Page 1
IMPORTANT MANUAL OPERATOR'S MANUAL MODEL: PB19546LT LAWN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 432448 Do Not Throw Away WARNING: Read this Man u al and follow all Warnings and Safety Instructions. Fail ure to do so can re sult in serious in ju ry.
Safe Operation Practices for Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. WARNING: In order to prevent ac ci den tal starting when setting up, trans port ing, ad just ing or making repairs, al ways dis con nect spark plug wire and place...
Page 3
Safe Operation Practices for Ride-On Mowers III. CHILDREN Tragic accidents can occur if the operator is not alert to the presence of children. Children are often attracted to the ma chine and the mowing activity. Never assume that children will remain where you last saw them. •...
UNASSEMBLED PARTS Keys (2) Keys Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier. Stan dard wrench sizes are listed. (1) 1/2"...
Page 6
NOTE: You may now roll your tractor off the skid. Follow the instructions below to remove the tractor from the skid. WARNING: Before start ing, read, un der stand and fol low all in struc tions in the Op er a tion section of this man u al. Be sure tractor is in a well-ventilated area.
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean- ing. REVERSE NEUTRAL REVERSE ENGINE ON ENGINE OFF OPERATION SYSTEM (ROS) OIL PRESSURE FUEL OVER TEMP LIGHT ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED LIGHTS ON FREE WHEEL...
Page 8
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. THROTTLE/CHOKE THROTTLE/CHOKE CONTROL CONTROL...
Page 9
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safety glass es or eye shields while operating your tractor or per form ing any adjustments or repairs. We rec om mend a wide vision safety mask over spec- tacles or stan dard safety glasses.
Page 10
• Start tractor with clutch/brake pedal depressed and gearshift lever in neutral position. • Move gearshift lever to desired po si tion. • Slowly release clutch/brake pedal to start ment. IMPORTANT: Bring tractor to a complete stop before shifting or changing gears. Failure to do so will shorten the useful life of your transaxle.
TO OPERATE MOWER Your tractor is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine. You must remain fully and centrally positioned in the seat to prevent the engine from hesitat- ing or cutting off when operating your equipment on rough, rolling terrain or hills.
TO START ENGINE (See Fig. 4) When starting the engine for the first time or if the engine has run out of fuel, it will take extra cranking time to move fuel from the tank to the engine. • Sit on seat in operating position, depress clutch/brake pedal and set parking brake.
TRACTOR Always observe safety rules when per form ing any main- te nance. BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in high est gear on a level, dry concrete or paved surface, then brake must be checked and ad just ed. TIRES •...
Page 15
TO CLEAN BATTERY AND TERMINALS Corrosion and dirt on the battery and terminals can cause the battery to “leak” power. • Disconnect BLACK battery cable first then RED bat- tery cable and remove battery from tractor. • Rinse the battery with plain water and dry. •...
Page 16
CLEAN AIR SCREEN Air screen must be kept free of dirt and chaff to prevent engine dam age from overheating. Clean with a wire brush or com pressed air to re move dirt and stubborn dried gum fibers. AIR FILTER Your engine will not run properly using a dirty air filter.
SERVICE AND ADJUSTMENTS WARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUST- MENTS: • Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment clutch in “DISENGAGED” position. •...
SERVICE AND ADJUSTMENTS • ATTACH MOWER SIDE SUSPENSION ARMS (A) TO CHASSIS - Position hole in arm over pin (B) on outside of tractor chassis and secure with retainer spring. • Repeat on opposite side of tractor. Fig. 20 • ATTACH REAR LIFT LINKS (C) - Lift rear corner of mower and position slot in link assembly over pin (D) on rear mower bracket and secure with washer and...
Page 19
SERVICE AND ADJUSTMENTS TO LEVEL MOWER Make sure tires are properly inflated to the PSI shown on tires. If tires are over or under inflated, it may affect the appearance of your lawn and lead you to think the mower is not adjusted properly.
SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 29) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL - • Remove mower from tractor (See “TO REMOVE MOW ER”...
Page 21
SERVICE AND ADJUSTMENTS • Loosen adjustment bolt in front of the right rear wheel. • Position the gear shift lever in the neutral position. • Tighten adjustment bolt securely. NOTE: If additional clearance is needed to get to ad just ment bolt, move mower deck height to the lowest position.
SERVICE AND ADJUSTMENTS • Lift seat pan to raised position. • Disconnect BLACK battery cable first then RED battery cable and carefully remove battery from tractor. • Install new battery with terminals in same position as old battery. • First connect RED battery cable to positive (+) terminal with bolt and nut as shown.
Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the trac tor with gas o line in the tank inside a building where fumes may reach an open flame or spark.
TROUBLESHOOTING POINTS PROBLEM CAUSE 1. Out of fuel. Will not start 2. Engine not “CHOKED” properly. 3. Engine flooded. 4. Bad spark plug. 5. Dirty air filter. 6. Dirty fuel filter. 7. Water in fuel. 8. Loose or damaged wiring. 9.
