Page 1
XR-M300 3 7 63 1515 0 XR-M301 SERVICE MANUAL L 13942296513 COMPACT DISC BASIC CD MECHANISM : DA11T3C STEREO SYSTEM REMOTE SYSTEM SPEAKER CONTROL XR-M300 SX-M310 RC-AAT15 XR-M301 This Service Manual is the "Revision Publishing" and replaces "Simple Manual"...
http://www.xiaoyu163.com SPECIFICATIONS 3 7 63 1515 0 • Design and specifications are subject to change without notice. • The word “BBE” and the “BBE symbol” are trademarks of BBE Sound, Inc. • Under license from BBE Sound, Inc. L 13942296513 ACCESSORIES LIST REF.
Page 3
http://www.xiaoyu163.com PROTECTION OF EYES FROM BEAM DURING SERVICING CAUTION This set employs laser. Therefore, be sure to follow carefully the 3 7 63 1515 0 instructions below when servicing. Use of controls or adjustments or performance of proce- dures other than those specified herin may result in WARNING!! hazardous radiation exposure.
Page 4
http://www.xiaoyu163.com DISASSEMBLY INSTRUCTIONS 1. Removing the Ornament Parts Remove the screw 1 and remove the PANEL, SIDE R 3 7 63 1515 0 Remove the nine screws. Remove the two screws. Remove the screw 1 and remove the PANEL, SIDE L L 13942296513 Remove the four screws (two screws 1, two screws 2) Remove the two FFCs 1 and 2, and remove the...
Page 5
http://www.xiaoyu163.com 2. Removing the CD ASSY Remove the screw. 3 7 63 1515 0 Remove the PWB, MICOM ASSY from the PWB, CD- SUB connector. Remove the two screws 1 and 2, and remove the Remove the four screws and remove the PWB, CD. CABI, FRONT ASSY 3.
http://www.xiaoyu163.com ELECTRICAL MAIN PARTS LIST 3 7 63 1515 0 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION C102 87-010-178-080 C-CAP,S 1000P-50 K B C2012 C103 87-010-178-080 C-CAP,S 1000P-50 K B C2012 87-A21-552-010 IC,LA4663A C104 87-010-234-040 CAP,E 47-16 M 5L SRE 8A-CJ6-681-030 C-IC,LC87F65C8A-R07...
Page 8
http://www.xiaoyu163.com 3 7 63 1515 0 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION C650 87-010-213-080 C-CAP,S 0.015-25 K B GRM C762 87-012-286-080 C-CAP,U 0.01-25 K B C651 87-010-182-080 C-CAP,S 2200P-50 K B C2012 C763 87-010-829-080 C-CAP,U 0.047-16 Z F C652 87-010-182-080...
Page 9
http://www.xiaoyu163.com 3 7 63 1515 0 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION L781 87-005-847-080 COIL,2.2UH K CECS C400 87-010-196-080 C-CAP,S 0.1-25 Z F C2012 L791 87-A50-027-010 COIL,1 POLE MPX(TOK) C401 87-010-196-080 C-CAP,S 0.1-25 Z F C2012 L792 87-A50-027-010 COIL,1 POLE MPX(TOK)
Page 10
http://www.xiaoyu163.com 3 7 63 1515 0 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION C764 87-016-081-080 C-CAP,S 0.1-16 K R GRM PIN3 S2-369-750-000 PLUG,6P C765 87-010-382-080 CAP,E 22-25 M 11L SME S4-S13-A01-600 SW,LEAF C766 87-016-081-080 C-CAP,S 0.1-16 K R GRM S0-M10-A09-700 MOTOR SLED ASSY C767...
http://www.xiaoyu163.com 3 7 63 1515 0 CHIP RESISTOR PART CODE Chip Resistor Part Coding Figure Resistor Code Value of resistor Chip resistor Dimensions (mm) Symbol Wattage Type Tolerance Resistor Code Form 1/16W 1005 0.35 1/16W 1608 0.45 1/10W 2125 1.25 0.45 1/8W 3216...
