Torque Values; Lubrication; Electrical System - HUSTLER MDV Operator's Manual

Seat bottom shown in the open position.
A. Seat bottom
Figure 4-3

Torque Values

• Particular attention must be given to tighten-
ing the wheel lug nuts. Failure to correctly
torque these items may result in the loss of a
wheel, which can cause serious damage or
personal injury.
• Never operate the vehicle with loose wheel
(lug) nuts.
Torque values are given below:
Wheel (lug) nuts . . . . . . . . . . . . . . . . . 73 . . . . . . . . 99
Lug nuts only - It is recommended that these be checked
after the first 2 hours of operation, initially, every 50 hours
and following removal for repair or replacement.
For all other torques refer to the General Service Manual for
a standard torque chart. See Product Literature section for
ordering information.
REV A
A
ft-lbs N•m
4-2
For engine torque values, refer to the engine owner's man-
ual.
Tires
• Do not attempt to replace a tire on a rim.
Only qualified persons with the proper equip-
ment should mount tires on a rim.
• Support the vehicle using jack stands before
removing a wheel
• Always maintain the correct tire pressure. Do
not over inflate the tires. Tires should only be
inflated to the pressures shown in this man-
ual.
Check tire pressure every day and inflate as necessary.
The recommended pressures are:
Front tires . . . . . . . . . . . . . . . . . . . . . . 18 psi (124 KPa)
Rear tires. . . . . . . . . . . . . . . . . . . . . . . 18 psi (124 KPa)

Lubrication

Use a SAE multi-purpose grease when greasing the lubrica-
tion points shown in the Maintenance Locator Chart.

Electrical System

IMPORTANT: Refer to the Safety Precautions section of this
manual for battery servicing safety information.
The electrical system is a 12 volt, negative ground. The rec-
ommended battery size is:
BCI group 24F with a 720 or better cranking AMP
rating
A maintenance-free battery is recommended. Otherwise,
follow battery manufacturer's maintenance, safety, storing
and charging specifications.
Access to the Battery Compartment
The battery compartment is located on the left side of the
vehicle.
To gain access to the battery, locate the battery compart-
ment door, rotate the door latch counterclockwise, and open
the door. Figure 4-4 & Figure 4-5
Battery Charging
Occasionally, it may be necessary to charge the battery.
Follow the battery charger manufacturer's warnings and
directions when connecting a charger to the battery and
charging the battery.
606653