1. Manuals
  2. Brands
  3. Emerson Manuals
  4. Control Unit
  5. Baumann 83000
  6. Instruction manual

Emerson Baumann 83000 Instruction Manual

Sanitary angle control valve
Hide thumbs
Table of Contents

Advertisement

Quick Links

Instruction Manual
D103367X012
October 2010
t
Baumann
Control Valve
Contents
Introduction
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Scope of Manual
. . . . . . . . . . . . . . . . . . . . . . . . .
Safety Precautions
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Dimensions and Weights
Introduction
The Baumann 83000 Sanitary angle control valve
(figures 1 and 2) features a packless design and is
intended for laboratory flow rates as low as 0.001
liters per minute (l/m) with a Cv range of 0.00001 to
0.7. This innovative design also allows for
clean in place (CIP) and sanitize in place (SIP)
procedures and is self draining. Meets 3 A sanitary
standards for design and fabrication.
Scope of Manual
This instruction manual includes installation,
maintenance, and parts information for the Baumann
83000 sanitary angle control valve.
Do not install, operate, or maintain Baumann 83000
control valves without being fully trained and
qualified in valve, actuator, and accessory
installation, operation, and maintenance. To avoid
personal injury or property damage, it is important to
carefully read, understand, and follow all the
contents of this manual, including all safety cautions
and warnings. If you have any questions about these
instructions, contact your Emerson Process
Management sales office before proceeding.
www.Fisher.com
83000 Sanitary Angle
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
1
1
2
3
3
4
4
4
4
4
5
5
5
9
W9848
Figure 1. 83000 Sanitary Angle Valve
W9849
Figure 2. 83000 Sanitary Angle Valve with
FIELDVUEt DVC2000 Digital Valve Controller
83000 Valve
with Baumann 16 Actuator

Advertisement

Table of Contents
loading

Related Manuals for Emerson Baumann 83000

Summary of Contents for Emerson Baumann 83000

  • Page 1: Table Of Contents

    This instruction manual includes installation, maintenance, and parts information for the Baumann 83000 sanitary angle control valve. Do not install, operate, or maintain Baumann 83000 control valves without being fully trained and qualified in valve, actuator, and accessory installation, operation, and maintenance. To avoid...
  • Page 2 Instruction Manual 83000 Valve October 2010 these conditions are you should WARNING contact your Emerson Process Management sales office for more complete specifications. Provide the Always wear protective gloves, product serial numbers (shown on the clothing and eyewear when performing...

  • Page 3: Maintenance

    Instruction Manual 83000 Valve October 2010 Maintenance that must be taken to protect against process media. WARNING Note Whenever a gasket seal is disturbed by removing or shifting gasketed Avoid personal injury and property parts, install a new gasket during damage from sudden release of reassembly.

  • Page 4: Air Piping

    Instruction Manual 83000 Valve October 2010 Air Piping retighten the valve body/joint nuts and return to the Warning at the beginning 1. For an air to extend actuator (air to close of the Maintenance section to provide action), connect the actuating air pressure line to the proper steps have been taken to 1/4 NPT opening in the upper diaphragm case.

  • Page 5: Valve Body To Bonnet Assembly

    (key 15) and diaphragm (key 5) into the valve body. Parts Ordering 2. Replace the bonnet yoke assembly (key 2) and When corresponding with your Emerson Process install the bolts (key 13) and tighten. Add the jam nut Management sales office about this equipment, (key 27) and travel indicator disk (key 58) to the always mention the valve serial number.
  • Page 6 Instruction Manual 83000 Valve October 2010 SEE DETAIL IN FIGURE 4 E1332 Figure 3. 83000 for Baumann 16 Actuator E1333 Figure 4. 83000 with Stem Adaptor for Baumann 32 Actuator...
  • Page 7 Hex Jam Nut, Baumann 16 Actuator 81841 971514 002 250 O Ring, Bonnet 81206 Travel Indicator Disk 011765 002 152 24299 Table 2. Baumann 83000 Valve Body and Plunger 83000 VALVE BODY PLUNGER PLUG TRAVEL ORIFICE DIAMETER DIAPHRAGM TRAVEL (KEY 1) (KEY 10)
  • Page 8 Instruction Manual 83000 Valve October 2010 E1370 W9918 Figure 5. Air to Extend (Air to Close Action) Figure 7. Seating (Sealing) Surfaces E1234 W9919 Figure 6. Air to Retract (Air to Open Action) Figure 8. 1/8 Inch Port...
  • Page 9 Instruction Manual 83000 Valve October 2010 PREFERRED MOUNTING (for outlet drain) NORMAL FLOW DIRECTION E1334 Figure 9. Baumann 83000 Rotated View to Show Locking Bolts (46.25) 212 (8.35) 146 (5.76) 87 (3.41) TRI CLAMP FITTINGS 30 (1.20) NPS 1/2 41 (1.63)
  • Page 10 Instruction Manual 83000 Valve October 2010 129 (5.1) 159 (46.25) 93 (3.7) (4.9) (1.6) (5.76) 67CFR 3660/3661 POSITIONER (inch) E1331 Figure 12. Baumann 16 Actuator with Fisher 3660/3661 Positioner and 67CFR Airset 159 (6.3) 83 (3.3) (5.01) (6.9) 166 (6.52) 166 (6.52) E1330 E1328...
  • Page 11 Instruction Manual 83000 Valve October 2010 Table 3. Baumann 83000 Valve Weight Table 4. Baumann Actuator Weights VALVE SIZE: 12.7 mm (NPS 1/2) BAUMANN 16 BAUMANN 32 1.82...
  • Page 12 October 2010 Baumann, Fisher, and FIELDVUE are marks owned by one of the companies in the Emerson Process Management business division of Emerson Electric Co. Emerson Process Management, Emerson, and the Emerson logo are trademarks and service marks of Emerson Electric Co. All other marks are the property of their respective owners.

Table of Contents