PIONEER Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. VSX-415-K...
Treble..... . .± 6 dB (10 kHz) Loudness..+10 dB/+5 dB (100 Hz/10 kHz) (at volume level –50 dB) VSX-415-K...
Page 6
VOLUME MUTE CH SELECT LEVEL EFFECT TEST TONE CLASS TUNER AUDIO TUNING STATION DISPLAY DVD CONTROL SUB TITLE AA size IEC R6 AM loop antenna FM wire antenna Dry cell batteries (x2) RECEIVER (ATB7013) (ADH7030) Remote control unit (XXD3067) VSX-415-K...
Left Pad V2 XHA3149 Right Pad V2 XHA3150 Operating instructions XRC3183 Packing Case See Contrast table(2) (Dutch, Spanish) (2) CONTRAST TABLE VSX-415-K/MYXJ and VSX-415-S/MYXJ are constructed the same except for the following : Mark Description VSX-415-K/MYXJ VSX-415-S/MYXJ Packing Case XHD3484 XHD3485 VSX-415-K...
2.3 FRONT PANEL NON-CONTACT SIDE CONTACT SIDE VSX-415-K...
Page 11
See Contrast table(2) Sub BTN See Contrast table(2) JOG BUTTON See Contrast table(2) • • • • • • (2) CONTRAST TABLE VSX-415-K/MYXJ and VSX-415-S/MYXJ are constructed the same except for the following : Mark Description VSX-415-K/MYXJ VSX-415-S/MYXJ JOG Knob V1K XAB3038...
1SS133 Unit:k-kΩ,M-MΩ or unless otherwise noted. Rated power:1/4W unless otherwise noted. Tolerance:(J) ± 5% unless otherwise noted. 2.CAPACITORS Umit: p-pF or µF unless otherwise noted. Ratings:Capacity(µF)/Voltage(V) unless otherwise noted. Rated Voltage:50V except for electrolytic capacitors. 3.DIODES Indicated in 1SS133-T VSX-415-K...
Page 27
NO. 491010 FOR IC604, IC605, IC606, Q691,692: AND IC607 MFD, BY LITTELFUSE INC. DC OUTPUT DETECTOR : AUDIO SIGNAL ROUTE • NOTE FOR FUSE REPLACEMENT FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. CAUTION - REPLACE WITH SAME TYPE AND RATINGS ONLY. VSX-415-K...
Q802 CN803 DTC114ES AC WUP KM200TA7 +12V AC RY SBOUT Stby5V SWOUT Q801 GNDA GNDU DTA124ES Q804 GNDA DTC114ES SWOUT SP-A RY SBOUT +12V GNDU SP-B RY Q803 HP.SW +12V DTA124ES R/C RY CN801 CN53 -12V 52045-2345 52045-2345 CN302 VSX-415-K...
Page 29
STANDBY TRANS XTF3004 NEUTRAL U+5V REG.IC ATT7040 AC POWER CORD VDG1077 : MY 0.01 YF AMP&PRIMARY ASSY (XWZ3783) • NOTE FOR FUSE REPLACEMENT FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. CAUTION - REPLACE WITH SAME TYPE AND RATINGS ONLY. VSX-415-K...
Symbol In PCB Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B P.C.Board Chip Part transistor Resistor array 3-terminal regulator VSX-415-K...
(XNP3076-C) SIDE A POWER TRANSFORMER ZSKJ35 HCI40HI TRANS1 XWZ3806 REMPLACER LE IC LINKS COMME INDIQUE. DE CHEZ LITTELFUSE INC. (XNP3076-C TRANS2 ASSY TRANS2 ATTENTION XWZ3809 SIDE A XWZ3810 BROWN BLUE PRIMARY (XNP3076-C) TRANS1 ASSY SIDE A D E H VSX-415-K...
Page 45
LINKS AS MARKED.MFD. BY LITTELFUSE INC. IC605 W518 W528 D752 ATTENTION C613 R676 491010 D723 C614 D605 D606 COMME INDIQUE. C770 R675 W508 IC601 D721 REMPLACER LE IC LINKS C758 KN601 DE CHEZ LITTELFUSE INC. D722 W509 CN53 CN53 D724 CN801 VSX-415-K...
TUNER EDIT TONE QUICK SETUP (EON MODE) S461 S462 CN702 POWER SW & H.P ASSY KEY ASSY 1551 S503 S502 TUNING- TUNING+ S504 S505 STATION- STATION+ CMKM-P3X PWR & KEY XWZ3917 S501 POWER (XNP3089-A) (XNP3089-A) M O P Q VSX-415-K...
Page 47
9 NC S469 S467 S468 S470 CDR/TAPE CN511 6 ENTER (XNP3089-A) 5 FENC A FRONT KEY ASSY 4 FENC B R.ENCODER 3 GNDU 2 VENC B S512 1 VENC A XWZ3920 S511 ENTER W289 CMKM-P3X S513 R.ENCODER ASSY (XNP3089-A) VSX-415-K...
Page 48
CDR/TAPE R466 C451 CN511 R451 R462 R459 6 ENTER 5 FENC A 4 FENC B (XNP3089-A) 3 GNDU FRONT KEY ASSY 2 VENC B 1 VENC A R.ENCODER XWZ3920 QUICK SETUP ENTER CMKM-P3X R.ENCODER ASSY (XNP3089-A) M N P VSX-415-K...
There is no information to be shown in this chapter. > R1551,R1552 RS2LMF331J Other Resistors RS1/16S###J OTHERS 1551 6P CABLE HOLDER 51048-0600 JA1551 HEADPHONE JACK RKB1014 KN1551 WRAPPING TERMINAL VNF1084 FM/AM TUNER UNIT FM/AM TUNER UNIT has no service part. VSX-415-K...
