Main Fuse; Replacing Headlight Lamp (H4); Charging The Battery - KTM 125 EXE 2001 Owner's Handbook Manual

1
4
2
6
VOLT

Main fuse

The main fuse
wing current consumers:
– Brake light
– Parking light
– Flasher lights
– Horn
Rated fuse current is 10 amperes
U
NDER NO CIRCUMSTANCES IS A STRONGER FUSE ALLOWED TO BE SET IN OR A FUSE
ALLOWED TO BE
ELECTRICAL INSTALLATION

Replacing headlight lamp (H4)

Loosen both rubber bands
bulb plug
clockwise and remove it from the reflector together with the bulb.
3
2
Insert a new bulb such that the noses
the glass body of the bulb, to keep if free from grease. Mount supporting
ring, rubber cap and plug. Position headlight mask with the bottom holders,
and fasten it with the rubber bands
5

Charging the battery

Remove the battery (under the seat) and check the charging level. Use a
voltmeter to measure the voltage between the battery poles (off-load
voltage).
Accurate results can only be obtained if the battery has neither been char-
ged nor discharged during a period of 30 minutes preceding the measuring.
off load voltage
Volt
>12,7
~12,5
~12,2
~12,0
~11,8
If the battery is empty, it can be recharged for a maximum period of
10 hours at 0.3 A and a maximum of 14.4 V.
– D
O NOT REMOVE THE SEALING STRIP
– A
LWAYS CONNECT THE BATTERY TO THE CHARGING UNIT BEFORE TURNING THE
7
CHARGING UNIT ON
– W
HEN RECHARGING THE BATTERY IN CLOSED ROOMS ENSURE SUFFICIENT VENTILA
. E
TION
– C
HARGING TIME AND CHARGING VOLTAGE SHOULD NOT EXCEED THE STATED VALUES
O
THERWISE ELECTROLYTE WILL BE RELEASED THROUGH THE SAFETY VALVES
– A
VOID QUICK CHARGING IF POSSIBLE
1
, which is located above the carburetor, protects the follo-
CAUTION
!
" ". A
REPAIRED N INEXPERT TREATMENT COULD DAMAGE THE WHOLE
!
2
and tilt headlight mask to the front. Remove
3 4
and remove rubber cap
5
2
.
charging level
%
100
75
50
25
0
CAUTION
!
7
.
.
XPLOSIVE GASES ARE RELEASED DURING THE BATTERY CHARGING PROCESS
.
!
. Turn the supporting ring counter-
6
fit into the recess . Do not touch
charging time charging voltage
0,3 A
––
4 h
Max.
7 h
14,4 V
11 h
14 h
!
.
25
-
.
.