats by lap belts or the lap belt portion of a lap-shoulder belt, or by the LATCH system.
Page 48 1-44 Seats and Restraints A label on the sun visor says, “Never put a rear-facing child seat in the front.” This is because the risk to the rear-facing child is so great, if the airbag deploys. CAUTION A child in a rear-facing child restraint can be seriously injured or killed if the right front passenger airbag inﬂates.
Page 49: Lower Anchors And Tethers For Children (Latch)
Lower Anchors and Tethers for Children (LATCH) The LATCH system holds a child restraint during driving or in a crash. This system is designed to make installation of a child restraint easier. The LATCH system uses anchors in the vehicle and attachments on the child restraint that are made for use with the LATCH system.
Page 50 1-46 Seats and Restraints Top Tether Anchor A top tether (A, C) anchors the top of the child restraint to the vehicle. A top tether anchor is built into the vehicle. The top tether attachment (B) on the child restraint connects to the top tether anchor in the vehicle in order to reduce the forward movement and rotation...
Page 51 To assist you in locating the lower anchors, each seating position with lower anchors has two labels, near the crease between the seatback and the seat cushion. If the top tether anchors are covered, the top tether anchor symbol will be located on the cover to assist you in locating them.
Page 52 1-48 Seats and Restraints Securing a Child Restraint Designed for the LATCH System CAUTION If a LATCH-type child restraint is not attached to anchors, the child restraint will not be able to protect the child correctly. In a crash, the child could be seriously injured or killed.
Page 53 Do not fold the empty rear seat with a safety belt buckled. This could damage the safety belt or the seat. Unbuckle and return the safety belt to its stowed position. 1. Attach and tighten the lower attachments to the lower anchors. If the child restraint does not have lower attachments or the desired seating position does not have...
Page 54: Replacing Latch System Parts After A Crash
1-50 Seats and Restraints If the position you are using has an adjustable headrest or head restraint and you are using a single tether, raise the headrest or head restraint and route the tether under the headrest or head restraint and in between the headrest or head restraint posts.
Page 55 Do not secure a child restraint in a position without a top tether anchor if a national or local law requires that the top tether be anchored, or if the instructions that come with the child restraint say that the top strap must be anchored.
Page 56 1-52 Seats and Restraints 4. Pull the rest of the shoulder belt all the way out of the retractor to set the lock. 5. To tighten the belt, push down on the child restraint, pull the shoulder portion of the belt to tighten the lap portion of the belt, and feed the shoulder belt back into the retractor.
Page 57: Securing Child Restraints (Right Front Seat)
Securing Child Restraints (Right Front Seat) Your vehicle has airbags. A rear seat is a safer place to secure a forward-facing child restraint. See Where to Put the Restraint on page 1-43. In addition, your vehicle has a passenger sensing system which is designed to turn off the right front passenger’s frontal and seat-mounted side impact airbag...
Page 58 1-54 Seats and Restraints Do not secure a child seat in a position without a top tether anchor if a national or local law requires that the top tether be anchored, or if the instructions that come with the child restraint say that the top strap must be anchored.
Page 59 6. To tighten the belt, push down on the child restraint, pull the shoulder portion of the belt to tighten the lap portion of the belt and feed the shoulder belt back into the retractor. If you are using a forward-facing child restraint, you may ﬁnd it helpful to use your knee to push down on the child restraint as you tighten the belt.
Page 60 1-56 Seats and Restraints NOTES...
Page 61: Keys
Keys, Doors and Windows Keys Keys ...2-2 Remote Keyless Entry (RKE) System ...2-3 Remote Keyless Entry (RKE) System Operation ...2-4 Doors and Locks Door Locks ...2-5 Power Door Locks ...2-5 Rear Door Security Locks ...2-6 Liftgate ...2-6 Keys, Doors and Windows Theft-Deterrent Systems ...2-7 Theft-Deterrent Systems...
Page 62: Keys, Doors And Windows
Keys, Doors and Windows Keys CAUTION Leaving children in a vehicle with the ignition key is dangerous for many reasons, children or others could be badly injured or even killed. They could operate the power windows or other controls or even make the vehicle move.
Page 63: Remote Keyless Entry (Rke) System
Keep this number in a safe place. If you lose your keys, you will be able to have one made easily using this number. If you need a new key, go to your dealer/retailer for the correct key code. Notice: If you ever lock your keys in the vehicle, you may have to damage the vehicle to get in.
Page 64: Remote Keyless Entry (Rke) System Operation
Keys, Doors and Windows Remote Keyless Entry (RKE) System Operation (Lock): Press to lock the doors, liftgate and fuel tank door. If the driver door is open, the doors will not lock. (Unlock): Press to unlock the doors, liftgate and fuel tank door. Press and hold to lower all the windows.
Page 65: Doors And Locks Door Locks
Doors and Locks Door Locks CAUTION Unlocked doors can be dangerous. • Passengers, especially children, can easily open the doors and fall out of a moving vehicle. When a door is locked, the handle will not open it. You increase the chance of being thrown out of the vehicle in a crash if the doors are not locked.
Page 66: Rear Door Security Locks
Keys, Doors and Windows Rear Door Security Locks Your vehicle has rear door security locks to prevent passengers from opening the rear doors from the inside. Open the rear doors to access the security locks on the inside edge of each door. To set the locks, insert a key into the slot and turn it to the horizontal position.
Page 67: Theft-Deterrent Systems
Notice: If you open the liftgate without checking for overhead obstructions such as a garage door, you could damage the liftgate or the liftgate glass. Always check to make sure the area above and behind the liftgate is clear before opening it. Press the touchpad located in the handle of the liftgate and lift up to open.
Page 68: Immobilizer Operation
Keys, Doors and Windows This device complies with RSS-210 of Industry Canada. Operation is subject to the following two conditions: 1. This device may not cause interference. 2. This device must accept any interference received, including interference that may cause undesired operation of the device.
Page 69: Content Theft-Deterrent
Content Theft-Deterrent This vehicle has a content theft-deterrent alarm system. The security light is located on the instrument panel. Do not use this system if there are people in the vehicle. The doors can not be unlocked from inside the vehicle.
Page 70: Windows
2-10 Keys, Doors and Windows Windows CAUTION Leaving children, helpless adults, or pets in a vehicle with the windows closed is dangerous. They can be overcome by the extreme heat and suffer permanent injuries or even death from heat stroke. Never leave a child, a helpless adult, or a pet alone in a vehicle, especially with the...
Page 71: Sun Visors
The window switches are located on each of the doors. To lower a window, press the switch down. To raise a window, pull the switch up. Keys, Doors and Windows Express-Down Window This feature is on all windows. It allows you to lower the window all the way without holding the switch down.
Page 72: Manual Rearview Mirror
2-12 Keys, Doors and Windows Mirrors Manual Rearview Mirror Hold the mirror in the center to move it for a clearer view of behind your vehicle. Headlamp Glare To reduce headlamp glare from vehicles following from behind, pull the lever toward you. Push the lever forward after the vehicle glare is gone, to return the mirror back to the original position.
Page 73: Sunroof
Outside Heated Mirrors The vehicle may have outside heated mirrors which help clear the condensation, snow, and ice. < (Rear Window Defogger): Press to heat the mirrors. See “Rear Window Defogger” under, Climate Control System on page 7-1 for more information. Keys, Doors and Windows Sunroof On vehicles with a sunroof, the...
Page 74 2-14 Keys, Doors and Windows NOTES...
Page 75: Storage
Storage Storage Glove Box ...3-1 Cupholders ...3-1 Cargo Cover ...3-1 Cargo Tie Downs ...3-1 Storage Glove Box Pull up on the handle to open the glovebox. There may be a shelf inside that can be removed by lifting up on the shelf and pulling it out. Cupholders There is a cupholder on the front edge of the rear seat cushion.
Page 76 Storage NOTES...
Page 77: Instruments And Controls
Instruments and Controls Instrument Panel Overview Instrument Panel Overview ...4-2 Hazard Warning Flashers ...4-4 Horn ...4-4 Tilt Wheel ...4-4 Turn Signal/Multifunction Lever ...4-4 Cruise Control ...4-5 Turn and Lane-Change Signals ...4-8 Headlamp High/Low-Beam ...4-8 Changer Flash-to-Pass ...4-8 Windshield Wipers ...4-9 Windshield Washer ...4-10 Rear Window Wiper/...
Page 78: Instruments And
Instruments and Controls Instrument Panel Overview...
Page 79 The main components of the instrument panel are the: A. Exterior Lamps Controls on page 5-1. B. Outlets. Outlet Adjustment on page 7-4. C. Turn Signal/Multifunction Lever on page 4-4. D. DIC Operation and Displays (Base Level DIC and Audio) on page 4-27 or DIC Operation and Displays (Uplevel DIC and Audio) on page 4-31 and...
Page 80: Hazard Warning Flashers
Instruments and Controls Hazard Warning Flashers : Press this button located on the instrument panel, to make the front and rear turn signal lamps ﬂash on and off. This warns others that you are having trouble. Press the button again to turn the ﬂashers off. While the hazard warning ﬂashers are on, the turn signals do not work.
Page 81: Cruise Control
Cruise Control CAUTION Cruise control can be dangerous where you cannot drive safely at a steady speed. So, do not use your cruise control on winding roads or in heavy traffic. Cruise control can be dangerous on slippery roads. On such roads, fast changes in tire traction can cause excessive wheel slip, and you could lose control.
Page 82 Instruments and Controls Setting Cruise Control For safety reasons the cruise control cannot be turned on until the brake has been applied once. With automatic transmission, only use cruise control in DRIVE (D). Press the On/Off button to turn on the cruise control.
Page 83 Resuming a Set Speed Once the vehicle speed reaches about 25 mph (40 km/h) or more and the cruise control is on, press The vehicle returns to the previous speed selected before the cruise was disengaged. The stored speed is deleted if the ignition is turned off.
Page 84: Turn And Lane-Change Signals
Instruments and Controls Turn and Lane-Change Signals The turn signal has two upward and downward positions to signal a turn or a lane change. To signal a turn, move the lever all the way up or down, past the detent. The lever returns to its starting position when released.
Page 85: Windshield Wipers
