Page 1: Table Of Contents
2004 Saturn L-Series Owner Manual Seats and Restraint Systems ... 1-1 Front Seats ... 1-3 Rear Seats ... 1-8 Safety Belts ... 1-11 Child Restraints ... 1-35 Air Bag Systems ... 1-62 Restraint System Check ... 1-72 Features and Controls ... 2-1 Keys ...
Page 2: How To Use This Manual
SATURN and the SATURN Emblem are registered trademarks of Saturn Corporation. GM and the GM Emblem are registered trademarks of General Motors Corporation. This manual includes the latest information at the time it was printed. We reserve the right to make changes after that time without further notice.
Page 3 Safety Warnings and Symbols You will ﬁnd a number of safety cautions in this book. We use a box and the word CAUTION to tell you about things that could hurt you if you were to ignore the warning. CAUTION: These mean there is something that could hurt you or other people.
Page 4: Vehicle Symbols
Vehicle Damage Warnings Also, in this manual you will ﬁnd these notices: Notice: These mean there is something that could damage your vehicle. A notice tells about something that can damage your vehicle. Many times, this damage would not be covered by your vehicle’s warranty, and it could be costly.
Page 5 These are some examples of symbols that may be found on the vehicle:...
Page 6 NOTES...
Page 7: Seats And Restraint Systems
Section 1 Front Seats ...1-3 Manual Seats ...1-3 Driver Seat Height Adjuster ...1-3 Six-Way Power Driver Seat ...1-4 Manual Lumbar ...1-4 Heated Seats ...1-5 Reclining Seatbacks ...1-5 Head Restraints ...1-7 Rear Seats ...1-8 Split Folding Rear Seat ...1-8 Safety Belts ...1-11 Safety Belts: They Are for Everyone ...1-11 Questions and Answers About Safety Belts ...1-15 How to Wear Safety Belts Properly ...1-16...
Page 8 Section 1 What Makes an Air Bag Inﬂate? ...1-68 How Does an Air Bag Restrain? ...1-68 What Will You See After an Air Bag Inﬂates? ...1-69 Servicing Your Air Bag-Equipped Vehicle ...1-71 Adding Equipment to Your Air Bag-Equipped Vehicle ...1-72 Seats and Restraint Systems Restraint System Check ...1-72 Checking Your Restraint Systems ...1-72...
Page 9: Front Seats
Front Seats Manual Seats CAUTION: You can lose control of the vehicle if you try to adjust a manual driver’s seat while the vehicle is moving. The sudden movement could startle and confuse you, or make you push a pedal when you do not want to.
Page 10: Manual Lumbar
Six-Way Power Driver Seat If your vehicle has this feature, the control is located on the outboard side of the driver’s seat. To adjust the seat do any of the following: • Move the seat forward or rearward by pressing the center switch forward or rearward.
Page 11: Heated Seats
Heated Seats If your vehicle has this feature, the thumbwheel controls for both driver and passenger heated seats are located in the center of the instrument panel. Move the thumbwheel to the ﬁrst circle to warm the seat to a lower temperature and to the second circle for a higher temperature.
Page 12 On a power driver’s seat, adjust the seatback by pressing the RECLINE switch forward or rearward. But don’t have a seatback reclined if your vehicle is moving.
Page 13: Head Restraints
CAUTION: Sitting in a reclined position when your vehicle is in motion can be dangerous. Even if you buckle up, your safety belts can not do their job when you are reclined like this. The shoulder belt can not do its job because it will not be against your body.
Page 14: Rear Seats
Rear Seats Split Folding Rear Seat Your vehicle is equipped with a split folding rear seat. A split folding rear seat enables you to carry long cargo by folding down part or all of the rear seat. Sedan On sedans, you can fold either the driver’s or passenger’s right side of the seatback separately or...
Page 15 CAUTION: A safety belt that is improperly routed, not properly attached, or twisted will not provide the protection needed in a crash. The person wearing the belt could be seriously injured. After raising the rear seatback, always check to be sure that the safety belts are properly routed and attached, and are not twisted.
Page 16 Wagon On wagons, you can fold either the passenger’s side of the seatback or the entire seatback. To fold down the passenger’s side of the seatback, pull the lever on the corner of the seatback. To lower the entire rear seatback, pull the lever on the corner of the driver’s side seatback.
Page 17: Safety Belts
Safety Belts Safety Belts: They Are for Everyone This part of the manual tells you how to use safety belts properly. It also tells you some things you should not do with safety belts. CAUTION: Do not let anyone ride where he or she can not wear a safety belt properly.
Page 18: Why Safety Belts Work
You never know if you’ll be in a crash. If you do have a crash, you don’t know if it will be a bad one. A few crashes are mild, and some crashes can be so serious that even buckled up, a person wouldn’t survive. But most crashes are in between.
Page 19 Put someone on it. Get it up to speed. Then stop the vehicle. The rider doesn’t stop. 1-13...
Page 20 The person keeps going until stopped by something. In or the instrument panel... a real vehicle, it could be the windshield... 1-14...
Page 21: Questions And Answers About Safety Belts
or the safety belts! With safety belts, you slow down as the vehicle does. You get more time to stop. You stop over more distance, and your strongest bones take the forces. That’s why safety belts make such good sense. Questions and Answers About Safety Belts Won’t I be trapped in the vehicle after an...
Page 22: How To Wear Safety Belts Properly
If I’m a good driver, and I never drive far from home, why should I wear safety belts? You may be an excellent driver, but if you’re in an accident – even one that isn’t your fault – you and your passengers can be hurt.
Page 23 Lap-Shoulder Belt The driver has a lap-shoulder belt. Here is how to wear it properly. 1. Close and lock the door. 2. Adjust the seat so you can sit up straight. To see how, see “Seats” in the Index. 3. Pick up the latch plate and pull the belt across you. Do not let it get twisted.
Page 24 5. To make the lap part tight, pull down on the buckle The lap part of the belt should be worn low and snug on end of the belt as you pull up on the shoulder belt. the hips, just touching the thighs. In a crash, this applies force to the strong pelvic bones.
Page 25: Shoulder Belt Height Adjuster
Shoulder Belt Height Adjuster Before you begin to drive, move the shoulder belt adjuster to the height that is right for you. To move it down, press down on the indented part of the height adjuster and move the height adjuster to the desired position.
Page 26 What’s wrong with this? The shoulder belt is too loose. It will not give nearly as much protection this way. 1-20 CAUTION: You can be seriously hurt if your shoulder belt is too loose. In a crash, you would move forward too much, which could increase injury.
Page 27 What’s wrong with this? The belt is buckled in the wrong place. CAUTION: You can be seriously injured if your belt is buckled in the wrong place like this. In a crash, the belt would go up over your abdomen. The belt forces would be there, not at the pelvic bones.
Page 28 What’s wrong with this? The shoulder belt is worn under the arm. It should be worn over the shoulder at all times. 1-22 CAUTION: You can be seriously injured if you wear the shoulder belt under your arm. In a crash, your body would move too far forward, which would increase the chance of head and neck injury.
Page 29 What’s wrong with this? The belt is twisted across the body. CAUTION: You can be seriously injured by a twisted belt. In a crash, you wouldn’t have the full width of the belt to spread impact forces. If a belt is twisted, make it straight so it can work properly, or ask your retailer to ﬁx it.
Page 30: Safety Belt Use During Pregnancy
To unlatch the belt, just push the button on the buckle. The belt should go back out of the way. Before you close the door, be sure the belt is out of the way. If you slam the door on it, you can damage both the belt and your vehicle.
Page 31: Rear Seat Passengers
The best way to protect the fetus is to protect the mother. When a safety belt is worn properly, it’s more likely that the fetus won’t be hurt in a crash. For pregnant women, as for anyone, the key to making safety belts effective is wearing them properly.
Page 32 Lap-Shoulder Belt All rear seating positions have lap-shoulder belts. Here is how to wear one properly. 1. Pick up the latch plate and pull the belt across you. Do not let it get twisted. The shoulder belt may lock if you pull the belt across you very quickly.
Page 33 The lap part of the belt should be worn low and snug on the hips, just touching the thighs. In a crash this applies force to the strong pelvic bones. And you would be less likely to slide under the lap belt. If you slid under it, the belt would apply force at your abdomen.
Page 34 To unlatch the belt, just push the button on the buckle. 1-28 Rear Seat Outside Passenger Positions (Wagon)
Page 35 Lap-Shoulder Belt The positions next to the windows have lap-shoulder belts. Here is how to wear one properly. 1. Pick up the latch plate and pull the belt across you. Do not let it get twisted. The shoulder belt may lock if you pull the belt across you very quickly.
Page 36 The lap part of the belt should be worn low and snug on the hips, just touching the thighs. In a crash this applies force to the strong pelvic bones. 1-30 And you would be less likely to slide under the lap belt. If you slid under it, the belt would apply force at your abdomen.
Page 37 Center Rear Passenger Position (Wagon) To unlatch the belt, just push the button on the buckle. 1-31...
Page 38: Lap Belt
Lap Belt When you sit in the center seating position, you have a lap safety belt, which has no retractor. To make the belt longer, tilt the latch plate and pull it along the belt. 1-32 To make the belt shorter, pull its free end as shown until the belt is snug.
Page 39: Rear Safety Belt Comfort Guides For Children And Small Adults
Rear Safety Belt Comfort Guides for Children and Small Adults If you would like to have rear shoulder belt comfort guides installed on your vehicle, contact your retailer. Rear shoulder belt comfort guides will provide added safety belt comfort for older children who have outgrown booster seats and for small adults.
Page 40 2. Slide the guide under and past the belt. The elastic cord must be under the belt. Then, place the guide over the belt, and insert the two edges of the belt into the slots of the guide. 3. Be sure that the belt is not twisted and it lies ﬂat. The elastic cord must be under the belt and the guide on top.
Page 41: Child Restraints
Safety Belt Extender If the vehicle’s safety belt will fasten around you, you should use it. But if a safety belt is not long enough to fasten, your retailer will order you an extender. When you go in to order it, take the heaviest coat you will wear, so the extender will be long enough for you.
Page 42 What is the proper way to wear safety belts? If possible, an older child should wear a lap-shoulder belt and get the additional restraint a shoulder belt can provide. The shoulder belt should not cross the face or neck. The lap belt should ﬁt snugly below the hips, just touching the top of the thighs.
Page 43 CAUTION: Never do this. Here two children are wearing the same belt. The belt can not properly spread the impact forces. In a crash, the two children can be crushed together and seriously injured. A belt must be used by only one person at a time. What if a child is wearing a lap-shoulder belt, but the child is so small that the shoulder belt is very close to the child’s face or neck?
Page 44: Infants And Young Children
1-38 CAUTION: Never do this. Here a child is sitting in a seat that has a lap-shoulder belt, but the shoulder part is behind the child. If the child wears the belt in this way, in a crash the child might slide under the belt.
Page 45 Every time infants and young children ride in vehicles, they should have the protection provided by appropriate restraints. Young children should not use the vehicle’s adult safety belts alone, unless there is no other choice. Instead, they need to use a child restraint. CAUTION: People should never hold a baby in their arms while riding in a vehicle.
Page 46 1-40 CAUTION: Children who are up against, or very close to, any air bag when it inﬂates can be seriously injured or killed. Air bags plus lap-shoulder belts offer outstanding protection for adults and older children, but not for young children and infants.
Page 47 For most basic types of child restraints, there are many different models available. When purchasing a child restraint, be sure it is designed to be used in a motor vehicle. If it is, the restraint will have a label saying that it meets federal motor vehicle safety standards.
Page 48: Child Restraint Systems
Child Restraint Systems An infant car bed (A), a special bed made for use in a motor vehicle, is an infant restraint system designed to restrain or position a child on a continuous ﬂat surface. Make sure that the infant’s head rests toward the center of the vehicle.
Page 49 A forward-facing child seat (C-E) provides restraint for the child’s body with the harness and also sometimes with surfaces such as T-shaped or shelf-like shields. A booster seat (F-G) is a child restraint designed to improve the ﬁt of the vehicle’s safety belt system. Some booster seats have a shoulder belt positioner, and some high-back booster seats have a ﬁve-point harness.
Page 50: Where To Put The Restraint
How do child restraints work? A child restraint system is any device designed for use in a motor vehicle to restrain, seat, or position children. A built-in child restraint system is a permanent part of the motor vehicle. An add-on child restraint system is a portable one, which is purchased by the vehicle’s owner.
Page 51 Here is why: CAUTION: A child in a rear-facing child restraint can be seriously injured or killed if the right front passenger’s air bag inﬂates. This is because the back of the rear-facing child restraint would be very close to the inﬂating air bag. Always secure a rear-facing child restraint in a rear seat.
Page 52: Top Strap
Top Strap Some child restraints have a top strap, or “top tether.” It can help restrain the child restraint during a collision. For it to work, a top strap must be properly anchored to the vehicle. Some top strap-equipped child restraints are designed for use with or without the top strap being anchored.
Page 53: Top Strap Anchor Location
CAUTION: Each top tether bracket is designed to anchor only one child restraint. Attaching more than one child restraint to a single bracket could cause the anchor to come loose or even break during a crash. A child or others could be injured if this happens.
