Related Manuals for Stanley PW6768
Summary of Contents for Stanley PW6768
- Page 1 6.5HP 2800PSI PRESSURE WASHER For service, spare parts or product information, MODEL NO. please contact Smart Marketing Group Pty. Ltd. PW6768 AUST. 1300 660 457 N.Z. 0800 474 876 02943 05/17...
-
Page 2: Table Of Contents
SUGGESTED APPLICATIONS CONTENTS These are some suggested articles which could be cleaned by this Section Page pressure washer: Contents • Concrete driveway • Paved area Suggested Applications • Introduction • Motorbike • Truck Guarantee 3 – 4 • Wall General Safety Instructions 5 –... -
Page 3: Introduction
INTRODUCTION • Call customer service, phone number at the top. • Ensure you have the following: Original purchase receipt, Dear Customer, Model of pressure washer, Serial number of pressure washer. Thank you for purchasing this pressure washer which has • Discuss the issue. - Page 4 COMPLETE WARRANTY STATEMENT – PRESSURE WASHER GROUP As soon as you have purchased the pressure washer, we Blockages caused by spider webs, insects, dirt, accumulated recommend that you check to make sure it is intact and that you dust, incorrect fuel or incorrectly mixed 2-stroke fuel are not read the operating instructions carefully before using it.
-
Page 5: General Safety Instructions
SAFETY SELECT A PRESSURE WASHER WITH A SUFFICIENT RATING Before attempting to operate this pressure washer the following basic safety precautions should be taken to reduce the risk Select the right pressure washer for the job. Do not use a of fire, electric shock and personal injury. -
Page 6: Fire Precautions
MAINTAIN YOUR PRESSURE WASHER RISK OF DAMAGE WITH CARE Damage may occur if nozzle is used too close to appliance being cleaned. Always trial test the pressure washer on an When not using your pressure washer ensure the fuel cock inconspicuous part of the appliance. -
Page 7: Personal Safety
PERSONAL SAFETY Clothing Do not wear loose clothing, jewellery or anything that could get caught in moving machinery. Hair Long hair should be tied back or contained in a protective covering. Eye Protection The use of safety goggles is highly recommended (normal glasses are not sufficient for eye protection) when using or refuelling pressure washers. -
Page 8: Specific Safety Instructions
SPECIFIC SAFETY INSTRUCTIONS • Never use coolant in the pressure washer as damage may occur. Warning! Do not use the pressure washer in areas where • Never transport the pressure washer with fuel in the tank. there is a risk of explosion or fire from combustible materials. ALWAYS empty the fuel tank. -
Page 9: Fuel & Oil Information
IMPORTANT FUEL - ONLY USE UNLEADED PETROL (ULP) Fuel tank capacity – 3.6 litres (3.6 L) Use of incorrect fuel and/or oil may damage the pressure washer and will not be covered under warranty. Do not use E10 or any type of ethanol fuel as this will damage the pressure washer and will not be covered under warranty. Do not use high octane fuels (greater than 91%) as this will damage the pressure washer and will not be covered under warranty. -
Page 10: Components And Controls
PIC. 1 COMPONENTS AND CONTROLS Pic. 1 1. Frame 2. Gun & Trigger 3. Fuel Tank 4. Lance 5. Nozzles 6. Engine Speed Lever 7. Hose 8. Recoil Starter (Not Shown) 9. Wheel 10. Adjustable Pressure on Pump... -
Page 11: Assembly Instructions
UNPACKING & ASSEMBLY PIC. 2 Unpacking Note: Carefully unpack your pressure washer. This pressure washer is bulky and heavy, two (2) person lift required. Dispose of all packing material in an environmentally responsible manner. Open carton, gently lift the pressure washer clear of the carton and packaging, this may require 2 people. - Page 12 Hose to Pump PIC. 5 Pic. 5 1. Attach the high pressure hose to the pump. Pull back collar and push male connector in fully. Release collar. Ensure that the hose does not touch the muffler or goes over the top of the fuel tank.