Windshield Wipers Clear ice and snow from the wiper blades before using them. If the wiper blades are frozen to the windshield, gently loosen or thaw them. If the blades do become damaged, install new blades or blade inserts. See Windshield Wiper Blade Replacement on page 9-21.
Page 86: Climate Controls
4-10 Instruments and Controls Windshield Washer CAUTION In freezing weather, do not use your washer until the windshield is warmed. Otherwise the washer ﬂuid can form ice on the windshield, blocking your vision. Pull the windshield wiper lever toward you to spray washer ﬂuid on the windshield.
Page 87: Warning Lights, Gages, And Indicators
Notice: Adding any electrical equipment to your vehicle may damage it or keep other components from working as they should. The repairs would not be covered by your warranty. Check with your dealer/retailer before adding electrical equipment. When adding electrical equipment, be sure to follow the installation instructions included with the equipment.
Page 88: Instrument Panel Cluster
4-12 Instruments and Controls Instrument Panel Cluster The instrument cluster is designed to let you know at a glance how the vehicle is running. You will know how fast you are going, about how much fuel you have used, and many other things you will need to know to drive safely and economically.
Page 89: Speedometer And Odometer
“INSP” is the 4-13 remaining distance that can be driven until service is required. See Engine Oil Life System on page 9-9 and the index of the Saturn Astra Limited Warranty, Maintenance and Owner Assistance Information Manual. Tachometer The tachometer displays the engine speed in revolutions per minute.
Page 90: Safety Belt Reminders
4-14 Instruments and Controls Safety Belt Reminders Driver Safety Belt Reminder Light There is a Driver Safety Belt Reminder Light on the instrument panel cluster. When the engine is started this light and chime will come on and stay on for several seconds to remind people to fasten their safety belts.
Page 91: Passenger Airbag Status Indicator
If the airbag readiness light stays on after you start the vehicle or comes on when your are driving, your airbag system may not work properly. Have your vehicle serviced right away. CAUTION If the airbag readiness light stays on after the vehicle is started, it means the airbag system may not be working properly.
Page 92 4-16 Instruments and Controls If the word ON or the on symbol is lit on the passenger airbag status indicator, it means that the right front passenger’s frontal airbag and seat-mounted side impact airbag are enabled (may inﬂate). CAUTION If the on indicator comes on when you have a rear-facing child restraint installed in the right front passenger’s seat,...
Page 93: Charging System Light
If, after several seconds, both status indicator lights remain on, or if there are no lights at all, there may be a problem with the lights or the passenger sensing system. See your dealer/retailer for service. CAUTION If the airbag readiness light in the instrument panel cluster ever comes on and stays on, it means that something may be...
Page 94: Antilock Brake System (Abs) Warning Light
4-18 Instruments and Controls If the light comes on while driving, a chime will sound. Pull off the road and stop. The pedal might be harder to push or go closer to the ﬂoor. It might also take longer to stop. If the light is still on, have the vehicle towed for service.
Page 95: Stabilitrak Indicator Light
® StabiliTrak Indicator Light For vehicles with this light, it should come on brieﬂy when the ignition is turned on. If the light does not come on, have it ﬁxed so it will be ready to warn if there is a problem. If the light stays on, or comes on while driving there may be a problem with the StabiliTrak system and your...
Page 96: Malfunction Indicator Lamp
4-20 Instruments and Controls Stop and check the tires as soon as it is safe to do so. If underinﬂated, inﬂate to the proper pressure. See Tires on page 9-38 for more information. This light ﬂashes for approximately one minute and then stays on when the system detects a malfunction.
Page 97 This light comes on during a malfunction in one of two ways: Light Flashing: A misﬁre condition has been detected. A misﬁre increases vehicle emissions and could damage the emission control system on the vehicle. Diagnosis and service might be required. The following can prevent more serious damage to the vehicle: •...
Page 98: Oil Pressure Light
4-22 Instruments and Controls Emissions Inspection and Maintenance Programs Some state/provincial and local governments have or might begin programs to inspect the emission control equipment on your vehicle. Failure to pass this inspection could prevent getting a vehicle registration. Here are some things to know to help the vehicle pass an inspection: •...
Page 99: Low Oil Level Light
Low Oil Level Light This light should come on brieﬂy when the ignition is turned on as a check to let you know that the light is working. If this light comes on and stays on while the engine is running, it means your engine is low on oil.
Page 100: Exterior Lamps Off
4-24 Instruments and Controls Exterior Lamps Off Reminder This light comes on whenever the exterior lights are off. See Exterior Lamps Controls on page 5-1 for more information. Cruise Control Light This light comes on whenever you set the cruise control. The light goes out when the cruise control is turned off or disengaged.
Page 101: Fuel Gage
Fuel Gage Your fuel gage tells you about how much fuel you have left, when the ignition is on. When the indicator nears empty, the low fuel warning light will come on. You still have a little fuel left, but you should get more soon. See Low Fuel Warning Light on page 4-25 for more information.
Page 102: Driver Information Center (Dic)
4-26 Instruments and Controls Driver Information Center (DIC) Vehicles with a Driver Information Center (DIC) can display: • Time • Outside temperature • Date or audio system, if it is turned on • Trip computer, on vehicles with this feature •...
Page 103: Dic Operation And Displays (Base Level Dic And Audio)
DIC Operation and Displays (Base Level DIC and Audio) CD 30 with MP3 Player shown, without MP3 Player similar If the vehicle has the base level DIC, the following information explains how the system works. Instruments and Controls Selecting Functions Functions and settings of some equipment can be accessed through the DIC.
Page 104 4-28 Instruments and Controls On some vehicles, if a warning message appears, the display is blocked from other functions. See DIC Warnings and Messages (Base and Uplevel Systems) on page 4-37 for information on acknowledging the message. System Settings To enter the Settings menu: 1.
Page 105 Trip Computer The vehicle may have a trip computer. The trip computer provides information on driving data. This information is continually recorded and evaluated electronically. If power has been interrupted or if the battery voltage has dropped too low, the values stored in the trip computer will be lost.
Page 106 4-30 Instruments and Controls Average Speed This display shows the average speed of the vehicle in miles per hour (mph) or kilometers per hour (km/h). This average is calculated based on the various vehicle speeds recorded since the last reset of this value. The measurement can be reset to zero at any time and restarted.
Page 107: Dic Operation And Displays (Uplevel Dic And Audio)
Reset The following trip computer information can be reset: • Average consumption • Trip consumption • Average speed • Distance travelled To reset the value: 1. Select the desired trip computer information. 2. Press the OK button on the audio system, or press the left thumbwheel, if your vehicle has this feature, on the steering wheel:...
Page 108 4-32 Instruments and Controls On some vehicles, menu options can be selected with the multifunction knob on the audio system: 1. Turn the multifunction knob until the desired menu item is highlighted. 2. Press the multifunction knob to select the menu item. To exit a menu, turn the multifunction knob clockwise or counterclockwise to “Return”...
Page 109 System Settings To enter the Settings menu, do one of the following: • Press MAIN, if your vehicle has this feature, on the audio system. • Press the SETTINGS button on the audio system. The Settings menu will appear. The functions are displayed in the following order: 1.
Page 110: Lighting
4-34 Instruments and Controls Day / Night The vehicle may have this feature. The display can be adjusted to best match the lighting conditions. To adjust this setting: 1. Select Day / Night from the Settings menu. The available options are displayed: •...
Page 111 For example, if driving in traffic and making frequent stops, this display may read one number, but if the vehicle is driven on a freeway, the number may change even though the same amount of fuel is in the fuel tank. This is because different driving conditions produce different fuel economies.
Page 112 4-36 Instruments and Controls Average Consumption This display shows the approximate average miles per gallon (mpg) or liters per 100 kilometers (l/100 km). This number is calculated based on the number of mpg (l/100 km) recorded since the last time this menu item was reset.
Page 113: Dic Warnings And Messages (Base And Uplevel Systems)
DIC Warnings and Messages (Base and Uplevel Systems) Messages are displayed on the DIC to notify the driver that the status of the vehicle has changed and that some action may be needed by the driver to correct the condition. Multiple messages may appear one after another.
Page 114: Onstar System
4-38 Instruments and Controls Brakelight switch check This message displays when the brake lamp does not come on when the brake is applied. Have your vehicle serviced by your dealer/retailer immediately. Coolant level check This message displays when the engine coolant level is low. Have the cooling system serviced by your dealer/retailer as soon as possible.
Page 115 OnStar service is provided to you subject to the OnStar Terms and Conditions. You may cancel your OnStar service at any time by contacting OnStar. A complete OnStar Owner’s Guide and the OnStar Terms and Conditions are included in the vehicle’s OnStar Subscriber glove box literature.
Page 116 4-40 Instruments and Controls Available Services included with Directions & Connections Plan • All Safe and Sound Plan Services • Driving Directions - Advisor delivered or OnStar Turn-by-Turn Navigation (If equipped) • RideAssist • Information and Convenience Services OnStar Hands-Free Calling OnStar Hands-Free Calling allows eligible OnStar subscribers to make and receive calls using voice...
Page 117 OnStar service cannot work unless your vehicle is in a place where OnStar has an agreement with a wireless service provider for service in that area. OnStar service also cannot work unless you are in a place where the wireless service provider OnStar has hired for that area has coverage, network capacity and reception when the service is...
Page 118 4-42 Instruments and Controls NOTES...
