Operation; Burner And Orifice; Leak Check - Coleman 9939 Series Instructions For Use Manual

■ Never operate
grill with propane
cylinder in an
inverted position.
(Fig. 9)

Burner and Orifice

■ Proper location of the burner with respect to
the orifice is important. To verify the proper
installation of the burner tube, remove the
cooking surface and the cooktop. The burner
tube, fuel tube, and orifice (on the regulator)
should be positioned as shown in Fig. 10.
Burner
■ Check and clean the burner/fuel tubes for
insects and insect nests. A clogged tube can
lead to a fire beneath the appliance.

Leak Check

WARNING
• Perform leak test outdoors.
• Extinguish all open flames.
• NEVER leak test when smoking.
• Do not use the outdoor grill until connec-
tion has been leak tested and does not leak.
■ Note: Use Coleman ® 16.4 oz. disposable
propane cylinders. The LP-gas supply cylinder
to be used must be constructed and marked
in accordance with the specifications for
LP-gas cylinders of the U.S. Department of
Transportation (DOT) or the National Standard
of Canada, CAN/CSA B339, Cylinders, Spheres
and Tubes for the Transportation of Dangerous
Goods.
Fig. 9
Fuel Tube
Orifice
Fig. 10

Operation

• CARBON MONOXIDE HAZARD
• For outdoor use only.
• Never use inside house, camper, tent,
vehicle or other unventilated or enclosed
areas. This grill consumes air (oxygen). Do
not use in unventilated or enclosed areas to
avoid endangering your life.
• EXPLOSION - FIRE HAZARD
• Propane is heavier than air and can
accumulate in low places. If you smell gas,
leave the area immediately.
• Always attach or detach propane source
outdoors; never while grill is lighted, near
flame, pilot lights, other ignition sources or
while grill is hot to touch.
• This grill is very hot during use and can
ignite flammables too close to the burners.
Minimum distance from sides and back of
unit to walls or railings is 24 inches (61 cm).
Do not use under overhead unprotected
combustible construction. Keep gasoline and
other flammable liquids and vapors well away
from grill.
■ Do not attempt to operate until you have read
and understood all General Safety Information
in this manual and all assembly is complete
and leak checks have been performed.
To Light
• This appliance will be hot during and after
use. Use insulated oven mitts or gloves
for protection from hot surfaces or splatter
from cooking liquids.
• Never leave grill unattended when hot or
in use.
• Keep out of reach of children.
Match Light Grills
■ Set on sturdy, flat surface. For outdoor use only.
■ Remove grill surface.
■ Hold lighted match near burner and open
regulator valve. (Fig. 11)
■ If the grill is hot, use proper protective
equipment.
English-5
DANGER
DANGER
WARNING
• BURN HAZARD