Page 1
DCR-TRV22 AEP Model UK Model North European Model East European Model Chinese Model Australian Model DCR-TRV22E E Model Hong Kong Model Photo : DCR-TRV22 Tourist Model Z MECHANISM DCR-TRV22/TRV22E Link Link SPECIFICATIONS BLOCK DIAGRAMS PRINTED WIRING BOARDS SPECIFICATIONS BLOCK DIAGRAMS...
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU PUBLISHED BY SONY.
Page 3
: North European model qg 2-pin conversion adaptor (1) : Hong Kong model 8 Shoe cover (1) (DCR-TRV22 : E, HK/TRV22E : E/HK only) 9 “Memory Stick” (1) MSA-8A SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer.
DCR-TRV22/TRV22E TABLE OF CONTENTS SERVICE NOTE • CK-129 (FUNCTION SWITCH) SCHEMATIC DIAGRAM ···························· 4-21 1-1. SERVICE NOTE ····························································· 1-1 • PD-188 (1/2)(DRIVER, TG) POWER SUPPLY DURING REPAIRS ·························· 1-1 SCHEMATIC DIAGRAM ···························· 4-23 TO TAKE OUT A CASSETTE WHEN NOT EJECT •...
Page 5
DCR-TRV22/TRV22E 5-1-11. MECHANICAL CHASSIS BLOCK ASSEMBLY ··· 5-13 5-2. ELECTRICAL PARTS LIST ········································ 5-13 Parts list of the VC-312 board are not shown. Pages from 5-21 to 5-26 are not shown. — 5 —...
DCR-TRV22/TRV22E SECTION 1 COVER COVER SERVICE NOTE 1-1. SERVICE NOTE POWER SUPPLY DURING REPAIRS In this unit, about 10 seconds after power is supplied to the battery terminal using the regulated power supply (8.4V), the power is shut off so that the unit cannot operate.
DCR-TRV22/TRV22E 1-2. SELF-DIAGNOSIS FUNCTION SELF-DIAGNOSIS FUNCTION SELF-DIAGNOSIS DISPLAY When problems occur while the unit is operating, the self-diagnosis When problems occur while the unit is operating, the counter of the function starts working, and displays on the viewfinder, or LCD viewfinder or LCD screen consists of an alphabet and 4-digit number, screen what to do.
DCR-TRV22/TRV22E SELF-DIAGNOSIS CODE TABLE Self-diagnosis Code Block Detailed Symptom/State Correction Function Code Non-standard battery is used. Use the info LITHIUM battery. Condensation. Remove the cassette, and insert it again after one hour. Video head is dirty. Clean with the optional cleaning cassette.
DCR-TRV22/TRV22E SECTION 2 COVER COVER HELP HELP DISASSEMBLY The following flow chart shows the disassembly procedure. DISASSEMBLY PD-188 board service position DISASSEMBLY HELP DISASSEMBLY SERVICE POSITION TO CHECK THE VTR SECTION DISASSEMBLY HELP DISASSEMBLY DISASSEMBLY HELP DISASSEMBLY DISASSEMBLY DISASSEMBLY HELP HELP PROCEDURE OF REMOVING THE MECHANISM DECK.
Page 10
DCR-TRV22/TRV22E NOTE: Follow the disassembly procedure in the numerical order given. [CONNECTION OF EQUIPMENT] LANC jack AC power Adjustment remote AC IN adaptor commander (RM-95) DC-IN connector CPC lid Screw (M1.7 × 4), CPC-7 jig lock ace, p2 (J-6082-382-A)
DCR-TRV22/TRV22E 2-1. P CABINET (C) ASSEMBLY Turn the Turn the LCD panel LCD panel Caution Rotation of the LCD panel has limitation due to its hinge in this model. Excessive force to rotate the LCD panel damages the hinge. Follow the precaution below.