PROBLEM CAUSE 1. Worn, bent or loose blade. Excessive 2. Bent blade mandrel. vibration 3. Loose/damaged part(s). 1. Faulty operator-safety presence control Engine continues system. to run when oper- ator leaves seat with attachment clutch engaged 1. Worn, bent or loose blade. Poor cut - uneven 2.
Page 28
'ON'. position dans couper avant lent) rapide (entre position dans commande l’alternateur. régulateur. connexions. toutes Vérifiez/remplacez batterie. manuel.) Reglages Revision section ENLEVER "POUR (Voyez d'axe. carrée déplacement. d'entraînement courroie manuel. Entretien section dans “NETTOYAGE” fusible. connexions. câblage phares. l’interrupteur Vérifiez/remplacez lampe(s).
Page 30
SONT D’ÉCHAPPEMENT ENDROITS QUAND TRACTEUR JAMAIS COUVREZ tracteur. condensation formation permet obstrue plastique plastique. N’uti perméable. couverture avec saleté. poussière couvrez-le possible, l’intérieur, à tracteur causera l’essence dans saleté et/ou rouiller. à commence s’il d’essence l’autre. à saison d’une d’essence SUPPLÉMENTAIRE d’allumage.
Page 31
réglage. et/ou réaration autorisé d'entretien centre gazon à tondeuse teur, avec problèms cause tion fonc moteur votre réglable. CARBURATEUR voir né réglage nécessaire. réglage l’usine à préréglée été COMMANDE voir nécessaire, réglage nécessaire. réglage l’usine à préréglée été CÂBLE Fig. PHARES CÂBLES CONNECTEUR...
Page 32
accidentelle. masse à mise étincelles prévenir pour chée doit positive borne début mé bagues montre, lets joux, tous enlevez batterie, Avant fois. même bornes deux contacte entrent objets autres qu'une permettre batterie court-circuitez AVERTISSEMENT: BATTERIE Fig. CHARGÉE MENT TIÈ BATTERIE FAIBLE batteries.
Page 33
res, né sont ré d’autres l'usine. préré- fermeture). (vanne position levier quand neutre être doit (Voir VITESSES BOÎTE CHAN- LEVIER NEUTRE manuel). section présente TON- INSTALLER POUR « (voir tondeuse dispositifs guides ainsi poulies, dans place bien courroie (B). d’embrayage fixe tension poulie...
Page 34
réglage. l’écrou contre fermement serrez clé avec place réglage inférieure 1/2" à 1/8" lame avant jusqu’à nécessaire ajustez mesures, 1/8". d’environ tondeuse modifie réglage l’écrou complet tour Fig. d’abord. contre-écrou 02950 tondeuse. baisser pour d’ajustement tondeuse. l’écrou Desserrez d’ajustement tondeuse. l’avant abaisser pour...
Page 35
"UTILISATION" section dans montré d’utiliser avant réglage roues ajustez haute. plus position à levage tondeuse. poulies place bien courroie Assurez-vous Fig. moteur poulie retenue(K). avec fixez-le guide collier dans d’embrayage câble carter (R). tondeuse braya trou tondeuse d’embrayage Fig. (J). ressort-arrêtoir d’une l’aide...
Page 36
celui-ci. soit qu’elle jusqu’à tracteur, sous tracteur. glisser avant l’avant vers pointent laté- suspension bras Assurez-vous basse. plus position enclenchez- lentement abaissez-le levier fermement Tenez ressort. mécan- possède levier ATTENTION basse. plus position à levage stationnement. niveau surface trouve tracteur Figs.
Page 37
Fig. SERRAGE BRIDE renversée. l’essence immédiatement placées. soient serrage d’es conduite fuites carburateur. avec d’es conduite dans filtre d’essence. conduite bouchez filtre enlevez froid, remplacer. d’es l’écoulement obstrue bouché saison. chaque moins remplacé être LIGNE INSTALLÉ D’ESSENCE tondeuse. gazon, l’air transmission, soient votre...
Page 38
Fig. 02744 DÉBRIS PAILLETTES NETTOYEZ moteur. dommages surchauffage montré secteur nettoyez ventilateur moteur. ventilation système obstruer Fig. (Voir VENTILATION fini. avez vous quand fond à Serrez d’huile. jauge (FULL) à d’huile niveau Maintenez d’huile. indication obtenir pour fond à serrée Assurez-vous d’huile.
Page 39
d'électrolyte. vérifie nécessaire n'est couvercles. d'en d'ouvrir N'essayez d'entretien. teur trac votre batterie d'origine L'équipement heure. pendant ampères raison à batterie ouverts. ventilations orifices serrés. batterie boulons propres. bornes batterie prolongera d’auto chargeur avec chargement tant, Pour normal. l’usa ment char tè...
