Electrical System - Volvo 2002 S60 Owner's Manual

Trunk lighting
Glove compartment lighting
Vanity mirror
pg. 201 Suspension
Wheel dimension
Rim diameter (mm)
tire side diameter(mm)
Toe- in front (degrees)
Toe- in rear (degrees)
Toe- in front (mm) rim measurement 2. 2± 0. 7
tire side measurement
Toe- in rear (mm) rim measurement 1. 4± 1. 4
tire side measurement
Rear suspension
Individual rear wheel suspension with longitudinal support arms, double link arms and track rods.
Front suspension
Spring strut suspension with integrated shock absorbers and control arms linked to the support frame. Power-assisted
rack and pinion steering. Safety type steering column.
pg. 202 Electrical system

Electrical system

12- volt system with voltage controlled generator. Single wire system in which the chassis and engine block are used
as conductors, grounded on the chassis.
Battery
Voltage 12 V
Cold start capacity (CCA) 600 A
Reserve capacity (RC) 115 min
If you must replace your battery, be sure to replace it with a battery of the same cold start capacity and reserve
capacity as the original (See the decal on the battery).
Generator max. current 140 A
Starter motor, power 1.4 kW
Spark plugs P/ N272313- 8 or equivalent
Gap 0.028- 0.032 in. 0.7- 0.8 mm
Tightening torque 22 ft. lbs. (30 Nm)
Firing order 1- 2- 4- 5- 3
WARNING!
The distributor ignition system operates at very high voltages. Special safety precautions must be followed to
prevent injury. Always turn the ignition off when:
áReplacing distributor ignition components e. g. plugs, coil, etc.
5 W SV 8.5
2 W BA 9 s
1.2 W SV 5.5
15" 16"
415 440
515 540
0.1°± 0. 1° 0.1°± 0. 1°
0.2°+± 0.2° 0.2+± 0. 2°
2.3± 0.8
2.7± 0.9 2. 8± 0. 9
1.5± 1.5
1.8± 1.8 1. 9± 1. 9