However, the method for disassembly is the same. Note : The unit does not operate when the screws of Speaker Terminal are taken off from Rear Panel. Heat-sink caution in the disassembling : Because Heat-sink becomes hot, please pay attention. VSX-415-K...
Page 58
DSP Assy FM/AM TUNER AMP&PRIMARY 5.1CH UNIT Assy Assy TRANS 2 Assy MAIN Assy AMP INPUT Assy TRANS 1 Assy TRANS 3 Assy R. ENCODER Assy FRONT DISPLAY Assy FRONT KEY Assy H.P. Assy POWER SW & KEY Assy VSX-415-K...
RY-AC P35/A13 Boad DET P76/TA3OUT HP DET MIC DET P75/TA2IN/W P36/A14 RY_A 1394 RST P74/TA2OUT/W P37/A15 RY_C/R 1394 CS P73/CTS2/RTS2/TA1IN/V P40/A16 RY_B P41/A17 1394 CK P72/CLK2/TA1OUT/V AMUTE P71/RxD2/SCL 1394 DO P42/A18 GAIN_SEL /TA0IN/TB5IN 1394 DI P70/TXD2/SDA P43/A19 INPUT_ATT /TA0OUT VSX-415-K...
Page 60
DIR DO Data input signal for communication with DIR/DAC P50/WRL/WR DIR CS Chip select signal for communication with DIR/DAC P47/CS3 P46/CS2 DIR CDC RST Reset signal for DIR CODEC P45/CS1 DIR ERR lock/unlock signal P44/CS0 XTL0 DIR X'tal change VSX-415-K...
Page 61
P02/D2 P01/D1 P00/D0 P107/AN7/KI3 P106/AN6/KI2 P105/AN5/KI1 P104/AN4/KI0 P103/AN3 P102/AN2 SIMUKE1 lnput 1 to switch region P101/AN1 SIMUKE2 lnput 2 to switch region AVSS AVSS Connect to VSS P100/AN0 VREF VREF Connect to VCC AVcc AVCC Connect to VCC P97/ADTRG/SIN4 VSX-415-K...
Page 62
FUNC_VIDEO LED NC(PD)(MULTIROOM SRIN) P01/INTP1 C-MOS P-CH FIP33/P41 FUNC_VCR/DVR LED SR IN P02/T1 C-MOS P-CH FIP34/P42 FUNC_TV/SAT LED AVSS P-CH FIP35/P43 FUNC_DVD/LD LED FUNC_CD LED KEY IN4 ANI3 COPM P-CH FIP36/P44 FUNC_CDR/TAPE LED KEY IN3 ANI2 COMP P-CH FIP37/P45 VSX-415-K...
Page 63
VOLUME JOG1(+) P57/FIP47 P56/FIP46 TEST test mode input for checker P55/FIP45 P54/FIP44 P53/FIP43 P52/FIP42 1W WUP output wakeup signal to main u-com P51/FIP41 VOL LED LED Output P50/FIP40 MCACC LED LED Output P47/FIP39 FUNC/AUX LED Output P46/FIP38 FUNC_TUNER LED Output VSX-415-K...
1) when tuner mute during Tuner function 2) when communicate to DSP 3) when initial processing 4) when detect trouble of AMP DC 5) when detect overload of AMP 6) when Power off 7) when muting by key input VSX-415-K...
When an overload is detected, A.MUTE* is turned on, speaker relay is turned off, then "OVERLOAD" flashes on the display. ↓ The abnormality continues for 3 seconds. ↓ Continues. ↓ Recovery The power is shut off even if the The power is shut off. unit recovers. VSX-415-K...
Page 70
When an boad error is detected, A.MUTE* is turned on, speaker relay is turned off, then "BOAD ERR" flashes on the display. ↓ The abnormality continues for 3 seconds. ↓ Continues. ↓ Recovery The power is shut off even if the The power is shut off. unit recovers. VSX-415-K...
5) Furthermore, check the output DC voltage of each channel of power pack IC601 and IC602 to limit the failure channel and identify the defect power pack. • After identify the failure channel, check that each part is not damaged (resistor, diode... etc. value / open / short) VSX-415-K...
The MULTI JOG dial performs a number of STANDARD tasks. Use it to select options after pressing the Press for Standard decoding and to switch designated MULTI JOG buttons. between the various Pro Logic II and Neo:6 options. STANDBY/ON Switches the receiver between on and standby. VSX-415-K...
Ω LOOP ANTENNA SURROUND DVR/ DVD 5.1CH INPUT DIGITAL IN VIDEO TV / FRONT CENTER SURROUND (TV/ SAT) ASSIGNABLE COAX MONITOR FRONT (CD) D V D 5.1CH COAX INPUT WOOFER CD-R PREOUT (DVD / TAPE /LD) / MD PLAY VSX-415-K...
Page 74
Direct playback bypasses the tone controls maximum level. and channel levels for the most accurate Depending on your level settings for each reproduction of a source. channel, the maximum volume can range • • • • • • between –10 dB and –0 dB. VSX-415-K...
TUNER EDIT Press to memorize and name a station for DVD CONTROL recall. SUB TITLE Press to use the DVD controls on the remote. RECEIVER CONTROL buttons VOLUME +/– Use to set the listening volume. RECEIVER MUTE Mutes/unmutes the sound. VSX-415-K...
Page 76
Adds or subtracts the amount of effect with name and frequency. the advanced surround modes. 12 DVD CONTROL buttons SLEEP You can use these buttons to control a Pioneer Use to set the sleep timer. DVD player connected to your system. FL DIMMER Button What it does Dims or brightens the display.