Sony CDX-GT51W Service Manual
Fm/am compact disc player
Hide thumbs
Also See for CDX-GT51W:
- User manual ,
- Service manual (46 pages) ,
- Operating instructions manual (40 pages)
Table of Contents
Advertisement
QQ
3 7 63 1515 0
SERVICE MANUAL
Ver. 1.2 2007.04
• The tuner and CD sections have no adjustments.
AUDIO POWER SPECIFICATIONS (US, CND MODEL)
POWER OUTPUT AND TOTAL HARMONIC DISTORTION
23.2 watts per channel minimum continuous average power into
4 ohms, 4 channels driven from 20 Hz to 20 kHz with no more
than 5% total harmonic distortion.
TE
L 13942296513
CD player section
Signal-to-noise ratio
Frequency response
Wow and flutter
Tuner section
FM
Tuning range
FM tuning interval
Antenna (aerial) terminal
Intermediate frequency 10.7 MHz/450 kHz
Usable sensitivity
Selectivity
Signal-to-noise ratio
Harmonic distortion at 1 kHz
Separation
Frequency response
www
.
Sony Corporation
9-887-402-03
eVehicle Division
2007D04-1
Published by Sony Techno Create Corporation
© 2007.04
http://www.xiaoyu163.com
120 dB
10 – 20,000 Hz
Below measurable limit
87.5 – 107.9 MHz (US, CND model)
87.5 – 108.0 MHz (EA model)
87.5 – 108.0 MHz (at 50 kHz step)
(E, MX model)
87.5 – 107.9 MHz (at 200 kHz step)
(E, MX model)
50 kHz/200 kHz switchable (E, MX model)
External antenna (aerial) connector
9 dBf
75 dB at 400 kHz
67 dB (stereo), 69 dB (mono)
0.5% (stereo), 0.3% (mono)
35 dB at 1 kHz
30 – 15,000 Hz
x
ao
y
i
http://www.xiaoyu163.com
CDX-GT51W/GT510/
8
Model Name Using Similar Mechanism
CD Drive Mechanism Type
Optical Pick-up Name
Q Q
3
6 7
1 3
SPECIFICATIONS
AM
Tuning range
AM tuning interval
Antenna (aerial) terminal
Intermediate frequency 10.7 MHz/450 kHz
Sensitivity
Power amplifier section
Outputs
Speaker impedance
Maximum power output
General
Outputs
FM/AM COMPACT DISC PLAYER
u163
.
2 9
GT560/GT560S
9 4
2 8
Canadian Model
CDX-GT51W/GT510
CDX-GT560/GT560S
1 5
0 5
8
2 9
9 4
530 – 1,710 kHz (US, CND model)
531 – 1,602 kHz (EA model)
531 – 1,602 kHz (at 9 kHz step) (E, MX model)
530 – 1,710 kHz (at 10 kHz step) (E, MX model)
9 kHz/10 kHz switchable (E, MX model)
External antenna (aerial) connector
30 µV
Speaker outputs (sure seal connectors)
4 – 8 ohms
52 W × 4 (at 4 ohms)
Audio outputs terminal (front, sub/rear
switchable)
Power antenna (aerial) relay control terminal
Power amplifier control terminal
– Continued on next page –
m
co
9 9
US Model
E Model
NEW
MG-101FA-188//Q
DAX-25A
2 8
9 9
Advertisement
Table of Contents
Related Manuals for Sony CDX-GT51W
Summary of Contents for Sony CDX-GT51W
- Page 1 Power amplifier control terminal Separation 35 dB at 1 kHz Frequency response 30 – 15,000 Hz – Continued on next page – FM/AM COMPACT DISC PLAYER u163 Sony Corporation 9-887-402-03 eVehicle Division 2007D04-1 Published by Sony Techno Create Corporation © 2007.04 http://www.xiaoyu163.com...
-
Page 2: Http://Www.xiaoyu163.Com
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REPLACE THESE COMPONENTS WITH SONY PARTS REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. - Page 3 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 • • CD Playback UNLEADED SOLDER You can play CD-DA (also containing CD TEXT*) and CD-R/ Boards requiring use of unleaded solder are printed with the lead- CD-RW (MP3/WMA/AAC files also containing Multi Session) free mark (LF) indicating the solder contains no lead.