Page 119 Lighting Lighting Exterior Lamps Controls ...5-1 Daytime Running Lamps (DRL) ...5-2 Delayed Headlamps ...5-2 Fog Lamps ...5-2 Instrument Panel ...5-3 Brightness Dome Lamp(s) ...5-3 Entry Lighting ...5-3 Reading Lamps ...5-3 Rear Compartment Lamp ...5-4 Battery Run-Down Protection ...5-4 Lighting Exterior Lamps Controls The exterior lamp control is located on the instrument panel to the left of the steering wheel.
Page 120: Daytime Running Lamps (Drl)
Lighting Daytime Running Lamps (DRL) Daytime Running Lamps (DRL) can make it easier for others to see the front of your vehicle during the day. DRL can be helpful in many different driving conditions, but they can be especially helpful in the short periods after dawn and before sunset.
Page 121: Instrument Panel Brightness
Instrument Panel Brightness (Instrument Panel Brightness): The knob with this symbol on it is located next to the exterior lamps control to the left of the steering wheel. Push the knob in all the way until it extends out and then turn the knob clockwise or counterclockwise to brighten or dim the lights.
Page 122: Rear Compartment Lamp
Lighting Rear Reading Lamps The rear seat reading lamps can be turned on while the ignition is on. (Off): Press to turn the lamp off. (On): Press to turn the lamp on. Rear Compartment Lamp The liftgate lamp turns on when the liftgate is opened and turns off when the liftgate is closed.
Page 123: Infotainment
Infotainment Audio System(s) Audio System(s) ...6-1 Radio(s) ...6-2 Theft-Deterrent Feature ...6-24 Audio Steering Wheel Controls ...6-24 Radio Reception ...6-25 ...6-25 Fixed Mast Antenna Audio System(s) Determine which audio system the vehicle has and then read the following pages to become familiar with its features.
Page 124 Infotainment Radio(s) CD 30 MP3 Shown, CD 30 Similar System Operation (Volume/Power): Press to turn the system on or off. Turn to increase or decrease the volume. BC (Board Computer): Press to use the Board Computer. See DIC Operation and Displays (Base Level DIC and Audio) on page 4-27 or DIC Operation and Displays (Uplevel DIC and Audio) on page 4-31.
Page 125 The Ignition Logic is preset to turn off the audio system when the ignition is turned off. To enable or disable Ignition Logic: 1. Press SETTINGS until Audio displays. 2. Press until System displays. 3. Press OK until Ign. Logic ON or Ign.
Page 126 Infotainment Audio displays and the audio system starts to play if SETTINGS, FM/AM, CD/MP3, or BC is not pressed within ﬁve seconds after the setting is saved. To adjust the Treble: 1. Press SOUND until Treble appears. 2. Press to adjust the level from -12 through +12.
Page 127 Adjusting the Speakers (Balance/Fade) To adjust the Balance using the SOUND button: 1. Press SOUND until Balance appears. 2. Press to adjust the level from -12 through +12. The setting is saved automatically. • Press SETTINGS again to go back one level in the menu. •...
Page 128 Infotainment ® OnStar Volume For vehicles with OnStar, the OnStar Volume is used to set the maximum initial volume level for the OnStar system when it is turned on. To set OnStar Volume: 1. Press SETTINGS until Audio appears. 2. Press OK until OnStar Vol. appears.
Page 129 Finding an FM/AM Station 1 - 9 (Station Preset Buttons): Press to play stations that are programmed to the radio preset pushbuttons. SCN (Station Preset Scan): Press to start station preset scan. The radio goes to the ﬁrst preset station, plays for a few seconds, then goes to the next preset station.
Page 130 Infotainment Radio stations can be stored manually, and by using Autostore. To manually store preset stations: 1. Select FM or AM and tune to the desired radio station. 2. Press and hold one of the nine station preset buttons, the radio brieﬂy mutes and displays the previously stored station.
Page 131 Random: Press CD/MP3 three times to hear the tracks in random, rather than sequential order. Press to select between Random on and Random off. RDM shows on the display when random is in use. Using an MP3 CD The CD 30 MP3 is capable of playing MP3 CDs that have been recorded to a CD-R.
Page 132 6-10 Infotainment Random Mode MP3 CD can be played in the following random modes: • Random album: Tracks from the selected album are played randomly. • Random CD: All tracks from all albums are played randomly. • Random Off: Turns off random play.
Page 133 System Operation (Volume/Power): Press to turn the system on or off. Turn to increase or decrease the volume. BC (Board Computer): Press to use the Board Computer, see DIC Warnings and Messages (Base and Uplevel Systems) on page 4-37. CDC 40 (Multifunction Knob): Turn to select a menu item, press to enable or disable a menu item.
Page 134 6-12 Infotainment The Ignition Logic is preset to turn off the audio system when the ignition is turned off. To enable or disable Ignition Logic: 1. Press SETTINGS, System Settings displays. 2. Turn the multifunction knob to select Ign. Logic and press the multifunction knob to select or un-select the option.
Page 135 Menus The menus of the audio systems are structured in levels. The current menu level is indicated by vertical lines at the edge of the screen. Selecting from a Menu The items within a menu are selected by turning the multifunction knob to move the cursor.
Page 136 6-14 Infotainment Overlay Menus Additional notes and information on the audio system or other vehicle components may appear on the display as an overlay in some cases. The current menu is overlaid with the information box. Some settings have to be conﬁrmed, others are automatically enabled after a short time.
Page 137 Adjusting the Sound Settings There are preset sound settings designed for different types of music. To adjust the sound settings: 1. Press SOUND and select the Sound menu item. 2. Select Sound. 3. Select: User, Jazz, Speech, Pop, Classical, and Rock. 4.
Page 138 6-16 Infotainment Speed-Dependant Volume Control (SDVC) SDVC automatically adjusts the volume for road and wind noise as the vehicle increases or decreases speed while driving. To adjust SDVC: 1. Press SOUND, then SETTINGS and select Volume from the menu. 2. Select SDVC. 3.
Page 139 Using the Radio FM/AM: Press to select between FM, FM-AS, AM, and AM-AS, or to listen to the radio while a CD is playing. The Tuner Menu displays. LOC (LOCAL/DX Function): Press to change between LOC ON or LOC OFF. When the LOC function is on, it searches for the strongest radio frequency.
Page 140 6-18 Infotainment Setting Preset Stations The radio can store up to 36 stations using the station preset buttons: • 9 FM • 9 FM - AS (Autostore) • 9 AM • 9 AM - AS (Autostore) Radio stations can be stored using the station preset buttons, the multifunction knob, and by using Autostore.
Page 141 Display Options The display can be changed depending on what type of CD is in the CD player. The display options are: • Disabled ( ): Track number, CD number, album number and playing time for an audio CD. • Enabled ( ): CD name, track name, artist name,...
Page 142 6-20 Infotainment Selecting CD CDs can be selected by: • Pressing the appropriate station preset button. • Pressing on the four-way switch. • Using the CD menu function. To use the CD menu function: 1. Select CD from the CD menu. 2.
Page 143 Scan CD The Scan CD function scans the ﬁrst ten seconds of each track on the current CD. The function can be enabled and disabled by using the four-way switch or the CD menu. To use Scan CD using the four-way switch: 1.
Page 144 6-22 Infotainment Playing an MP3 or Mixed Mode CD CDC: Press to play an MP3 CD that is already loaded into the CD player while the radio is playing. The CD Menu displays. Selecting a Track Tracks can be selected using the four-way switch or the CD menu functions.
Page 145 Tracks play in the following order for Random play CD: • MP3 CD: If there are ﬁve or fewer albums on an MP3 CD, four tracks per album are played in random order. If there are more than ﬁve albums on the MP3 CD, one track is played per album.
Page 146: Audio Steering Wheel Controls
6-24 Infotainment Care of the CD Player Do not add labels to a CD, it could get caught in the CD player. Use a marking pen to write on the top of the CD if a description is needed. Do not use CD lens cleaners, they could damage the CD player.
Page 147: Radio Reception
: Press to toggle between the radio and CD or MP3 as an active source for playback. : Press the arrows to go back or advance to the previous or next preset station if playing the radio. Press and hold to scroll through the preset stations.
Page 148 6-26 Infotainment NOTES...
Page 149: Climate Control System
Climate Controls Climate Controls Climate Control System ...7-1 Outlet Adjustment ...7-4 Climate Controls Climate Control System The heating, cooling, and ventilation for the vehicle can be controlled with this system. Operation The air delivery mode or fan speed can be manually adjusted. Climate Controls Air Delivery Mode Knob To change the current air delivery...
Page 150 Climate Controls (Vent): This mode directs air to the instrument panel outlets. (Defog): This mode directs air to the windshield and front door windows. To reduce fogging, press to turn on the air conditioner. The fan must also be on. (Defog/Floor): This mode directs air to the windshield, front door windows, and ﬂoor outlets.
Page 151 For quicker cool down, do the following: 1. Press to turn on the air conditioning. 2. Select mode. 3. Set the temperature knob to the coldest temperature. 4. Set the fan knob to 4. 5. Open all vents. Recirculation (Recirculation): Press to turn the recirculation mode on or off.
Page 152: Outlet Adjustment
Climate Controls Outlet Adjustment Use the thumbwheel below the air outlets to change the direction of the air ﬂow. Use the vertical thumbwheel next to the outlets to control the amount of air ﬂow or to shut off the airﬂow completely. Keep all outlets open whenever possible for best system performance.
Page 153 Driving and Operating Starting and Operating Your Vehicle New Vehicle Break-In ...8-2 Ignition Positions ...8-2 Retained Accessory Power (RAP) ...8-3 Starting the Engine ...8-3 Engine Heater ...8-4 Automatic Transmission Operation ...8-5 Manual Transmission Operation ...8-9 Parking Brake ...8-10 ...8-11 Shifting Into Park Shifting Out of Park ...8-13 Parking the Vehicle...
Page 154: Driving And Operating
Driving and Operating Starting and Operating Your Vehicle New Vehicle Break-In Notice: Your vehicle does not need an elaborate break-in. But it will perform better in the long run if you follow these guidelines: • Do not drive at any one constant speed, fast or slow, for the ﬁrst 500 miles (805 km).
Page 155: Retained Accessory Power (Rap)
B (STEERING UNLOCKED/ IGNITION OFF): This position unlocks the steering wheel. C (ON/RUN): The ignition switch stays in this position when the engine is running. This position can be used to operate the electrical accessories, as well as to display some warning and indicator lights.
Page 156: Engine Heater
Driving and Operating Your vehicle has a Computer-Controlled Cranking System. This feature assists in starting the engine and protects components. If the ignition key is turned to the START position, and then released when the engine begins cranking, the engine will continue cranking for a few seconds or until the vehicle starts.
Page 157: Automatic Transmission Operation
