Reassembling The Xpo - Invacare XPO2 Service Manual

The thermal pad is between the battery and the bottom
of the tray. It is a soft "dough-like" material that adheres
to the tray. If thermal pad is damaged or pulled up during
battery removal it MUST be replaced.
Locate the black wire L and the red wire M on the new battery
5.
pack (Figure 6).
6. Move the black and red wires away from the rest of the wires
(yellow, white and green).
The red and black wires CAN NOT be twisted. See
Figure 6.
7. Open the ferrite N.
8. Place the ferrite around the black and red wires.
9. Close and lock the ferrite around the black and red wires.
10. Slide the ferrite to ensure it is not pinching the wires.
1154285B
11. Position the new battery on the thermal pad as shown in Figure 5.
When installing the new battery, ensure the battery label
faces up.
12. Connect the battery wiring harness J to the internal printed
circuit board (PCB) G.
13. Re-assemble the XPO2. Refer to 3.3 Reassembling the XPO
page 3 .

3.3 Reassembling the XPO

Carefully, re-install the front cover F onto the XPO
1.
4).
2. Turn the XPO On to ensure proper operation.
2
3. Turn the XPO Off.
2
4. While holding the unit together, position the XPO
back panel label C is facing up.
Install four mounting screws D and secure the two sections of
5.
the XPO together (Figure 2). Securely tighten.
2
6. Remove the glue residue from the top of the XPO
label was removed. Apply 91% isopropyl alcohol, and wipe with a
clean cloth. Make sure the surface is dry and free of any residue.
This will ensure a good seal for the new label.
7. Install replacement label A on the top of the XPO
adheres to both the front and rear sections (Figure 1).
1 Généralités
1.1 Symboles
Les mentions d'avertissement utilisées dans le présent manuel
s'appliquent aux risques ou aux pratiques dangereuses qui pourraient
provoquer des blessures ou des dommages matériels. Reportez-vous
aux informations ci-dessous pour la définition des mentions
d'avertissement.
La mention Danger indique une situation dangereuse
imminente qui, si elle n'est pas évitée, provoquera des
blessures graves ou la mort.
La mention Avertissement indique une situation
potentiellement dangereuse qui, si elle n'est pas évitée,
pourrait provoquer des blessures graves ou la mort.
La mention Attention indique une situation
potentiellement dangereuse qui, si elle n'est pas évitée,
peut provoquer des dommages matériels et/ou des
blessures légères.
,
2
2
B (Figure
2
so that the
2
, where the
2
so that it
2
IFRI
3