Page 54 Sedan The anchors are located behind the rear seat on the ﬁller panel. In order to get to one of these brackets, you will have to open the trim cover. The trim cover is marked with the symbol for child seat top tether anchor. 1-48 Wagon Anchor brackets are located on the ﬂoor in the...
Page 55 CAUTION: Routing the top strap for a child restraint over or under the cargo shade could cause the shade to come loose and even break. If this happens, the shade could be thrown about the vehicle in a collision or sudden maneuver. You or others could be injured.
Page 56 Lower Anchorages and Top Tethers for Children (LATCH System) Your vehicle has the LATCH system. You’ll ﬁnd anchors (A) for all three rear seating positions. This system, designed to make installation of child restraints easier, does not use the vehicle’s safety belts. Instead, it uses vehicle anchors (A, B) and child restraint attachments to secure the restraints.
Page 57 In order to use the LATCH system in your vehicle, you need a child restraint designed for that system. To assist you in locating the lower anchors for this child restraint system, each seating position with the LATCH system has a label on the seatback at each lower anchor position.
Page 58: Securing A Child Restraint Designed For The Latch System
Securing a Child Restraint Designed for the LATCH System 1. Find the LATCH anchorages for the seating position you want to use, where the bottom of the seatback meets the back of the seat cushion. See Lower Anchorages and Top Tethers for Children (LATCH System) on page 1-50.
Page 59 3. Buckle the belt. Make sure the release button is 4. Pull the rest of shoulder belt all the way out of the positioned so you would be able to unbuckle the retractor to set the lock. safety belt quickly if you ever had to. 1-53...
Page 60 5. To tighten the belt, pull up on the shoulder belt while you push down on the child restraint. If you are using a forward-facing child restraint, you may ﬁnd it helpful to use your knee to push down on the child restraint as you tighten the belt.
Page 61 3. Buckle the belt. Make sure the release button is 4. Pull the rest of shoulder belt all the way out of the positioned so you would be able to unbuckle the retractor to set the lock. safety belt quickly if you ever had to. 1-55...
Page 62 5. To tighten the belt, pull up on the shoulder belt while you push down on the child restraint. If you are using a forward-facing child restraint, you may ﬁnd it helpful to use your knee to push down on the child restraint as you tighten the belt.
Page 63 1. Make the belt as long as possible by tilting the latch plate and pulling it along the belt. 2. Put the restraint on the seat. 3. Run the vehicle’s safety belt through or around the restraint. The child restraint instructions will show you how.
Page 64: Securing A Child Restraint In The Right Front Seat Position
4. Buckle the belt. Make sure the release button is positioned so you would be able to unbuckle the safety belt quickly if you ever had to. 5. To tighten the belt, pull its free end while you push down on the child restraint. If you are using a forward-facing child restraint, you may ﬁnd it helpful to use your knee to push the child restraint as you tighten the belt.
Page 65 There is no top strap anchor in the right front passenger’s position. Do not secure a child seat in this position if a national or local law requires that the top strap be anchored, or if the instructions that come with the child restraint say that the top strap must be anchored.
Page 66 4. Buckle the belt. Make sure the release button is 5. Pull the rest of the shoulder belt all the way out of positioned so you would be able to unbuckle the the retractor to set the lock. safety belt quickly if you ever had to. 1-60...
Page 67 6. To tighten the belt, push down on the child restraint, pull the shoulder portion of the belt to tighten the lap portion of the belt and feed the shoulder belt back into the retractor. You may ﬁnd it helpful to use your knee to push down on the child restraint as you tighten the belt.
Page 68: Air Bag Systems
Air Bag Systems This part explains the frontal and side impact air bag systems. Your vehicle has four air bags: • A frontal air bag for the driver and another frontal air bag for the right front passenger, • A roof-mounted side impact air bag for the driver and passenger directly behind the driver, and •...
Page 69 CAUTION: (Continued) They are not designed to inﬂate in frontal, in rollover or in rear crashes. Everyone in your vehicle should wear a safety belt properly – whether or not there is an air bag for that person. CAUTION: Both frontal and side impact air bags inﬂate with great force, faster than the blink of an eye.
Page 70: Where Are The Air Bags
There is a air bag readiness light on the instrument panel, which shows the air bag symbol. The system checks the air bag electrical system for malfunctions. The light tells you if there is an electrical problem. See Air Bag Readiness Light on page 3-28 for more information.
Page 71 The right front passenger’s frontal air bag is in the instrument panel on the passenger’s side. If your vehicle has a side impact air bag for the driver and the person seated directly behind the driver, it is in the ceiling above the side windows. 1-65...
Page 72 If your vehicle has a side impact air bag for the right front passenger and the person seated directly behind that passenger, it is in the ceiling above the side windows. 1-66 CAUTION: If something is between an occupant and an air bag, the bag might not inﬂate properly or it might force the object into that person causing severe injury or even death.
Page 73: When Should An Air Bag Inﬂate
When Should an Air Bag Inﬂate? The driver’s and right front passenger’s frontal air bags are designed to inﬂate in moderate to severe frontal or near-frontal crashes. But they are designed to inﬂate only if the impact speed is above the system’s designed “threshold level.”...
Page 74: How Does An Air Bag Restrain
What Makes an Air Bag Inﬂate? In an impact of sufficient severity, the air bag sensing system detects that the vehicle is in a crash. For both frontal and side impact air bags, the sensing system triggers a release of gas from the inﬂator, which inﬂates the air bag.
Page 75: What Will You See After An Air Bag Inﬂates
What Will You See After an Air Bag Inﬂates? After the air bag inﬂates, it quickly deﬂates, so quickly that some people may not even realize the air bag inﬂated. Some components of the air bag module will be hot for a short time. These components include the steering wheel hub for the driver’s frontal air bag and the instrument panel for the right front passenger’s frontal air bag.
Page 76 You must ﬁrst turn your ignition key to the following ignition switch positions: 1. Turn the ignition key to the OFF position. 2. Turn the ignition key to the RUN position. 3. Turn the ignition key to the OFF position. In many crashes severe enough to inﬂate an air bag, windshields are broken by vehicle deformation.
Page 77: Servicing Your Air Bag-Equipped Vehicle
You don’t want the system to inﬂate while someone is working on your vehicle. Your retailer and the Saturn Service Manual have information about servicing your vehicle and the air bag systems. To purchase a service manual, see Service Publications Ordering Information on page 7-10.
Page 78: Restraint System Check
Adding Equipment to Your Air Bag-Equipped Vehicle If I add a luggage carrier or sunroof to the roof of my vehicle, will it keep the roof-mounted side impact air bags from working properly? As long as the luggage carrier or sunroof is properly installed so that the vehicle’s basic structure isn’t changed, it’s not likely to keep the roof-mounted side impact air bags from working...
Page 79: Replacing Restraint System Parts After A Crash
Replacing Restraint System Parts After a Crash CAUTION: A crash can damage the restraint systems in your vehicle. A damaged restraint system may not properly protect the person using it, resulting in serious injury or even death in a crash. To help make sure your restraint systems are working properly after a crash, have them inspected and any necessary replacements made as soon as possible.
Page 80 NOTES 1-74...
Page 81: Features And Controls
Section 2 Keys ...2-3 Remote Keyless Entry System ...2-4 Remote Keyless Entry System Operation ...2-5 Doors and Locks ...2-9 Door Locks ...2-9 Power Door Locks ...2-10 Delayed Locking ...2-10 Programmable Automatic Door Locks ...2-11 Rear Door Security Locks ...2-11 Lockout Protection ...2-12 Leaving Your Vehicle ...2-12 Trunk/Liftgate ...2-13 Windows ...2-16...
Page 82 Section 2 Storage Areas ...2-41 Glove Box ...2-41 Center Console Storage Area ...2-41 Assist Handles ...2-41 Features and Controls Load Floor Storage Box ...2-42 Roof Rack System ...2-42 Cargo Cover ...2-43 Sunroof ...2-45...
Page 83: Keys
Keys CAUTION: Leaving children in a vehicle with the ignition key is dangerous for many reasons. They could operate the power windows or other controls or even make the vehicle move. The children or others could be badly injured or even killed.
Page 84: Remote Keyless Entry System
One key is used for the ignition and all of the locks. Key code information can be obtained only at the retailer where your vehicle was purchased. These code numbers can be used to make new keys. Additional keys that are needed can be made at any retail service facility provided you have the key code information.
Page 85: Remote Keyless Entry System Operation
Replacement” and “Resynchronization” under Remote Keyless Entry System Operation on page 2-5. • If you are still having trouble, see your Saturn retailer or authorized service provider for service. Remote Keyless Entry System Operation With this feature, you can lock and unlock the doors or...
Page 86: Theft-Deterrent System
UNLOCK: Press this button on the remote keyless entry transmitter to unlock the driver’s door. This also disarms the theft-deterrent system. See “Theft-Deterrent System” following for information on disarming the theft-deterrent system. Press the button again within 5 seconds to unlock the rest of the doors. (Panic Alarm): Press the button with the horn symbol when the ignition is turned off.
Page 87: Battery Replacement
A chime will sound once the mode has been selected. If you accidentally set off the alarm when entering/exiting the vehicle, you can shut it off by pressing any button on the remote keyless entry transmitter other than the panic alarm button. If you hear three horn chirps when you press the unlock button on the transmitter, that means the vehicle’s alarm was triggered while you were away.
Page 88 2. Once the transmitter is separated, use a pencil or similar object to remove the old battery. Do not use a metal object. 3. Insert the new battery as the instructions under the cover indicate. 4. Snap the transmitter back together tightly to be sure no moisture can enter.
Page 89: Doors And Locks
Doors and Locks Door Locks CAUTION: Unlocked doors can be dangerous. • Passengers — especially children — can easily open the doors and fall out of a moving vehicle. When a door is locked, the handle will not open it. You increase the chance of being thrown out of the vehicle in a crash if the doors are not locked.
Page 90: Power Door Locks
Power Door Locks Press the bottom half of the switch on either front door to lock all of the doors. Push the top half of the switch to unlock all of the doors. The unlocked door indicators on the manual door lock pins will be hidden when the doors are locked.
Page 91: Programmable Automatic Door Locks
Programmable Automatic Door Locks With this feature, all the doors will lock as the transaxle is shifted out of PARK (P) if the ignition key is in the RUN position and all doors are closed. The doors will automatically lock if the vehicle is going faster than 3 mph (5 km/h).
Page 92: Lockout Protection
When you want to open a rear door when the security lock is on, do the following: 1. Unlock the door using the remote keyless entry transmitter, the front door power lock switch, or by lifting the rear door manual lock. 2.
Page 93: Trunk (Sedan)
Trunk/Liftgate CAUTION: It can be dangerous to drive with the trunk or liftgate open because carbon monoxide (CO) gas can come into your vehicle. You can not see or smell CO. It can cause unconsciousness and even death.If you must drive with the trunk or liftgate open or if electrical wiring or other cable connections must pass through the seal between the body...
Page 94: Liftgate Release (Wagon)
Liftgate Release (Wagon) Unlock the liftgate by doing any of the following: • Press the unlock button on your remote keyless entry transmitter twice. • Press the liftgate button on your transmitter. • Press the interior door unlock switch. • Enable the automatic door unlocking feature.
Page 95: Emergency Trunk Release Handle
Emergency Trunk Release Handle (Sedan) There is a glow-in-the-dark trunk release handle located inside the trunk near the bottom edge of the trunk lid. This handle will glow following exposure to light. Notice: Using the emergency trunk release handle as a tie-down or anchor point when securing items in the trunk may damage it.
Page 96: Windows
Windows CAUTION: Leaving children, helpless adults, or pets in a vehicle with the windows closed is dangerous. They can be overcome by the extreme heat and suffer permanent injuries or even death from heat stroke. Never leave a child, a helpless adult, or a pet alone in a vehicle, especially with the windows closed in warm or hot weather.
Page 97: Power Windows
Manual Windows On a vehicle with manual windows, use the window crank to open and close each window. Power Windows Switches are located on each side of the shift lever on the console. To open a window press the switch down and lift up to close it.
Page 98: Theft-Deterrent Systems
Window Lock Out The driver’s window controls also include a lock-out switch. Press the window lock switch to the left to stop rear passengers from using their window switches. The driver can still control all the windows with the lock on.
Page 99: Starting And Operating Your Vehicle
During normal operation, the security light will go off approximately ﬁve seconds after the key is turned to the RUN ignition position following an engine start. If the engine stalls and the security light ﬂashes, wait until the light stops ﬂashing before trying to restart the engine.
Page 100: Ignition Positions
Ignition Positions With the key in the ignition switch, you can turn the switch to four positions. OFF: This position locks your steering column in a vehicle with a manual transmission. It is a theft-deterrent feature. You will only be able to remove your key when the ignition is turned to OFF.
Page 101: Starting Your Engine
Starting Your Engine Automatic Transaxle Move your shift lever to PARK (P) or NEUTRAL (N). Your engine won’t start in any other position — that is a safety feature. To restart when you’re already moving, use NEUTRAL (N) only. Notice: Shifting into PARK (P) with the vehicle moving could damage the transaxle.