To Use the Engine Heater 1. Turn off the engine. 2. The engine heater connector is located in the passenger side lower front grille. Open the cover and insert the 110-volt AC adapter delivered in the vehicles glove box. 3. Plug the other end of the adapter into a grounded 110-volt AC outlet.
Page 158 Driving and Operating PARK (P): This position locks the front wheels. It is the best position to use when the engine is started because your vehicle cannot move easily. CAUTION It is dangerous to get out of your vehicle if the shift lever is not fully in PARK (P) with the parking brake ﬁrmly set.
Page 159 Notice: Shifting out of P (Park) or N (Neutral) with the engine running at high speed may damage the transmission. The repairs would not be covered by the vehicle warranty. Be sure the engine is not running at high speed when shifting the vehicle. DRIVE (D): This position is for normal driving.
Page 160 Driving and Operating Winter Driving Mode This feature helps you accelerate in slippery driving conditions by using THIRD (3) gear when you begin to accelerate from a stopped position. The winter driving mode button is located on the center console. Press once to turn on the winter driving mode feature.
Page 161: Manual Transmission Operation
When you release the brake with the transmission in gear, you may feel the transmission shift from Neutral to Drive automatically. You may also feel the transmission shift from Drive to Neutral when the brake is applied. This is normal operation of the automatic transmission.
Page 162: Parking Brake
8-10 Driving and Operating If reverse gear does not engage, set the selector lever in neutral, and release the clutch pedal. Press the clutch pedal again and repeat the gear selection. Notice: Shifting to R (Reverse) while the vehicle is moving forward could damage the transmission.
Page 163: Shifting Into Park
A warning chime will sound and a brake warning light located on the instrument panel cluster will come on, if the parking brake is set, the ignition is on and the vehicle speed is greater than 5 mph (8 km/h). Notice: Driving with the parking brake on can overheat the brake system and cause...
Page 164 8-12 Driving and Operating Leaving Your Vehicle with the Engine Running CAUTION It can be dangerous to leave the vehicle with the engine running. The vehicle could move suddenly if the shift lever is not fully in P (Park) with the parking brake ﬁrmly set.
Page 165: Shifting Out Of Park
Shifting Out of Park This vehicle has an electronic shift lock release system. The shift lock release is designed to: • Prevent ignition key removal unless the shift lever is in PARK (P) with the shift lever button fully released. •...
Page 166: Engine Exhaust
8-14 Driving and Operating Engine Exhaust CAUTION Engine exhaust can kill. It contains the gas carbon monoxide (CO), which you cannot see or smell. It can cause unconsciousness and death. You might have exhaust coming in if: • The exhaust system sounds strange or different.
Page 167 CAUTION (Continued) Also, idling in a closed-in place can let deadly carbon monoxide (CO) into your vehicle even if the climate control fan is at the highest setting. One place this can happen is a garage. Exhaust — with CO — can come in easily.
Page 168: Driving Your Vehicle Defensive Driving
8-16 Driving and Operating Driving Your Vehicle Defensive Driving Defensive driving means “always expect the unexpected.” The ﬁrst step in driving defensively is to wear your safety belt, see Safety Belts on page 1-8. CAUTION Assume that other road users (pedestrians, bicyclists, and other drivers) are going to be careless and make mistakes.
Page 169: Control Of A Vehicle
Medical research shows that alcohol in a person’s system can make crash injuries worse, especially injuries to the brain, spinal cord, or heart. This means that when anyone who has been drinking — driver or passenger — is in a crash, that person’s chance of being killed or permanently disabled is higher than if the person had not been drinking.
Page 170: Antilock Brake System (Abs)
8-18 Driving and Operating If your vehicle’s engine ever stops while you are driving, brake normally but do not pump the brakes. If you do, the pedal could get harder to push down. If the engine stops, you will still have some power brake assist.
Page 171: Stabilitrak System
Remember: ABS does not change the time you need to get your foot up to the brake pedal or always decrease stopping distance. If you get too close to the vehicle in front of you, you will not have time to apply the brakes if that vehicle suddenly slows or stops.
Page 172 8-20 Driving and Operating It is recommended to leave the system on for normal driving conditions, but it may be necessary to turn the system off if your vehicle is stuck in sand, mud, ice or snow, and you want to “rock” your vehicle to attempt to free it.
Page 173 Steering Tips It is important to take curves at a reasonable speed. A lot of the “driver lost control” accidents mentioned on the news happen on curves. Here is why: Experienced driver or beginner, each of us is subject to the same laws of physics when driving on curves.
Page 174: Off-Road Recovery
8-22 Driving and Operating Steering in Emergencies There are times when steering can be more effective than braking. For example, you come over a hill and ﬁnd a truck stopped in your lane, or a car suddenly pulls out from nowhere, or a child darts out from between parked cars and stops right in front of you.
Page 175: Passing
Turn the steering wheel 3 to 5 inches (about one-eighth turn) until the right front tire contacts the pavement edge. Then turn the steering wheel to go straight down the roadway. Passing Passing another vehicle on a two-lane road can be dangerous. To reduce the risk of danger while passing: •...
Page 176: Driving At Night
8-24 Driving and Operating If your vehicle starts to slide, ease your foot off the accelerator pedal and quickly steer the way you want the vehicle to go. If you start steering quickly enough, your vehicle may straighten out. Always be ready for a second skid if it occurs.
Page 177: Driving In Rain And On Wet Roads
Driving in Rain and on Wet Roads Rain and wet roads can reduce vehicle traction and affect your ability to stop and accelerate. Always drive slower in these types of driving conditions and avoid driving through large puddles and deep-standing or ﬂowing water. CAUTION Wet brakes can cause crashes.
Page 178: Before Leaving On A Long Trip
8-26 Driving and Operating Before Leaving on a Long Trip To prepare your vehicle for a long trip, consider having it serviced by your dealer/retailer before departing. Things to check on your own include: • Windshield Washer Fluid: Reservoir full? Windows clean —...
Page 179: Winter Driving
CAUTION Coasting downhill in N (Neutral) or with the ignition off is dangerous. The brakes will have to do all the work of slowing down and they could get so hot that they would not work well. You would then have poor braking or even none going down a hill.
Page 180 8-28 Driving and Operating You can get wet ice when it is about freezing, 32°F (0°C), and freezing rain begins to fall. Try to avoid driving on wet ice until salt and sand crews can get there. Whatever the condition — smooth ice, packed, blowing, or loose snow —...
Page 181: If Your Vehicle Is Stuck In Sand, Mud, Ice, Or Snow
CAUTION Snow can trap exhaust gases under your vehicle. This can cause deadly CO (carbon monoxide) gas to get inside. CO could overcome you and kill you. You cannot see it or smell it, so you might not know it is in your vehicle. Clear away snow from around the base of your vehicle, especially any that is blocking the exhaust...
Page 182: Rocking Your Vehicle To Get It Out
8-30 Driving and Operating Rocking Your Vehicle to Get It Out First, turn the steering wheel left and right to clear the area around the front wheels. Turn off any stability ® system. See StabiliTrak System on page 8-19. Then shift back and forth between REVERSE (R) and a forward gear, or with a manual transmission, between FIRST (1) or...
Page 183 CAUTION Do not load the vehicle any heavier than the Gross Vehicle Weight Rating (GVWR), or either the maximum front or rear Gross Axle Weight Rating (GAWR). If you do, parts on the vehicle can break, and it can change the way your vehicle handles.
Page 184 8-32 Driving and Operating Steps for Determining Correct Load Limit Locate the statement “The combined weight of occupants and cargo should never exceed XXX kg or XXX lbs” on your vehicle placard. Determine the combined weight of the driver and passengers that will be riding in your vehicle.
Page 185 Example 2 Vehicle Capacity Weight for Example 2 = 1,000 lbs (453 kg). Subtract Occupant Weight 150 lbs (68 kg) × 5 = 750 lbs (340 kg). Available Cargo Weight = 250 lbs (113 kg). Example 3 Vehicle Capacity Weight for Example 3 = 1,000 lbs (453 kg).
Page 186 8-34 Driving and Operating The GVWR includes the weight of the vehicle, all occupants, fuel, and cargo. Never exceed the GVWR for your vehicle, or the Gross Axle Weight Rating (GAWR) for either the front or rear axle. And, if you do have a heavy load, you should spread it out.
Page 187: Fuel
Fuel Use of the recommended fuel is an important part of the proper maintenance of your vehicle. To help keep the engine clean and maintain optimum vehicle performance, we recommend the use of gasoline advertised as TOP TIER Detergent Gasoline. Gasoline Octane Use regular unleaded gasoline with a posted octane rating of 87 or...
Page 188: Additives
8-36 Driving and Operating Additives To provide cleaner air, all gasolines in the United States are now required to contain additives that help prevent engine and fuel system deposits from forming, allowing the emission control system to work properly. In most cases, you should not have to add anything to the fuel.
Page 189: Filling The Tank
Filling the Tank CAUTION Fuel vapor burns violently and a fuel ﬁre can cause bad injuries. To help avoid injuries to you and others, read and follow all the instructions on the pump island. Turn off your engine when you are refueling.
Page 190: Filling A Portable Fuel Container
8-38 Driving and Operating When replacing the fuel cap, turn it clockwise until it clicks. Make sure the cap is fully installed. The diagnostic system can determine if the fuel cap has been left off or improperly installed. This would allow fuel to evaporate into the atmosphere.
Page 191: Vehicle Service And Care
Vehicle Service and Care Service Service ...9-2 Accessories and Modiﬁcations ...9-3 California Proposition 65 Warning ...9-3 California Perchlorate Materials Requirements ...9-3 Doing Your Own Service Work ...9-4 Adding Equipment to the Outside of the Vehicle ...9-4 Owner Checks Owner Checks ...9-5 Hood Release ...9-5...
Page 192 Underbody Maintenance ...9-79 Chemical Paint Spotting ...9-79 Vehicle Care/Appearance Materials ...9-80 Service For service and parts needs, visit your dealer/retailer. You will receive genuine Saturn parts and Saturn-trained and supported service people. Genuine Saturn parts have one of these marks.
Page 193: Accessories And Modiﬁcations