DCR-TRV22/TRV22E Ver 1.1 2003. 06 2-2. CABINET (R) COVER (39E) ASSEMBLY Raise the Finder in the Two screws ´ direction of the arrow (M1.7 lock ace, p2 Screw ´ (M1.7 lock ace, p2 Two screws ´ (M1.7 lock ace, p2...
DCR-TRV22/TRV22E 2-3. F PANEL SECTION Screw (M1.7 × 4), lock ace, p2 Open the Cassette lid Screw (M1.7 × 4), lock ace, p2 Screw (M1.7 × 4), lock ace, p2 Remove the claw Remove the F panel section in the direction of the arrow...
DCR-TRV22/TRV22E 2-4. MA-421 BOARD Remove the MA-421 board in the way of twisting it in the direction of the arrow 9 HP sheet Microphone Microphone retainer Microphone (4P) Tapping screw (M1.7 × 5) MA cover, MA cover cushion MA-421 board Two tapping screws (M1.7 ×...
DCR-TRV22/TRV22E 2-8. PD-188 BOARD, LCD UNIT Four claws Two screws (M1.7 × 4), lock ace, p2 P cabinet (C) assembly (M) Caution When remove the Harness (PV-140), be careful to damage the Harness (PV-140). Harness (PV-140) (20P, 40P) 1 Two tapping screw (M1.7 ×...
DCR-TRV22/TRV22E 2-9. HINGE (40) ASSEMBLY Caution Rotation of the LCD panel has limitation due to its hinge in this model. Excessive force to rotate the LCD panel damages the hinge. (Refer to "Caution"of 2.1 Pcabinet assembly.) Rotate to the "A" marked portion...
DCR-TRV22/TRV22E 2-11. LB-085 BOARD (REMOVING OF THE EVF)-1 Caution When installing the EVF flexible retainer, please be sure to install it while the viewfinder is kept pushed up to attach. Finder EVF flexible retainer Caution When installing, pass the FP-619 flexible...
DCR-TRV22/TRV22E 2-12. LB-085 BOARD (REMOVING OF THE EVF)-2 Visiblity knob (40) VF slide cabinet (upper) assembly To raise the VF slide cabinet (upper) Tapping screw (M1.7 × 3.5) assembly, insert a flat head (-) screwdriver into the position shown by the arrow.
DCR-TRV22/TRV22E 2-13. LB-085 BOARD (REMOVING OF THE EVF)-3 Two screws (M1.7 × 2.5), lock ace, p2 Pull out the VF slide assembly fully in the direction of the arrow. VF slide Cabinet (upper) assembly VF slide assembly, etc. 3 Slide the VF slide cabinet assembly and others once...
DCR-TRV22/TRV22E 2-14. VA-118 BOARD, LENS SECTION Caution Caution Fold the harness of the control switch When attach the Tape (A), fold the FP-620 block (FK-CX4000) toward the board as flexible board as shown in the illustration. shown in the illustration.
DCR-TRV22/TRV22E 2-19. CONTROL SWITCH BLOCK (FK-CX4000) Caution FK flexible retainer When installing, fix the flexible board of the Control switch block (FK-CX4000) with the FK flexible retainer as shown in the illustration. Control switch block (FK-CX4000) FK flexible retainer Screw (M1.7 ×...
Page 27
DCR-TRV22/TRV22E [SERVICE POSITION TO CHECK THE VTR SECTION] Connection to Check the VTR Section To check the VTR section, set the VTR to the “Forced VTR power ON” mode. Operate the VTR functions using the adjustment remote commander (with the HOLD switch set in the OFF position).
DCR-ITRV22/TRV22E 2-22.FLEXIBLE BOARDS LOCATION The flexible boards contained in the mechanism deck and that in the lens device are not shown. CONTROL SWITCH BLOCK (FK-CX4000) FP-620 CONTROL SWITCH BLOCK (CF-CX4000) FP-618 FP-621 FP-630 FP-623 FP-626 FP-619 FP-625 2-21E...