Page 102: Engine Coolant Heater
Engine Coolant Heater If your vehicle has this feature, in very cold weather, 20°F ( 29°C) or colder, the engine coolant heater can help. You’ll get easier starting and better fuel economy during engine warm-up. Usually, the coolant heater should be plugged in a minimum of four hours prior to starting your vehicle.
Page 103: Automatic Transaxle Operation
Automatic Transaxle Operation Your vehicle is equipped with an automatic transaxle, the shift lever is located on the console between the seats. There are several positions for the shift lever. PARK (P): This position locks your front wheels. It’s the best position to use when you start your engine because your vehicle can’t move easily.
Page 104 Then move the shift lever into the gear you wish. Press the shift lever button before moving the shift lever. See Shifting Out of Park (P) on page 2-30. REVERSE (R): Use this gear to back up. Notice: Shifting to REVERSE (R) while your vehicle is moving forward could damage the transaxle.
Page 105 AUTOMATIC OVERDRIVE ( ): This position is for normal driving with the automatic transaxle. If you need more power for passing, and you’re: • Going less than about 35 mph (55 km/h), push your accelerator pedal about halfway down. • Going about 35 mph (55 km/h), push your accelerator all the way down.
Page 106: Shift Lock Release
Shift Lock Release If you ever hold the brake pedal down, but still cannot shift out of PARK (P), try this: 1. Turn the ignition to OFF and remove the key. 2. Carefully pry the shift lock override cover from the ﬂoor shift console.
Page 107: Parking Brake
Parking Brake The parking brake lever is located between the bucket seats. When parking your vehicle, set the parking brake before shifting your automatic transaxle into PARK (P). To set the parking brake, hold the brake pedal down and pull up on the parking brake lever. If the ignition is on, the brake system warning light will come on.
Page 108: Shifting Into Park (P) (Automatic Transaxle)
Shifting Into Park (P) (Automatic Transaxle) CAUTION: It can be dangerous to get out of your vehicle if the shift lever is not fully in PARK (P) with the parking brake ﬁrmly set. Your vehicle can roll. If you have left the engine running, the vehicle can move suddenly.
Page 109: Torque Lock
Leaving Your Vehicle With the Engine Running CAUTION: It can be dangerous to leave your vehicle with the engine running. Your vehicle could move suddenly if the shift lever is not fully in PARK (P) with the parking brake ﬁrmly set. And, if you leave the vehicle with the engine running, it could overheat and even catch ﬁre.
Page 110: Parking Over Things That Burn
Shifting Out of Park (P) Your vehicle has an automatic transaxle shift lock control system. You have to fully apply your regular brakes before you can shift from PARK (P) when the ignition is in RUN. See Automatic Transaxle Operation on page 2-23. If you cannot shift out of PARK (P), ease pressure on the shift lever and push the shift lever all the way into PARK (P), while pressing the button on the shift...
Page 111: Engine Exhaust
Engine Exhaust CAUTION: Engine exhaust can kill. It contains the gas carbon monoxide (CO), which you can not see or smell. It can cause unconsciousness and death. You might have exhaust coming in if: • Your exhaust system sounds strange or different.
Page 112: Running Your Engine While You Are Parked
Running Your Engine While You Are Parked It is better not to park with the engine running. But if you ever have to, here are some things to know. CAUTION: Idling the engine with the climate control system off could allow dangerous exhaust into your vehicle.
Page 113: Mirrors
Mirrors Manual Rearview Mirror While you are sitting in a comfortable driving position, adjust the mirror so you can see clearly behind your vehicle. Grip the mirror in the center to move it up or down and side to side. The day/night adjustment, located at the bottom of the mirror, allows you to adjust the mirror to avoid glare from the lamps behind you.
Page 114: Temperature And Compass Display
Automatic Dimming Rearview Mirror ® with OnStar , Compass and Temperature Display Your vehicle may have this feature. When on, an automatic dimming mirror automatically dims to the proper level to minimize glare from lights behind you after dark. The mirror also includes a duel display in the upper right corner of the mirror face.
Page 115: Automatic Dimming Mirror Operation
Automatic Dimming Mirror Operation The automatic dimming mirror function is turned on automatically each time the ignition is started. To operate the automatic dimming mirror do the following: 1. Make sure the indicator light, located to the left of the on/off button, is lit. If it’s not, press and hold the on/off button for approximately six seconds until the light comes on, indicating that the mirror is in automatic dimming mode.
Page 116 To adjust for compass variance do the following: 1. Find your current location and variance zone number on the following zone map. 2. Press and hold the on/off button until a zone number appears in the display. The compass is now in zone mode.
Page 117: Compass Operation
Temperature Display The temperature can be displayed by pressing the TEMP button. Pressing the TEMP button once brieﬂy, will toggle the temperature reading from Fahrenheit (°F), Celsius (°C), to off. Automatic Dimming Mirror Operation Press the COMP button to turn the automatic dimming feature on and off.
Page 118: Outside Remote Control Mirror
To adjust for compass variance: 1. Find your current location and variance zone number on the following zone map. 2. Press and hold the COMP button for ﬁve seconds until a zone number appears in the display. 3. Press the COMP button on the bottom of the mirror until the new zone number appears in the display.
Page 119 Outside Power Mirrors The outside power mirror control is located on the driver’s door. Use the selector switch located above the round touch pad to choose either the left or right outside mirror. To adjust the mirror press the round touch pad in the desired direction.
Page 120: Onstar System
® OnStar System ® OnStar uses global positioning system (GPS) satellite technology, wireless communications, and call centers to provide you with a wide range of safety, security, information and convenience services. ® A complete OnStar user’s guide and the terms and ®...
Page 121: Storage Areas
Luxury and Leisure Plan • All Directions and Connections Plan services • Personal Concierge ® OnStar Personal Calling ® With OnStar Personal Calling, you have a safer way to stay connected while driving. It’s a hands-free wireless phone that’s integrated into your vehicle. You can place calls nationwide using voice-activated dialing with no contracts and no additional roaming charges.
Page 122: Roof Rack System
Load Floor Storage Box Some wagon models have a load ﬂoor storage box, which is located in the rear of the vehicle. This storage space is designed to hold small items. Roof Rack System Your vehicle may have the roof rack system to load things on.
Page 123: Cargo Cover
Do not exceed the maximum vehicle capacity when loading your vehicle. For more information on vehicle capacity and loading, see Loading Your Vehicle on page 4-34. To prevent damage or loss of cargo as you’re driving, check frequently to ensure your cargo is securely fastened.
Page 124: Removing The Cargo Cover
Removing the Cargo Cover To remove the cargo shade: 1. Unhook the shade and allow it to retract all the way. 2. Grasp the shade on the driver’s side of the vehicle and move it toward the passenger’s side, compressing the spring. 3.
Page 125: Sunroof
Sunroof If your vehicle has this feature, the switch will be located above your rearview mirror. Your ignition key must be in the RUN or ACC position to operate the sunroof. To open the sunroof three-quarters of the way, press and hold the SLIDE portion of the switch.
Page 126 NOTES 2-46...
Page 127: Instrument Panel
Section 3 Instrument Panel Overview ...3-2 Hazard Warning Flashers ...3-4 Other Warning Devices ...3-5 Horn ...3-5 Tilt Wheel ...3-5 Turn Signal/Multifunction Lever ...3-6 Windshield Wiper Lever ...3-8 Cruise Control ...3-10 Exterior Lamps ...3-13 Interior Lamps ...3-15 Accessory Power Outlets ...3-16 Ashtrays and Cigarette Lighter ...3-17 Climate Controls ...3-17 Climate Control System ...3-17...
Page 128: Instrument Panel Overview
Instrument Panel Overview...
Page 129 The main components of the instrument panel are the following: A. Air Outlets. See Outlet Adjustment on page 3-24. B. Turn Signal/Multifunction Lever. See Turn Signal/Multifunction Lever on page 3-6. C. Cruise Control (If Equipped). See Cruise Control on page 3-10. D.
Page 130: Hazard Warning Flashers
Hazard Warning Flashers Your hazard warning ﬂashers let you warn others. They also let police know you have a problem. Your front and rear turn signal lamps will ﬂash on and off. The hazard warning ﬂasher button is located near the center of the instrument panel.
Page 131: Other Warning Devices
Other Warning Devices If you carry reﬂective triangles, you can set one up at the side of the road about 300 feet (100 m) behind your vehicle. Horn You can sound the horn by pressing the center of your steering wheel. Tilt Wheel Your vehicle may have a tilt wheel which allows you to adjust the steering wheel before you drive.
Page 132: Turn Signal/Multifunction Lever
Turn Signal/Multifunction Lever The lever on the left side of the steering column includes the following: • Turn and Lane-Change Signals • Headlamps • Headlamp High/Low-Beam Changer • Flash-to-Pass Feature For additional information on the exterior lamps, see Exterior Lamps on page 3-13. Turn and Lane-Change Signals The turn signal has two upward (for right) and two downward (for left) positions.
Page 133: Headlamp High/Low-Beam Changer
Headlamp High/Low-Beam Changer To change the headlamps from low beam to high or high beam to low, pull the turn signal lever all the way towards you. Then release it. When the high beams are on, this light on the instrument panel cluster will also be on.
Page 134: Windshield Wiper Lever
Windshield Wiper Lever The lever on the right side of the steering column operates the windshield wipers. : Pull the lever down and release it for a single wiping cycle. The lever will return to its original position. For more cycles, hold the lever down before releasing it. : Put the lever in this position to turn off the wipers.
Page 135: Windshield Washer
Windshield Washer CAUTION: In freezing weather, do not use your washer until the windshield is warmed. Otherwise the washer ﬂuid can form ice on the windshield, blocking your vision. Pull the windshield wiper lever toward you to operate the windshield wipers. Washer ﬂuid will squirt onto the windshield and the wipers will run for a few cycles to clear the windshield.
Page 136: Cruise Control
Cruise Control The buttons for the cruise control are located on the steering wheel. (Cruise On/Off): Push this button to turn the system on and off. (Resume/Accelerate): Push this button to make the vehicle resume a previously set speed or to accelerate when cruise is already active.
Page 137 Setting Cruise Control CAUTION: If you leave your cruise control on when you are not using cruise, you might hit a button and go into cruise when you do not want to. You could be startled and even lose control. Keep the cruise control switch off until you want to use cruise control.
Page 138 Increasing Speed While Using Cruise Control There are two ways to go to a higher speed: • Use the accelerator pedal to get to the higher speed. Press the set/coast button, then release the button and the accelerator pedal. You’ll now cruise at the higher speed.
Page 139: Exterior Lamps
Ending Cruise Control To end a cruise control session, step lightly on the brake pedal. Stepping on the brake will end the current cruise control session only. Press the cruise on/off button to turn off the system completely. Erasing Speed Memory When you turn off the cruise control or the ignition, your cruise control set speed memory is erased.
Page 140: Automatic Headlamp System
Automatic Headlamp System When it is dark enough outside, the headlamps will come on automatically. Your vehicle has a light sensor located on top of the instrument panel. Make sure it is not covered, or the headlamps will be on when you don’t need them.
Page 141: Dome Lamp
Interior Lamps Instrument Panel Brightness This feature controls the brightness of the instrument panel lights. The thumbwheel for this feature is located on the instrument panel to the left of the steering column. Turn the thumbwheel up to brighten the lights or down to dim them.
Page 142: Accessory Power Outlets
Battery Run-Down Protection Your vehicle is equipped with a battery saver feature designed to protect your vehicle’s battery. When any interior lamp is left on and the ignition is turned off, the battery rundown protection system will automatically turn the lamp off after 20 minutes. Accessory Power Outlets The accessory power outlets can be used to connect electrical equipment such as a cellular phone or...
Page 143: Climate Controls
Ashtrays and Cigarette Lighter Your vehicle may have an ashtray and cigarette lighter. To use the lighter, just push it in all the way and let go. When it’s ready, it will pop back out by itself. Notice: Holding a cigarette lighter in while it is heating will not allow the lighter to back away from the heating element when it is hot.
Page 144 Operation To change the current mode, turn the right knob to select one of the following: (Vent): This mode directs air to the instrument panel outlets. (Bi-Level): This mode directs half of the air to the instrument panel outlets, and then directs most of the remaining air to the ﬂoor outlets.
Page 145: Defogging And Defrosting
AC (Air Conditioning): Press this button to turn the air-conditioning system on or off. When A/C is pressed, an indicator light above the button will come on to let you know that air conditioning is activated. On hot days, open the windows to let hot inside air escape;...
Page 146: Rear Window Defogger
Rear Window Defogger The rear window defogger uses a warming grid to remove fog or frost from the rear window. < REAR: Press this button to turn the rear window defogger on or off. An indicator light above the button will come on to let your know that the rear window defogger is activated.
Page 147: Automatic Operation
Automatic Operation To switch the temperature display from degrees Fahrenheit to degrees Celsius, press and hold the AUTO, ECON, and MODE buttons at the same time. AUTO (Automatic): When automatic operation is active the system will control the inside temperature, the air delivery, and the fan speed.
Page 148: Manual Operation
