Sony CDP-XE530 Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. CD Player
  5. CDP-XE530
  6. Service manual

Sony CDP-XE530 Service Manual

Hide thumbs Also See for CDP-XE530:
Table of Contents

Advertisement

Quick Links

QQ
3 7 63 1515 0
SERVICE MANUAL
TE
L 13942296513
Compact Disc Player
Laser
Laser output
Frequency response 2 Hz to 20 kHz ± 0.5 dB
Signal-to-noise ratio More than 100 dB
Dynamic range
Harmonic distortion Less than 0.0045%
Channel separation
Output
LINE OUT
DIGITAL OUT
(OPTICAL)
PHONES
www
MICROFILM
http://cxema.ru
http://www.xiaoyu163.com
Semiconductor laser (λ = 780 nm)
Emission duration: continuous
Max 44.6 µW*
* This output is the value measured at adistance of
200 mm from the objective lens surface on the
Optical Pick-up block with 7 mm aperture.
More than 98 dB
More than 95 dB
Jack
Maximum
type
output
level
Phono
2V
jacks
(at 50 kΩ)
Optical
–18 dBm
output
connector
Stereo
10 mW
phone
jack
x
ao
y
.
i
http://www.xiaoyu163.com
CDP-XE530
8
Photo : SILVER
Model Name Using Similar Mechanism
CD Mechanism Type
Base Unit Type
Optical Pick-up Type
SPECIFICATIONS
Q Q
3
6 7
1 3
General
Power requirements
Power consumption
Dimensions (approx.) 430 × 110 × 290 mm
(w/h/d)
Mass (approx.)
Supplied accessories
Audio cord (2 phono plugs–2 phono plugs) (1)
Remote commander (remote) (1)
R6 (size AA) batteries (2)
Design and specifications are subject to change without notice.
Load
impedance
Over 10 kΩ
Wave length:
660 nm
32 Ω
u163
.
2 9
9 4
2 8
AEP Model
1 5
0 5
8
2 9
9 4
220 V – 230 V AC, 50/60 Hz
11W
(17 × 4
× 11
3
/
1
/
in.) incl. projecting parts
8
2
3.4 kg (7 lbs 8 oz)
m
COMPACT DISC PLAYER
co
9 9
UK Model
NEW
CDM14FL-5BD25
BU-5BD25
KSS-213BA/F-NP
2 8
9 9

Advertisement

Table of Contents
loading

Related Manuals for Sony CDP-XE530

Summary of Contents for Sony CDP-XE530

  • Page 1 CDP-XE530 3 7 63 1515 0 SERVICE MANUAL AEP Model UK Model Photo : SILVER Model Name Using Similar Mechanism CD Mechanism Type CDM14FL-5BD25 Base Unit Type BU-5BD25 Optical Pick-up Type KSS-213BA/F-NP SPECIFICATIONS L 13942296513 Compact Disc Player General Laser Semiconductor laser (λ...

  • Page 2: Table Of Contents

    COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

  • Page 3: Servicing Note

    http://www.xiaoyu163.com SECTION 1 SERVICING NOTE 3 7 63 1515 0 HOW TO OPEN THE DISC TRAY WHEN POWER SWITCH NOTES ON HANDLING THE OPTICAL PICK-UP BLOCK TURNS OFF OR BASE UNIT Insert a tapering driver into the aperture of the unit bottom, and turn The laser diode in the optical pick-up block may suffer in the direction of arrow.
  • Page 4 http://www.xiaoyu163.com 3 7 63 1515 0 CD-TEXT TEST DISC This unit is able to display the TEXT data (character information) written in the CD on its fluorescent indicator tube. The CD-TEXT TEST DISC (TGCS-313: J-2501-126-A) is used for checking the display. To check, perform the following procedure.
  • Page 5 http://www.xiaoyu163.com 3 7 63 1515 0 Table 2: CD-TEXT TEST DISC Recorded Contents and Display (In this unit, some special characters cannot be displayed. This is not a fault.) TRACK Recorded contents Display ···· ! ” # $ % & are not displayed ! ”...

  • Page 6: General

    http://www.xiaoyu163.com SECTION 2 GENERAL 3 7 63 1515 0 Front Panel !ª !• !¶ !§ !∞ !¢ !£ !™ !¡ LOCATION OF PARTS AND CONTROLS AMS knob (PUSH ENTER) switch !¡ PHONES jack PLAY MODE button !™ p (stop) button REPEAT button !£...