Page 30
DCR-TRV22/TRV22E 4/Feb/2003 HELP Sheet attachment positions and procedures of processing the flexible boards/harnesses are shown. OVERALL SECTION -1 FK flexible retainer Flexible board FP-618 flexible board FP-620 flexible board Tape (A) VA-118 board VA-118 board VA-118 board Harness of the Control...
DCR-TRV22/TRV22E COVER COVER 3. BLOCK DIAGRAMS Link Link OVERALL BLOCK DIAGRAM (1/4) POWER BLOCK DIAGRAM (1/2) OVERALL BLOCK DIAGRAM (1/4) POWER BLOCK DIAGRAM (1/2) OVERALL BLOCK DIAGRAM (2/4) OVERALL BLOCK DIAGRAM (2/4) POWER BLOCK DIAGRAM (2/2) POWER BLOCK DIAGRAM (2/2)
Page 34
DCR-TRV22/TRV22E SECTION 3 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS COVER COVER BLOCK DIAGRAMS ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. 3-1. OVERALL BLOCK DIAGRAM (1/4) CD-430 BOARD...
Page 35
DCR-TRV22/TRV22E 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS COVER COVER ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. 3-2. OVERALL BLOCK DIAGRAM (2/4) VA-118 BOARD(2/4) PD-188 BOARD(1/2) CN1002 CN4004...
Page 36
DCR-TRV22/TRV22E 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS COVER COVER 3-3. OVERALL BLOCK DIAGRAM (3/4) ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. CN1004 Z MECHA DECK FOR ADJUSTMENTS...
Page 37
DCR-TRV22/TRV22E 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS COVER COVER ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. 3-4. OVERALL BLOCK DIAGRAM (4/4) VC-312 BOARD(4/4) CK-129 BOARD VA-118 BOARD(4/4)
Page 38
DCR-TRV22/TRV22E 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS COVER COVER 3-5. POWER BLOCK DIAGRAM (1/2) ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. VA-118 BOARD D 2.8V (3/5) R400,4005...
Page 39
DCR-TRV22/TRV22E 3. BLOCK DIAGRAMS 3. BLOCK DIAGRAMS COVER COVER ( ) : Number in parenthesis ( ) indicates the division number of schematic diagram where the component is located. 3-6. POWER BLOCK DIAGRAM (2/2) MA-421 BOARD PD-188 BOARD LCD901 2.5 INCH CN5402 EP 4.6V...
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS COVER COVER THIS NOTE IS COMMON FOR SCHEMATIC DIAGRAMS (In addition to this, the necessary note is printed in each block) (For schematic diagrams) 1. Connection • All capacitors are in µF unless otherwise noted. pF : µ...
Page 45
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS CD-430 BOARD CD-430 BOARD LB-085 BOARD LB-085 BOARD COVER COVER For Schematic Diagram 4-2. SCHEMATIC DIAGRAMS • Refer to page 4-67 for printed wiring board of CD-430 board. • Refer to page 4-69 for printed wiring board of LB-085 board.
Page 46
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS VA-118 BOARD SIDE A VA-118 BOARD SIDE A VA-118 BOARD SIDE B VA-118 BOARD SIDE B COVER COVER For Schematic Diagram • Refer to page 4-73 for printed wiring board. VA-118 BOARD(1/5) EP_4.6V RGB DRIVE,TG(EVF BLOCK) D_2.8V...
Page 47
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS VA-118 BOARD SIDE A VA-118 BOARD SIDE A VA-118 BOARD SIDE B VA-118 BOARD SIDE B COVER COVER For Schematic Diagram • Refer to page 4-73 for printed wiring board. VA-118 BOARD(2/5) NO MARK:REC/PB MODE...
Page 48
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS VA-118 BOARD SIDE A VA-118 BOARD SIDE A VA-118 BOARD SIDE B VA-118 BOARD SIDE B COVER COVER For Schematic Diagram • Refer to page 4-73 for printed wiring board. CN4004 100P B TO B...