Manual Operation You may manually adjust the air delivery mode or fan speed. OFF: Press this button to turn off the entire climate control system. Outside air will still enter the vehicle. (Fan): The knob with the fan symbol allows you to manually adjust the fan speed.
Page 149 Sensor A sensor located on top of the instrument panel is used by the automatic climate control system to adjust the automatic operation of the system. Do not cover this sensor. Defogging and Defrosting You can use either defog or front defrost to clear fog or frost from your windshield.
Page 150: Passenger Compartment Air Filter
Outlet Adjustment Use the louvers located on the air outlets to change the direction of the airﬂow. Operation Tips • Clear away any ice, snow or leaves from the air inlets at the base of the vehicle that may block the ﬂow of air into your vehicle.
Page 151: Warning Lights, Gages, And Indicators
5. Release the two locking tabs and pull the ﬁlter out. 6. Reverse the steps to install the new air ﬁlter. Warning Lights, Gages, and Indicators This part describes the warning lights and gages that may be on your vehicle. The pictures will help you locate them.
Page 152: Instrument Panel Cluster
Instrument Panel Cluster The instrument cluster is designed to let you know at a glance how the vehicle is running. You will know how fast you are going, about how much fuel you have used, and many other things you will need to know to drive safely and economically.
Page 153: Speedometer And Odometer
Speedometer and Odometer Your speedometer lets you see your speed in both miles per hour (mph) and kilometers per hour (km/h). Your odometer shows how far your vehicle has been driven, in either miles or kilometers. Your vehicle has a tamper-resistant odometer. You may wonder what happens if your vehicle needs a new odometer installed.
Page 154: Safety Belt Reminder Light
Safety Belt Reminder Light When the key is turned to RUN or START, a chime will come on for several seconds to remind people to fasten their safety belts, unless the driver’s safety belt is already buckled. The safety belt light will also come on and stay on for several seconds, then it will ﬂash for several more.
Page 155: Battery Warning Light
CAUTION: If the air bag readiness light stays on after you start your vehicle, it means the air bag system may not be working properly. The air bags in your vehicle may not inﬂate in a crash, or they could even inﬂate without a crash. To help avoid injury to yourself or others, have your vehicle serviced right away if the air bag readiness light stays on after you start your...
Page 156 Brake System Warning Light Your vehicle’s hydraulic brake system is divided into two parts. If one part isn’t working, the other part can still work and stop you. For good braking, though, you need both parts working well. If the brake system warning light comes on, there is a brake problem.
Page 157: Anti-Lock Brake System Warning Light
Anti-Lock Brake System Warning Light If your vehicle has anti-lock brakes, the anti-lock brake system (ABS) warning light will come on brieﬂy, as a check, when you start your vehicle. If it does not, have your vehicle serviced so that the light works properly when it needs to.
Page 158: Traction Control System (Tcs) Warning Light
Traction Control System (TCS) Warning Light The Traction Control System (TCS) light will come on when the system is limiting wheel spin. You may feel or hear the system working, but this is normal. The roads may be slippery if this light comes on. Adjust your driving accordingly.
Page 159: Engine Coolant Temperature Gage
Engine Coolant Temperature Gage This gage measures the temperature of the vehicle’s engine. If the indicator needle moves into the shaded area, the engine is too hot. A temperature indicator light will turn on and a chime will sound. If you have been operating your vehicle under normal driving conditions, and the temperature indicator light comes on, you should pull off the road, stop your vehicle and turn off the engine as soon as possible.
Page 160: Malfunction Indicator Lamp
Malfunction Indicator Lamp Service Engine Soon Light Your vehicle is equipped with a computer which monitors operation of the fuel, ignition and emission control systems. This system is called OBD II (On-Board Diagnostics-Second Generation) and is intended to assure that emissions are at acceptable levels for the life of the vehicle, helping to produce a cleaner environment.
Page 161: If The Light Is On Steady
This light should come on, as a check to show you it is working, when the ignition is on and the engine is not running. If the light does not come on, have it repaired. This light will also come on during a malfunction in one of two ways: •...
Page 162: Emissions Inspection And Maintenance Programs
Have you recently changed brands of fuel? If so, be sure to fuel your vehicle with quality fuel. See Gasoline Octane on page 5-5. Poor fuel quality will cause your engine not to run as efficiently as designed. You may notice this as stalling after start-up, stalling when you put the vehicle into gear, misﬁring, hesitation on acceleration or stumbling on acceleration.
Page 163: Maintenance Schedule
Oil Pressure Light If you have a low engine oil pressure problem, this light will stay on after you start your engine, or come on when you are driving. This indicates that your engine is not receiving enough oil. The engine could be low on oil, or could have some other oil problem.
Page 164: Change Engine Oil Light
Change Engine Oil Light If this light comes on and stays on, it means that service is required for your vehicle. See Scheduled Maintenance on page 6-4 Engine Oil on page 5-16 for more information. Security Light Your vehicle is equipped with a Passlock theft-deterrent system.
Page 165: Daytime Running Lamps Indicator Light
Daytime Running Lamps Indicator Light This light is located on the instrument panel cluster. It goes on whenever the Daytime Running Lamps are on. See Daytime Running Lamps under Exterior Lamps on page 3-13 for further information. Low Washer Fluid Warning Light This light will come on when your vehicle is low on windshield washer ﬂuid.
Page 166: Fuel Gage
Fuel Gage When the ignition is on, the fuel gage tells you about how much fuel you have left in your tank. When the indicator nears empty, the low fuel light will come on. You still have a little fuel left, but you should get more soon.
Page 167: Audio System(S)
Audio System(s) Notice: Before adding any sound equipment to your vehicle, like a tape player, CB radio, mobile telephone, or two-way radio, make sure that it can be added by checking with your dealer. Also, check federal rules covering mobile radio and telephone units.
Page 168: Am-Fm Radio
AM-FM Radio Playing the Radio ON (Power): Push this knob to turn the system on and off. VOL (Volume): Turn this knob to increase or to decrease the volume. RCL (Recall): Press this knob to switch the display between the radio station frequency and the time. When the ignition is off, press this knob to display the time.
Page 169: Setting Preset Stations
Setting Preset Stations Up to 18 stations (six FM1, six FM2, and six AM) can be programmed on the six numbered pushbuttons, by performing the following steps: 1. Turn the radio on. 2. Press AM FM to select FM1, FM2, or AM. 3.
Page 170: Adjusting The Speakers (Balance/Fade)
Cancelling Automatic Set The radio retains the previously stored stations so they can be recalled when automatic set is canceled. Press and hold A.SET until you hear a beep. A.SET will no longer appear on the display. Setting the Tone (Bass/Treble) BASS: Press this knob lightly so it extends.
Page 171: Radio With Cd
Radio with CD Playing the Radio PUSH ON (Power): Press this knob to turn the system on and off. VOL (Volume): Turn this knob to increase or to decrease volume. RCL (Recall): Press this knob to switch the display between the radio station frequency and the time. Time display is available with the ignition turned off.
Page 172 Setting Preset Stations The six numbered pushbuttons let you return to your favorite stations. You can set up to 18 stations (six FM1, six FM2, and six AM) by performing the following steps: 1. Turn the radio on. 2. Press AM FM to select FM1, FM2, or AM. 3.
Page 173: Playing A Cd
Setting the Tone (Bass/Treble) MODE: Press this button until BAS or TRE appears on the display. Press the plus or minus buttons to increase or to decrease. The display will show the bass or the treble level. If a station is weak or noisy, you may want to decrease the treble.
Page 174 Do not add paper labels to CDs, they could get caught in the CD player. Do not play 3 inch CDs without a standard adapter CD. If an error appears on the display, see “CD Messages” later in this section. 1 PRV (Previous): Press this pushbutton to go to the start of the current track if more than eight seconds have played.
Page 175 RCL (Recall): Press this button to see the track number. Press this button again to see how long the current track has been playing. AM FM: Press this button to listen to the radio when a CD is playing. The inactive CD will remain safely inside the radio for future listening.
Page 176: Finding A Station
Radio with Cassette and CD Single CD Player Audio System Shown — Six-CD CD Player Similar 3-50 Playing the Radio PUSH ON (Power): Press this knob to turn the system on and off. VOL (Volume): Turn this knob to increase or to decrease volume.
Page 177 Setting Preset Stations The six numbered pushbuttons let you return to your favorite stations. You can set up to 18 stations (six FM1, six FM2, and six AM) by performing the following steps: 1. Turn the radio on. 2. Press AM FM to select FM1, FM2, or AM. 3.
Page 178: Playing A Cassette Tape
Setting the Tone (Bass/Treble) BASS/TREB (Treble): Press and release this knob until BASS or TREB appears on the display. Turn the knob to increase or to decrease. The display will show the bass or the treble level. If a station is weak or noisy, you may want to decrease the treble.
Page 179 1 PREV (Previous): Press this pushbutton to go to the beginning of the current selection. Press this pushbutton again to go to the previous selection on the tape. 2 NEXT: Press this pushbutton to go to the next selection on the tape. The radio will play while the tape advances.
Page 180: Cassette Tape Messages
Cassette Tape Messages ERR (Error): If this message appears on the display, the tape will not play because of one of the following errors. • The tape is tight and the player cannot turn the tape hubs. Remove the tape. Hold the tape with the open end down and try to turn the right hub counterclockwise with a pencil.
Page 181 If playing a CD-R the sound quality may be reduced due to CD-R quality, the method of recording, the quality of the music that has been recorded, and the way the CD-R has been handled. You may experience an increase in skipping, difficulty in ﬁnding tracks and/or difficulty in loading and ejecting.
Page 182: Playing The Six–Disc Cd Player
CD TP (Tape): Press this button to play a CD when listening to the radio. Press this button to switch between the tape, CD, and DVD (if equipped) if loaded. The inactive tape, CD, or DVD will remain safely inside the radio for future listening. EJ (Eject): Press this button, located to the left of the CD slot, to eject a CD.
Page 183 3. Press the pushbutton (1-6) for the CD slot to load or to eject. WAIT will appear on the display. If a CD is already loaded the CD will eject. If the CD slot is empty, LOAD will appear on the display, and a CD can be loaded.
Page 184 REW (Rewind): Press and hold the down arrow to rewind quickly within a track. Release it to play the passage. The display will show the elapsed time of the track. FF (Fast Forward): Press and hold the up arrow to advance quickly within a track.
Page 185: Rear Seat Entertainment System
Rear Seat Entertainment System Your vehicle may have a DVD Rear Seat Entertainment (RSE) system. The RSE system works with the vehicles audio system and includes a DVD radio, a video display screen, two sets of wireless headphones, and a remote control. Before You Drive The RSE is designed for rear seat passengers only.
Page 186: Stereo Rca Jacks
Battery Replacement To change the batteries, do the following: 1. Slide open the battery door located on the left side of the headphones. 2. Replace the two AAA batteries in the compartment. Make sure that they are installed correctly, using the diagram on the inside of the battery compartment.
Page 187: Audio Output
The RCA jacks are color coded to match typical home entertainment system equipment. The yellow jack (right) is for the video input. The white jack (middle) is for the left audio input. The red jack (left) is for the right audio input.
Page 188: Video Screen
Video Screen The video screen is located in the overhead console. To use the video screen, do the following: 1. Push forward on the release button on the DVD display console. 2. Pull the screen down, away from you, and adjust its position as desired.
Page 189 The DVD radio is only compatible with DVDs authorized for use in the United States and Canada (Region Code 1). The DVD region code is printed on the jacket of most DVDs. Regular audio CDs, CD-R, CD-RW, and MP3s can also be played by the DVD radio. If an error message appears on the video screen or the radio, see “DVD Display Error Messages”...
Page 190: Remote Control
Stopping and Resuming Playback To stop playing a disc, press the stop button on the remote control. To resume playback, press the play/pause button on the remote control. The movie should resume play from where it last stopped if the disc has not been ejected and the stop button has not been pressed twice on the remote control.
Page 191 Remote Control Buttons (Power): Press this button to turn the DVD player on and off. (Title): Press this button to return the DVD to the main menu of the DVD. (Menu Navigation Arrows): Use the arrow buttons to navigate through a menu. (Set-up Menu): Press this button to adjust the color, tint, brightness, contrast, and display mode (normal, full, or zoom).
Page 192 1 through 0 (Numeric Keypad): The numeric keypad provides the capability of direct chapter, title, and track number selection. 10 (Double Digit Entries): Press the button, to select chapter, title, and track numbers greater than 9. Press this button before inputting the number. (Clear): Press this button, within 3 seconds after inputting a numeric selection to clear all numeric inputs.
Page 193: Dvd Display Error Messages
(Play/Pause): Press this button to start play of a DVD or CD. Press this button while a DVD or CD is playing to pause it. Press this button again to continue playing the DVD or CD. When the DVD is playing, press the pause button then press the fast forward button.
Page 194: Dvd Radio Error Messages
DVD Radio Error Messages The radio may display one of the following: No Disc: This message will be displayed, if no disc is present when the play, eject, or DVD/AUX button is pressed on the remote control or the eject, RSE, or AUX button is pressed on the radio.