Page 40
GRAPHITE. TYPE POUDRE SEC, LUBRIFIANT AVEC SEULEMENT UTILISEZ LUBRIFIÉS, PENSEZ VOUS AUTOMATIQUE. LUBRIFICATION DURABILITÉ DIMINUENT SALETÉS LUBRIFIANTS NYLON. PALIERS POINTS GRAISSE HUILE MOTEUR SOUS ENTRETIEN SECTION USAGE 10W30 VITESSE MENT CHAN PIVOTS TEUR ANTÉRIEURE ROUE PALIER PRESSION À GRAISSEUR BROCHE PRESSION À...
Page 41
utilisé. l'ac à terrain toujours choisissez accessoires, coupe. meilleure rendement basse suffisamment vitesse ment char dé rendement meilleur plein à commande avec tondre. avant l'herbe sécher Laissez tondeuse. mouillée L'herbe mouillée. elle quand désirée. hauteur à faire doit haute. assez coupe pour l'appareil...
Page 42
causés. nents sinon ré- dans carburateur moteur produits jamais N’uti autres pour l’en tez-vous saison des. soient carburateur com- conduites jusqu’à laissez-le moteur dé ré- plus. jours tout avant vidangé être doit moteur, blè éviter Pour dant moteur d’un d’essence peut acide l’entreposage.
Page 43
Fig. MOTEUR POSITION horaire sens contact faites nécessaire, plus n’est mouvement. arrière marche vitesse levier tout reculer, avant vous derrière anti-horaire sens tourner faites-la com- dans clé introduisez marche, sans l’embrayage/frein pédale complètement tondre. n’est tiers enfant qu’aucun certain êtes FONCTIONNEMENT SYSTÈME nécessaire.
Page 44
Fig. (J). vitesse commandées sont déplacement RECULER POUR performance meilleure permet (rapide) (D). moteur l’efficacité réduit (rapide) à inférieure vitesse à moteur (rapide). vitesse pleine à moteur COMMANDE Fig. etc. se-herbe, vider tracteur; quitter ci-dessus, décrit comme ment, tracteur toujours Arrêtez ATTENTION: gazon.
Page 45
moteur. commencer pour Utilisé D'ETRANGLE/BUSE inverse. sens qu'en pendant autre gazon à tondeuse pont POSI- » « (ROS) D'OPERATION frein pédale saisissent Serrures phares Allume LEGER commencer pour Utilisé D'ALLUMAGE Institute. dards Stan CHANGEMENT CHANGEMENT DE LEVIER LEVIER LE ADAPTER ADAPTER D'ALLUMAGE D'ALLUMAGE...
Page 46
propriété. l'endommagement blessures mort, conséquence pourrait évité, n'est s'il propriété. et/ou sérieuses conséquence comme avoir s'il qui, risque indique et/ou tracteur résulter pourrait situation symbole sans utilisé mineures blessures évité, n'est s'il qui, risque sérieuses. conséquence comme n'est s'il qui, risque mort conséquence...
Page 47
Entretien Fonctionnement fonctionnent (ROS) Système l’opérateur que. sans fonctionne com- toutes l’emplacement vous assurez-vous plomb sans UTILISER ment soient nexions toutes rieur té l’in à poulies rez- d’entraînement. ment être doivent obtenir pour l’autre correctement été pneus (Les gonflés. été confortable chargée.
Page 48
suivantes instructions contre décharge déflecteur tient rouler. faisant palette point position à vitesse changement stationnement. dégager pour frein/embrayage pédale plus position à d’accessoire levage des.) ment l'em connaître pour tion (Voir ROULER FAISANT PALET- TRACTEUR objet. qu'il S'assurer aérée. bien zone S'assurer d’instructions.
Page 49
25-26 DÉPANNAGE 18-23 RÉGLAGES 14-17 manuel). PIÈCES tion (Voir proche plus centre disponible silencieux l’opérateur. etat maintenu être doit Quand applicables. locales lois pare-étincelles d’un muni n’est d’herbe d’arbrisseaux, d’arbres, près utilisé être doit à moteur d’un équipé tracteur propriétaire. manuel Entretien sections...
Page 50
descente. dans lentement tournez dans nécessaire, n’est cela pentes dans virage lentement. reculez arrière lames, dégagez montée, s’arrête pente. vers lames dégagez plus, n’adhèrent dans virages arrêts démarrages, pentes. dans vitesse devoir afin faible vitesse pénètre enfant moteur éteignez transversalement. maxi), (15°...
Page 51
s’éboule. bord par-dessus l’improviste à culbuter risque fossés ravins, proximité pied mettant machine stabiliser raides. très pentes l’utilisez machine. à nuire risquent accessoires d’autres avec machine utilisez vous lorsque machine. culbuter faire vitesse brusquement jamais changez lents mouvements n’effectuez pente. vers lames dégagez...
Page 52
AVERTISSEMENT: JETEZ www.poulan-pro.com l’utilisation. lors PELOUSE struc vous sures tions struc tous suivez Lisez PROPRIÉTAIRE web: site notre sécurité lunettes toujours TRACTEUR PB19546LT MODÈLE: MANUEL IMPORTANT 432448 Visitez Portez MANUEL...