Accessories and Modiﬁcations When non-dealer/non-retailer accessories are added to your vehicle they can affect your vehicle’s performance and safety, including such things as, airbags, braking, stability, ride and handling, emissions systems, aerodynamics, durability, and electronic systems like antilock brakes, traction control and stability control.
Page 194: Doing Your Own Service Work
Vehicle Service and Care Doing Your Own Service Work CAUTION You can be injured and your vehicle could be damaged if you try to do service work on a vehicle without knowing enough about it. • Be sure you have sufficient knowledge, experience, the proper replacement parts, and tools before you attempt any...
Page 195: Owner Checks
Owner Checks CAUTION An electric fan under the hood can start up and injure you even when the engine is not running. Keep hands, clothing, and tools away from any underhood electric fan. CAUTION Things that burn can get on hot engine parts and start a ﬁre.
Page 196: Engine Compartment Overview
Vehicle Service and Care Engine Compartment Overview When you open the hood, this is what you will see:...
Page 197: Engine Oil
A. Engine Air Cleaner/Filter on page 9-11. B. Engine Oil Fill Cap. Engine Oil on page 9-7. C. Brake Fluid Reservoir. Brakes on page 9-22. D. Coolant Reservoir. Cooling System on page 9-16. E. Coolant Reservoir Pressure Cap. Pressure Cap on page 9-15. F.
Page 198 Vehicle Service and Care When to Add Engine Oil If the oil is below the MIN (minimum) mark, add at least one quart/liter of the recommended oil. This section explains what kind of oil to use. For engine oil crankcase capacity, see Capacities and Speciﬁcations on page 10-2.
Page 199: Engine Oil Life System
• American Petroleum Institute (API) starburst symbol Oils meeting these requirements should have the starburst symbol on the container. This symbol indicates that the oil has been certiﬁed by the American Petroleum Institute (API). Notice: Use only engine oil identiﬁed as meeting GM Standard GM6094M and showing the American Petroleum Institute Certiﬁed For Gasoline Engines...
Page 200 9-10 Vehicle Service and Care How to Reset the Engine Oil Life System The Engine Oil Life System calculates when to change the engine oil and ﬁlter based on vehicle use. Whenever the oil is changed, reset the system so it can calculate when the next oil change is required.
Page 201: Engine Air Cleaner/Filter
Engine Air Cleaner/Filter See Engine Compartment Overview on page 9-6 for the location of the engine air cleaner/ﬁlter. When to Inspect the Engine Air Cleaner/Filter Inspect the air cleaner/ﬁlter at the Maintenance II intervals and replace it at the ﬁrst oil change after each 50,000 mile (83 000 km) interval.
Page 202: Automatic Transmission Fluid
9-12 Vehicle Service and Care Automatic Transmission Fluid It is not necessary to check the transmission ﬂuid level. A transmission ﬂuid leak is the only reason for ﬂuid loss. If a leak occurs, take your vehicle to the dealer/retailer service department and have it repaired as soon as possible.
Page 203 A 50/50 mixture of clean, drinkable ® water and DEX-COOL coolant will: • Give freezing protection down to −34°F (−37°C). • Give boiling protection up to 265°F (129°C). • Protect against rust and corrosion. • Help keep the proper engine temperature.
Page 204 9-14 Vehicle Service and Care Checking Coolant The coolant reservoir is located in the engine compartment on the driver’s side of the vehicle. See Engine Compartment Overview on page 9-6 for more information on location. CAUTION Turning the coolant reservoir pressure cap when the engine and radiator are hot can allow steam and scalding liquids to...
Page 205: Pressure Cap
Pressure Cap Notice: If the pressure cap is not tightly installed, coolant loss and possible engine damage may occur. Be sure the cap is properly and tightly secured. See Engine Compartment Overview on page 9-6 for more information on location. Engine Overheating There is an engine coolant temperature warning light on...
Page 206: Cooling System
9-16 Vehicle Service and Care If you get the engine coolant temperature warning with no sign of steam, try this for a minute or so: 1. If your air conditioner is on, turn it off. 2. In heavy traffic, let the engine idle in N (NEUTRAL) while stopped.
Page 207 CAUTION An electric engine cooling fan under the hood can start up even when the engine is not running and can cause injury. Keep hands, clothing, and tools away from any underhood electric fan. If the coolant inside the coolant reservoir is boiling, do not do anything else until it cools down.
Page 208 9-18 Vehicle Service and Care How to Add Coolant to the Coolant Reservoir Notice: This vehicle has a speciﬁc coolant ﬁll procedure. Failure to follow this procedure could cause the engine to overheat and be severely damaged. If you have not found a problem yet, check to see if coolant is visible in the coolant reservoir.
Page 209 CAUTION You can be burned if you spill coolant on hot engine parts. Coolant contains ethylene glycol and it will burn if the engine parts are hot enough. Do not spill coolant on a hot engine. 1. Remove the coolant reservoir pressure cap when the cooling system, including the coolant reservoir pressure cap and...
Page 210: Power Steering Fluid
9-20 Vehicle Service and Care Power Steering Fluid When to Check Power Steering Fluid It is not necessary to check the power steering ﬂuid level. A power steering ﬂuid leak is the only reason for ﬂuid loss. If a leak occurs, take your vehicle to the dealer/retailer service department and have it repaired as soon...
Page 211: Windshield Wiper Blade Replacement
Windshield Wiper Blade Replacement Front Windshield Wiper Windshield wiper blades should be inspected for wear or cracking. See “Maintenance Replacement Parts” in the Limited Warranty, Maintenance and owner Assistance Information manual for the proper type and length. Raise the wiper arm, tilt the wiper blade at a 90°...
Page 212: Brakes
9-22 Vehicle Service and Care Brakes Brake Fluid The brake master cylinder and, on manual transmission vehicles, the clutch hydraulic system use the same reservoir. The reservoir is ﬁlled with DOT-4 brake ﬂuid. See Engine Compartment Overview on page 9-6 for the location of the reservoir.
Page 213 Required Services” in the Limited Warranty, Maintenance and Owner Assistance Information manual. Use new brake ﬂuid from a sealed container only. See “Recommended Fluids and Lubricants” in the Limited Warranty, Maintenance and Owner Assistance Information manual. Always clean the brake ﬂuid reservoir cap and the area around the cap before removing it.
Page 214 9-24 Vehicle Service and Care Rear disc brake pads do not have built-in brake pad wear indicators. Periodic visual inspection of the rear brake pads is required to determine when to replace the pads. Visually inspect the rear brake pads whenever the rear wheels are removed such as during tire rotation.
Page 215: Battery
Replacing Brake System Parts The braking system on a vehicle is complex. Its many parts have to be of top quality and work well together if the vehicle is to have really good braking. Your vehicle was designed and tested with top-quality brake parts.
Page 216: Headlamp Aiming
9-26 Vehicle Service and Care Headlamp Aiming The optical headlamp aiming system has been preset at the factory and should need no further adjustment. However, If the vehicle is damaged in a crash, the headlamp aim may be affected and adjustment may be necessary.
Page 217 3. Record the distance from the ground to the aim dot on the low-beam headlamp. 4. At a wall, measure from the ground upward (A) to the recorded distance from Step 3 and mark it. 5. Draw or tape a horizontal line (B) on the wall the width of the vehicle at the height of the mark in Step 4.
Page 218: Bulb Replacement
9-28 Vehicle Service and Care 9. Make sure that the light from the headlamp is positioned at the bottom edge of the horizontal tape line. The lamp on the left (A) shows the correct headlamp aim. The lamp on the right (B) shows the incorrect headlamp aim.
Page 219: Taillamps (Five-Door Hatchback)
2. Turn the bulb socket counterclockwise and pull straight out. 3. Turn bulb counterclockwise and remove. 4. Install new bulb. 5. Reverse Steps 2 through 4 to reinstall. Vehicle Service and Care Taillamps (Five-Door Hatchback) A. Backup Lamp B. Taillamp C.
Page 220: Taillamps (Three-Door Hatchback)
9-30 Vehicle Service and Care 4. Turn the nuts counterclockwise and hold the outside of taillamp assembly. 5. Pull the taillamp assembly straight out. 6. Remove the three nuts. 7. Press on the tabs on the outside of bulb assembly and remove the bulb assembly.
Page 221 To replace one of these bulbs: 1. Open the liftgate. See Liftgate on page 2-6 for more information. 2. Detach the plug connector from the bulb assembly. 3. Turn the nuts counterclockwise and hold the outside of taillamp assembly. 4. Pull the taillamp assembly straight out.
Page 222 9-32 Vehicle Service and Care License Plate Lamp To replace one of these bulbs: 1. Push tab in and pull down on it to remove the license plate lamp. 2. Turn and pull the license plate lamp toward you through the opening.
Page 223: License Plate Lamp
Replacement Bulbs Bulb Exterior Lamp Number Front Turn 3157 NAK Signal Lamp License Plate Lamp Parking Lamp 4157K Taillamp For replacement bulbs not listed here, contact your dealer/retailer. Vehicle Service and Care Electrical System Add-On Electrical Equipment Notice: Do not add anything electrical to your vehicle unless you check with your dealer/retailer ﬁrst.
Page 224: Windshield Wiper Fuses
9-34 Vehicle Service and Care Windshield Wiper Fuses The windshield wiper motor is protected by a circuit breaker and a fuse. If the motor overheats due to heavy snow, etc., the wiper will stop until the motor cools. If the overload is caused by some electrical problem, have it ﬁxed.
Page 225 Fuses Usage Antilock Brake System (ABS) Valves ABS Pump Vehicle Service and Care Fuses Usage Climate Control System (Ignition) Engine Cooling Fan (AT and AC only) 9-35 Fuses Usage Engine Cooling Fan Windshield & Liftgate Glass Washer Motor...
Page 226: Rear Compartment Fuse Block
9-36 Vehicle Service and Care Fuses Usage Horn Door Locks Foglamps Windshield Wipers (high speed) Windshield Wipers (low speed) Antilock Brake System, Brake Lamp Switch Vacuum Pump Starter Air Conditioning Clutch Engine Control Module (ECM) (Main Relay) ECM (Battery) Fuel Pump/Injectors Fuses Usage ECM (Sensor and...
Page 227 Use the fuse puller, to remove and replace fuses. Fuses Usage Front Power Window Cluster Vehicle Service and Care Fuses Usage Climate Control System (Battery) Rear Defogger 9-37 Fuses Usage Rear Windshield Wiper Climate Control System (Ignition)
Page 228: Tires
9-38 Vehicle Service and Care Fuses Usage Front Passenger Seat Detection Sensor Tire Pressure Monitoring System (TPMS)/ Rain Sensor/Inside Rearview Mirror Interior Lights Outside Mirror Heating Sunroof Rear Power Window Diagnostic Link Connector Accessory Power Outlet (APO) Sunroof Door Locks Seat Heating Driver Seat Heating Front Passenger...
Page 229: Winter Tires