Page 195: Theft-Deterrent Feature
Theft-Deterrent Feature The Radio with Cassette and CD and the Radio with Cassette and Six-Disc CD have a theft deterrent feature. The theft deterrent feature is designed to discourage theft of your vehicle’s radio. It works by using a secret code to disable all radio functions whenever battery power is interrupted.
Page 196 5. Press the SEEK/SCAN up arrow to make the ﬁrst digit agree with your code. 6. Press the SEEK/SCAN down arrow to make the second digit agree with your code. 7. Press the TUNE up arrow to make the third digit agree with your code.
Page 197: Radio Reception
Disabling the Theft-Deterrent Feature Enter your secret code as follows; pause no more than 15 seconds between steps: Preform Steps 1 through 9 from the “Activating the Theft-Deterrent Feature” earlier to enter your secret code. OFF will appear on the display indicating the theft deterrent feature is off.
Page 198: Care Of Your Cassette Tape Player
Care of Your Cassette Tape Player A tape player that is not cleaned regularly can cause reduced sound quality, ruined cassettes, or a damaged mechanism. Cassette tapes should be stored in their cases away from contaminants, direct sunlight, and extreme heat. If they are not, they may not operate properly or they may cause failure of the tape player.
Page 199: Care Of Your Cds And Dvds
Care of Your CDs and DVDs Handle discs carefully. Store them in their original cases or other protective cases and away from direct sunlight and dust. If the surface of a disc is soiled, dampen a clean, soft cloth in a mild, neutral detergent solution and clean it, wiping from the center to the edge.
Page 200 NOTES 3-74...
Page 201 Section 4 Your Driving, the Road, and Your Vehicle ...4-2 Defensive Driving ...4-2 Drunken Driving ...4-2 Control of a Vehicle ...4-5 Braking ...4-6 Traction Control System (TCS) ...4-9 Steering ...4-10 Off-Road Recovery ...4-12 Passing ...4-13 Loss of Control ...4-14 Driving at Night ...4-15 Driving in Rain and on Wet Roads ...4-17 Driving Your Vehicle City Driving ...4-20...
Page 202: Your Driving, The Road, And Your Vehicle
Your Driving, the Road, and Your Vehicle Defensive Driving The best advice anyone can give about driving is: Drive defensively. Please start with a very important safety device in your vehicle: Buckle up. See Safety Belts: They Are for Everyone on page 1-11. Defensive driving really means “be ready for anything.”...
Page 203 Many adults — by some estimates, nearly half the adult population — choose never to drink alcohol, so they never drive after drinking. For persons under 21, it is against the law in every U.S. state to drink alcohol. There are good medical, psychological and developmental reasons for these laws.
Page 204 There is a gender difference, too. Women generally have a lower relative percentage of body water than men. Since alcohol is carried in body water, this means that a woman generally will reach a higher BAC level than a man of her same body weight will when each has the same number of drinks.
Page 205: Control Of A Vehicle
CAUTION: Drinking and then driving is very dangerous. Your reﬂexes, perceptions, attentiveness and judgment can be affected by even a small amount of alcohol. You can have a serious — or even fatal — collision if you drive after drinking. Please do not drink and drive or ride with a driver who has been drinking.
Page 206: Braking
Braking Braking action involves perception time and reaction time. First, you have to decide to push on the brake pedal. That is perception time. Then you have to bring up your foot and do it. That is reaction time. Average reaction time is about 3/4 of a second. But that is only an average.
Page 207: Anti-Lock Brake System (Abs)
Anti-lock Brake System (ABS) Your vehicle has anti-lock brakes. ABS is an advanced electronic braking system that will help prevent a braking skid. When you start your engine and begin to drive away, your anti-lock brake system will check itself. You may hear a momentary motor or clicking noise while this test is going on, and you may even notice that your brake pedal moves a little.
Page 208: Braking In Emergencies
The anti-lock system can change the brake pressure faster than any driver could. The computer is programmed to make the most of available tire and road conditions. This can help you steer around the obstacle while braking hard. As you brake, your computer keeps receiving updates on wheel speed and controls braking pressure accordingly.
Page 209: Traction Control System (Tcs)
Traction Control System (TCS) Your vehicle has a traction control system that limits wheel spin. This is especially useful in slippery road conditions. The system operates only if it senses that one or both of the front wheels are spinning or beginning to lose traction.
Page 210: Steering
To turn the system off, press the trac switch. The traction control system warning light will come on and stay on. If the system is limiting wheel spin when you press the button, the warning light will come on – but the system won’t turn off right away.
Page 211: Steering In Emergencies
Suppose you are steering through a sharp curve. Then you suddenly apply the brakes. Both control systems — steering and braking — have to do their work where the tires meet the road. Unless you have four-wheel anti-lock brakes, adding the hard braking can demand too much of those places.
Page 212: Off-Road Recovery
An emergency like this requires close attention and a quick decision. If you are holding the steering wheel at the recommended 9 and 3 o’clock positions, you can turn it a full 180 degrees very quickly without removing either hand. But you have to act fast, steer quickly, and just as quickly straighten the wheel once you have avoided the object.
Page 213: Passing
Passing The driver of a vehicle about to pass another on a two-lane highway waits for just the right moment, accelerates, moves around the vehicle ahead, then goes back into the right lane again. A simple maneuver? Not necessarily! Passing another vehicle on a two-lane highway is a potentially dangerous move, since the passing vehicle occupies the same lane as oncoming traffic for several seconds.
Page 214: Loss Of Control
• Check your mirrors, glance over your shoulder, and start your left lane change signal before moving out of the right lane to pass. When you are far enough ahead of the passed vehicle to see its front in your inside mirror, activate your right lane change signal and move back into the right lane.
Page 215: Driving At Night
If your vehicle starts to slide, ease your foot off the accelerator pedal and quickly steer the way you want the vehicle to go. If you start steering quickly enough, your vehicle may straighten out. Always be ready for a second skid if it occurs. Of course, traction is reduced when water, snow, ice, gravel or other material is on the road.
Page 216 Here are some tips on night driving. • Drive defensively. • Do not drink and drive. • Adjust your inside rearview mirror to reduce the glare from headlamps behind you. • Since you can not see as well, you may need to slow down and keep more space between you and other vehicles.
Page 217: Driving In Rain And On Wet Roads
Driving in Rain and on Wet Roads Rain and wet roads can mean driving trouble. On a wet road, you can not stop, accelerate or turn as well because your tire-to-road traction is not as good as on dry roads. And, if your tires do not have much tread left, you will get even less traction.
Page 218 Driving too fast through large water puddles or even going through some car washes can cause problems, too. The water may affect your brakes. Try to avoid puddles. But if you can not, try to slow down before you hit them. 4-18 CAUTION: Wet brakes can cause accidents.
Page 219: Driving Through Flowing Water
Hydroplaning Hydroplaning is dangerous. So much water can build up under your tires that they can actually ride on the water. This can happen if the road is wet enough and you are going fast enough. When your vehicle is hydroplaning, it has little or no contact with the road.
Page 220: Some Other Rainy Weather Tips
Some Other Rainy Weather Tips • Turn on your low-beam headlamps — not just your parking lamps — to help make you more visible to others. • Besides slowing down, allow some extra following distance. And be especially careful when you pass another vehicle.
Page 221: Freeway Driving
Here are ways to increase your safety in city driving: • Know the best way to get to where you are going. Get a city map and plan your trip into an unknown part of the city just as you would for a cross-country trip.
Page 222 The most important advice on freeway driving is: Keep up with traffic and keep to the right. Drive at the same speed most of the other drivers are driving. Too-fast or too-slow driving breaks a smooth traffic ﬂow. Treat the left lane on a freeway as a passing lane. At the entrance, there is usually a ramp that leads to the freeway.
Page 223: Before Leaving On A Long Trip
Of course, you will ﬁnd experienced and able service experts at Saturn retailers all across North America. They will be ready and willing to help if you need it. Here are some things you can check before a trip: •...
Page 224: Hill And Mountain Roads
What can you do about highway hypnosis? First, be aware that it can happen. Then here are some tips: • Make sure your vehicle is well ventilated, with a comfortably cool interior. • Keep your eyes moving. Scan the road ahead and to the sides.
Page 225 • Know how to go down hills. The most important thing to know is this: let your engine do some of the slowing down. Shift to a lower gear when you go down a steep or long hill. CAUTION: If you do not shift down, your brakes could get so hot that they would not work well.
Page 226: Winter Driving
Winter Driving Here are some tips for winter driving: • Have your vehicle in good shape for winter. • You may want to put winter emergency supplies in your trunk. Also see Tires on page 5-54. 4-26 Include an ice scraper, a small brush or broom, a supply of windshield washer ﬂuid, a rag, some winter outer clothing, a small shovel, a ﬂashlight, a red cloth and a couple of reﬂective warning triangles.
Page 227: Driving On Snow Or Ice
Driving on Snow or Ice Most of the time, those places where your tires meet the road probably have good traction. However, if there is snow or ice between your tires and the road, you can have a very slippery situation. You will have a lot less traction or “grip”...
Page 228: If You Are Caught In A Blizzard
Remember, unless you have anti-lock, if you brake so hard that your wheels stop rolling, you will just slide. Brake so your wheels always keep rolling and you can still steer. • Whatever your braking system, allow greater following distance on any slippery road. •...
Page 229 • Put on extra clothing or wrap a blanket around you. If you have no blankets or extra clothing, make body insulators from newspapers, burlap bags, rags, ﬂoor mats — anything you can wrap around yourself or tuck under your clothing to keep warm. You can run the engine to keep warm, but be careful.
Page 230: If You Are Stuck: In Sand, Mud, Ice Or Snow
Then, shut the engine off and close the window almost all the way to preserve the heat. Start the engine again and repeat this only when you feel really uncomfortable from the cold. But do it as little as possible. Preserve the fuel as long as you can. To help keep warm, you can get out of the vehicle and do some fairly vigorous exercises every half hour or so until help comes.
Page 231: Rocking Your Vehicle To Get It Out
Rocking Your Vehicle To Get It Out First, turn your steering wheel left and right. That will clear the area around your front wheels. You should turn your traction control system off. See Traction Control System (TCS) on page 4-9. Then shift back and forth between REVERSE (R) and a forward gear, spinning the wheels as little as possible.
Page 232: Towing
Towing Towing Your Vehicle Consult your dealer or a professional towing service if you need to have your disabled vehicle towed. See Roadside Assistance Program on page 7-6. If you want to tow your vehicle behind another vehicle for recreational purposes (such as behind a motorhome), see “Recreational Vehicle Towing”...
Page 233: Dinghy Towing
Dinghy Towing You may dinghy tow your vehicle from the front following these steps: 1. Set the parking brake. 2. Turn the ignition key to ACC to unlock the steering wheel. 3. Shift your transaxle to NEUTRAL (N). 4. Open the lid on the underhood fuse block and remove the IGN 0/3/CR and IGN 1/2 fuses.
Page 234: Loading Your Vehicle
Dolly Towing Your vehicle can be towed using a dolly. To tow your vehicle using a dolly, follow these steps: 1. Put the front wheels on a dolly. 2. Put the vehicle in PARK (P). 3. Set the parking brake and remove the key. 4.
Page 235 Tire and Loading Information Label Example 2 A. Vehicle Capacity Weight Example 1 The Tire and Loading Information label shows the seating A. Vehicle Capacity Weight capacity and the total weight your vehicle can properly carry. This weight is called the vehicle capacity weight. If your vehicle has the Tire and Loading Information label, Example 1, the label is attached to the center pillar, near the driver’s door latch.
Page 236 The Tire and Loading Information label also gives you the size and recommended inﬂation pressure for the factory-installed, original equipment tires on your vehicle. For more information on tires and inﬂation see Tires on page 5-54 and Inﬂation - Tire Pressure on page 5-61.
Page 237 Example 1 Loading Your Vehicle Item Description Vehicle Capacity Weight for Example 1= Subtract Occupant Weight 150 lbs (68 kg) Available Occupant and Cargo Weight = Total Item Vehicle Capacity Weight 1,000 lbs (453 kg) for Example 2 = Subtract Occupant 300 lbs (136 kg) Weight 150 lbs (68 kg)
Page 238 Example 3 Loading Your Vehicle Item Description Vehicle Capacity Weight for Example 3 = Subtract Occupant Weight 200 lbs (91 kg) Available Occupant and Cargo Weight = 4-38 Refer to your vehicle’s tire and loading information label for speciﬁc information about your vehicle’s capacity weight and seating positions.
Page 239 The GVWR includes the weight of the vehicle, all occupants, fuel and cargo. Never exceed the GVWR for your vehicle or the Gross Axle Weight Rating (GAWR) for either the front or rear axle. If you do have a heavy load, spread it out. Don’t carry more than 167 pounds (75 kg) in your trunk.
Page 240: Towing A Trailer
Towing a Trailer CAUTION: If you do not use the correct equipment and drive properly, you can lose control when you pull a trailer. For example, if the trailer is too heavy, the brakes may not work well — or even at all.
Page 241: If You Do Decide To Pull A Trailer
You can ask your dealer for our trailering information or advice, or you can write us at: Saturn Customer Assistance Center 100 Saturn Parkway Mail Code 371-999-S24 Spring Hill, TN 37174-1500...
