General Maintenance And Lubrication Chart (For Cdn) - Yamaha YFM45FXV Supplementary Service Manual

GENERAL MAINTENANCE AND LUBRICATION CHART

GENERAL MAINTENANCE AND LUBRICATION CHART (For CDN)

ITEM
• Check coolant leakage.
Cooling system • Repair if necessary.
• Replace coolant every 24 months.
• Clean.
Air filter element
• Replace if necessary.
Engine oil • Replace. (Warm engine before draining.)
Engine oil filter car-
• Replace.
tridge
Engine oil strainer* • Clean.
Final gear oil
• Check oil level/oil leakage.
• Replace every 12 months.
Differential gear oil
• Check operation/fluid leakage. (See NOTE page 22.)
Front brake*
• Correct if necessary.
• Check operation/fluid leakage. (See NOTE page 22.)
Rear brake*
• Correct if necessary.
Select lever safety • Check operation.
system cable* • Adjust if necessary.
• Check operation.
V-belt*
• Check for cracks or damage.
• Check balance/damage/runout.
Wheels*
• Repair if necessary.
• Check bearing assemblies for looseness/damage.
Wheel bearing*
• Replace if damaged.
Front and rear • Check operation.
suspension* • Correct if necessary.
• Check operation./Replace if damaged.
Steering system*
• Check toe-in./Adjust if necessary.
Drive shaft universal
• Lubricate with lithium-soap-based grease.
joint*
Engine mount* • Check for cracks or damage.
• Check operation.
Axle boots*
• Replace if damaged.
Fittings and fasten- • Check all chassis fittings and fasteners.
ers* • Correct if necessary.
• Check operation.
Lights and switches*
• Adjust headlight beams.
NOTE:
• Recommended brake fluid: DOT 4
• Brake fluid replacement:
• When disassembling the master cylinders or calipers, replace the brake fluid. Normally check the
brake fluid level and add fluid as required.
• On the inner parts of the master cylinders and calipers, replace the oil seals every two years.
• Replace the brake hoses every four years, or if cracked or damaged.
WARNING
Indicates a potential hazard that could result in serious injury or death.
Whichever
ROUTINE comes first
(For CDN)
month 1
km 320
(mi) (200)
hours 20
– 22 –
CHK
ADJ
INITIAL
3 6
1,300 2,500 2,500
(800) (1,600) (1,600)
80 160 160
Every 20 ~ 40 hours
(More often in wet or dusty areas.)
EVERY
6 12
5,000
(3,200)
320