Page 49
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS VA-118 BOARD SIDE A VA-118 BOARD SIDE A VA-118 BOARD SIDE B VA-118 BOARD SIDE B COVER COVER For Schematic Diagram • Refer to page 4-73 for printed wiring board. VA-118 BOARD(4/5) BATT_UNREG...
Page 50
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS VA-118 BOARD SIDE A VA-118 BOARD SIDE A VA-118 BOARD SIDE B VA-118 BOARD SIDE B COVER COVER For Schematic Diagram • Refer to page 4-73 for printed wiring board. VA-118 BOARD(5/5) POWER IN,CHARGE(FU BLOCK)
Page 51
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS CK-129 PRINTED WIRING BOARD CK-129 PRINTED WIRING BOARD COVER COVER For Schematic Diagram • Refer to page 4-77 for printed wiring board. CK-129 BOARD FUNCTION SWITCH XX MARK:NO MOUNT CN5208 CN5210 TP_TOP LI_3V...
Page 52
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS PD-188 PRINTED WIRING BOARD PD-188 PRINTED WIRING BOARD COVER COVER For Schematic Diagram • Refer to page 4-79 for printed wiring board. PD-188 BOARD(1/2) DRIVER,TG(RGB/TG BLOCK) XX MARK:NO MOUNT Q6004 NO MARK:REC/PB MODE...
Page 53
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS PD-188 PRINTED WIRING BOARD PD-188 PRINTED WIRING BOARD COVER COVER For Schematic Diagram • Refer to page 4-79 for printed wiring board. PD-188 BOARD(2/2) BACKLIGHT DRIVE(BL BLOCK) XX MARK:NO MOUNT NO MARK:REC/PB MODE...
Page 54
DCR-TRV22/TRV22E 4-2. SCHEMATIC DIAGRAMS 4-2. SCHEMATIC DIAGRAMS JK-242 PRINTED WIRING BOARD JK-242 PRINTED WIRING BOARD COVER COVER For Schematic Diagram • Refer to page 4-81 for printed wiring board. JK-242 BOARD A.V/DV IN/OUT XX MARK:NO MOUNT FB5301 J5301 AUDIO/VIDEO R5306...
Page 60
DCR-TRV22/TRV22E 4-3. PRINTED WIRING BOARDS 4-3. PRINTED WIRING BOARDS COVER COVER THIS NOTE IS COMMON FOR WIRING BOARDS (In addition to this, the necessary note is printed in each block) (For printed wiring boards) • Chip parts. • : Uses unleaded solder.
DCR-TRV22/TRV22E CD-430 BOARD CD-430 BOARD VA-118 BOARD SIDE A VA-118 BOARD SIDE A VA-118 BOARD SIDE B VA-118 BOARD SIDE B PD-188 BOARD PD-188 BOARD COVER COVER 4-4. WAVEFORMS CD-430 VA-118 PD-188 BOARD CAMERA REC BOARD BOARD REC/PB IC5001 1,2...
DCR-TRV22/TRV22E 4-3. PRINTED WIRING BOARDS 4-3. PRINTED WIRING BOARDS COVER COVER 4-5. MOUNTED PARTS LOCATION no mark : side A * mark : side B CD-430 BOARD LB-085 BOARD VA-118 BOARD * C5001 * C5601 * C4001 C4538 * L4511...
DCR-TRV22/TRV22E COVER COVER NOTE NOTE 5. REPAIR PARTS LIST NOTE: Characters A to Z of the electrical parts list indicate location of exploded views in which the desired part is shown. EXPLODED VIEWS EXPLODED VIEWS Link Link OVERALL SECTION F PANEL SECTION...
Page 74
DCR-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER NOTE: • -XX, -X mean standardized parts, so they may have some differences from When indicating parts by reference number, the original one. please include the board name. •...
Page 76
DCR-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-2. F PANEL SECTION ns : not supplied MIC901 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 3-080-516-01 COVER, S TERMINAL 3-080-517-01 RETAINER, MICROPHONE 3-080-402-01 PLATE, NAME (TRV22) 3-713-791-11 SCREW (M1.7X5), TAPPING, P2...