Page 242: Weight Of The Trailer Tongue
Weight of the Trailer Tongue The tongue load (A) of any trailer is an important weight to measure because it affects the total or gross weight of your vehicle. The Gross Vehicle Weight (GVW) includes the curb weight of the vehicle, any cargo you may carry in it, and the people who will be riding in the vehicle.
Page 243: Safety Chains
Hitches It’s important to have the correct hitch equipment. Crosswinds, large trucks going by and rough roads are a few reasons why you will need the right hitch. Here are some rules to follow: • The rear bumper on your vehicle is not intended for hitches.
Page 244: Driving With A Trailer
Driving with a Trailer Towing a trailer requires a certain amount of experience. Before setting out for the open road, you will want to get to know your rig. Acquaint yourself with the feel of handling and braking with the added weight of the trailer. And always keep in mind that the vehicle you are driving is now a good deal longer and not nearly as responsive as your vehicle is by itself.
Page 245: Turn Signals When Towing A Trailer
Turn Signals When Towing a Trailer When you tow a trailer, your vehicle may need a different turn signal ﬂasher and/or extra wiring. Check with your dealer. The arrows on your instrument panel will ﬂash whenever you signal a turn or lane change.
Page 246: Maintenance When Trailer Towing
When You Are Ready to Leave After Parking on a Hill 1. Apply your regular brakes and hold the pedal down while you: • start your engine, • shift into a gear, and • release the parking brake. 2. Let up on the brake pedal. 3.
Page 247 Section 5 Service ...5-3 Doing Your Own Service Work ...5-4 Adding Equipment to the Outside of Your Vehicle ...5-5 Fuel ...5-5 Gasoline Octane ...5-5 Gasoline Speciﬁcations ...5-6 California Fuel ...5-6 Additives ...5-7 Fuels in Foreign Countries ...5-7 Filling Your Tank ...5-8 Filling a Portable Fuel Container ...5-9 Checking Things Under the Hood ...5-10 Hood Release ...5-10...
Page 248 Section 5 Tire Chains ...5-68 If a Tire Goes Flat ...5-69 Changing a Flat Tire ...5-70 Compact Spare Tire ...5-81 Appearance Care ...5-82 Cleaning the Inside of Your Vehicle ...5-82 Care of Safety Belts ...5-85 Weatherstrips ...5-85 Cleaning the Outside of Your Vehicle ...5-85 Sheet Metal Damage ...5-87 Finish Damage ...5-88 Underbody Maintenance ...5-88...
Page 249: Service
You will get genuine Saturn parts and Saturn-trained and supported service people. We hope you will want to keep your Saturn vehicle all Saturn. Genuine Saturn parts have one of these marks. California Proposition 65 Warning...
Page 250: Doing Your Own Service Work
Doing Your Own Service Work If you want to do some of your own service work, you will want to use the proper service manual. It tells you much more about how to service your vehicle than this manual can. To order the proper service manual, see Service Publications Ordering Information on page 7-10.
Page 251: Adding Equipment To The Outside Of Your Vehicle
Adding Equipment to the Outside of Your Vehicle Things you might add to the outside of your vehicle can affect the airﬂow around it. This may cause wind noise and affect windshield washer performance. Check with your retailer before adding equipment to the outside of your vehicle.
Page 252: Gasoline Speciﬁcations
(see Malfunction Indicator Lamp on page 3-34 ) and your vehicle may fail a smog-check test. If this occurs, return to your authorized Saturn retailer for diagnosis. If it is determined that the condition is caused by the type of fuel used, repairs may not...
Page 253: Additives
MMT can reduce the life of spark plugs and the performance of the emission control system may be affected. The malfunction indicator lamp may turn on. If this occurs, return to your authorized Saturn retailer for service. Fuels in Foreign Countries...
Page 254: Filling Your Tank
Filling Your Tank CAUTION: Fuel vapor burns violently and a fuel ﬁre can cause bad injuries. To help avoid injuries to you and others, read and follow all the instructions on the pump island. Turn off your engine when you are refueling. Do not smoke if you are near fuel or refueling your vehicle.
Page 255: Filling A Portable Fuel Container
CAUTION: (Continued) This spray can happen if your tank is nearly full, and is more likely in hot weather. Open the fuel cap slowly and wait for any “hiss” noise to stop. Then unscrew the cap all the way. Be careful not to spill fuel. Clean fuel from painted surfaces as soon as possible.
Page 256: Checking Things Under The Hood
Checking Things Under the Hood CAUTION: An electric fan under the hood can start up and injure you even when the engine is not running. Keep hands, clothing and tools away from any underhood electric fan. CAUTION: Things that burn can get on hot engine parts and start a ﬁre.
Page 257 2. Then go to the front of the vehicle and lift up on the secondary hood release lever. 3. Lift the hood, release the hood prop from its retainer and put the hood prop into the slot in the hood. Before closing the hood, be sure all the ﬁller caps are on properly.
Page 258: Engine Compartment Overview
Engine Compartment Overview When you open the hood on the 2.2L L4 (L61) engine, you’ll see the following: 5-12...
Page 259 A. Engine Air Cleaner/Filter. See Engine Air Cleaner/Filter on page 5-20 for more information. B. Engine Oil Dipstick. See Engine Oil on page 5-16 for more information. C. Engine Oil Fill Cap. See Engine Oil on page 5-16 for more information. D.
Page 260 When you open the hood on the 3.0L V6 (L81) engine, you’ll see the following: 5-14...
Page 261 A. Engine Air Cleaner/Filter. See Engine Air Cleaner/Filter on page 5-20 for more information. B. Engine Oil Dipstick. See Engine Oil on page 5-16 for more information. C. Engine Oil Fill Cap. See Engine Oil on page 5-16 for more information. D.
Page 262: Engine Oil
Engine Oil Checking Engine Oil It is a good idea to check your engine oil every time you get fuel. In order to get an accurate reading, the oil must be warm and the vehicle must be on level ground. The engine oil dipstick handle is a yellow loop.
Page 263: What Kind Of Engine Oil To Use
See Engine Compartment Overview on page 5-12 for the location of the engine oil ﬁll cap. Be sure to add enough oil to put the level somewhere in the proper operating range. Push the dipstick all the way back in when you are through. What Kind of Engine Oil to Use Look for two things: •...
Page 264: Engine Oil Additives
• SAE 5W-30 As shown in the viscosity chart, SAE 5W-30 is best for your vehicle. However, if it is going to be 0°F (–18°C) or above and SAE 5W-30 is not available, you may use SAE 10W-30. These numbers on an oil container show its viscosity, or thickness.
Page 265 Your retailer has trained service people who will perform this work using genuine Saturn parts and reset the system. It is also important to check your oil regularly and keep it at the proper level.
Page 266: What To Do With Used Oil
What to Do with Used Oil Used engine oil contains certain elements that may be unhealthy for your skin and could even cause cancer. Do not let used oil stay on your skin for very long. Clean your skin and nails with soap and water, or a good hand cleaner.
Page 267 CAUTION: Operating the engine with the air cleaner/ﬁlter off can cause you or others to be burned. The air cleaner not only cleans the air, it helps to stop ﬂame if the engine backﬁres. If it is not there and the engine backﬁres, you could be burned.
Page 268 3. Pull the air cleaner/ﬁlter box cover out and remove the air ﬁlter element from the air ﬁlter box. If the element is dirty, you should replace it. If the element is only dusty, it may be cleaned by blowing compressed air through it from the clean side.
Page 269: Automatic Transaxle Fluid
Automatic Transaxle Fluid It is not necessary to check the transaxle ﬂuid level. A transaxle ﬂuid leak is the only reason for ﬂuid loss. If a leak occurs, take the vehicle to retailer’s service department and have it repaired as soon as possible. You may also have your ﬂuid level checked by your retailer or service center when you have your oil changed.
Page 270: What To Use
What to Use Use a mixture of one-half clean, drinkable water and ® one-half DEX-COOL coolant which won’t damage aluminum parts. If you use this coolant mixture, you don’t need to add anything else. CAUTION: Adding only plain water to your cooling system can be dangerous.
Page 271: Checking Coolant
Checking Coolant The surge tank is located on the driver”s side of the engine compartment. See Engine Compartment Overview on page 5-12 for more information on location. CAUTION: Turning the surge tank pressure cap when the engine and radiator are hot can allow steam and scalding liquids to blow out and burn you badly.
Page 272: Coolant Surge Tank Pressure Cap
Be sure the cap is properly and tightly secured. If you replace your coolant surge tank pressure cap, a Saturn cap is required. Engine Overheating You will ﬁnd a coolant temperature gage and a coolant temperature warning light on your vehicle’s instrument panel.
Page 273: If Steam Is Coming From Your Engine
If Steam Is Coming From Your Engine CAUTION: Steam from an overheated engine can burn you badly, even if you just open the hood. Stay away from the engine if you see or hear steam coming from it. Just turn it off and get everyone away from the vehicle until it cools down.
Page 274: If No Steam Is Coming From Your Engine
If No Steam Is Coming From Your Engine An overheat warning, along with a low coolant light, can indicate a serious problem. See Low Coolant Warning Light on page 3-33. If you get an engine overheat warning with no low coolant light, but see or hear no steam, the problem may not be too serious.
Page 275: Cooling System
Cooling System When you decide it is safe to lift the hood, here is what you will see: A. Coolant Surge Tank with Pressure Cap B. Electric Engine Fan CAUTION: An electric engine cooling fan under the hood can start up even when the engine is not running and can injure you.
Page 276 The coolant level should be at the COLD line (surge tank seam). If it is not, you may have a leak at the radiator hoses, heater hoses, radiator, water pump or somewhere else in the cooling system. 5-30 CAUTION: Heater and radiator hoses, and other engine parts, can be very hot.
Page 277: How To Add Coolant To The Coolant Surge Tank
How to Add Coolant to the Coolant Surge Tank Notice: This vehicle has a speciﬁc coolant ﬁll procedure. Failure to follow this procedure could cause your engine to overheat and be severely damaged. If you have not found a problem yet, check to see if coolant is visible in the surge tank.
Page 278 CAUTION: Adding only plain water to your cooling system can be dangerous. Plain water, or some other liquid such as alcohol, can boil before the proper coolant mixture will. Your vehicle’s coolant warning system is set for the proper coolant mixture. With plain water or the wrong mixture, your engine could get too hot but you would not get the overheat warning.
Page 279 1. You can remove the coolant surge tank pressure cap when the cooling system, including the coolant surge tank pressure cap and upper radiator hose, is no longer hot. Turn the pressure cap slowly counterclockwise (left) about one-quarter of a turn.
Page 280: Power Steering Fluid
Check the level in the surge tank when the cooling system has cooled down. If the coolant is not at the proper level, repeat Steps 1 through 3 and reinstall the pressure cap. If the coolant isn’t at the proper level when the system cools down again, see your retailer.
Page 281: Windshield Washer Fluid
Windshield Washer Fluid What to Use When you need windshield or rear window (wagon models) washer ﬂuid be sure to read the instructions before use. If you will be operating your vehicle in an area where the temperature may fall below freezing, use a ﬂuid that has sufficient protection against freezing.
Page 282: Brakes
Brakes Brake Fluid Your brake master cylinder reservoir is ﬁlled with DOT-3 brake ﬂuid. See Engine Compartment Overview on page 5-12 for the location of the reservoir. There are only two reasons why the brake ﬂuid level in the reservoir might go down. The ﬁrst is that the brake ﬂuid goes down to an acceptable level during normal brake lining wear.
Page 283 What to Add When you do need brake ﬂuid, use only DOT-3 brake ﬂuid. Use new brake ﬂuid from a sealed container only. See Recommended Fluids and Lubricants on page 6-12. Always clean the brake ﬂuid reservoir cap and the area around the cap before removing it.
Page 284: Brake Wear
Properly torqued wheel nuts are necessary to help prevent brake pulsation. When tires are rotated, inspect brake pads for wear and evenly tighten wheel nuts in the proper sequence to Saturn torque speciﬁcations. Brake linings should always be replaced as complete axle sets.
Page 285: Battery
— be sure you get new approved Saturn replacement parts. If you do not, your brakes may no longer work properly. For example, if someone puts in brake linings that are wrong for your vehicle, the balance between your front and rear brakes can change —...
Page 286: Vehicle Storage
See Jump Starting on page 5-40 for tips on working around a battery without getting hurt. Contact your Saturn retailer to learn how to prepare your vehicle for longer storage periods. Also, for your audio system, see Theft-Deterrent Feature on page 3-69.
Page 287 1. Check the other vehicle. It must have a 12-volt battery with a negative ground system. Notice: If the other vehicle’s system is not a 12-volt system with a negative ground, both vehicles can be damaged. Only use vehicles with 12-volt systems with negative grounds to jump start your vehicle.
Page 288 4. Open the hoods and locate the batteries. Find the positive (+) and negative ( ) terminal locations on each vehicle. See Engine Compartment Overview on page 5-12 for more information on location. CAUTION: An electric fan can start up even when the engine is not running and can injure you.
Page 289 CAUTION: Fans or other moving engine parts can injure you badly. Keep your hands away from moving parts once the engine is running. 5. Check that the jumper cables do not have loose or missing insulation. If they do, you could get a shock.
Page 290 7. Do not let the other end touch metal. Connect it to the positive (+) terminal of the good battery. Use a remote positive (+) terminal if the vehicle has one. 8. Now connect the black negative ( ) cable to the negative ( ) terminal of the good battery.
Page 291 10. Now start the vehicle with the good battery and run the engine for a while. 11. Press UNLOCK on the RKE transmitter to disarm your security system (if equipped). 12. Try to start the vehicle that had the dead battery. If it won’t start after a few tries, it probably needs service.
Page 292: Bulb Replacement
