Improper Combustion; Gas; When Servicing The Water Heating System; Heater Water - Westinghouse WGR-076 Series Installation, Start-Up, Maintenance, Parts, Warranty

DO NOT USE THIS WATER HEATER IF ANY PART HAS
BEEN SUBMERGED IN WATER. Immediately call a qualified
service technician. The water heater MUST BE replaced if it
has been submerged. Attempting to operate a water heater
that has been submerged could create numerous harmful
conditions, such as a potential gas leakage causing a fire
and/or explosion, or the release of mold, bacteria, or other
harmful particulates into the air. Operating a previously
submerged water heater could result in property damage,
severe personal injury, or death.
NOTE: Water heater damage due to flood or submersion is
considered an Act of God, and IS NOT covered under product
warranty.
NOTE: Obey all local codes. Obtain all applicable permits
before installing the water heater.
NOTE: Install all system components and piping in such a
manner that does not reduce the performance of any fire
rated assembly.
Altering any Westinghouse water heater with parts not
manufactured by Westinghouse WILL INSTANTLY VOID the
water heater warranty and could result in property damage,
personal injury, or death.
This water heater has been designed to heat potable water
ONLY. Using this water heater to heat non-potable fluid WILL
VOID product warranty, and could result in property damage,
personal injury, or death.
Do not use this water heater for anything other than its
intended purpose (as described in this manual). Doing so
could result in property damage and WILL VOID product
warranty.
High heat sources (sources generating heat 100
greater, such as stove pipes, space heaters, etc.) may damage
plastic components of the water heater as well as plastic
vent pipe materials. Such damages ARE NOT covered by
warranty. It is recommended to keep a minimum clearance of
8" from high heat sources. Observe heat source manufacturer
instructions, as well as local, state, provincial, and national
codes, laws, regulations and ordinances when installing this
water heater and related components near high heat sources.
A. Improper Combustion
Do not obstruct the flow of combustion and ventilating air.
Adequate air is necessary for safe operation. Failure to keep
the exhaust vent and combustion air intake clear of ice, snow,
or other debris could result in property damage, serious
personal injury, or death.
B. Gas
Should overheating or gas supply fail to shut off, turn off the
manual gas control valve to the water heater.
C. When Servicing the Water Heating System
Be sure to disconnect electrical power before performing
service. Failure to do so could result in electrical shock, property
damage, serious personal injury, or death.
To avoid electric shock, disconnect electrical supply before
performing maintenance.
NOTE: When inquiring about service or troubleshooting,
reference the model and serial numbers from the water heater
rating label.
To avoid severe burns, allow water heater and associated
equipment to cool before servicing.
D. Heater Water
Do not use petroleum-based cleaning or sealing compounds in
a water heating system. Gaskets and seals in the system may be
damaged. This can result in substantial property damage.
Do not use "homemade cures" or "patent medicines". Damage
to the water heater, substantial property damage, and/or
serious personal injury may result.
E. Freeze Protection
NOTE: Consider piping and installation when determining
heater location.
Failure of the water heater due to freeze related damage IS
NOT covered by product warranty.
NEVER use any toxic chemical, including automotive, standard
glycol antifreeze, or ethylene glycol made for hydronic (non-
potable) systems. These chemicals can attack gaskets and seals
in water systems, are poisonous if consumed, and can cause
F / 37 C or
o o
personal injury or death.
UNCRATING THE WATER HEATER - Any claims for damage
or shortage in shipment must be filed immediately against the
transportation company by the consignee.
F. Water Temperature Adjustment
If the water heater is going to have a set temperature above
120 o F, you must use an ASSE 1017 rated mixing valve to avoid
severe burns or death from scalding temperatures.
Households with small children, disabled, or elderly persons
may require a 120
severe personal injury or death due to scalding.
o F or lower temperature setting to prevent
WHL-001 Rev. 3.16.15
5