Napoleon GDI-30N Installation And Operation Instructions Manual
  1. Manuals
  2. Brands
  3. Napoleon Manuals
  4. Indoor Fireplace
  5. GDI-30N
  6. Installation and operation instructions manual
Napoleon GDI-30N Installation And Operation Instructions Manual

Napoleon GDI-30N Installation And Operation Instructions Manual

Gas-fired direct vent insert vented gas fireplace natural and propane gas models
Hide thumbs Also See for GDI-30N:
Table of Contents

Advertisement

Quick Links

INSTALLER: THESE INSTRUCTIONS MUST BE CONVEYED TO AND REMAIN WITH THE HOMEOWNER.
CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS, CSA 2.33, ANSI Z21.88 FOR VENTED GAS FIREPLACE HEATERS
GAS-FIRED DIRECT VENT INSERT
INSTALLATION AND OPERATION INSTRUCTIONS FOR:
WARNING: If the information in these instructions is not followed exactly, a fire
or explosion may result causing property damage, personal injury or death.
Do not store or use gasoline or other flammable vapours and liquids in the
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Do not use any phone in your
building.
Installation and service must be performed by a qualified installer, service
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON L4M 4Y8 Canada • (705)721-1212 • fax(705)722-6031
VENTED GAS FIREPLACE
NATURAL GAS MODELS
PROPANE GAS MODELS
FOR YOUR SAFETY
vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
agency or the gas supplier.
www.napoleonfireplaces.com • ask@napoleon.on.ca
GDI-30N
GDI-30P
/
• Immediately call your gas supplier
from a neighbour's phone. Follow the
gas supplier's instructions.
• If you cannot reach your gas supplier,
call the fire department.
1
W415-0384 / D / 09.13.05

Advertisement

Table of Contents
loading

Related Manuals for Napoleon GDI-30N

Summary of Contents for Napoleon GDI-30N

  • Page 1 Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON L4M 4Y8 Canada • (705)721-1212 • fax(705)722-6031 www.napoleonfireplaces.com • ask@napoleon.on.ca VENTED GAS FIREPLACE GDI-30N GDI-30P FOR YOUR SAFETY • Immediately call your gas supplier from a neighbour's phone. Follow the gas supplier's instructions.

  • Page 2: Table Of Contents

    TABLE of CONTENTS Pg 2-4 INTRODUCTION Warranty General Instructions General Information Care of Glass & Plated Parts INSTALLATION Insert Vent Connection Chimney Connection Gas Pipe Installation Wall Switch / Thermostat FINISHING Log Placement Door Operation Mantle Clearances PLEASE RETAIN THIS MANUAL FOR FUTURE REFERENCE •...

  • Page 3: Warranty

    NAPOLEON gas fireplaces are manufactured under the strict Standard of the world recognized ISO 9001:2000 Quality Assurance Certificate. NAPOLEON products are designed with superior components and materials, assembled by trained craftsmen who take great pride in their work. The burner and valve assembly are leak and test-fired at a quality test station.

  • Page 4: General Instructions

    GENERAL INSTRUCTIONS THIS GAS FIREPLACE INSERT SHOULD BE INSTALLED AND SERVICED BY A QUALIFIED INSTALLER to con- form with local codes. Installation practices vary from re- gion to region and it is important to know the specifics that apply to your area, for example: in Massachusetts State: •...

  • Page 5: Installation

    WHEN HOT! If the glass is not kept clean permanent discolouration and / or blemishes may result. Provide adequate ventilation air. Provide adequate accessibility clearance for servicing and operating the fireplace insert. Never obstruct the front opening of the fire- place insert.

  • Page 6: Insert Vent Connection

    INSERT VENT CONNECTION Move the insert close to its final position inside the wood- burning fireplace. This unit is equipped with 4 levelling screws located in the four inside corners beneath the log support. Level using the levelling screws to eliminate rock- ing or excessive noise when the fan is in operation.

  • Page 7: Finishing

    LOG PLACEMENT PHAZER logs and glowing embers exclusive to Napoleon Fire- places, provide a unique and realistic glowing effect that is different in every installation. Take the time to carefully po- sition the glowing embers for a maximum glowing effect. Log colours may vary.

  • Page 8: Door Operation

    DOOR OPERATION The upper louvres must be removed to allow the door to be opened or closed. Release the top and bottom door latches, located at the right side of the door. FIGURE 6 OPERATION / MAINTENANCE OPERATING INSTRUCTIONS Purge all gas lines with the glass door open. Assure that a continuous gas flow is at the burner before clos- ing the door.

  • Page 9: Maintenance

    FOR YOUR SAFETY READ BEFORE LIGHTING: A. This fireplace is equipped with a pilot which must be lit by hand. While following these instructions exactly. B. Before operating smell all around the fireplace area for gas and next to the floor because some gas is heavier than air and will settle on the floor.

  • Page 10: Blower Replacement

    BLOWER REPLACEMENT INSTALLATION 1. Turn off the electri- cal power and the gas supply to the fireplace insert. 2. Open the glass door and remove the logs and fibre bricks, if in- FIGURE 8 stalled. FIGURE 9 BLOWER ACCESS COVER 3.

  • Page 11: Replacements

    Contact your dealer for questions concerning prices and availability of replacement parts. Normally all parts can be ordered through your Napoleon dealer or distributor. FOR WARRANTY REPLACEMENT PARTS ORIGINAL INVOICE WILL BE REQUIRED TO HONOUR THE CLAIM REPLACEMENT PARTS PART # DESCRIPTION GZ552 REPLACEMENT BLOWER W725-0035...
  • Page 12 W415-0384 / D / 09.13.05 WARNING: This is a fast acting thermocouple. It is an integral safety component. Replace only with a fast acting thermocouple supplied by Wolf Steel Ltd.

  • Page 13: Trouble Shooting Guide

    TROUBLE SHOOTING GUIDE EFORE ATTEMPTING TO TROUBLESHOOT PURGE YOUR UNIT AND INITIALLY LIGHT THE PILOT AND THE MAIN BURNER WITH THE GLASS DOOR OPEN SYMPTOM PROBLEM No spark at pilot burner Pilot will not light. Spark gap is incorrect No gas at the pilot burner Out of propane gas.
  • Page 14 SYMPTOM PROBLEM REFER TO "MAIN BURNER GOES OUT; PILOT STAYS ON" Main burner goes out; pilot goes out. Vent re-circulating Thermocouple shorting or faulty. Vent is reversing Exhaust fumes Fireplace is spilling. smelled room, headaches. Carbon is being de- Air shutter has become posited on glass, blocked logs or combustion...
  • Page 15 W415-0384 / D / 09.13.05...
  • Page 16 W415-0384 / D / 09.13.05...

This manual is also suitable for:

Gdi-30p

Table of Contents