To disconnect the jumper cables from both vehicles, do the following: 1. Disconnect the black negative ( ) cable from the vehicle that had the dead battery. 2. Disconnect the black negative ( ) cable from the vehicle with the good battery. 3.
Page 293: Headlamps, Front Turn Signal, Sidemarker, And Parking Lamps
Headlamps, Front Turn Signal, Sidemarker, and Parking Lamps 1. Open the hood and secure it with the prop rod. 2. Remove push-pin fasteners from grill assembly. 3. Tilt grill assembly forward and lift it up to remove it from the body of the vehicle. 4.
Page 294 5. Push headlamp housing lever up to disengage headlamp housing from headlamp housing pocket. 6. Turn the bulb socket being replaced counterclockwise one–quarter of a turn while pressing the socket in ﬁrmly. Pull the socket rearward until the bulb clears the headlamp housing, and lift it up to access the bulb.
Page 295: Fog Lamps
Fog Lamps 1. Reach up from underneath the front body panel and turn the bulb socket counterclockwise one– quarter of a turn while pressing the socket in ﬁrmly. Pull the socket rearward until the bulb clears the fog lamp housing. 2.
Page 296: Taillamps, Turn Signal, Stoplamps And
Center High-Mounted Stoplamp (CHMSL) (Wagon) 1. Open the liftgate. 2. Remove the center high mounted stop lamp cover by pulling down on the cover edges. 3. Turn the bulb socket being replaced counterclockwise one–quarter of a turn and remove the bulb. 4.
Page 297 3. Remove fasteners from backside of taillamp housing. 4. Remove taillamp housing from body of vehicle. 5. Turn the bulb socket being replaced counterclockwise one–quarter of a turn while pressing the socket in ﬁrmly. Pull the socket rearward until the bulb clears the taillamp housing. 6.
Page 298: Taillamps, Turn Signal, Stoplamps And
Taillamps, Turn Signal, Stoplamps and Back-up Lamps (Wagon) 1. Open the liftgate. 2. Remove the interior access trim panel. 3. Turn the bulb socket being replaced counterclockwise one–quarter of a turn while pressing the socket in ﬁrmly. Pull the socket rearward until the bulb clears the taillamp housing.
Page 299: Windshield Wiper Blade Replacement
Windshield Wiper Blade Replacement Windshield wiper blades should be inspected at least twice a year for wear or cracking. See “Windshield Wipers, Blade Check” under Scheduled Maintenance on page 6-4 for more information. Replacement blades come in different types and are removed in different ways.
Page 300: Tires
Tires Your new vehicle comes with high-quality tires made by a leading tire manufacturer. If you ever have questions about your tire warranty and where to obtain service, see your GM Warranty booklet for details. For additional information refer to the tire manufacturer’s booklet included with your vehicle’s Owner’s Manual.
Page 301 (A) Tire Size: The tire size code is a combination of letters and numbers used to deﬁne a particular tire’s width, height, aspect ratio, construction type and service description. See the “Tire Size” illustration later in this section for more detail. (B) Tire Performance Criteria Speciﬁcation (TPC Spec): Original equipment tires designed to GM’s speciﬁc tire performance criteria have a TPC speciﬁcation...
Page 302 (E) Tire Ply Material: The type of cord and number of plies in the sidewall and under the tread. (F) Uniform Tire Quality Grading (UTQG): Tire manufacturers are required to grade tires based on three performance factors: treadwear, traction and temperature resistance.
Page 303 (A) Temporary Use Only: The compact spare tire or temporary use tire has a tread life of approximately 3,000 miles (5 000 km) and should not be driven at speeds over 65 mph (105 km/h). The compact spare tire is for emergency use when a regular road tire has lost air and gone ﬂat.
Page 304: Tire Size
Tire Size The following illustration shows an example of a typical passenger car tire size. (A) P-Metric Tire: The United States version of a metric tire sizing system. The letter “P” as the ﬁrst character in the tire size means a passenger vehicle tire engineered to standards set by the U.
Page 305: Tire Terminology And Deﬁnitions
Tire Terminology and Deﬁnitions Air Pressure: The amount of air inside the tire pressing outward on each square inch of the tire. Air pressure is expressed in pounds per square inch (psi) or kilopascal (kPa). Accessory Weight: This means the combined weight of optional accessories.
Page 306 Load Index: An assigned number ranging from 1 to 279 that corresponds to the load carrying capacity of a tire. Maximum Inﬂation Pressure: The maximum air pressure to which a cold tire may be inﬂated. The maximum air pressure is molded onto the sidewall. Maximum Load Rating: The load rating for a tire at the maximum permissible inﬂation pressure for that tire.
Page 307: Inﬂation - Tire Pressure
UTQGS: Uniform Tire Quality Grading Standards, a tire information system that provides consumers with ratings for a tire’s traction, temperature and treadwear. Ratings are determined by tire manufacturers using government testing procedures. The ratings are molded into the sidewall of the tire. See Uniform Tire Quality Grading on page 5-65.
Page 308: How To Check
When to Check Check your tires once a month or more. Don’t forget your compact spare tire. It should be at 60 psi (420 kPa). How to Check Use a good quality pocket-type gage to check tire pressure. You can’t tell if your tires are properly inﬂated simply by looking at them.
Page 309 When rotating your tires, always use the correct rotation pattern shown here. Don’t include the compact spare tire in your tire rotation. If you are towing your Saturn vehicle with all four wheels on the ground, the transaxle and tire maintenance should be scheduled by mileage accumulated through both driving and towing, not to driven (odometer) mileage.
Page 310: When It Is Time For New Tires
When It Is Time for New Tires One way to tell when it’s time for new tires is to check the treadwear indicators, which will appear when your tires have only 1/16 inch (1.6 mm) or less of tread remaining. You need a new tire if any of the following statements are true: •...
Page 311: Uniform Tire Quality Grading
10 to 12 inches (25 to 30 cm), or to some limited-production tires. While the tires available on Saturn passenger cars and light trucks may vary with respect to these grades, they must also conform to federal safety requirements and additional General Motors Tire Performance Criteria (TPC) standards.
Page 312 Treadwear The treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a speciﬁed government test course. For example, a tire graded 150 would wear one and a half (1.5) times as well on the government course as a tire graded 100.
Page 313: Wheel Alignment And Tire Balance
If the wheel leaks air, replace it (except some aluminum wheels, which can sometimes be repaired). See your Saturn Retailer if any of these conditions exist. Your retailer will know the kind of wheel or wheel bolt you need.
Page 314: Tire Chains
Putting a used wheel on your vehicle is dangerous. You can’t know how it’s been used or how far it’s been driven. It could fail suddenly and cause a crash. If you have to replace a wheel, use a new Saturn original equipment wheel. 5-68 Tire Chains CAUTION: Don’t use tire chains.
Page 315: If A Tire Goes Flat
If a Tire Goes Flat It’s unusual for a tire to “blowout” while you’re driving, especially if you maintain your tires properly. If air goes out of a tire, it’s much more likely to leak out slowly. But if you should ever have a “blowout,” here are a few tips about what to expect and what to do: If a front tire fails, the ﬂat tire will create a drag that pulls the vehicle toward that side.
Page 316: Changing A Flat Tire
Changing a Flat Tire If a tire goes ﬂat, avoid further tire and wheel damage by driving slowly to a level place. Turn on your hazard warning ﬂashers. CAUTION: Changing a tire can be dangerous. The vehicle can slip off the jack and roll over or fall on you or other people.
Page 317: Removing The Spare Tire And Tools
The following steps will tell you how to use the jack and change a tire. Removing the Spare Tire and Tools (Sedan) The equipment you’ll need is located in the trunk. 1. Open the jack access door on the left side panel of the trunk.
Page 318 3. Lift the trunk liner and place the plastic hook in the lip of the trunk. 4. Remove the nut that holds down the spare tire. 5. Remove the compact spare tire. See Compact Spare Tire on page 5-81 6. The wheel wrench is held in place by two clips which are attached to the jack.
Page 319 1. Lift up the spare tire cover by the handle. Fold the side panels in and then attach the cover to the liftgate with the hook provided. 2. Remove the nut that holds down the spare tire. 3. Remove the compact spare tire. See Compact Spare Tire on page 5-81 4.
Page 320: Removing The Wheel
Removing the Wheel You must take off the wheel cover or hubcap to reach the wheel bolts. For steel wheels with full plastic covers and aluminum wheels with large circular center caps, do the following: 1. Loosen all ﬁve hex-shaped plastic caps by turning the wrench counterclockwise.
Page 321 4. Position the lift head at the jack location nearest the ﬂat tire. Your vehicle has jack notches. Position the jack in the notch near the tire being changed, but make sure all of the jack lift head is touching the jacking ﬂange under the body.
Page 322 6. Raise the vehicle by turning the jack handle clockwise. Raise the vehicle far enough off the ground so there is enough room for the compact spare tire to ﬁt underneath the wheel well. 7. Remove all of the wheel nuts. 8.
Page 323 CAUTION: Never use oil or grease on wheel bolts. If you do, the wheel bolts might come loose. Your wheel could fall off, causing a serious accident. 10. Place the compact spare tire on the wheel-mounting surface. 11. Reinstall the wheel nuts. Tighten each nut by hand until the wheel is held against the hub.
Page 324 Be sure to use the correct wheel bolts. If you have to replace them, be sure to get new Saturn original equipment wheel bolts. Stop somewhere as soon as you can and have the bolts tightened with a torque wrench to the proper torque speciﬁcation.
Page 325: Storing A Flat Or Spare Tire And Tools
Storing a Flat or Spare Tire and Tools CAUTION: Storing a jack, a tire, or other equipment in the passenger compartment of the vehicle could cause injury. In a sudden stop or collision, loose equipment could strike someone. Store all these in the proper place. Sedan 5-79...
Page 326 Wagon 1. Place the wheel wrench into the clips on the jack. 2. Install the jack in the left side panel of the trunk for sedans or the spare tire compartment for wagons and secure as shown on the jacking instruction label located in the trunk or cargo area.
Page 327: Compact Spare Tire
Compact Spare Tire Although the compact spare tire was fully inﬂated when your vehicle was new, it can lose air after a time. Check the inﬂation pressure regularly. It should be 60 psi (420 kPa). After installing the compact spare tire on your vehicle, you should stop as soon as possible and make sure your compact spare tire is correctly inﬂated.
Page 328: Appearance Care
Appearance Care Remember, cleaning products can be hazardous. Some are toxic. Others can burst into ﬂames if you strike a match or get them on a hot part of the vehicle. Some are dangerous if you breathe their fumes in a closed space.
Page 329: Special Fabric Cleaning Problems
• Use a clean cloth or sponge, and change to a clean area often. A soft brush may be used if stains are stubborn. • If a ring forms on fabric after spot cleaning, clean the entire area immediately or it will set. Using Cleaner on Fabric 1.
Page 330: Cleaning Vinyl
Cleaning Vinyl Use warm water and a clean cloth. • Rub with a clean, damp cloth to remove dirt. You may have to do this more than once. • Things like tar, asphalt and shoe polish will stain if you do not get them off quickly. Use a clean cloth and vinyl cleaner.
Page 331: Care Of Safety Belts
Care of Safety Belts Keep belts clean and dry. CAUTION: Do not bleach or dye safety belts. If you do, it may severely weaken them. In a crash, they might not be able to provide adequate protection. Clean safety belts only with mild soap and lukewarm water.
Page 332: Cleaning Exterior Lamps/Lenses
Cleaning Exterior Lamps/Lenses Use only lukewarm or cold water, a soft cloth and a car washing soap to clean exterior lamps and lenses. Follow instructions under “Washing Your Vehicle.” Finish Care Occasional waxing or mild polishing of your vehicle by hand may be necessary to remove residue from the paint ﬁnish.
Page 333: Cleaning Aluminum Or Chrome-Plated Wheels
Cleaning Aluminum or Chrome-Plated Wheels Your vehicle may be equipped with either aluminum or chrome-plated wheels. Keep your wheels clean using a soft clean cloth with mild soap and water. Rinse with clean water. After rinsing thoroughly, dry with a soft clean towel. A wax may then be applied.
Page 334: Finish Damage
Finish Damage Any stone chips, fractures or deep scratches in the ﬁnish should be repaired right away. Bare metal will corrode quickly and may develop into major repair expense. Minor chips and scratches can be repaired with touch-up materials avaliable from your dealer. Larger areas of ﬁnish damage can be corrected in your dealer’s body and paint shop.
Page 335: Vehicle Care/Appearance Materials
Vehicle Care/Appearance Materials See your Saturn retailer for more information on purchasing the following products. Vehicle Care/Appearance Materials Description Polishing Cloth Interior and exterior Wax-Treated polishing cloth. Car Wash Soap Cleans Exterior Made to use on Non-Abrasive Wax basecoat/clearcoat paint ﬁnish...
Page 336: Vehicle Identiﬁcation
Odorless spray odor eliminator used on Odor Eliminator fabrics, vinyl, leather and carpet. See your Saturn parts department for these products. See Recommended Fluids and Lubricants on page 6-12. 5-90 Vehicle Identiﬁcation Usage Vehicle Identiﬁcation Number (VIN) This is the legal identiﬁer for your vehicle.
Page 337: Service Parts Identiﬁcation Label
Engine Identiﬁcation The 8th character in your VIN is the engine code. This code will help you identify your engine, speciﬁcations and replacement parts. Service Parts Identiﬁcation Label You’ll ﬁnd this label on your spare tire cover. It’s very helpful if you ever need to order parts. On this label is: •...
Page 338: Power Windows And Other Power Options
Power Windows and Other Power Options Circuit breakers in the fuse panel protect the power windows and other power accessories. When the current load is too heavy, the circuit breaker opens and closes, protecting the circuit until the problem is ﬁxed. Fuses and Circuit Breakers The wiring circuits in your vehicle are protected from short circuits by fuses.
Page 339 Fuses Usage ® Audio, OnStar , Rear Seat DVD RADIO (Option) Windshield Washers and Wipers WIPER (Front) Left Heated Seat Switch, Right IGN 3 Heated Seat Switch, Air Conditioning, Rear Defogger Relay DEFOG LED Rear Defog LED BTSI/BCM/ Brake Transaxle Shift Interlock, MIRROR Body Control Module, Power Mirror DIMMER...
