Check The Rear Brake Fluid Level; Refilling The Rear Brake Fluid Reservoir; Checking The Rear Brake Pads - KTM 400LC4 Owner's Handbook Manual

2
3
min.
1 mm
Checking rear brake fluid level
The reservoir for the rear disc brake is located on the left-hand side of the
vehicle next to the carburetor carburetor connection boot. The brake fluid
level may not drop below the „MlN" marking when the vehicle is in an
upright position.
I
F THE BRAKE FLUID LEVEL DROPS BELOW THE MINIMUM EITHER THE BRAKE SYSTEM HAS A
LEAK OR THE BRAKE PADS ARE COMPLETELY WORN DOWN
KTM
AUTHORIZED DEALER IMMEDIATELY
1

Refilling the rear brake fluid reservoir*

When the brake fluid level has dropped to the MIN mark, you need to refill
the brake fluid reservoir.
For easier access to the brake fluid reservoir it is recommended to remove
the hexagon screw
the illustration. Remove plug
DOT 5.1 (Shell Advance Brake DOT 5.1) up to the „MAX" mark. Replace
rubber boot and plug. Overflown or spilled brake liquid must be rinsed off
with water. Mount the screw and fix the brake fluid reservoir to the frame,
always making sure to prevent kinks in the connecting hose.
– NEVER DOT5
USE
. S
COLOR EALS AND BRAKE HOSES MUST BE ESPECIALLY ADAPTED TO IT
– S
TORE BRAKE FLUID OUT OF REACH OF CHILDREN
– B
RAKE FLUID CAN CAUSE SKIN IRRITATION
YOU GET BRAKE FLUID IN YOUR EYES
A DOCTOR
!
– D '
ON T LET BRAKE FLUID GET IN CONTACT WITH PAINT
.
REMOVER
– U
SE ONLY CLEAN BRAKE FLUID TAKEN FROM A TIGHTLY SEALED CONTAINER

Checking the rear brake pads

The brake pads can be inspected from the rear. The thickness of the linings
may not be less than 1 mm (0.04 in).
A
T THEIR MOST WORN POINT BRAKE PAD LININGS SHOULD NOT BE THINNER THAN
1 ,
MM OTHERWISE THEY COULD LEAD TO BRAKE FAILURE
'
DON T PUT OFF HAVING YOUR BRAKE PADS CHANGED
!
I
F THE BRAKE PADS ARE REPLACED TOO LATE SO THAT THE LINING IS PARTLY OR ENTIRELY
,
WORN AWAY THE STEEL COMPONENTS OF THE BRAKE PAD WILL RUB AGAINST THE BRAKE
,
DISC IMPARING THE BRAKING EFFECT AND DESTROYING THE BRAKE DISC
WARNING
.
1 . Then move the container outwards as indicated in
with rubber boot
2
WARNING
! I
BRAKE FLUID T IS BASED ON SILICONE OIL AND OF A PURPLE
.
. A
VOID CONTACT WITH SKIN AND EYES
,
RINSE WITH PLENTY OF WATER AND CONSULT
CAUTION
WARNING
.
CAUTION
. I ,
N THIS CASE CONSULT AN
19
and add brake fluid
3
.
. I
F
!
,
IT IS AN EFFECTIVE PAINT
.
. F
OR YOUR OWN SAFETY
!
.