  • Page 7: Disassembly

    http://www.xiaoyu163.com SECTION 3 DISASSEMBLY 3 7 63 1515 0 Note : Follow the disassembly procedure in the numerical order given. 3-1. FRONT PANEL • In order to remove the front panel block when the power supply does not turn on, rotate the cam with tapering driver as the figure shows, and the loading part will be moved.

  • Page 8: Test Mode

    http://www.xiaoyu163.com SECTION 4 TEST MODE 3 7 63 1515 0 4-1. AF MODE Button No. Button No. Button Button The following checks can be performed in the AF mode, which is Displayed Displayed set by connecting the JW617 (AFADJ) terminal on MAIN LANGUAGE board to the Ground and turning on the power.
  • Page 9 http://www.xiaoyu163.com 3 7 63 1515 0 4-3. AGING MODE [ MAIN BOARD ] – Component Side – This unit is equipped with an aging mode to check operations of the mechanism deck. • When faults occur: Aging stops, and the state when aging stopped is displayed on the fluorescent display tube.

  • Page 10: Electrical Block Checking

    http://www.xiaoyu163.com SECTION 5 ELECTRICAL BLOCK CHECKING 3 7 63 1515 0 Note: CD Block is basically designed to operate without adjustment. symmetry Therefore, check each item in order given. S-curve waveform Use YEDS-18 disc (3-702-101-01) unless otherwise indicated. Use an oscilloscope with more than 10MΩ impedance. Clean the object lens by an applicator with neutral detergent Within 3.8 ±...
  • Page 11 http://www.xiaoyu163.com 3 7 63 1515 0 Adjustment Location : 1 track jump waveform Center of the waveform [ MAIN BOARD ] – Component Side – A (DC voltage) + 0.7 CN621 level : 1.3 Vp-p symmetry – 0.6 E-F Balance Check (With general remote commander) oscilloscope BD board JW613 (ADJ)

  • Page 12: Diagrams

    http://www.xiaoyu163.com SECTION 6 DIAGRAMS 3 7 63 1515 0 6-1. CIRCUIT BOARDS LOCATION LOADING board BD board POWER SW board KEY board MAIN board DISPLAY board HP board L 13942296513 u163 — 12 — http://cxema.ru http://www.xiaoyu163.com...
  • Page 13 http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 http://cxema.ru http://www.xiaoyu163.com...
  • Page 14 http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 http://cxema.ru http://www.xiaoyu163.com...
  • Page 15 http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 http://cxema.ru http://www.xiaoyu163.com...
  • Page 16 http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 http://cxema.ru http://www.xiaoyu163.com...
  • Page 17 http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 http://cxema.ru http://www.xiaoyu163.com...
  • Page 18 http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 http://cxema.ru http://www.xiaoyu163.com...
  • Page 19 http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 http://cxema.ru http://www.xiaoyu163.com...
  • Page 20 http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 http://cxema.ru http://www.xiaoyu163.com...
  • Page 21 http://www.xiaoyu163.com 3 7 63 1515 0 • IC501 SYSTEM CONTROL (CXP82832-012Q)(DISPLAY board) Pin No. Pin Name Function FL grid signal output FL grid signal output – Connected to VDD – Power supply (+5V) SCOR Sub code sync input 6, 7 –...
  • Page 22 http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Function – Ground – Not used – Connected to ground VDD (+5V) – Power supply (+5V) VFDP (–30V) – Pull down voltage (–30V) XSEL Not used — – Not used LP CONTROL LP control hold output 49 to 66...

  • Page 23: Ic Block Diagrams

    http://www.xiaoyu163.com 3 7 63 1515 0 6-11. IC BLOCK DIAGRAMS • BD SECTION IC101 CXD2585Q 71 70 67 66 65 64 63 62 61 Digital VPCO Clock DVDD0 V16M Generator XRST VCTL MUTE Interface BIAS Error AVDD1 Corrector DATA XLAT CLOCK FILI Interface...
  • Page 24 http://www.xiaoyu163.com 3 7 63 1515 0 IC102 BA6392FP BUFF CH1 OUT F 28 GND BUFF BUFF CH1 OUT R 27 CH4 OUT F LEVEL SHIFT CAPA IN 1 26 CH4 OUT R BUFF CH1 R IN 25 VB IN INTERFACE CH1 F IN 24 VS IN BUFF...