-
Page 4: Table Of Contents
When repairing, the complete SERVO board (A-1177-362-A) should be replaced since any parts in the SERVO board cannot be repaired. GENERAL Location of Controls (CDX-GT51W: US) ...... 5 NOTE FOR REPLACEMENT OF THE AUX JACK (J901) Connections (CDX-GT51W: US) ........5 To replace the AUX jack requires alignment. -
Page 5: General
SECTION 1 GENERAL This section is extracted 3 7 63 1515 0 from instruction manual. • LOCATION OF CONTROLS (CDX-GT51W: US) Location of controls and basic operations Main unit H EQ3 (equalizer) button 9 The following buttons on the card remote... -
Page 6: Diagrama De Conexión
CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 Source selector (not supplied) Supplied with the CD/MD changer Selector de fuente Suministrado con el cambiador de CD/MD (no suministrado) Supplied with XA-C40 XA-C40 Suministrado con el XA-C40 AUDIO OUT REMOTE FRONT BUS AUDIO IN... -
Page 7: Location Of Controls (Cdx-Gt51W: Cnd/Gt510)
CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 • LOCATION OF CONTROLS (CDX-GT51W: CND/GT510) Location of controls and basic operations Main unit H EQ3 (equalizer) button 9 The following buttons on the card remote commander have also different buttons/functions To select an equalizer type (XPLOD, from the unit. - Page 8 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 Source selector Supplied with the CD/MD changer (not supplied) Fourni avec le changeur de CD/MD Sélecteur de source (non fourni) Supplied with XA-C40 XA-C40 Fourni avec le XA-C40 AUDIO OUT REMOTE FRONT BUS AUDIO IN...
-
Page 9: Location Of Controls (Cdx-Gt560: E, Mx/Gt560S)
CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 • LOCATION OF CONTROLS (CDX-GT560: E, MX/GT560S) Location of controls and basic operations Main unit H EQ3 (equalizer) button 9 The following buttons on the card remote commander have also different buttons/functions To select an equalizer type (XPLOD, from the unit. - Page 10 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 Source selector (not supplied) Selector de fuente Supplied with the CD/MD changer (no suminidtrado) Suministrado con el cambiador de CD/MD Supplied with XA-C40 XA-C40 Suministrado con el XA-C40 AUDIO OUT REMOTE FRONT BUS AUDIO IN...
-
Page 11: Disassembly
CDX-GT51W/GT510/GT560/GT560S Ver. 1.2 SECTION 2 DISASSEMBLY 3 7 63 1515 0 Note: This set can be disassemble according to the following sequence. 2-1. SUB PANEL ASSY (Page 12) 2-2. CD MECHANISM BLOCK (Page 12) 2-4. SERVO BOARD 2-3. MAIN BOARD... -
Page 12: Sub Panel Assy
CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 Note: Follow the disassembly procedure in the numerical order given. 2-1. SUB PANEL ASSY 3 two claws 2 two claws 4 flexible flat cable (20 core) 1 two screws (CN802) (+PTT 2.6 × 6) -
Page 13: Main Board
CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 2-3. MAIN BOARD 4 screw (+PTT 2.6 × 10) 5 two screws (+P 2.6 × 8) 6 two screws (+P 2.6 × 8) 7 two screws 1 three ground point screws (+PTT 2.6 × 10) (+PTT 2.6 ×... -
Page 14: Chassis (T) Sub Assy
CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 2-5. CHASSIS (T) SUB ASSY 2 two precision screws 1 two precision screws (+P 1.7 × 2.2) (+P 1.7 × 2.2) 4 chassis (T) sub assy 3 claw L 13942296513 2-6. ROLLER ARM ASSY... -
Page 15: Chassis (Op) Assy
CDX-GT51W/GT510/GT560/GT560S Ver. 1.2 3 7 63 1515 0 2-7. CHASSIS (OP) ASSY 6 chassis (OP) assy 1 tension spring (KF) 7 coil spring (damper) (natural) 8 coil spring (damper) (green) 4 slider (R) 3 lever (D) 2 gear (LE1) -
Page 16: Diagnosis Function
CDX-GT51W/GT510/GT560/GT560S SECTION 3 DIAGNOSIS FUNCTION 3 7 63 1515 0 Description of the Diagnostics function: 4. Contents of each display mode 4-1. Reset count display mode 1. Setting the Diag display mode With the power off, press the [4/SHUF] button, [5] button, and [4/SHUF] button on the set body or the remote control (for more than 2 seconds) in turn. - Page 17 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 4-5. CD error information display mode 4-6. OFFSET/FAILURE error display mode 4-5-1. Error description 0 6 1 X X X X X 0 5 1 Operating hours Error information Error description Error description...
- Page 18 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 MEMO L 13942296513 u163 http://www.xiaoyu163.com...