CAUTION (Continued) • Worn, old tires can cause accidents. If your tread is badly worn, or if your tires have been damaged, replace them. See High-Speed Operation on page 9-47 for inﬂation pressure adjustment for high speed driving. Low-Proﬁle Tires If the vehicle has 225/40ZR18 or 215/45R18 size tires, they are classiﬁed as low-proﬁle...
Page 230: Tire Sidewall Labeling
9-40 Vehicle Service and Care See your dealer/retailer for details regarding winter tire availability and proper tire selection. Also, see Buying New Tires on page 9-54. If you choose to use winter tires: • Use tires of the same brand and tread type on all four wheel positions.
Page 231 (D) Tire Identiﬁcation Number (TIN) The letters and numbers following DOT (Department of Transportation) code is the Tire Identiﬁcation Number (TIN). The TIN shows the manufacturer and plant code, tire size, and date the tire was manufactured. The TIN is molded onto both sides of the tire, although only one side may have the date of manufacture.
Page 232 9-42 Vehicle Service and Care (D) Maximum Cold Inﬂation Load Limit Maximum load that can be carried and the maximum pressure needed to support that load. (E) Tire Inﬂation temporary use tire or compact spare tire should be inﬂated to 60 psi (420 kPa). For more information on tire pressure and inﬂation see Inﬂation - Tire Pressure on page 9-46.
Page 233: Tire Terminology And Deﬁnitions
(D) Construction Code A letter code is used to indicate the type of ply construction in the tire. The letter R means radial ply construction; the letter D means diagonal or bias ply construction; and the letter B means belted-bias ply construction.
Page 234 9-44 Vehicle Service and Care DOT Markings A code molded into the sidewall of a tire signifying that the tire is in compliance with the U.S. Department of Transportation (DOT) motor vehicle safety standards. The DOT code includes the Tire Identiﬁcation Number (TIN), an alphanumeric designator which can also identify the tire manufacturer,...
Page 235 Passenger (P-Metric) Tire A tire used on passenger cars and some light duty trucks and multipurpose vehicles. Recommended Inﬂation Pressure Vehicle manufacturer’s recommended tire inﬂation pressure as shown on the tire placard. See Inﬂation - Tire Pressure on page 9-46 and Loading the Vehicle on page 8-30.
Page 236: Inﬂation - Tire Pressure
9-46 Vehicle Service and Care Inﬂation - Tire Pressure Tires need the correct amount of air pressure to operate effectively. Do not let anyone tell Notice: you that under-inﬂation or over-inﬂation is all right. It is not. If your tires do not have enough air (under-inﬂation), you can get the following: •...
Page 237: High-Speed Operation
Remove the valve cap from the tire valve stem. Press the tire gage ﬁrmly onto the valve to get a pressure measurement. If the cold tire inﬂation pressure matches the recommended pressure on the Tire and Loading Information label, no further adjustment is necessary.
Page 238: Tire Pressure Monitor System
9-48 Vehicle Service and Care When high-speed driving ends, return the tire pressure to the recommended cold inﬂation pressure shown on the Tire and Loading Information label. See Loading the Vehicle on page 8-30. Tire pressure should be checked and correctly set when the tires are cold.
Page 239 When the malfunction indicator is illuminated, the system may not be able to detect or signal low tire pressure as intended. TPMS malfunctions may occur for a variety of reasons, including the installation of replacement or alternate tires or wheels on the vehicle that prevent the TPMS from functioning properly.
Page 240: Tire Pressure Monitor Operation
9-50 Vehicle Service and Care Tire Pressure Monitor Operation The Tire Pressure Monitor System (TPMS) is designed to warn the driver when a low tire pressure condition exists. TPMS sensors are mounted onto each tire and wheel assembly, excluding the spare tire.
Page 241: Tire Inspection And Rotation
TPMS Malfunction Light The TPMS will not function properly if one or more of the TPMS sensors are missing or inoperable. When the system detects a malfunction, the low tire warning light ﬂashes for about one minute and then stays on for the remainder of the ignition cycle.
Page 242 9-52 Vehicle Service and Care Use this pattern when rotating the vehicle tires. Do not include the compact spare tire in the tire rotation. CAUTION Rust or dirt on a wheel, or on the parts to which it is fastened, can make wheel bolts become loose after time.
Page 243: When It Is Time For New Tires
When It Is Time for New Tires Various factors, such as maintenance, temperatures, driving speeds, vehicle loading, and road conditions inﬂuence when you need new tires. One way to tell when it is time for new tires is to check the treadwear indicators, which will appear when the tires have only 1/16 inch (1.6 mm) or less of tread remaining.
Page 244: Buying New Tires
9-54 Vehicle Service and Care Buying New Tires GM has developed and matched speciﬁc tires for your vehicle. The original equipment tires installed on your vehicle, when it was new, were designed to meet General Motors Tire Performance Criteria Speciﬁcation (TPC Spec) system rating.
Page 245: Different Size Tires And Wheels
You may increase the chance that you will crash and suffer serious injury. Only use Saturn speciﬁc wheel and tire systems developed for your vehicle, and have them properly installed by a Saturn certiﬁed technician.
Page 246: Uniform Tire Quality Grading
9-56 Vehicle Service and Care Uniform Tire Quality Grading Quality grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: Treadwear 200 Traction AA Temperature A The following information relates to the system developed by the United States National Highway Traffic Safety Administration (NHTSA), which...
Page 247 Traction – AA, A, B, C The traction grades, from highest to lowest, are AA, A, B, and C. Those grades represent the tire’s ability to stop on wet pavement as measured under controlled conditions on speciﬁed government test surfaces of asphalt and concrete.
Page 248: Wheel Alignment And Tire Balance
9-58 Vehicle Service and Care Wheel Alignment and Tire Balance The tires and wheels on your vehicle were aligned and balanced carefully at the factory to give you the longest tire life and best overall performance. Adjustments to wheel alignment and tire balancing will not be necessary on a regular basis.
Page 249: Tire Chains
Notice: The wrong wheel can also cause problems with bearing life, brake cooling, speedometer or odometer calibration, headlamp aim, bumper height, vehicle ground clearance, and tire or tire chain clearance to the body and chassis. See Changing a Flat Tire on page 9-60 for more information.
Page 250: Tire Changing If A Tire Goes Flat
9-60 Vehicle Service and Care Tire Changing If a Tire Goes Flat It is unusual for a tire to blowout while you are driving, especially if you maintain your vehicle’s tires properly. If air goes out of a tire, it is much more likely to leak out slowly.
Page 251: Removing The Spare Tire And Tools
CAUTION (Continued) 3. Turn off the engine and do not restart while the vehicle is raised. 4. Do not allow passengers to remain in the vehicle. To be certain the vehicle will not move, put blocks at the front and rear of the tire farthest away from the one being changed.
Page 252: Removing The Flat Tire And Installing The Spare Tire
9-62 Vehicle Service and Care 5. The jack and tools are stored below the spare tire. 6. The tools you will be using include the jack (A), wheel wrench (B) and jack handle (C). Removing the Flat Tire and Installing the Spare Tire 1.
Page 253 Notice: Make sure that the jack lift head is in the correct position or you may damage your vehicle. The repairs would not be covered by your warranty. Vehicle Service and Care 4. Position the jack lift head at the jack location nearest the ﬂat tire.
Page 254 9-64 Vehicle Service and Care 6. Raise the vehicle by turning the jack handle clockwise. Raise the vehicle far enough off the ground so there is enough room for the compact spare tire to ﬁt under the vehicle. 7. Remove all of the wheel bolts. CAUTION Rust or dirt on a wheel, or on the parts to which it is...
Page 255 9. Place the compact spare tire on the wheel-mounting surface. 10. Reinstall the wheel bolts with the rounded end of the bolts toward the wheel. Tighten each bolt by hand until the wheel is held against the hub. 11. Lower the vehicle by turning the jack handle counterclockwise.
Page 256: Storing A Flat Or Spare Tire And Tools
9-66 Vehicle Service and Care Storing a Flat or Spare Tire and Tools CAUTION Storing a jack, a tire, or other equipment in the passenger compartment of the vehicle could cause injury. In a sudden stop or collision, loose equipment could strike someone.
Page 257: Compact Spare Tire
4. Put the load ﬂoor back in place. The compact spare tire is for temporary use only. Replace the compact spare with a full-size tire as soon as possible. Vehicle Service and Care Compact Spare Tire Although the compact spare tire was fully inﬂated when the vehicle was new, it can lose air after a time.
Page 258: Jump Starting
9-68 Vehicle Service and Care Jump Starting If your battery has run down, try to use another vehicle and some jumper cables to start your vehicle. Be sure to use the following steps to do it safely. CAUTION Batteries can hurt you. They can be dangerous because: •...
Page 259 4. Open the hoods and locate the batteries. Find the positive (+) and negative (−) terminal locations on each vehicle. Your vehicle’s positive (+) terminal is identiﬁed by “+” sign on battery case or terminal. Engine Compartment Overview on page 9-6. CAUTION An electric fan can start up even when the engine is not...
Page 260 9-70 Vehicle Service and Care 5. Check that the jumper cables do not have loose or missing insulation. If they do, you could get a shock. The vehicles could be damaged too. Before you connect the cables, here are some things you to know.
Page 261 10. Now start the vehicle with the good battery and run the engine for a while. 11. Try to start the vehicle that had the dead battery. If it will not start after a few tries, it probably needs service. Notice: If the jumper cables are connected or removed in the wrong order, electrical shorting...
Page 262: Towing
9-72 Vehicle Service and Care Towing Towing Your Vehicle The vehicle was neither designed nor intended to be towed with any of its wheels on the ground. Consult your dealer/retailer or a professional towing service if the disabled vehicle needs to be towed.
Page 263 When cleaning your vehicle’s interior, only use cleaners speciﬁcally designed for the surfaces being cleaned. Permanent damage may result from using cleaners on surfaces for which they were not intended. Use glass cleaner only on glass. Remove any accidental over-spray from other surfaces immediately.
Page 264 9-74 Vehicle Service and Care Fabric/Carpet Use a vacuum cleaner with a soft brush attachment frequently to remove dust and loose dirt. A canister vacuum with a beater bar in the nozzle may only be used on ﬂoor carpet and carpeted ﬂoor mats.
Page 265: Exterior Cleaning
change the appearance and feel of your leather and are not recommended. Do not use silicone or wax-based products, or those containing organic solvents to clean your vehicle’s interior because they can alter the appearance by increasing the gloss in a non-uniform manner.