  • Page 25: Main Section

    http://www.xiaoyu163.com 3 7 63 1515 0 • MAIN SECTION IC631 LB1641 IC601 LA5602 T.S.D O.C.P V IN MOTOR MOTOR ERROR DRIVE DRIVE REFERENCE VOLTAGE OVER CURRENT LIMITTER FWD/REV/STOP OVER HEAT CONTROL LOGIC PROTECTION ON/OFF RESET CDEL V OUT IC661 CXD8567AM L 13942296513 INIT D Vdd 2...
  • Page 26 http://www.xiaoyu163.com SECTION 7 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • -XX, -X mean standardized parts, so they may • The mechanical parts with no reference number • Color Indication of Appearance Parts have some differences from the original one. in the exploded views are not supplied.
  • Page 27 Description Remarks X-4950-693-1 PANEL ASSY, FRONT(BLACK) 4-210-291-01 SCREW (CASE 3 TP2)(BLACK)(AEP,AED,CIS) X-4950-694-1 PANEL ASSY, FRONT(SILVER) 4-210-291-11 SCREW (CASE 3 TP2)(SILVER)(AEP) 4-996-698-01 EMBLEM, SONY 4-999-877-01 SCREW (CASE)(UK) 4-977-593-11 RING(DIA. 50), ORNAMENTAL 1-776-100-11 WIRE(FLAT TYPE) (23 CORE) ! 18 4-977-358-11 CUSHION(AEP,UK,CIS) 1-575-651-21 CORD, POWER...

  • Page 28: Cd Mechanism Section (Cdm14Fl-5Bd25)

    http://www.xiaoyu163.com 3 7 63 1515 0 7-2. CD MECHANISM SECTION (CDM14FL-5BD25) BU-5BD25 not supplied L 13942296513 M151 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 1-452-925-21 MAGNET ASSY 1-645-721-11 LOADING BOARD 4-933-134-01 SCREW (+PTPWH M2.6 × 6) 4-933-110-41 HOLDER (MG) 4-995-814-21 TABLE (FL), DISC 4-959-996-01 SPRING (932), COMPRESSION...

  • Page 29: Base Unit Section (Bu-5Bd25)

    http://www.xiaoyu163.com 3 7 63 1515 0 7-3. BASE UNIT SECTION (BU-5BD25) L 13942296513 M102 M101 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks ! 151 8-848-379-31 OPTICAL PICK-UP KSS-213BA/F-NP 4-917-564-01 GEAR (P), FLATNESS 1-769-069-11 WIRE (FLAT TYPE) (16 CORE) * 157 A-4724-002-A BD BOARD, COMPLETE 3-713-786-51 SCREW +P 2 ×...

  • Page 30: Electrical Parts List

    http://www.xiaoyu163.com SECTION 8 ELECTRICAL PARTS LIST 3 7 63 1515 0 NOTE: • Due to standardization, replacements in the • CAPACITORS: • SEMICONDUCTORS parts list may be different from the parts uF: µF In each case, u: µ, for example: specified in the diagrams or the components •...
  • Page 31 http://www.xiaoyu163.com DISPLAY LOADING 3 7 63 1515 0 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks A-4724-502-A DISPLAY BOARD, COMPLETE S521 1-762-752-11 SWITCH, TACTILE(§OPEN/CLOSE) S522 1-762-752-11 SWITCH, TACTILE(·) *********************** S523 1-762-752-11 SWITCH, TACTILE(P) 4-997-495-01 GUIDE(FL) S524 1-762-752-11 SWITCH, TACTILE(p) S531 1-475-543-11 ENCODER, ROTARY(AMS)
  • Page 32 http://www.xiaoyu163.com MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks A-4724-503-A MAIN BOARD, COMPLETE(AEP,AED,CIS) C690 1-164-159-11 CERAMIC 0.1uF C691 1-164-159-11 CERAMIC 0.1uF ********************* C695 1-161-494-00 CERAMIC 0.022uF A-4724-507-A MAIN BOARD, COMPLETE(UK) C801 1-162-282-31 CERAMIC 100PF...
  • Page 33 http://www.xiaoyu163.com MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks < IC > R651 1-249-429-11 CARBON 1/4W R661 1-249-417-11 CARBON 1/4W F IC601 8-759-061-65 IC LA5602 R662 1-249-417-11 CARBON 1/4W F IC602 8-749-011-78 IC BA17807T R663...
  • Page 34 CDP-XE530 POWER SW 3 7 63 1515 0 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 1-672-319-11 POWER SW BOARD ACCESSORIES & PACKING MATERIALS *************** ******************************* 7-685-871-01 SCREW +BVTT 3 × 6 (S) 1-473-720-11 REMOTECOMMANDER (RM-DX50) 1-776-263-11 CORD,CONNECTION (AUDIO) <...

Table of Contents