-
Page 13: Operating Instructions
OPERATING INSTRUCTIONS PIC. 8 Pre - Operation Preparation Note: If unit has previously been used, the motor, muffler and exhaust may still be hot enough to burn. Always exercise caution when checking the pressure washer. 1. Check that the fuel/engine switch is OFF. 2. - Page 14 Adding Lubricating Oil PIC. 9 Always use clean fresh oil as specified on page 9. Incorrect or old oil can cause the pressure washer to run rough and damage the motor; this will not be covered by warranty. 1. Ensure that engine is OFF when filling oil. 2.
- Page 15 STARTING YOUR PRESSURE WASHER PIC. 11 Warning: Never start your pressure washer without water running through the pump. 1. Check oil level. 2. Check and fill fuel. 3. Connect garden hose to cold water source. 4. Connect garden hose to garden connection on pump. 5.
- Page 16 SELECTING NOZZLE PIC. 17 Black This nozzle is for low pressure and for use with detergent tube and filter. Engine speed must be set on slow. Spray nozzle tip Red 0º This nozzle is for high pressure and proves a single “pencil” stream of water.
- Page 17 TAKING A BREAK DURING USE CLEANING If taking a break of more than 2 minutes during use you must NEVER use this pressure cleaner to clean itself. Damage turn the pressure cleaner off. See stopping below for how to caused by cleaning the pressure washer with its own gun will do this.
-
Page 18: Cleaning Tips
CLEANING TIPS For best results, clean one side of vehicle at a time and always apply detergent from bottom to top, do not allow detergent to dry on surface. Rinse at high pressure in a sweeping motion Deck Cleaning keeping the spray nozzle approximately 150mm to 200mm from - with or without detergent the cleaning surface (distance should increase with in rinsing Pre-rinse deck and surrounding area with fresh water. -
Page 19: Maintenance
MAINTENANCE INFORMATION PIC. 19 If scheduled maintenance is NOT carried out then this will void your warranty. Use the Service Log on page 23 to keep track of the regular servicing. Ensure that the authorised service agent has dated, signed and stamped this log to ensure your warranty is not void. - Page 20 Air Filter PIC. 21 Air filter should be checked daily and replaced every 50 hours (operation) or every 3 months which ever occurs first or whenever considered necessary. To check or replace the air filter; 1. Remove the air filter thumb nut and cover, see Pic. 21. Air filter cover and thumb nut 2.
-
Page 21: Trouble Shooting
TROUBLE SHOOTING Engine will not start Possible Cause Suggested Fix No or low fuel in the fuel tank Fill fuel tank No or low oil in sump Fill oil sump Fuel/Engine lever is OFF Turn fuel/engine lever ON Choke is set to RUN Slide choke to START Unit does not reach high pressure Diameter of garden hose is too small... -
Page 22: Parts Diagram
PARTS DIAGRAM User replaceable parts listed below. All other parts must be serviced/replaced by an authorised service agent. Part Description Part No. Gun - trigger 84 PW6768GT Lance 84 PW6768L High pressure hose 15m QC 84 PW6768HPH Nozzle yellow 84 PW6768NY Nozzle black 84 PW6768NB Nozzle red... -
Page 23: Service Log
SERVICE LOG Purchase Date Place of Purchase This Service is to be complete within 50 hours or This Service is to be complete within 100 hours or 3 months of purchase, which ever comes first. 6 months of purchase, which ever comes first. Replace Replace Check &... -
Page 24: Technical Information
TECHNICAL INFORMATION Specifications Pressure washer PW6768 Maximum pressure 2800PSI Flow rate 9.3L/min Water inlet pressure 0.4MPa 40 o C Water inlet temp Engine 6.5HP 4 stroke OHV Weight 40Kg (no fuel) Fuel volume 3.6L SAE 30W or SAE 15W-40 Oil Quantity...