Page 266 9-76 Vehicle Service and Care If your vehicle has a basecoat/ clearcoat paint ﬁnish, the clearcoat gives more depth and gloss to the colored basecoat. Always use waxes and polishes that are non-abrasive and made for a basecoat/clearcoat paint ﬁnish. Notice: Machine compounding or aggressive polishing on a basecoat/clearcoat paint ﬁnish...
Page 267 page 9-80. Follow all manufacturers’ directions regarding correct product usage, necessary safety precautions and appropriate disposal of any vehicle care product. Rinse the vehicle well, before washing and after to remove all cleaning agents completely. If they are allowed to dry on the surface, they could stain.
Page 268: Sheet Metal Damage
9-78 Vehicle Service and Care Notice: Using chrome polish on aluminum wheels could damage the wheels. The repairs would not be covered by your warranty. Use chrome polish on chrome wheels only. Use chrome polish only on chrome-plated wheels, but avoid any painted surface of the wheel, and buff off immediately after application.
Page 269: Finish Damage
Finish Damage Any stone chips, fractures or deep scratches in the ﬁnish should be repaired right away. Bare metal will corrode quickly and may develop into major repair expense. Minor chips and scratches can be repaired with touch-up materials available from your dealer/retailer. Larger areas of ﬁnish damage can be corrected in your dealer’s/ retailer’s body and paint shop.
Page 270: Vehicle Care/Appearance Materials
9-80 Vehicle Service and Care Vehicle Care/Appearance Materials Description Polishing Cloth Tar and Road Oil Remover Chrome Cleaner and Polish White Sidewall Tire Cleaner Vinyl Cleaner Glass Cleaner Chrome Wheel Cleaner Finish Enhancer Swirl Remover Polish Cleaner Wax Usage Interior and exterior polishing cloth. Removes tar, road oil, and asphalt.
Page 271 Description Foaming Tire Shine Low Gloss Wash Wax Concentrate Spot Lifter Odor Eliminator Vehicle Service and Care Usage Cleans, shines, and protects tires. No wiping necessary. Medium foaming shampoo. Cleans and lightly waxes. Biodegradable and phosphate free. Quickly removes spots and stains from carpets, vinyl, and cloth upholstery.
Page 272 9-82 Vehicle Service and Care NOTES...
Page 273: Vehicle Identiﬁcation
Technical Data Vehicle Identiﬁcation Vehicle Identiﬁcation Number (VIN) ...10-1 Service Parts Identiﬁcation Label ...10-1 Capacities and Speciﬁcations Capacities and Speciﬁcations ...10-2 Vehicle Identiﬁcation Vehicle Identiﬁcation Number (VIN) This is the legal identiﬁer for your vehicle. It appears on a plate in the front corner of the instrument panel, on the driver side.
Page 274: Capacities And Speciﬁcations
10-2 Technical Data Capacities and Speciﬁcations The following approximate capacities are given in English and metric conversions. See “Fluids and Lubricants” in the index of the “Limited Warranty, Maintenance and Owner Assistance Information” manual. Application Air Conditioning Refrigerant Cooling System Automatic Transmission Manual Transmission Engine Oil with Filter...
Page 275 Technical Data 10-3 Engine Speciﬁcations Engine VIN Code Transmission Spark Plug Gap Automatic 1.8L L4 0.035 in (0.90 mm) Manual...
Page 276 10-4 Technical Data NOTES...
Page 277: Customer Information
Saturn vehicle, for total customer satisfaction. We call this the Saturn Difference. Normally, any concerns with the sales transaction or the operation of the vehicle are resolved by the retailer’s sales or service...
Page 278 That is why we suggest you follow Step One ﬁrst. STEP THREE (U.S. Owners): Both Saturn and its retailers are committed to making sure you are completely satisﬁed with your Saturn vehicle. However, if you continue to remain unsatisﬁed after following the...
Page 279: Customer Information
This program is available in all 50 states and the District of Columbia. Eligibility is limited by vehicle age, mileage and other factors. Saturn Corporation reserves the right to change eligibility limitations and/or discontinue its participation in this program. STEP THREE (Canadian Owners):...
Page 280: Online Owner Center
11-4 Customer Information Online Owner Center (United States only) This is a resource for your Saturn ownership needs. Speciﬁc vehicle information can be found in one place. The Online Owner Center allows you to: • Get e-mail service reminders. •...
Page 281: Customer Assistance Offices
Telephone (TTY): 1-800-889-2438). For vehicles purchased in Canada, call 1-800-268-6800. Service is available 24 hours a day, 365 days a year. As the owner of a new Saturn vehicle, you are automatically enrolled in the Saturn Roadside Assistance Program. 11-5...
Page 282 • Emergency Tow From a Public Roadway or Highway: Tow to the nearest Saturn retailer for warranty service or in the event of a vehicle-disabling crash. Winch-out assistance is provided when the vehicle is mired in sand, mud, or snow.
Page 283 However, any cost for parts and labor for non-warranty repairs are the responsibility of the driver. Saturn and General Motors of Canada Limited reserve the right to limit services or reimbursement to an Customer Information owner or driver when, in their sole...
Page 284: Scheduling Service Appointments
Roadside Assistance is not part of or included in the coverage provided by the New Vehicle Limited Warranty. Saturn and General Motors of Canada Limited reserve the right to make any changes or discontinue the Roadside Assistance program at any time without notiﬁcation.
Page 285 Saturn for shuttle service. In addition, for U.S. customers, should you arrange transportation through a friend or relative, limited reimbursement for reasonable fuel expenses may be available.
Page 286: Collision Damage Repair
All Courtesy Transportation arrangements will be administered by appropriate retailer personnel. Saturn reserves the right to unilaterally modify, change or discontinue Courtesy Transportation at any time and to resolve all questions of claim eligibility pursuant...
Page 287 Aftermarket parts are not covered by your GM New Vehicle Limited Warranty, and any vehicle failure related to such parts are not covered by that warranty. Repair Facility We recommend that you choose a collision repair facility that meets your needs before you ever need collision repairs.
Page 288 11-12 Customer Information • If you need roadside assistance, call GM Roadside Assistance. See Roadside Assistance Program on page 11-5 for more information. • If your vehicle cannot be driven, know where the towing service will be taking it. Get a card from the tow truck operator or write down the driver’s name, the service’s name, and the phone...
Page 289: Reporting Safety Defects To The United States Government
Customer Information However, NHTSA cannot become involved in individual problems between you, your retailer or Saturn Corporation. To contact NHTSA, call the Vehicle Safety Hotline toll-free at 1-888-327-4236 (TTY: 1-800-424-9153); go to safercar.gov; or...
Page 290: Reporting Safety Defects To The Canadian Government
Oshawa, Ontario L1H 8P7 Service Publications Ordering Information Service Manuals A variety of publications are available to you. Saturn service manuals are written for trained technicians, and in some cases, specialized tools and equipment are necessary to complete certain repairs. However, the manuals are...
Page 291: Vehicle Data Recording And Privacy
Customer Information Vehicle Data Recording and Privacy Your Saturn vehicle has a number of sophisticated computers that record information about the vehicle’s performance and how it is driven. For example, your vehicle uses computer modules to monitor and...
Page 292: Event Data Recorders
11-16 Customer Information Event Data Recorders This vehicle has an Event Data Recorder (EDR). The main purpose of an EDR is to record, in certain crash or near crash-like situations, such as an airbag deployment or hitting a road obstacle, data that will assist in understanding how a vehicle’s systems performed.
Page 293: Onstar
Saturn will not access this data or share it with others except: with the consent of the vehicle owner or, if the vehicle is leased, with the consent of the lessee; in response to an official request of police or similar government office;...
Page 294 11-18 Customer Information NOTES...
Page 295 Accessories and Modiﬁcations ... 9-3 Accessory Power Outlets ... 4-10 Adding Equipment to Your Airbag-Equipped Vehicle ... 1-35 Additives, Fuel ... 8-36 Add-On Electrical Equipment ... 9-33 Air Cleaner/Filter, Engine ... 9-11 Air Conditioning ... 7-1 Airbag Passenger Status Indicator ... 4-15 Readiness Light ...
Page 296 Offices ... 11-5 Customer Satisfaction Procedure ... 11-1 GM Mobility Reimbursement Program ... 11-5 Reporting Safety Defects to Saturn ... 11-14 Reporting Safety Defects to the Canadian Government ... 11-14 Reporting Safety Defects to the United States Government ... 11-13 Roadside Assistance Program ...
Page 297 Daytime Running Lamps ... 5-2 Defensive Driving ... 8-16 Delayed Headlamps ... 5-2 Doing Your Own Service Work ... 9-4 Dome Lamps ... 5-3 Door Ajar Light ... 4-24 Locks ... 2-5 Power Door Locks ... 2-5 Rear Door Security Locks ... 2-6 Driver Information Center (DIC) ...
Page 298 INDEX Filter Engine Air Cleaner ... 9-11 Finish Damage ... 9-79 Fixed Mast Antenna ... 6-25 Flashers, Hazard Warning ... 4-4 Flash-to-Pass ... 4-8 Flat Tire ... 9-60 Flat Tire, Changing ... 9-60 Flat Tire, Storing ... 9-66 Fluid ... 9-12 Automatic Transmission ...
Page 299 Hood Release ... 9-5 Horn ... 4-4 How to Wear Safety Belts Properly ... 1-12 Hydraulic Clutch ... 9-12 Ignition Positions ... 8-2 Immobilizer ... 2-7 Immobilizer Operation ... 2-8 Infants and Young Children, Restraints ... 1-38 Inﬂation - Tire Pressure ... 9-46 Instrument Panel Brightness ...
Page 300 INDEX Loading Your Vehicle ... 8-30 Locks Door ... 2-5 Power Door ... 2-5 Rear Door Security Locks ... 2-6 Loss of Control ... 8-23 Low Fuel Warning Light ... 4-25 Lumbar Seat Adjustment ... 1-3 Malfunction Indicator Light ... 4-20 Manual Seats ...
Page 301 Replacing LATCH System Parts After a Crash ... 1-50 INDEX Reporting Safety Defects Canadian Government ... 11-14 Saturn ... 11-14 United States Government ... 11-13 Restraint System Check Replacing Airbag System Parts After a Crash ... 1-36 Replacing Safety Belt System Parts After a Crash ...
Page 302 INDEX Safety Belts ... 1-8 Care of ... 1-22 Check ... 1-22 How to Wear Safety Belts Properly ... 1-12 Lap-Shoulder Belt ... 1-17 Reminder Light ... 4-14 Replacing Parts After a Crash ... 1-23 Safety Belt Extender ... 1-22 Safety Belt Use During Pregnancy ...
Page 303 Tachometer ... 4-13 Taillamps ... 9-29, 9-30 Theft-Deterrent, Radio ... 6-24 Theft-Deterrent Systems ... 2-7 Content Theft-Deterrent ... 2-9 Immobilizer ... 2-7 Immobilizer Operation ... 2-8 Tilt Wheel ... 4-4 Tire Pressure Light ... 4-19 Tires ... 9-38 Buying New Tires ... 9-54 Chains ...
Page 304 i-10 INDEX Uniform Tire Quality Grading ... 9-56 Using this Manual ... ii Vehicle Control ... 8-17 Loading ... 8-30 Parking Your ... 8-13 Running While Parked ... 8-14 Service Soon Light ... 4-24 Symbols ... iii Vehicle Data Recording and Privacy ...