-
Page 19: Diagrams
CDX-GT51W/GT510/GT560/GT560S SECTION 4 3 7 6 3 1 5 1 5 0 DIAGRAMS 4-1. BLOCK DIAGRAM — MAIN SECTION — J451 (2/2) FRONT ELECTRONIC VOLUME IC401 R-CH J451 (1/2) AUDIO OUT 2 A2 OUTS2 R-CH 1 A1 OUTS1 R-CH... -
Page 20: Block Diagram -Display Section
CDX-GT51W/GT510/GT560/GT560S 3 7 6 3 1 5 1 5 0 4-2. BLOCK DIAGRAM — DISPLAY SECTION — • NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. SYSTEM CONTROL... -
Page 21: Printed Wiring Board -Main Section
CDX-GT51W/GT510/GT560/GT560S 4-3. PRINTED WIRING BOARD — MAIN SECTION — : Uses unleaded solder. 3 7 6 3 1 5 1 5 0 • Semiconductor Location J451 Ref. No. Location AUDIO OUT D101 REAR FRONT AUDIO IN J370 D102 (REMOTE IN) -
Page 22: Schematic Diagram -Main Section (1/3)
CDX-GT51W/GT510/GT560/GT560S 3 7 6 3 1 5 1 5 0 4-4. SCHEMATIC DIAGRAM — MAIN SECTION (1/3) — • Refer to page 29 for IC Block Diagram. C303 JC999 C323 C306 C308 C324 R302 C319 JC302 C309 JC504 C305... -
Page 23: Schematic Diagram -Main Section (2/3)
CDX-GT51W/GT510/GT560/GT560S 3 7 6 3 1 5 1 5 0 4-5. SCHEMATIC DIAGRAM — MAIN SECTION (2/3) — • Refer to page 30 for IC Block Diagram. J451 C432 C413 C414 C442 C422 C452 JC998 R418 R416 JW26 C443... -
Page 24: Schematic Diagram -Main Section (3/3)
CDX-GT51W/GT510/GT560/GT560S 3 7 6 3 1 5 1 5 0 • Refer to page 20 for Waveforms. 4-6. SCHEMATIC DIAGRAM — MAIN SECTION (3/3) — • Refer to page 31 for IC Pin Descriptions. (Page 22) (Page 23) Q590... -
Page 25: Printed Wiring Board -Sub Section
CDX-GT51W/GT510/GT560/GT560S 3 7 6 3 1 5 1 5 0 4-7. PRINTED WIRING BOARD — SUB SECTION — : Uses unleaded solder. (Page 27) KEY BOARD CN901 LED202, S201 FMA4 LED202 R202 CN201 LED201 R201 S201 LED201 (DISC IN) -
Page 26: Schematic Diagram -Sub Section
CDX-GT51W/GT510/GT560/GT560S 3 7 6 3 1 5 1 5 0 4-8. SCHEMATIC DIAGRAM — SUB SECTION — CN202 CN201 (Page 28) (Page 23) R202 R201 S201 LED202 LED201 1 3 9 4 2 2 9 6 5 1 3... -
Page 27: Q Q 4-9. Printed Wiring Board -Key Section
CDX-GT51W/GT510/GT560/GT560S 4-9. PRINTED WIRING BOARD — KEY SECTION — : Uses unleaded solder. 3 7 6 3 1 5 1 5 0 LED902,952, S902 SOURCE LSW901 LED908,958, S908 R939 S902 S908 LSW901 R941 LED941–944, LED991–994 LED903,953, (VOLUME ILLUMINATE) S903... -
Page 28: Schematic Diagram -Key Section
CDX-GT51W/GT510/GT560/GT560S 3 7 6 3 1 5 1 5 0 4-10. SCHEMATIC DIAGRAM — KEY SECTION — D982 R991 R992 R993 FL900 R973 LED917 LED967 LED909 LED959 LED943 LED993 LED907 LED957 LSW901(2/2) R972 R971 IC971 LED914 LED964 LED941 LED991... - Page 29 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 • IC BLOCK DIAGRAMS IC300 TDA8588AJ/N2/R1 (MAIN Board (1/3)) LF– C BUS LR– PGND3 IN-RL IN_RR S-GND PROTECTION/ DIAGNOSTIC IN_LR IN_LF ACGND PGND2 RR– STANDBY/ MUTE L 13942296513 RF– CHIP DETECT/ PGND1 DIAGNOSTIC...
- Page 30 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 IC401 BD3442FS-E2 (MAIN Board (2/3)) VCC2 32 FIL 100k 31 GND INPUT INPUT VOLUME1 TREBLE VOLUME2 100k SELECTOR GAIN /MUTE /BASS B1 3 30 SDA /MIDDLE 100k LOGIC 29 SCL 28 MUTE 100k...