Page 77
DC-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-3. MAIN CHASSIS SECTION ns : not supplied Cabinet (L) section (See page 5-7) Mechanism deck (See page 5-11 to 5-13) Lens section (See page 5-6) Ref. No. Part No. Description Remarks Ref.
Page 78
DCR-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-4. LENS SECTION IC5001 Be sure to read “Precautions upon replacing CCD imager” on page 4-9 when changing the CCD imager. Ref. No. Part No. Description Remarks Ref. No.
Page 79
DC-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-5. CABINET L SECTION ns : not supplied Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks X-3953-219-2 CABINET (G) ASSY (40E) X-3953-217-1 CABINET (L) ASSY (39E) 3-989-735-01 SCREW (M1.7), LOCK ACE, P2 1-815-795-11 CONNECTOR, MEMORY STCK 3-713-791-51 SCREW (M1.7X3.5), TAPPING, P2...
Page 80
DCR-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-6. BT PANEL/EVF SECTION ns : not supplied LCD902 BT901 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 3-080-420-01 CABINET, VF TILT 3-713-791-51 SCREW (M1.7X3.5), TAPPING, P2...
Page 81
DC-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-7. CABINET R SECTION ns : not supplied LCD section (See page 5-10) SP901 : BT5201 (Lithium battery) CK-129 board on the mount position. (See page 4-77) CAUTION : Danger of explosion if battery is incorrectly replaced.
Page 82
DCR-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-8. LCD SECTION ns : not supplied S101 LCD901 ND901 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 3-080-441-01 EMBLEM, P A-7013-528-A PD-188 BOARD, COMPLETE...
Page 83
Ver 1.1 2003. 06 DC-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-9. OVERALL (MECHANISM DECK-Z100) M901 LS chassis block assembly (See page 5-12) Mechancal chassis block assembly (See page 5-13) Ref. No. Part No. Description Remarks Ref.
Page 84
DCR-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-10. LS CHASSIS BLOCK ASSEMBLY ns : not supplied MIC902 Q901 FP-468 D901 (Note) H901 Q902 H902 S903 Note: FP-468 is included in the LS block assy and is attached to chassis by hot-press.
Page 85
DC-TRV22/TRV22E 5. REPAIR PARTS LIST 5. REPAIR PARTS LIST COVER COVER 5-1-11. MECHANICAL CHASSIS BLOCK ASSEMBLY ns : not supplied M902 S902 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 3-079-314-01 SPRING (EJ), EXTENSION 3-079-308-01 SHAFT, WORM 3-079-327-01 ARM, EJ 3-079-309-01 GEAR, DECELERATION 3-079-323-02 GEAR, CONVERSION...
Page 86
DCR-TRV22/TRV22E CD-430 CK-129 FP-626 JK-242 LB-085 5-2. ELECTRICAL PARTS LIST Ref. No. Part No. Description Ref. No. Part No. Description A-7013-526-A CD-430 BOARD, COMPLETE 1-687-550-11 FP-626 BOARD, COMPLETE *********************** ********************** (IC5001 is not included in this COMPLETE board) S101 1-771-039-31 SWITCH, PUSH (PANEL REVERSE) <...
Page 93
DCR-TRV22/TRV22E Ver 1.1 2003. 06 Ref. No. Checking supplied accessories. Part No. Description Ref. No. Part No. Description Make sure that the following accessories are supplied with your camcorder. A/V connecting cable Power cord (Main lead)(1) AC power adaptor (1) (AC-L15A) NP-FM30 battery pack (1) (1.5m) (1)
Reverse 987622232.pdf Revision History S.M. Rev. Ver. Date History Contents issued 2003.02 Official Release — — 2003.06 Correction-1 Change of the parts S.M. Correction: Page 2-4, Page 5-11, Page 5-27...