This manual is also suitable for:

Astra 2008

Saturn 2008 Astra Owner's Manual

Table of Contents

Seats and Child Restraints 1-37 Older Children

Seats and Restraints

Front Seats Manual Seats

Rear Seats Rear Seat Operation

Safety Belts

Airbag System

Child Restraints Older Children

Keys, Doors and Windowstheft-Deterrent Systems

Keys

Keys, Doors and Windows

Doors and Locks Door Locks

Theft-Deterrent Systems

Windows

Mirrors

Sunroof

Storage

Instruments and Warning Lights, Gages, and Indicators

Instruments and Controls

Instruments and

Climate Controls

Warning Lights, Gages, and Indicators

Overview

Instrument Panel

Center (DIC)

Driver Information Center (DIC)

Lighting

Onstar System

Lighting 5-1 Lighting Lighting

Lighting

Infotainment

Driving and Operating

Driving and Operating

Starting and Operating Your Vehicle New Vehicle Break-In

Driving Your Vehicle Defensive Driving

Fuel

Vehicle Service and Care

California Perchlorate Materials Requirements

Owner Checks

Headlamp Aiming

Electrical System Add-On Electrical Equipment

Winter Tires

Tire Changing if a Tire Goes Flat

Towing

Appearance Care Interior Cleaning

Customer Information 11-1 Customer Information Reporting Safety Defects Customer Information

Customer Information

Customer Information

Reporting Safety Defects to the United States Government

Vehicle Data Recording and Privacy

Quick Links

Chapters

Related Manuals for Saturn 2008 Astra

Summary of Contents for Saturn 2008 Astra