- Page 31 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 • IC PIN DESCRIPTIONS • IC501 MB90F045PF-G-9016-SPE1 (SYSTEM CONTROL) (MAIN BOARD (3/3)) Pin No. Pin Name Pin Description AREASEL0 Destination setting pin AREASEL1 Destination setting pin AREASEL2 Frequency select signal input B-OUTSEL Blackout existence distinction signal input (L: blackout none, H: blackout)
- Page 32 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 Pin No. Pin Name Pin Description Operation mode setting pin (Pull up) Operation mode setting pin (Pull up) Operation mode setting pin (Pull down) KEYACK Key acknowledgment detect signal input Not used in this set. (Pull down)
-
Page 33: Exploded Views
CDX-GT51W/GT510/GT560/GT560S SECTION 5 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • The mechanical parts with no reference • -XX and -X mean standardized parts, so The components identified by mark 0 or dotted line with mark. number in the exploded views are not supplied. -
Page 34: Front Panel Section
CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 5-2. FRONT PANEL SECTION RE901 not supplied (KEY board) J901 FL901 not supplied not supplied not supplied L 13942296513 not supplied not supplied not supplied Ref. No. Part No. Description Remark Ref. No. -
Page 35: Cd Mechanism Section (Mg-101Fa-188//Q)
CDX-GT51W/GT510/GT560/GT560S Ver. 1.2 3 7 63 1515 0 5-3. CD MECHANISM SECTION (MG-101FA-188//Q) NOTE: Refer to SUPPLEMENT-1 for disassembly of OPTICAL PICK-UP. not supplied not supplied not supplied not supplied not supplied not supplied not supplied L 13942296513 not supplied... -
Page 36: Electrical Parts List
CDX-GT51W/GT510/GT560/GT560S SECTION 6 ELECTRICAL PARTS LIST 3 7 63 1515 0 NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by mark 0 or dotted line with mark. the parts list may be different from the they are seldom required for routine service. - Page 37 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark LED992 8-719-078-21 LED SML-310PTT86 (VOLUME ILLUMINATE) R948 1-216-030-00 RES-CHIP 1/10W LED993 8-719-078-21 LED SML-310PTT86 (VOLUME ILLUMINATE) R949 1-216-031-00 RES-CHIP 1/10W LED994 8-719-078-21 LED SML-310PTT86 (VOLUME ILLUMINATE)
- Page 38 CDX-GT51W/GT510/GT560/GT560S MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-1204-625-A MAIN BOARD, COMPLETE (GT51W/GT510) C403 1-126-176-11 ELECT 220uF A-1206-171-A MAIN BOARD, COMPLETE (GT560:E,MX/GT560S) C405 1-124-248-00 ELECT 22uF A-1206-183-A MAIN BOARD, COMPLETE (GT560:EA)
- Page 39 CDX-GT51W/GT510/GT560/GT560S MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C703 1-126-163-11 ELECT 4.7uF D365 8-719-977-12 DIODE DTZ6.8B C704 1-115-340-11 CERAMIC CHIP 0.22uF D366 8-719-977-12 DIODE DTZ6.8B C705 1-162-970-11 CERAMIC CHIP 0.01uF...
- Page 40 CDX-GT51W/GT510/GT560/GT560S MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark JC53 1-216-864-11 SHORT CHIP Q590 8-729-027-23 TRANSISTOR DTA114EKA-T146 JC100 1-216-864-11 SHORT CHIP Q600 8-729-047-76 TRANSISTOR FMC2A-T148 JC300 1-216-296-11 SHORT CHIP...
- Page 41 CDX-GT51W/GT510/GT560/GT560S MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R471 1-216-809-11 METAL CHIP 1/10W R549 1-216-825-11 METAL CHIP 2.2K 1/10W R472 1-216-833-11 METAL CHIP 1/10W R550 1-216-845-11 METAL CHIP...
- Page 42 CDX-GT51W/GT510/GT560/GT560S MAIN SERVO 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark < THERMISTOR (POSITIVE) > ACCESSORIES ************ TH400 1-803-350-21 THERMISTOR, POSITIVE 1-479-077-13 REMOTE COMMANDER (RM-X151) < TUNER UNIT > 2-548-729-01 LID, BATTERY CASE (for RM-X151)
- Page 43 CDX-GT51W/GT510/ 3 7 63 1515 0 GT560/GT560S US Model Canadian Model CDX-GT51W/GT510 SERVICE MANUAL E Model CDX-GT560/GT560S Ver. 1.2 2007.04 SUPPLEMENT-1 File this supplement with the service manual. Subject: Notes for removal of the OPTICAL PICK-UP added. DISASSEMBLY L 13942296513 1.
- Page 44 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 2. SLED MOTOR ASSY 2 three serration screws (M 2 × 3) 3 sled mtor assy 1 spring turn table spring stand Note: Never remove these parts since they were adjusted. stand Note: Place the stand with care not to touch the turn table.
- Page 45 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 3. OPTICAL PICK-UP SECTION 2 optical pick-up section Note: Be careful not to touch the lens and hologram terminal when removing the optical pick-up section. L 13942296513 4. OPTICAL PICK-UP 1 pan tapping screw (M 1.4 ×...
- Page 46 CDX-GT51W/GT510/GT560/GT560S 3 7 63 1515 0 REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page.