Page 12
http://www.xiaoyu163.com SCHEMATIC DIAGRAM-1 (LINE OUT/PT SECTION) 3 7 63 1515 0 L 13942296513 2200p CN603 2200p J601 MD IN L AUX IN L LINE OUT L MD IN R AUX IN R LINE OUT R u163 J600 http://www.xiaoyu163.com...
Page 24
http://www.xiaoyu163.com ADJUSTMENT <TUNER> 3 7 63 1515 0 TUNER C.B CN701 (GND) (RCH) (LCH) L981 TP3(DC) TP4(DC) TP2(CLK) IC771 L771 L941 L942 TC942 L772 FFE801 TP1(VT) 1. Clock Frequency Check 6. AM IF Adjustment Settings : • Test point : TP8 (Lch), TP9 (Rch) Settings : •...
Page 25
http://www.xiaoyu163.com IC DESCRIPTION IC, CXA1992AR 3 7 63 1515 0 Pin No. Pin Name Description Output terminal for focus error amplifier. Internally connected to window comparator input for bias condition. Input terminal for focus error. FDFCT Capacitor connection terminal for time constant used when there is defect. This pin is connected to GND via capacitor when high frequency gain of the focus servo is attenuated.
Page 26
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Description Anti-reverse input terminal for RF summing amplifier. The gain of RF amplifier is decided by the connection resistance between RF-M and RF-O terminals. RFTC This is a pin where the selection time constant is externally connected to control the RF level. APC amplifier output terminal.
Page 27
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Description IN/SW Microcomputer extended interface (input B). (CD pickup inside limit switch.) XLON Microcomputer extended interface (output). Focus OK input. Used for SENS output and the servo auto sequencer. VDD1 –...
Page 28
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Description WFCK WFCK output. (Not used) SCOR Outputs a high signal when either subcode sync S0 or S1 is deteected. (Not used) SBSO Sub P to W serial output. (Not used) EXCK SBSO readout clock input.
Page 29
http://www.xiaoyu163.com IC, LC87F65C8A 3 7 63 1515 0 Pin No. Pin Name Description O-CD-CE Chip enable output to CD DSP IC (CXD2589Q). I-CD-SENSE SENS input from CD DSP IC (CXD2589Q). O-CD-SQCLK SUBQ data readout clock output to CD DSP IC (CXD2589Q). O-AMP-ON Power on control output to POWER AMP IC (LA4663A).
Page 31
http://www.xiaoyu163.com IC, LC72131D 3 7 63 1515 0 Pin No. Pin Name Description X-IN A crystal oscillator (4.5MHz) is connected between these pins. X-OUT – Not connected. To enable the IC. Active "H". Digital data input from CPU (LC87F65C8A) when relevant key is operated. Active "H". To clock in the data DI.
http://www.xiaoyu163.com SPEAKER DISASSEMBLY INSTRUCTIONS 3 7 63 1515 0 Type.4 Type.1 Insert a flat-bladed screwdriver into the position indicated by the TOOLS arrows and remove the panel. Remove the screws of each speaker 1 Plastic head hammer unit and then remove the speaker units. 2 ( –...
Page 38
http://www.xiaoyu163.com SPEAKER MAIN PARTS LIST 1/1 3 7 63 1515 0 REF. NO PART NO. KANRI DESCRIPTION 1 8A-CJ6-402-010 PANEL,FR 2 8A-CJ6-406-010 GRILLE,FRAME ASSY<EZ> 2 8A-CJ6-420-010 GRILLE,FRAME ASSYV<K> 3 8A-CJ6-403-010 PANEL,SP<EZ> 3 8A-CJ6-419-010 PANEL,SP V<K> 4 8A-CJ6-404-010 PANEL,TW 5 8A-CJ6-415-010 SPKR, W 100<K>...
Page 39
http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111 920074 920074 Printed in Singapore http://www.xiaoyu163.com...