Page 340 The passenger’s side fuse block is located by the passenger’s right leg. Use a key or a coin to remove the fuse panel door and access the fuses and relays. 5-94 Fuses LOCKS Power Door Locks Power Door Locks, Heated Mirror BODY Relay, Liftgate Latch POWER SEAT...
Page 341: Engine Compartment Fuse Block
Engine Compartment Fuse Block The engine compartment fuse block is located in the forward part of the engine compartment near the battery. Fuses IGN 1/2 Ignition switch IGN 0/3/CR Ignition switch COOL 1 Cooling fan module COOL 2 Cooling fan module ABS 1 Anti-Lock Brake System ABS 2...
Page 342 Fuses Fuel Injectors (2.2L L4 (L61)) Backup Lamps, Coolant Level BACK-UP/TURN Switch BRAKE Brake Lamps FUEL PUMP Fuel Pump Relay Park Neutral Position Switch, IGN 0 Powertrain Control Module CRUISE SW Cruise Control Switch Cooling Fan Control Module, Powertrain Control Module, CONTROLS Transaxle (2.2L L4 (L61)), IGN 1...
Page 343 Relays Usage Air Conditioning System Daytime Running Lamp HORN Horn MAIN 3.0L V6 (L81) Engine WIPER Wiper System FUEL PUMP Fuel Pump System REAR WIPER Rear Wiper System (Wagon Only) Circuit Usage Breakers WINDOWS/ Power Window Relay, Sunroof SUNROOF (3.0L V6 (L81)) WINDOW/ Power Window Relay, Sunroof and SUNROOF/AIR...
Page 344: Capacities And Speciﬁcations
Capacities and Speciﬁcations Application Air Conditioning Refrigerant R134a Cooling System 2.2L L4 (L61) Engine 3.0L V6 (L81) Engine Engine Oil with Filter Fuel Tank Transaxle Wheel Nut Torque All capacities are approximate. When adding, be sure to ﬁll to the approximate level, as recommended in this manual.
Page 345 Section 6 Maintenance Schedule ...6-2 Introduction ...6-2 Maintenance Requirements ...6-2 Your Vehicle and the Environment ...6-2 Using Your Maintenance Schedule ...6-2 Scheduled Maintenance ...6-4 Additional Required Services ...6-6 Maintenance Footnotes ...6-7 Maintenance Schedule Owner Checks and Services ...6-9 At Each Fuel Fill ...6-9 At Least Once a Month ...6-9 At Least Once a Year ...6-10 Recommended Fluids and Lubricants ...6-12...
Page 346: Maintenance Schedule
Using Your Maintenance Schedule We at Saturn want to help you keep your vehicle in good working condition. But we do not know exactly how you will drive it. You may drive very short distances only a few times a week.
Page 347 Saturn retailer do these jobs. When you go to your Saturn retailer for your service needs, you will know that Saturn-trained and supported service technicians will perform the work using genuine Saturn parts.
Page 348: Scheduled Maintenance
However, your engine oil and ﬁlter must be changed at least once a year and at this time the system must be reset. Your Saturn retailer has Saturn-trained service technicians who will perform this work using genuine Saturn parts and reset the system.
Page 349 Scheduled Maintenance Service Maintenance I Maintenance II Change engine oil and ﬁlter. Reset oil life system. See Engine Oil on page 5-16. An Emission Control Service. Visually check for any leaks or damage. See footnote (j). Inspect engine air cleaner ﬁlter. If necessary, replace ﬁlter. See Engine Air Cleaner/Filter on page 5-20.
Page 350: Additional Required Services
Additional Required Services The following services should be performed at the ﬁrst maintenance service (I or II) after the indicated miles (kilometers) shown for each item. Service and Miles (Kilometers) Inspect fuel system for damage or leaks. Inspect exhaust system for loose or damaged components.
Page 351: Maintenance Footnotes
Additional Required Services (cont’d) Service and Miles (Kilometers) Engine cooling system service (or every 5 years, whichever occurs ﬁrst). An Emission Control Service. See footnote (i). 3.0L V6 engine only: Replace timing belt. An Emission Control Service. Inspect engine accessory drive belt. An Emission Control Service.
Page 352 Inspect all pipes, ﬁttings and clamps; replace with genuine Saturn parts as needed. To help ensure proper operation, a pressure test of the cooling system and pressure cap and cleaning the outside of the radiator and air conditioning condenser is recommended at least once a year.
Page 353: Owner Checks And Services
These owner checks and services should be performed at the intervals speciﬁed to help ensure the safety, dependability and emission control performance of your vehicle. Your Saturn retailer can assist you with these checks and services. Be sure any necessary repairs are completed at once.
Page 354: At Least Once A Year
At Least Once a Year Starter Switch Check CAUTION: When you are doing this inspection, the vehicle could move suddenly. If the vehicle moves, you or others could be injured. 1. Before you start, be sure you have enough room around the vehicle.
Page 355 Ignition Transaxle Lock Check While parked, and with the parking brake set, try to turn the ignition key to OFF in each shift lever position. • The key should turn to OFF only when the shift lever is in PARK (P). •...
Page 356: Recommended Fluids And Lubricants
12377985, in Canada 88901242) or Cable Guides lubricant meeting requirements of NLGI #2, Category LB or GC-LB. 6-12 Usage Fluid/Lubricant Power Steering Fluid (Saturn Part Power Steering No. 21007583 or GM Part No. U.S. System 89021184, in Canada 89021186). ® Automatic...
Page 357: Normal Maintenance Replacement Parts
3.0L V6 (L81) 2.2L L4 (L61) Windshield Wiper Blade Type – Shepherd’s hook Length – 22.0 inches (56.0 cm) Rear Wiper Blade – 13.0 Inches (33.0 cm) *Bosch Part Number. Saturn Part Number AC Delco Part Number 90571362 21018826 22685727 52493319 09195166 12569190 —...
Page 358: Engine Drive Belt Routing
Engine Drive Belt Routing 2.2L Four Cylinder (L61) Engine 3.0L V6 (L81) Engine 6-14...
Page 359: Maintenance Record
Maintenance Record After the scheduled services are performed, record the date, odometer reading, who performed the service and the type of services performed in the boxes provided. See Maintenance Requirements on page 6-2 in this section. Any additional information from Owner Checks and Services on page 6-9 can be added on the following record pages.
Page 360 Maintenance Record (cont’d) Odometer Maintenance I or Date Serviced By Services Performed Reading Maintenance II 6-16...
Page 361 Vehicle Data Collection and Event Data Recorders ...7-8 Customer Assistance and Information Reporting Safety Defects ...7-9 Reporting Safety Defects to the United States Government ...7-9 Reporting Safety Defects to the Canadian Government ...7-10 Reporting Safety Defects to Saturn ...7-10 Service Publications Ordering Information ...7-10...
Page 362: Customer Assistance And Information
Information Customer Satisfaction Procedure Your satisfaction and goodwill are important to your retailer and to Saturn. Together we are committed to providing our customers with unparalleled service, before, during and after the purchase of a Saturn vehicle, for total customer satisfaction. We call this the Saturn Difference.
Page 363 If you wish to write to the Saturn Customer Assistance Center, our address is: Saturn Customer Assistance Center 100 Saturn Parkway Mail Code 371-999-S24 Spring Hill, TN 37174-1500 In Canada, write to: Saturn Customer Communication Centre General Motors of Canada Ltd.
Page 364: Online Owner Center
Arlington, VA 22203-1804 This program is available in all 50 states and the District of Columbia. Eligibility is limited by vehicle age, mileage and other factors. Saturn Corporation reserves the right to change eligibility limitations and/or discontinue its participation in this program.
Page 365: Customer Assistance For Text Telephone (Tty) Users
For more details, or to determine your vehicle’s eligibility, see your Saturn retailer or call the Saturn Customer Assistance Center at 1-800-553-6000. Text telephone (TTY) users, call 1-800-833-6000. In Canada, customers may call the Saturn Customer Communication Centre at 1-800-263-1999.
Page 366: Roadside Assistance Program
For vehicles purchased in the U.S. call 1-800-553-6000 (TTY: 1-800-833-6000). For vehicles purchased in Canada call 1-800-268-6800. As the proud owner of a new Saturn vehicle, you are automatically enrolled in the Saturn Roadside Assistance Program. This value-added service is intended to provide you with peace of mind as you drive in the city or travel the open road.
Page 367: Canadian Roadside Assistance
Saturn Roadside Assistance: 1-800-553-6000; text telephone (TTY) users, call 1-800-833-6000. Saturn reserves the right to limit services or reimbursement to an owner or driver when, in Saturn’s judgment, the claims become excessive in frequency or type of occurrence. Roadside Assistance is not part of or included in the coverage provided by the New Vehicle Limited Warranty.
Page 368: Vehicle Data Collection And Event Data Recorders
Vehicle Data Collection and Event Data Recorders Your vehicle, like other modern motor vehicles, has a number of sophisticated computer systems that monitor and control several aspects of the vehicle’s performance. Your vehicle uses on-board vehicle computers to monitor emission control components to optimize fuel economy, to monitor conditions for air bag deployment and, if so equipped, to provide anti-lock braking and to help the driver control the vehicle...
Page 369: Reporting Safety Defects
National Highway Traffic Safety Administration (NHTSA), in addition to notifying Saturn Corporation. If NHTSA receives similar complaints, it may open an investigation, and if it ﬁnds that a safety defect exists in ®...
Page 370: Reporting Safety Defects To The Canadian Government
Oshawa, Ontario L1H 8P7 Service Publications Ordering Information Service Manuals A variety of publications are available to you. Saturn service manuals are written for trained technicians, and in some cases, specialized tools and equipment are necessary to complete certain repairs. However,...
Page 371: Service Bulletins
GVWR less than 10,000 pounds (4 536 kg). Copies of individual bulletins are also at your participating Saturn retailer. You can ask to see them. In Canada, information relating to product service bulletins can be obtained by contacting your Saturn retailer.
Page 372 NOTES 7-12...
Page 373 Accessory Power Outlets ... 3-16 Activating the Theft-Deterrent Feature ... 3-69 Adding Windshield Washer Fluid ... 5-35 Additives, Fuel ... 5-7 Add-On Electrical Equipment ... 5-91 Adjusting the Speakers (Balance/Fade) ... 3-44, 3-47, 3-52 Air Bag Readiness Light ... 3-28 Air Bag Systems ...
Page 374 Backing Up ... 4-44 Battery ... 5-39 Battery Replacement ... 2-7 Battery Run-Down Protection ... 3-16 Battery Warning Light ... 3-29 Before Leaving on a Long Trip ... 4-23 Before You Drive ... 3-59 Brake Parking ... 2-27 System Warning Light ... 3-30 Brake Fluid ...
Page 375 Child Restraints Child Restraint Systems ... 1-42 Infants and Young Children ... 1-38 Lower Anchorages and Top Tethers for Children (LATCH System) ... 1-50 Older Children ... 1-35 Securing a Child Restraint Designed for the LATCH System ... 1-52 Securing a Child Restraint in a Center Rear Seat Position ...
Page 376 Users ... 7-5 Customer Satisfaction Procedure ... 7-2 GM Mobility Program for Persons with Disabilities ... 7-5 Reporting Safety Defects to Saturn ... 7-10 Reporting Safety Defects to the Canadian Government ... 7-10 Reporting Safety Defects to the United States Government ...
Page 377 Electrical System Add-On Equipment ... 5-91 Fuses and Circuit Breakers ... 5-92 Power Windows and Other Power Options ... 5-92 Windshield Wiper Fuses ... 5-91 Emergency Trunk Release Handle (Sedan) ... 2-15 Emissions Inspection and Maintenance Programs ... 3-36 Engine Air Cleaner/Filter ...
Page 378 Fuel (cont.) Filling a Portable Fuel Container ... 5-9 Filling Your Tank ... 5-8 Fuels in Foreign Countries ... 5-7 Gage ... 3-40 Gasoline Octane ... 5-5 Gasoline Speciﬁcations ... 5-6 Low Warning Light ... 3-40 Fuses Fuses and Circuit Breakers ... 5-92 Windshield Wiper ...
Page 379 If No Steam Is Coming From Your Engine ... 5-28 If Steam Is Coming From Your Engine ... 5-27 If the Light Is Flashing ... 3-35 If the Light Is On Steady ... 3-35 If You Are Caught in a Blizzard ... 4-28 If You Are Stuck in Sand, Mud, Ice or Snow ...
Page 380 Light (cont.) Malfunction Indicator ... 3-34 Oil Pressure ... 3-37 Reduced Engine Power ... 3-38 Safety Belt Reminder ... 3-28 Security ... 3-38 Service Vehicle Soon ... 3-39 TCS Warning Light ... 3-32 Traction Control System (TCS) Warning ... 3-32 Trunk Ajar ...
Page 381 Mirrors Automatic Dimming Rearview with Compass and Temperature Display ... 2-36 Automatic Dimming Rearview with OnStar Compass and Temperature Display ... 2-34 Manual Rearview Mirror ... 2-33 Manual Rearview Mirror with OnStar Outside Convex Mirror ... 2-39 Outside Heated Mirrors ... 2-39 Outside Power Mirrors ...
Page 382 Playing the Radio ... 3-42, 3-45, 3-50 Playing the Single CD Player ... 3-54 Playing the Six–Disc CD Player ... 3-56 Power ... 1-4 Accessory Outlets ... 3-16 Door Locks ... 2-10 Electrical System ... 5-92 Reduced Engine Light ... 3-38 Steering Fluid ...
Page 383 Reporting Safety Defects Canadian Government ... 7-10 Saturn ... 7-10 United States Government ... 7-9 Restraint System Check Checking Your Restraint Systems ... 1-72 Replacing Restraint System Parts After a Crash ... 1-73 Restraint Systems Checking ... 1-72 Replacing Parts ... 1-73 Resynchronization ...
Page 384 Service ... 5-3 Adding Equipment to the Outside of Your Vehicle ... 5-5 Doing Your Own Work ... 5-4 Engine Soon Light ... 3-34 Publications Ordering Information ... 7-10 Vehicle Soon Light ... 3-39 Service Bulletins ... 7-11 Service Engine Soon Light ... 3-34 Service Manuals ...
Page 385 Buying New Tires ... 5-64 Chains ... 5-68 Changing a Flat Tire ... 5-70 Compact Spare Tire ... 5-81 If a Tire Goes Flat ... 5-69 Inﬂation - Tire Pressure ... 5-61 Inspection and Rotation ... 5-62 Uniform Tire Quality Grading ... 5-65 Wheel Alignment and Tire Balance ...
Page 386 Vehicle Storage ... 5-40 Ventilation Adjustment ... 3-24 Video Screen ... 3-62 Visor Vanity Mirrors ... 2-18 Visors ... 2-18 Wagon ... 1-10, 1-48 Warning Lights, Gages and Indicators ... 3-25 Warnings Hazard Warning Flashers ... 3-4 Other Warning Devices ... 3-5 Safety and Symbols ...

This manual is also suitable for:

2004 l300

Saturn 2004 L-Series Owner's Manual

Table of Contents

Seats and Restraint Systems

Features and Controls

Section 3 Instrument Panel

Instrument Panel

Climate Controls

Warning Lights, Gages, and Indicators

Maintenance Schedule

Audio System(S)

Section 4 Driving Your Vehicle

Your Driving, the Road, and Your Vehicle

Towing

Section 5 Service and Appearance Care

Service

Fuel

Service and Appearance Care

Bulb Replacement

Windshield Wiper Blade Replacement

Tires

Appearance Care

Vehicle Identiﬁcation

Electrical System

Capacities and Speciﬁcations

Quick Links

Chapters

Related Manuals for Saturn 2004 L-Series

Summary of Contents for Saturn 2004 L-Series